Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 1995 Ford Aerostar submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 11 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
ON OUR IGNITION KEY TURN THE IGNITION CAN BE TURNED ON WITHOUT A KEY IN IT AND IT ROTATES ROUND AND ROUND. ON OUR SLIDING DOOR THE SCREWS KEEP FALLING OUT @ THE DOOR KEEPS COMING OFF TRACK AND IT ALWAYS SHOWS DOOR AJAR. I THINK THIS IS UNSAFE AND BOTH NEED A RECALL ON THEM. *AK
SLIDING DOOR INSIDE PANEL HAD LOOSE SCREWS. THIS CAUSED THE PANEL TO DEPRESS THE LOCK SWITCH. IT WOULD JAM & COULD NOT BE OPENED FROM THE INSIDE. COULD OPEN FROM OUTSIDE WITH REMOTE CONTROL. SCREWS FOR THE PANEL WERE REPLACED BY OWNER. HAD NOT TAKEN VEHICLE TO DEALER TO CHECK PANEL. *AK
ELECTRICAL MALFUNCTION/SHORT BEHIND THE DASH WHICH CAUSES THE LIGHTS TO GO OUT AT TIMES WHEN THE DOOR ADJAR LIGHT COMES ON. *MJS
UPON STARTING OF VEHICLE IN PARKING LOT, A BURNING SMELL AND THEN SMOKE CAME OUT OF THE DRIVER SIDE DOOR. IMMEDIATELY TURNED VEHICLE OFF AND EXITED. VEHICLE TOWED TO DEALERSHIP. PREVIOUSLY INCIDENTS HAVE BEEN REPORTED TO NHTSA ON 2 OTHER OCCASIONS, BUT STILL NO RECALL. FORD HAS ASSUMED NO RESPONSIBILITY FOR THIS! *AK
I ALREADY SUBMITTED THIS FORM EARLIER TODAY, BUT I REALIZED I MADE SOME ERRORS ON THE FORM SO HERE IS AN UPDATED FORM WITH THE CORRECT INFORMATION. AS I EXPLAINED ON THE FIRST FORM, THERE ARE TWO RELATED PROBLEMS WHICH HAVE BEEN OCCURRING WITH OUR FORD AEROSTAR MINI VAN. THE FIRST PROBLEM IS THAT THE SLIDING SIDE DOOR DOES NOT CLOSE PROPERLY BECAUSE THE DOOR GUIDE-TRACK IS DEFECTIVE AND HAS BROKEN AT THE POINT WHERE IT ATTACHES TO THE VEHICLE BODY BEHIND THE LATCH STRIKE-PIN. WE HAD THIS REPAIRED IN DECEMBER OF 1998, BUT IT HAS BROKEN AGAIN ONLY 15 MONTHS AFTER THE FIRST REPAIR. THE OTHER PROBLEM IS FAILURE OF THE ELECTRICAL SYSTEM, WHICH IS RELATED TO THE DOOR DEFECT, BECAUSE SOMETIMES WHEN THE DOOR IS NOT LATCHED PROPERLY, THE DOOR-AJAR LIGHT COMES ON AND MAKES A TERRIBLE GRATING/BUZZING NOISE AND AT THE SAME T IME CAUSES ALL THE ELECTRICAL SYSTEMS TO FAIL. THE TURN SIGNALS, WINDSHIELD WIPERS, FAN , RADIO, ETC ALL FREEZE-UP. THIS HAS HAPPENED TWICE WHILE DRIVING, AND TWICE THE IGNITION FROZE AND I COULD NOT START THE VAN. I HAD TO TURN OFF THE KEY AND RESTART IT TO GET EVERYTHING WORKING AGAIN. THESE ELECTRICAL FAILURES ARE CLEARLY LINKED TO THE SLIDING DOOR PROBLEM BECAUSE THE ONLY OCCUR WHEN THE DOOR-AJAR LIGHT IS FLASHING AND MAKING THAT GRATING SOUND WHEN THE DOOR IS NOT PROPERLY CLOSED. *AK
THE REAR CROSS MEMBER THAT SUPPORTS THE ENGINE/TRANSMISSION AND TRANSFER CASE SAGS DOWN ABOUT 1 INCH OR MORE, CAUSING THE STEEL BOLT TO REST ON THE STEEL FRAME. THE ORIGINAL SUPPORT BAR FAILED ALONG WITH 2 REPLACEMENT BARS. THE OWNER IS EXPERIENCING THE PROBLEM AGAIN. THE REPLACED PART DOES NOT CORRECT THE PROBLEM. REPLACEMENT PART # FMCF09Z6A023C. *AK CONSUMER STATES THAT THIS PART IS DEFECTIVE AND IT CAN NOT SUPPORT THE WEIGHT OF THE ENGINE, TRANSMISSION, AND THE TRANSFER CASE, THE SOFT RUBBER GROMETS ON EACH SIDE WILL SAG UNTIL THE STEEL BOLT RESTS ON THE STEEL SUPPORT. *SLC
SLIDING DOOR NOT CLOSING PROPERLY DUE TO FAILURE OF THE DOOR TRACK.
NO ALARM FOR THE SIDE DOOR ENTRY. SIDE DOORS CANNOT BE OPENED WITH A KEY. WHEELCHAIR TIE DOWN SYSTEM IS INSTALLED SIDEWAYS--SHOULD BE FACING FORWARD.
DOOR AJAR WARNING BUZZER INOPERATIVE. *AW
TRIM RATTLES. *TT
PURCHASE VAN BRAND NEW AND FOUND THAT VAN BODY DAMAGE. TT
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .