1996 Ford Aspire Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1996 Ford Aspire, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes820.5%
- Airbags615.4%
- Electrical512.8%
- Transmission410.3%
- Visibility37.7%
- Fuel system37.7%
- Suspension37.7%
- Steering25.1%
- Seat belts25.1%
- Engine12.6%
- Tires & wheels12.6%
- Other / unspecified12.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
DT*: THE CONTACT STATED WITHOUT WARNING THE BRAKES AND STEERING FAILED, WHILE DRIVING 5-10 MPH. THE VEHICLE RAN INTO A BRICK WALL AND THERE WAS DAMAGE TO THE FRONT END OF THE VEHICLE. THERE WAS A POLICE REPORT TAKEN AT THE SCENE AND THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE HAS NOT BEEN INSPECTED BY A MECHANIC. ALSO, AT 14,000 MILES WHILE DRIVING 15 MPH THE VEHICLE STOPPED. THE ENGINE WAS STILL ON, BUT THE VEHICLE WOULD NOT MOVE. THE DEALERSHIP DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED. THIS HAPPENED AGAIN AT 40,000 MILES AND THE TRANSMISSION WAS REPLACED BY THE DEALERSHIP. AT 55,000 MILES THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR THE SAME PROBLEM AND THE TRANSMISSION WAS REBUILT. THE TRANSMISSION WAS REBUILT A FINAL TIME AT 65,000 MILES. THERE HAVE BEEN NO FURTHER PROBLEMS WITH THE TRANSMISSION.
FRONT WHEELS VIBRATE ON HIGHWAY, DUE TO POSSIBLE FAULTY RIMS. YH
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
THE DRIVER LOST CONTROL OF THE VEHICLE WHEN THE RIGHT WHEEL HIT A GRAVEL PATCH AND SLID INTO A EMBANKMENT. THE DRIVER SIDE AIR BAG DIDN'T DEPLOY. *NLM
AIRBAG LIGHT HAS BEEN FLASHING, NOT TAKEN TO DEALER YET.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
IGNITION SWITCH WAS REPLACED ON JANUARY 4, 1999. CONSUMER WAS UNABLE TO GET KEY OUT OF IGNITION. KEY WAS STUCK IN THE ON POSITION.
MY ASPIRE EXHIBITED A NUMBER OF COMPONENT FAILURES, AND I CONSIDER MYSELF LUCKY NOT TO HAVE BEEN INJURED BY THEM. IN THE FIRST INSTANCE, THE DISTRIUBUTOR FAILURE OCCURRED AS I ENTERED AN INTERSECTION, AND AS A RESULT THE CAR STALLED AT THE LIGHT NOT IN THE TRAFFIC LANE. IN THE SECOND INSTANCE, THE STEERING COMPONENT FAILURE OCCURRED ON THE HIGHWAY RESULTING IN SIGNIFICANT VIBRATION BUT I WAS ABLE TO CONTROL THE CAR AND TAKE IT INTO THE DEALER FOR REPAIRS. IN THE THIRD INSTANCE, THE FUEL PUMP FAILURE CAUSED THE CAR NOT TO START, BUT FROM WHAT I UNDERSTAND, THE PART COULD HAVE FAILED DURING OPERATION AND COULD HAVE CAUSED A STALL. I CONSIDER MYSELF LUCKY. DISAPPOINTED IN THE ASPIRE, BUT LUCKY. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
DT*: THE CONTACT STATED WITHOUT WARNING THE BRAKES AND STEERING FAILED, WHILE DRIVING 5-10 MPH. THE VEHICLE RAN INTO A BRICK WALL AND THERE WAS DAMAGE TO THE FRONT END OF THE VEHICLE. THERE WAS A POLICE REPORT TAKEN AT THE SCENE AND THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE HAS NOT BEEN INSPECTED BY A MECHANIC. ALSO, AT 14,000 MILES WHILE DRIVING 15 MPH THE VEHICLE STOPPED. THE ENGINE WAS STILL ON, BUT THE VEHICLE WOULD NOT MOVE. THE DEALERSHIP DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED. THIS HAPPENED AGAIN AT 40,000 MILES AND THE TRANSMISSION WAS REPLACED BY THE DEALERSHIP. AT 55,000 MILES THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR THE SAME PROBLEM AND THE TRANSMISSION WAS REBUILT. THE TRANSMISSION WAS REBUILT A FINAL TIME AT 65,000 MILES. THERE HAVE BEEN NO FURTHER PROBLEMS WITH THE TRANSMISSION.
TRANSMISSION FAILED COMPLETLY AS DRIVER WAS MAKING A LEFT TURN AT AN INTERSECTION. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WHILE PASSENGER'S SIDE WINDOW WAS ROLLED DOWN IT EXPLODED. ALSO, DRIVER'S SIDE WINDOW EXPLODED PRIOR TO THIS. MANUFACTURER HAS BEEN NOTIFIED. *AK
WINDSHIELD WIPER LINKAGE PIVOT ASSEMBLY MALFUNCTIONED, CAUSING THE WINDSHIELD WIPERS TO FAIL 3 TIMES IN THE LAST 18 MONTHS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
CAR SMELLS LIKE GASOLINE MOST OF THE TIME INSIDE. DEALER CONTACTED, AND CANNOT REMEDY THE PROBLEM. PROBLEM STILL EXISTS. PROBLEM FURTHER INFORMATION. *AK
THE VEHICLE EXPERIENCED A GAS SMELL AND VAPOR THROUGHOUT THE VEHICLE WHICH MAY CAUSE A FIRE IFIT IS A SOURCE OF IGNITION. DEALER CANNOT DETERMINE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
WHILE DRIVING THE VEHICLE PULLS TO LEFT. DRIVER CANNOT CONTROL THIS PROBLEM. THIS PROBLEM HAS BEEN HAPPENING SINCE THE VEHICLE WAS BOUGHT AND THAT WAS IN 1996. DEALER SAID THAT THE CASTER IS NOT ADJUSTABLE TO THE VEHICLE SO THEY CANNOT FIX THE VEHICLE.. *AK
STEERING WHEEL SHIMMIES WHILE DRIVING. THIS ALSO OCCURS WHILE DRIVING AROUND CORNERS. DEALERS HAVE NOT BEEN ABLE TO CORRECT PROBLEM. OWNER IS VERY CONCERNED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
DT*: THE CONTACT STATED WITHOUT WARNING THE BRAKES AND STEERING FAILED, WHILE DRIVING 5-10 MPH. THE VEHICLE RAN INTO A BRICK WALL AND THERE WAS DAMAGE TO THE FRONT END OF THE VEHICLE. THERE WAS A POLICE REPORT TAKEN AT THE SCENE AND THE VEHICLE WAS TOWED TO THE CONTACT'S HOME. THE VEHICLE HAS NOT BEEN INSPECTED BY A MECHANIC. ALSO, AT 14,000 MILES WHILE DRIVING 15 MPH THE VEHICLE STOPPED. THE ENGINE WAS STILL ON, BUT THE VEHICLE WOULD NOT MOVE. THE DEALERSHIP DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED. THIS HAPPENED AGAIN AT 40,000 MILES AND THE TRANSMISSION WAS REPLACED BY THE DEALERSHIP. AT 55,000 MILES THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR THE SAME PROBLEM AND THE TRANSMISSION WAS REBUILT. THE TRANSMISSION WAS REBUILT A FINAL TIME AT 65,000 MILES. THERE HAVE BEEN NO FURTHER PROBLEMS WITH THE TRANSMISSION.
MY ASPIRE EXHIBITED A NUMBER OF COMPONENT FAILURES, AND I CONSIDER MYSELF LUCKY NOT TO HAVE BEEN INJURED BY THEM. IN THE FIRST INSTANCE, THE DISTRIUBUTOR FAILURE OCCURRED AS I ENTERED AN INTERSECTION, AND AS A RESULT THE CAR STALLED AT THE LIGHT NOT IN THE TRAFFIC LANE. IN THE SECOND INSTANCE, THE STEERING COMPONENT FAILURE OCCURRED ON THE HIGHWAY RESULTING IN SIGNIFICANT VIBRATION BUT I WAS ABLE TO CONTROL THE CAR AND TAKE IT INTO THE DEALER FOR REPAIRS. IN THE THIRD INSTANCE, THE FUEL PUMP FAILURE CAUSED THE CAR NOT TO START, BUT FROM WHAT I UNDERSTAND, THE PART COULD HAVE FAILED DURING OPERATION AND COULD HAVE CAUSED A STALL. I CONSIDER MYSELF LUCKY. DISAPPOINTED IN THE ASPIRE, BUT LUCKY. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
CONSUMER STATES THAT THE LEFT REAR SAFETY BELT DOES NOT STAY SECURELY FASTENED, A CHILD CAN EASILY PULL BELT TO RELEASE.*AK
WHEN THE DRIVER'S SEAT BELT RETRACTED IT SHATTERED THE WINDOW , CAUSING MINOR INJURIES TO THE DRIVER. DEALER WILL BE NOTIFIED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE CUT OFF WHILE DRIVING DRIVER GOT OUT OF VEHICLE AND FLAMES WERE COMING FROM UNDER THE HOOD. DEALER HAS THE VEHICLE NOW. THE PROBLEM HAS NOT BEEN CORRECTED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
ROTORS AND PADS EXPERIENCED EXCESSIVE WEAR, ROTORS WERE WARPED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
FRONT WHEELS VIBRATE ON HIGHWAY, DUE TO POSSIBLE FAULTY RIMS. YH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .