2009 Fleetwood American Eagle Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2009 Fleetwood American Eagle, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine133.3%
- Other / unspecified133.3%
- Suspension133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
EXCESSIVE HEAT FELT IN FLOOR AREA AND IN THE BACK ROOM OF THE MOTORHOME. INSPECTION OF THE EXHAUST PIPE REVEALED THAT IT WAS COMPLETELY BROKEN OFF FROM THE ATTACH CLAMP AT THE MUFFLER, ALLOWING EXHAUST TO VENT DIRECTLY UNDER MOTORHOME FLOOR AND APPROXIMATELY 12 INCHES FROM FUEL AND HYDRAULIC FILTERS AND LINES. HEAT WAS DETECTED WHILE MOTORHOME WAS BEING DRIVEN ON HIGHWAY AT HIGHWAY SPEEDS. THE PHOTOS SHOW WHERE THE PIPE BROKE AND SPEWED VERY HOT BLACK EXHAUST FROM THE TURBOCHARGER OVER THE PIPE STILL ATTACHED TO THE MUFFLER. PHOTOS ALSO SHOW RELATIONSHIP OF HOT EXHAUST TO FUEL AND HYDRAULIC OIL FILTERS AND SUPPLY LINES.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
2007 FLEETWOOD AMERICAN ALLEGIANCE FRONT AXLE PROBLEM. *BF THE CONSUMER STATED THE DESIGN AND CERTIFIED RATING OF THE FRONT AXLE WAS NOT SUFFICIENT TO ALLOW FOR THE USUAL AND INTENDED USE OF THE MOTORHOME. THE CONSUMER WAS INFORMED BY AN ENGINEER THAT THE AXLE SYSTEM WOULD BE UPGRADED ONCE A SOLUTION HAD BEEN OBTAINED. THE FRONT AXLE HAS A DESIGN AND CERTIFICATION LOAD RATING OF 14,600 POUNDS. WITH THE MOTORHOME LOADED AS SPECIFIED IN THE FLEETWOOD OWNER'S MANUAL, THE FRONT AXLE IS OVERLOADED WITHOUT CARGO. THE LOADING INCLUDES FULL FUEL, FRESH WATER TANKS, EMPTY WASTE WATER TANKS, TWO PEOPLE HAVING A COMBINED WEIGHT OF 308 POUNDS AND ZERO CARGO. THE TOTAL WEIGHT UNDER THOSE CONDITIONS, AS WEIGHED, IS 39,000 POUNDS WITH A DESIGN RATING OF 44,600. THEREFORE, THE CONSUMER SHOULD BE ABLE TO CARRY OVER 5,000 POUNDS OF CARGO. NONE OF THE DESIGNED CAPACITIES CAN BE ATTAINED WITH THE PRESENT FRONT AXLE CONFIGURATION.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
2007 FLEETWOOD AMERICAN ALLEGIANCE FRONT AXLE PROBLEM. *BF THE CONSUMER STATED THE DESIGN AND CERTIFIED RATING OF THE FRONT AXLE WAS NOT SUFFICIENT TO ALLOW FOR THE USUAL AND INTENDED USE OF THE MOTORHOME. THE CONSUMER WAS INFORMED BY AN ENGINEER THAT THE AXLE SYSTEM WOULD BE UPGRADED ONCE A SOLUTION HAD BEEN OBTAINED. THE FRONT AXLE HAS A DESIGN AND CERTIFICATION LOAD RATING OF 14,600 POUNDS. WITH THE MOTORHOME LOADED AS SPECIFIED IN THE FLEETWOOD OWNER'S MANUAL, THE FRONT AXLE IS OVERLOADED WITHOUT CARGO. THE LOADING INCLUDES FULL FUEL, FRESH WATER TANKS, EMPTY WASTE WATER TANKS, TWO PEOPLE HAVING A COMBINED WEIGHT OF 308 POUNDS AND ZERO CARGO. THE TOTAL WEIGHT UNDER THOSE CONDITIONS, AS WEIGHED, IS 39,000 POUNDS WITH A DESIGN RATING OF 44,600. THEREFORE, THE CONSUMER SHOULD BE ABLE TO CARRY OVER 5,000 POUNDS OF CARGO. NONE OF THE DESIGNED CAPACITIES CAN BE ATTAINED WITH THE PRESENT FRONT AXLE CONFIGURATION.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .