2025 Ford Bronco Driver assistance Problems

Flat towing a 2025 Bronco behind a 2025 Newmar Dutchstar using a Blue Ox tow bar with Demco AirForce Braking System. Ford has a setting called neutral towing. It allows you to tow behind a motorhome with brake lights, braking, etc. When the Ford is in neutral tow, and in neutral gear, all 4 wheel roll freely and you can tow safely. What's happening is the Ford is waking up out of neutral tow when the 12V battery gets low. This isn't supposed to happen as there is a 7 Pin electrical connector from the motorhome to the 6 pin electrical connected to the Bronco. Once the 12v battery gets low, the Ford computer wakes up, see's it moving the back tow tires, so the system is applying the emergency brake locking up the 2 back tires. This has now happened three times as we have traveled from [XXX] to [XXX] (had it looked at Crossroads of Ford of Apex where I bought it). I took it in to Schmop Ford in Denver and after almost a deadly accident on XXX near [XXX], to XXX. They found the back two tires destroyed. Ford replaced the tires at no charge, but the issue remains. THIS SUV SHOULD NOT BE APPROVED FOR FLAT TOWING. It is dangerous and could be deadly. You have no way of knowing unless someone else tells you. Thanks to the stranger on XXX on XXX. They told us of our issue so we pulled over. If we were to continue driving the motorhome, the tires would've been totally destroyed, a fire, or cause us to flip over. There are so many complaints on the internet about this issue. You must make Ford fix this issue with a software fix immediately. Don't make my complaint for another unlucky traveler like myself. I have enclosed the back tire picture. You can see one tire with the tread completely gone, the other tire tread missing is not shown. You can also see how the tires are mis-shaped from rubbing across the highway cement. I AM TRYING TO UPLOAD PICTURES BUT YOUR SYSTEM IS GIVING ME AN ERROR FOR A JPEG LESS THAN 10MB INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11753632

Incident

Jul 28, 2026

Car would shut off shortly after using remote start on key fob then display a warning on digital instrument cluster for two days now. It would also show my speed going back and forth from 0 to 1mph while parked.

NHTSA ID

11741856

Incident

Jun 2, 2026

The Pre-Collision Assist false-triggers on turns daily, flashing the red collision warning and actively applying autonomous emergency braking without any obstruction present. This phantom braking is a severe safety hazard. The vehicle has been serviced before for this issue - and is going back to the shop next week (for the same issue).

NHTSA ID

11741790

Incident

Jun 2, 2026

Sunday April 19 2026, in a drive thru while stopped, the following alerts popped up with their corresponding dash lights: Check Brake System Park Brake limited service function Pre-collision assist not available Service Advance Track Brake pedal lost vacuum / pressure and became hard. Brake would not engage and needed to use electric park brake to stop vehicle. Got out of the drive thru and into an empty parking lot. I tried accelerating and then stopping but vehicle would not stop while pressing the brake. Used e brake again to stop. I turned vehicle off and back on. All errors did not pop up again and there were no lights on the dash. While driving home less then a mile from original incident location, the same errors and brake failure occurred while going 30+ miles per hour. Same issue with a hard brake pedal occurred. This time, if brake pedal was depressed far enough, the e brake would engage but only the rear wheels would lock up and vehicle would skid/slide in order to slow down. I have video recordings of these incidents. Brake system failed as vehicle lost ability to brake at low and high speeds. The loss of brakes could result in a car crash and deaths. The vehicle has been towed to a ford dealer and they are in possession of the vehicle. They are currently investigating the issue. The vehicle has not been inspected by manufacturer or authority agency. There were no warning lamps, messages, or symptoms prior to the brake system failing. The brakes worked normally and then suddenly failed.

NHTSA ID

11732854

Incident

Apr 19, 2026

The contact owns a 2025 Ford Bronco. The contact was made aware by the Turo App that the VIN was associated with NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was not yet available. The dealer was contacted. The vehicle was not diagnosed or repaired. The dealer confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure.

