1992 Ford Bronco Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1992 Ford Bronco, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes918.8%
- Body & structure714.6%
- Fuel system612.5%
- Electrical510.4%
- Tires & wheels48.3%
- Engine48.3%
- Visibility36.3%
- Transmission36.3%
- Interior & seats24.2%
- Exterior lighting12.1%
- Airbags12.1%
- Powertrain (other)12.1%
- Steering12.1%
- Suspension12.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE PARKING BRAKE DID NOT HOLD THE VEHICLE. THE CONSUMER LOOKED ON NHTSA SITE AND DISCOVERED A RECALL (94V-169001) FOR THE SAME PROBLEM. THE CONSUMER CONTACTED A LOCAL DEALER WHO INDICATED THE CONSUMERS VEHICLE WAS NOT INCLUDED DUE TO VIN. *NLM *NLM
CONSUMER IS HAVING THE SAME DEFECT WITH THERE VEHICLE'S EMERGENCY PARKING BRAKES, AS STATED IN RECALL NUMBER 94 V 169 000 BUT THERE VIN NUMBER IS NOT INCLUDED. PH
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
TAILGATE RUSTS EXCESSIVELY, AND IT IS THE ONLY PART OF THE CAR TO DO SO.
I DONT KNOW IF RECALL IS STILL VALID, DEALER DOES NOT SHOW ON COMPUTER. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL TANK DEVELOPED LEAKS DUE TO RUST CAUSED BY WATER TRAPPED BETWEEN BRUSH GUARD AND TANK BOTTOM. BRUSH GUARD DESIGNED WITHOUT HOLES TO ALLOW WATER TO DRAIN PROPERLY THUS TRAPPING WATER BETWEEN THE GUARD AND TANK BOTTOM. *NLM
VEHICLE STALLS LIKE A VAPOR LOCK IN MIDDLE OF TRAFFIC. SOMETHING TELLS THE CAR THAT IT OVERHEATING AND IT WILL JUST STOP RUNNING.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WINDOW MOTOR/BUFFER WIND MECH HAS FAILED TWICE. DEALER NOTIFIED AND THEN MANUFACTURER. HAD TO "FIGHT" FFOR THE REPLACEMENT UNDER WARRANTY THE FIRST TIME. HAD TO "FIGHT" W/ FOMOCO IN ADDITION. HAS FAILED FOR SECOND TIME, THREE MONTHS AGO. ALONG W/ A/C. A/C 1200.00 WINDOW 210.00
VEHICLE EXPERIENCED AN ELECTRICAL FIRE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
REPLACEMENT TIRES ON A FORD, BRONCO 1992, VNHL P23575R15. TWO FRONT TIRES HAVE CRACKS GOING ALL THE WAY AROUND. TOOK TO MECHANIC, AND HE SAID THAT TREAD WAS ABOUT TO SEPARATE. *AK
THE FRONT BRAKES WERE REPLACED FOUR TIMES, METALLIC DISC PADS WERE INSTALLED, AND ROTORS WERE REPLACED, RESURFACED, AND MACHINED. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
THE FRONT BRAKES WERE REPLACED FOUR TIMES, METALLIC DISC PADS WERE INSTALLED, AND ROTORS WERE REPLACED, RESURFACED, AND MACHINED. *SLC
MUFFLER MALFUNCTIONED, ALSO REPLACED POWER DOOR LOCKS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
OWNED 5 BRONCO'S AND 3 OUT OF THE 5 ALL HAD A GAS TANK LEAKAGE PROBLEM. THIS SHOULD BE INVESTIGATED.
WINDOW MOTOR/BUFFER WIND MECH HAS FAILED TWICE. DEALER NOTIFIED AND THEN MANUFACTURER. HAD TO "FIGHT" FFOR THE REPLACEMENT UNDER WARRANTY THE FIRST TIME. HAD TO "FIGHT" W/ FOMOCO IN ADDITION. HAS FAILED FOR SECOND TIME, THREE MONTHS AGO. ALONG W/ A/C. A/C 1200.00 WINDOW 210.00
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
ABOUT TWO MONTHS AGO MY TRANSMISSION WENT OUT IN MY 92 FORD BRONCO ON MY WAY TO WORK WITH A CO-WORKER WITH ME, I WAS PULLING UP TO A RED LIGHT AND WENT TO DOWNSHIFT TO FIRST BUT IT WASN'T THERE, TRIED SECOND NOT THERE EITHER,I HAS TO GIMP ME BRONCO HOME IN THIRD GEAR THERE BY SMOKING AND BURNING UP THE CLUTCH,AFTER GETTING THE POS(PIECE OF ?!@#$%) HOME I CALLED A FEW SHOPS AND FOUND THIS TO BE A COMMON PROBLEM WITH ALL FORD TRUCKS USING A MAZDA MANUAL TRANSMISSION,BEING A MECHANIC MYSELF I PROCEEDED TO BUY A REBUILT TRANSMISSION AND INSTALL IT MYSELF, NOW IT IS OUT AGAIN WITH THE SAME PROBLEM NO FIRST OR SECOND. NOW UNTIL I BOUGHT THIS POS I HAVE ALWAYS BEEN A FORD MAN BUT NOW I DON'T KNOW WHAT MANUFACTURER TO TRUST, CHEVY HAS PROBLEMS WITH THEIR BLAZER TRANSMISSIONS TOO. I BOUGHT THIS CAR USED WITH LESS THAN A HUNDRED THOUSAND ON THE ODOMETER AND FOUND THAT THE TRANSMISSION WAS NOT ORIGINAL WHEN I CHANGED IT LAST TIME NOW AFTER I FIX IT I WILL SELL IT A DRIVE IT THROUGH THE LOCAL FORD DEALERSHIP SHOW ROOM,MAYBE THAT WOULD MAKE THEM ANSWER FOR ALL THE PROBLEMS EVERYONE HAS WITH THESE PROBLEMS. MAYBE WHAT MY BROTHER SAYS IS TRUE FORD MEANS F%*@ED OVER REBUILT DODGE. *JB
OWNED 5 BRONCO'S AND 3 OUT OF THE 5 ALL HAD A GAS TANK LEAKAGE PROBLEM. THIS SHOULD BE INVESTIGATED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
BOTH DOORS WILL NOT OPEN FROM INSIDE FIRST PASSENGER SIDE, MONTHS LATER DRIVER'S SIDE. *AK
PARKING BRAKE OPERATION INTERMITTENT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
HEADLIGHTS GO OFF WHEN MAKING TURN. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
WHILE DRVING 35 MPH HAD A DIRECT FRONTAL IMPACT AND THE DRIVER'S AIRBAG DID NOT DEPLOY WHICH DID NOT PROTECT THE OCCUPANT IN ACCIDENT. NO PRIOR PROBLEM WITH THE AIRBAG. CAUSE UNKNOWN, PLEASE PROVIDE DETAILS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
BRAKE AND TRANSMISSION FAILURE, FOUR WHEEL DRIVE MALFUNCTION, AND AN INACCURATE SPEEDOMETER.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
AFTER STARTING THE VEHICLE, SMOKE STARTED COMING OUT OF THE STEERING COLUMN. PLEASE DESCRIBE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
THE FRONT BRAKES WERE REPLACED FOUR TIMES, METALLIC DISC PADS WERE INSTALLED, AND ROTORS WERE REPLACED, RESURFACED, AND MACHINED. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .