2012 Fiat 500 Problems

The clutch went out while downshifting upon making a turn onto a street. The gear shift became wobbly and would not shift into any gear. This happened without warning. Minutes before, my passenger and I were driving across town on a freeway.

The contact owns a 2012 Fiat 500. The contact stated while driving at approximately 65 MPH, the accelerator pedal was depressed; however, the vehicle lost motive power and stalled. The contact stated no warning light was illuminated. The contact was able to exit the highway. The contact stated that while attempting to restart the vehicle, the clutch pedal went to the floorboard and the contact was unable to start the vehicle. The contact had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the clutch pedal limiter and a clutch pedal switch needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 16V302000 (Power Train) which had been completed in 2023 on the vehicle by the same dealer. The manufacturer was not informed of the failure. The failure mileage was approximately 214,000.

The vehicle had been stalling out on numerous occasions one being a freezing Xmas eve in Drive thru if it had happened somewhere isolated the driver could have frozen. I rented cars several times and replaced the alternator ,battery and at the final point at the dealership the mechanic suggested I purchase a $600 battery though I had a brand new one. The dealership gave me a $200 credit but it happened again, the mechanic in town said the Bluetooth component was draining the battery. They removed it and no problem since. The dealership mechanic talked around the issue and would not answer my questions about this. The safety issues related to this are dangerous and it appears to be known by mechanics about this model.

The wiring harness bundle leading to the trunk failed between the trunk & upper drivers side of the car. Upper brake lights stopped working, then rear defroster, then trunk wouldn’t open & I got a license plate light warning on the dash. Mechanic tried to replace switch, still didn’t work, the tried to replace handle (with license plate light). Mechanic broke more wires in bundle, back brake lights stopped working. The wiring harness bundle leading into the trunk is defective.

I've had 3 different issues with the transmission- There's been 1 recall on the clutch- The transmission put me in Great danger I was driving on the freeway about 60 mph when the car just popped into neutral- I was terrified and I managed to pull to safety to put the manual transmission into gear- I didn't want it to happen again- I had to hold the gear until I got to an exit to get off the freeway- I had the Fiat towed to the dealership and fixed- then 6 months later driving again and it jumps out of gear into Neutral another scare- I put it in the shop and it cost me $4646,00 to replace the transmission, I really would like this serious safety hazzard investigated so no one gets hurt- I was Blessed to be able to think fast to save my life on a busy Highway my safety and others was put at risk because it could have caused a crash- It gives no warning at all- car is available upon request I have all receipts I can send -for some reason I was unable to download to this Site

I bought this car about a year ago, ever since I got the car the first issue started within a month it just started to shut off for no reason first at a traffic light, afterward while I was driving called the dealership who sold me the car I was told to bring it to find out they did not have a certified Fiat Mechanic that would be able to look at the car so it was towed to another dealership. I was told they fixed the issue but once again the vehicle started doing the same thing even more frequently fast forward my car has yet to be fixed I feel like I am going to get rear-ended and hurt really bad and all I get from the dealership is that they can't fix it. My question to them is why I sell me a car that you knew you could not repair or you knew you really didn't check properly as per your words you don't have a certified mechanic.

The air bag light will come on then turn off Is their a malfunction of the air bag or is it just coming on and off and will the air bag respond normally in a crash it been happening for approximately a year now it hasn't been inspected

I bought this car from a dealer in Fortville (Carlux) who said it had a clean history, this car was meant to be driven by my 17 year old to school, after driving it for 1 week she noticed weird sounds on turning and the engine being very loud and not responding to acceleration or deceleration, thankfully she made it back home safely, I then took it to my local mechanic who noticed major safety issues with the vehicle and on running the VIN number found out there are 2 safety recalls on it. Is there a law or regulation against the dealership that does that? It could have cost my child's life. Their address is: 222 W Broadway street, Fortville , IN 46040 and contact # is (317) 777 1931

Every time I pump fuel in the vehicle, the pump stops prematurely. It’ll pump for a few seconds and then seize. I would have to continuously press the handle every time the pump stops and clicks every few seconds. After I’m done fueling, it smells like gasoline inside my vehicle. I took my Fiat 500 to the dealership in January of 2019 to have Sunland Park technicians check the issue. Technicians diagnosed the vehicle and claimed it was a faulty fuel tank. Fuel tank was replaced and issue had gone away for approximately a year then proceeded to do the same issue again. Went back to the dealership when I began having the same issue and technicians say there is nothing wrong with my vehicle and they said that the repairs of my whole fuel tank were no longer under warranty. My fiat 500 is still having the same fuel issue of clicking nonstop and odor of the fuel is still strong. There are many fiat 500 owners going through this same issue continually paying fiat dealerships just to have the same issue of inhaling fuel and not being able to pump fuel in properly. This is a major hazard and needs to be resolved.

The contact owns a 2012 Fiat 500. The contact stated that she was having difficulties refueling the vehicle as the gas pump would constantly stop pumping gas though the tank was not full. The vehicle was taken to an independent mechanic who diagnosed that the fuel tank sensor had failed, and the fuel tank needed to be replaced. The dealer was notified of the failure and advised the contact that it was a known failure however, she would be responsible for the cost of the repair since there was no recall related to the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 67,000.

The contact owns a 2012 Fiat 500. The contact stated that while driving at an undisclosed speed, there was an abnormal clunking sound coming from underneath the front of the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.

I've had 3 different issues with the transmission- There's been 1 recall on the clutch- The transmission put me in Great danger I was driving on the freeway about 60 mph when the car just popped into neutral- I was terrified and I managed to pull to safety to put the manual transmission into gear- I didn't want it to happen again- I had to hold the gear until I got to an exit to get off the freeway- I had the Fiat towed to the dealership and fixed- then 6 months later driving again and it jumps out of gear into Neutral another scare- I put it in the shop and it cost me $4646,00 to replace the transmission, I really would like this serious safety hazzard investigated so no one gets hurt- I was Blessed to be able to think fast to save my life on a busy Highway my safety and others was put at risk because it could have caused a crash- It gives no warning at all- car is available upon request I have all receipts I can send -for some reason I was unable to download to this Site

MY WIFE WAS EXITING A MALL PARKING LOT TO PULL INTO THE LEFT TURN LANE OF THE ADJOINING ROAD (A VERY SHORT DISTANCE, PERHAPS 25 FEET). THERE WAS A CAR ALREADY IN THE LEFT TURN LANE, WHICH WAS WAITING FOR THE TRAFFIC SIGNAL TO CHANGE. WHILE PULLING IN BEHIND THIS CAR, THE BRAKE PEDAL WAS DEPRESSED, BUT THE CAR SUDDENLY AND RAPIDLY ACCELERATED. PRESSING HARDER ON THE BRAKE HAD NO EFFECT. WITH ONLY 1 OR 2 SECONDS TO REACT, A FUTILE ATTEMPT WAS MADE TO STEER CLEAR OF THE CAR AHEAD, WHICH WAS STRUCK. THE FIAT THEN VEERED TO THE RIGHT AND HIT A SECOND CAR THAT HAD BEEN WAITING FOR THE LIGHT IN THE RIGHT LANE. THE SECOND CAR WAS PUSHED INTO A VEHICLE AHEAD OF IT WHICH HAD ALSO BEEN WAITING FOR THE LIGHT. AFTER STRIKING THIS SECOND VEHICLE, THE FIAT FINALLY CAME TO A HALT IN THE RIGHT LANE.

WHILE DRIVING HOME VIA LOCAL CITY SURFACE STREETS, THE GEARBOX FAIL LIGHT AND THE HAVE TRANSMISSION CHECKED MESSAGE CAME UP ON THE DASH CLUSTER. I DROVE THE CAR 4 MORE MILES TO A SERVICE STATION, STOPPING TWICE ON THE WAY. THE CAR BEGAN RUNNING POORLY. INCLUDING BUCKING, REVVING HIGH, WHILE STAYING AT LOW SPEED, STALLING AND BUCKING AT LIGHTS LOW IDLE OR STOPS. THE SERVICE STATION SAID OTHER THAN A LOW NUMBER (4 TIMES PER 1000 I THINK...A CYLINDER MISFIRE) NO CODES CAME UP. WHEN RESET THE CAR WOULD RUN BRIEFLY AS NORMAL BUTAT FIRST STOP ALL ISSUES WOULD RESUME IN FULL AGAIN. I WAS ABLE TO DRIVE THE CAR HOME (2 BLOCKS) BUT WAS NOT SURE IT WOULD MAKE IT. IT SITS IN MY PARKING SPOT AS WE SPEAK.

As reported by numerous consumers the power steering just stop working while driving with no warnings. This caused a wreck involving my son & I and we're admitted to hospital. Apparently this is a widely reported problem yet it has not attention. It's extremely dangerous and cost more to fix than what the car is worth.

While I was driving on a busy dyreet the warning light flashed and my car shut off, I was nearly hit by another vehicle. I took my car in to have it checked out and the dealer days the steering module loss confection and the steering column needs to be replaced. I see that this has been a known issue by Fiat but they fail to include all vehicles in their recall. I request that this be addressed. This is a safety issue.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT AFTER DRIVING, THE TIRES WERE EXTREMELY WARM. THE VEHICLE WAS TAKEN TO A TIRE SPECIALIST TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE PASSENGER'S SIDE FRONT CONTROL ARM BOLT LOOSENED FROM THE VEHICLE WHICH CAUSED THE TIRE TO TILT INWARD WITH THE FRONT CONTROL ARM SLIGHTLY DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO PALMETTO ALFA ROMEO-FIAT SERVICE DEPARTMENT (2065 NE 151ST ST, NORTH MIAMI BEACH, FL 33162, (305) 948-6794) WHERE THE MECHANIC REPLACED THE FRONT ROTOR, ROTOR SHIELD, WHEEL BEARING, FRONT CONTROL ARM AND BOLTS. THE CONTACT STATED THAT THE VEHICLE PREVIOUSLY EXPERIENCED A SIMILAR FAILURE ON THE FRONT DRIVER'S SIDE AND WAS REPAIRED BY MASSEY YARDLEY JEEP CHRYSLER DODGE RAM (777 N. STATE RD 7, PLANTATION, FL 33317, (954) 327-4000). THE CONTACT STATED THAT THE FAILURE RECURRED WHILE DRIVING APPROXIMATELY 15 MPH, WHILE ATTEMPTING TO MAKE A TURN WHEN THE CONTROL ARM DETACHED FROM THE VEHICLE. THE CONTACT STATED THAT THERE WAS FLUID LEAKING FROM THE BALL JOINT ON THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS TOWED TO AN UNKNOWN DEALER BUT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,161.

I AM A REAL ESTATE AGENT. LAST YEAR 2019 I WENT TO AN OPEN HOUSE AND PARKED IN THE DRIVEWAY WHICH WAS ON AN INCLINE - WITH A PLATEAU FOR PARKING. I'VE BEEN DRIVING A STANDARD TRANSMISSION FOR 30 YEARS. WHEN I PARK I PLACE MY GEAR IN 1ST WITH THE PARKING BRAKE FULLY ENGAGED. I PARKED THE CAR, WENT INTO THE HOME TO VIEW THE HOME, AND WAS INSIDE 15 MINUTES. WHEN I WENT BACK TO MY CAR, IT WAS GONE. THE CAR HAD ROLLED BACKWARD DOWN THE HILL AND INTO A GUARDRAIL. THERE WERE NEIGHBORS ALL AROUND MY CAR, AND ONE MAN SAID, "IT MAKES NO SENSE IT THE PARKING BREAK IS ENGAGED." THE NEIGHBORS HAD VIDEO OF THE CRASH. THE CAR WAS PARKED APPROX 10 MINUTES BEFORE ROLLING DOWN THE HILL. MY CAR WAS DAMAGED BY THE GUARD RAIL, AND THANKFULLY NO HUMANS WERE HURT. HAD THE GUARDRAIL NOT BEEN THERE -- THE CAR WOULD HAVE GONE OVER A RAVINE AND INTO A HOME.

I AM A REAL ESTATE AGENT. LAST YEAR 2019 I WENT TO AN OPEN HOUSE AND PARKED IN THE DRIVEWAY WHICH WAS ON AN INCLINE - WITH A PLATEAU FOR PARKING. I'VE BEEN DRIVING A STANDARD TRANSMISSION FOR 30 YEARS. WHEN I PARK I PLACE MY GEAR IN 1ST WITH THE PARKING BRAKE FULLY ENGAGED. I PARKED THE CAR, WENT INTO THE HOME TO VIEW THE HOME, AND WAS INSIDE 15 MINUTES. WHEN I WENT BACK TO MY CAR, IT WAS GONE. THE CAR HAD ROLLED BACKWARD DOWN THE HILL AND INTO A GUARDRAIL. THERE WERE NEIGHBORS ALL AROUND MY CAR, AND ONE MAN SAID, "IT MAKES NO SENSE IT THE PARKING BREAK IS ENGAGED." THE NEIGHBORS HAD VIDEO OF THE CRASH. THE CAR WAS PARKED APPROX 10 MINUTES BEFORE ROLLING DOWN THE HILL. MY CAR WAS DAMAGED BY THE GUARD RAIL, AND THANKFULLY NO HUMANS WERE HURT. HAD THE GUARDRAIL NOT BEEN THERE -- THE CAR WOULD HAVE GONE OVER A RAVINE AND INTO A HOME.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT THE LICENSE PLATE BULB WAS OUT AND THE LIFTGATE DID NOT OPEN MANUALLY. THE VEHICLE WAS TAKEN TO FLOWER MOTOR COMPANY (2580 N TOWNSEND AVE, MONTROSE, CO 81401, (970) 249-9664) WHERE THE CONTACT WAS INFORMED THAT THE WIRES WERE FRACTURED AND THE LIFTGATE HANDLE WAS REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THERE WERE NO RECALLS. NO FURTHER ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 133,000.

The contact owns a 2012 FIAT 500. The contact stated that the vehicle was parked, when she noticed there was a crack in the center of the windshield going towards the driver's side. There was no impact to the windshield that could have caused the crack. The vehicle was not diagnosed nor repaired. The dealer and manufacturer were not made aware of the failure. The failure mileage was 38,045.

INTERMITTENT EXTERIOR MARKER LIGHT FAILURE. FRONT PASSENGER MARKER LIGHT AND REAR DRIVER'S SIDE BRAKE LIGHT FAIL TO OPERATE ON OCCASION. THE LIGHT SENSOR IN THE GAUGE CLUSTER ALERTS TO FAILURE. WHEN LATER INVESTIGATING, ALL LIGHTS APPEAR TO FUNCTION PROPERLY.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED WHILE DRIVING 30 MPH, THE CHECK REAR DRIVER LIGHT WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THE LEFT LICENSE PLATE BULB WAS NOT ILLUMINATING. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER ARRIGO FIAT WEST PALM BEACH (6500 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33411, (561) 618-3160) WHERE IT WAS DIAGNOSED WITH NEEDING THE REAR LIGHTS ASSEMBLY TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 51,000. THE CONSUMER STATED THE REPAIR WOULD COST $475 AT THE DEALER. THE CONSUMER PURCHASED THE LICENSE PLATE BULBS AND PERSONALLY INSTALLED THE BULBS.

THE REAR HIGH BRAKE LIGHT WIRING ON THE CONVERTIBLE WEARS AND BREAKS IN THE DRIVER'S SIDE C PILLAR DUE TO USE OF THE CONVERTIBLE TOP RENDERING THE BRAKE LIGHT NON-OPERATIVE. THIS SEEMS TO BE A COMMON PROBLEM WITH THE FIAT 500 CONVERTIBLE.

I have been dealing with identity theft and not really sure why when I put vin number to my vehicle I purchased September 25 2025 it says a different color

MY TIRE PRESSURE MONITORING SYSTEM LIGHT STAYS ON DESPITE HAVING CHANGED ALL FOUR TIRES AND VALVE PRESSURE STEMS. THERE SEEMS TO BE AN INHERENT PROBLEM WITH THE SYSTEM. LOOKING ON THE FIAT FORUMS ONLINE APPARENTLY MANY OTHER OWNERS ARE HAVING THE SAME PROBLEM WITH THE WIRELESS SYSTEM. MY VEHICLE IS A 2012 WITH LESS THAN 40K MILES. I REMEMBER HAVING THE PROBLEM WHEN THE CAR WAS UNDER WARRANTY AND NOW AGAIN. TIRES AND VALVE PRESSURE STEMS ALL NEW AND INSTALLED AND CHECKED BY COSTCO TIRE CENTER. THE SYSTEM HAS NOT RESET ITSELF DESPITE NUMEROUS ATTEMPTS.