NHTSA ID

11729064

Incident

Apr 3, 2026

The contact owns a 2025 Ford Bronco. The contact received notification of NHTSA Campaign Number: 26V124000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted and confirmed that the part was not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11724861

Incident

Mar 4, 2026

The contact owns a 2025 Ford Bronco. The contact was made aware of NHTSA Campaign Number: 26V124000 (BACK OVER PREVENTION) after contacting the manufacturer. The contact had recently purchased the vehicle and was not informed about the recall. The contact became aware afterwards that the part was not yet available. The local dealer was contacted. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11723822

Incident

Mar 12, 2026

Loss of braking. Note weather was cold in single digits Fahrenheit and midly snowy. I drove my 2025 Ford Bronco that was purchased in Octorber about 20 minutes to drop off my child at daycare. Going into the daycare I turned to Slippery/4A mode. After about 5 minutes inside I pulled out and switched back to Normal/2H mode. Less than half a mile later I got multiple warnings that the brakes, EBB, collision detect, and ABS had faulted, and I should service now. I only had the electronic parking brake available. I was able to use it and engine braking with my manual transmission to get to off the road to a parking lot, although I did also receive a parking brake overheat fault the turn before getting into the parking lot. I shut the vehicle off without the parking brake on. I turned it back on and the dash warning lights all disappeared after a few seconds. Brake function returned and I drove it to a Ford service center about 1 mile away. They were not able to reproduce the problem or find any DTCs. I did get notifications of some of the faults to my Ford app on my phone. I am uploading the redacted RO and screenshots of the Ford notifications. Losing braking obviously put myself and my passenger pregnant wife at risk. Thankfully I was moving at lower speeds on a flat section of road and not taking a highway exit at the time of failure.

NHTSA ID

11714693

Incident

Jan 28, 2026

While slowly backing into our home garage, the vehicle accelerated brakes were not working and smashed into the side of the house, put the car in drive to move it. It accelerated forward over correcting and drove into our power box and came to a halt. No brakes were working and the wheels/steering locked up.

NHTSA ID

11711063

Incident

Jan 15, 2026

Accident Statement – Instrument Panel Cluster Failure & Collision While driving my 2025 Ford Outerbanks, the Instrument Panel Cluster (IPC) screen suddenly went completely black without warning. At the time of the malfunction, I was attempting to merge into traffic on my left with my left turn signal activated. Simultaneously, an 18-wheeler in the lane beside me was merging to his right. The sudden loss of my IPC screen meant I could not see my speedometer, warning indicators, safety messages, or any visibility cues needed to safely judge traffic speed and spacing. This created an immediate hazardous situation and made it extremely difficult to manage both my own speed and the surrounding traffic patterns. As I recognized the danger, I attempted to brake and avoid a collision. During this moment, my steering wheel began to shake slightly—possibly due to the lane-keeping or lane-safety system responding. Despite my efforts to correct and avoid impact, the 18-wheeler collided with my vehicle. At the time of the crash, I had no visibility of any dashboard warnings, alerts, vehicle speed, or safety notifications due to the IPC failure. My insurance representative has inspected my vehicle and deemed it a total loss.

NHTSA ID

11703800

Incident

Nov 30, 2025

The display panel for the speedometer and gas would not work or display anything.

NHTSA ID

11692761

Incident

Oct 11, 2025

I was driving the vehicle on high mountain pass roads in Colorado. Anytime I would approach approximately 11,400 feet of elevation. The vehicle would instantly lose all power with no warning lights of any kind. All gauges were in the normal operating range. Vehicle would barely move 2 mph. Created a very unsafe condition on narrow steep dirt roads in the mountains. As soon as I turned around and descended approximately 100 feet in elevation the power came back instantly and vehicle operated normally. This happened on three occasions. The roads we were on were narrow, off-road vehicle mountain roads, and it created an extremely dangerous situation. I contacted Ford and they have not heard of this issue and there are no recalls associated with it. I spoke to a Ford bronco ambassador, who was also on the trail system with a lot of other off-road vehicles, including Broncos and they had never heard of this happening . This vehicle is Six months old. Ford says there are no codes set on my computer and since they cannot duplicate this where I live in Phoenix because there are no roads high enough I don’t know where to turn.

NHTSA ID

11685755

Incident

Sep 7, 2025

Repeated cross traffic alert and blind spot alert fault message.

NHTSA ID

11681145

Incident

Aug 17, 2025