TL* THE CONTACT OWNS A 2012 FIAT 500. AFTER THE VEHICLE WAS STARTED, THE CLUTCH PEDAL JAMMED AND WOULD NOT RETRACT INTO THE ORIGINAL POSITION. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TOWED TO RED'S AUTO & TRUCK (1451 VISTA VIEW DR., LONGMONT, CO) WHERE IT WAS DIAGNOSED THAT THE CLUTCH ASSEMBLY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WERE NO RECALLS ATTRIBUTED TO THE VIN. THE FAILURE MILEAGE WAS APPROXIMATELY 52,020.

2012 FIAT. CONSUMER WRITES IN REGARDS TO MANUAL TRANSAXLE CLUTCH PEDAL FAILURE. *LD THE CONSUMER STATED WHILE DRIVING THE CLUTCH FAILED, ALMOST CAUSING AN ACCIDENT. THE CONSUMER STATED THE VEHICLE WAS REPAIRED. THE CONSUMER WAS REIMBURSED FOR THE RECALL REPAIRS, BUT STATED THERE WERE REPAIR COSTS THAT STILL NEEDED TO BE REIMBURSED. *JS

The contact owns a Cybex Car Seat, Model Name: Aton 2, Manufactured Date: Aug 2019. The car seat was used in a 2012 Fiat 500. The contact received notification of NHTSA Campaign Number: 23C001000 (Child Seat). The contact reached out to the manufacturer to have a replacement seat mailed out; however, the contact was not provided the replacement car seat. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT WHILE HIS WIFE WAS INSTALLING THE CAR SEAT INSIDE THE VEHICLE, THE SEATBELT DETACHED FROM THE SEAT ON THE REAR DRIVER'S SIDE OF THE VEHICLE. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE CONTACT 'S WIFE WAS WAITING TO SPEAK WITH A SUPERVISOR. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2012 FIAT 500. THE CONTACT STATED THAT WHILE DRIVING AT 25 MPH, THE PASSENGER'S SIDE DOOR UNLATCHED AND BECAME AJAR WITHOUT WARNING. THE CONTACT PULLED OVER AND SECURELY LOCKED THE DOOR AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO NYLE MAXWELL FIAT (13049 RESEARCH BLVD, AUSTIN, TX 78750 (512) 228-3428) WHERE IT WAS DIAGNOSED AND DETERMINED THAT THE DOOR LATCH NEEDED TO BE REPAIRED OR REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,700.

FRONT SEAT MECHANISM WILL NOT OPERATE, OCCUPANTS CAN NOT GET OUT OF CAR ON DRIVER'S SIDE BECAUSE THE SEAT MECHANISM DOES NOT WORK AND THE BACK OF THE SEAT DOES NOT FLIP FORWARD

REALLY COLD MORNING, UPON STARTING, THE TPMS REPORTED THE LEFT FRONT TIRE LOW ON PRESSURE. AND TIRE LIGHT STAYED ON. I HAD ALL 4 TIRES CHECKED AND FILLED TO SPECS, CONTINENTAL TIRES, BUT THE TIRE LIGHT STAYED ON FOR THE NEXT DAY AND A HALF, WHEREIN I DROVE ABOUT 65 MILES, AND TURNED THE CAR ON/OFF NUMEROUS TIMES. (AT WORK, STORE, OVERNIGHT, ETC.) THE TIRE PLACE THAT I TOOK THE CAR TOO TO HAVE THE AIR CHECKED, WAS UNABLE TO DETERMINE HOW TO RESET THE TPMS. THERE WAS NOTHING OUT ABOUT THIS CAR YET. (FYI, YOU CAN USE A CHRYSLER RESET UNIT) THE TIRE LIGHT FINALLY WENT OUT THE NEXT DAY ON IT'S OWN ON THE WAY HOME FROM WORK. WENT TO THE FIAT DEALERSHIP A FEW DAYS LATER TO FIND OUT HOW TO RESET THE TPMS IF/WHEN IT HAPPENS AGAIN. THE SERVICE MANAGER CHECKED IT OUT. LET AIR OUT UNTIL THE LIGHT CAME ON, THEN FILLED IT TO THE CORRECT PRESSURE, THEN DROVE IT ABOUT 50 FEET, AND THE TPMS LIGHT RESET ITSELF. SO, THE SYSTEM APPEARS TO OPERATING PROPERLY NOW AFTER WHAT I HAD OBSERVED. WILL WATCH TO SEE IF IT BECOMES A PROBLEM. *TR