2015 Ford E-150 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2015 Ford E-150, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Driver assistance225.0%
- Engine225.0%
- Brakes112.5%
- Electrical112.5%
- Powertrain (other)112.5%
- Visibility112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2015 FORD E-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE DECELERATED ON ITS OWN. THE FAILURE RECURRED DURING THE 1,100 MILE ROAD TRIP. THE VEHICLE HAD JUST BEEN REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V614000 (FORWARD COLLISION AVOIDANCE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE NEEDED TO BE REPROGRAMMED. THE FAILURE MILEAGE WAS 4,000.
AS REPORTED TO DEALER : CUSTOMER STATES WHEN ACCELERATING IN LOW GEAR AND LETTING OFF THE ACCELERATOR IT WILL CONTINUE TO MAINTAIN THE RPM UNTIL YOU HIT HARD ON THE BRAKES. MY ADDED COMMENTS IS THAT 1800 RPM WHEN NORMAL HIGHWAY SPEED IS OVER 60 MPH. IN STOP AND GO TRAFFIC THE DRIVER MUST MAINTAIN BRAKE WITH LEFT FOOT AND GAS WITH RIGHT FOOT OR YOU WILL REAR END THE CAR IN FRONT OF YOU. PS DEALER PERFORMED TEST AND STATED AT THIS TIME COMPARED TO LIKE UNITS AND THEY DO THE SAME THING. I TEST DROVE A NEW TRUCK WITH SAME ENGINE AND TRANS. AS MINE AND IT DID NOT DO THE SAME THING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
UNEXPECTED AND RANDOM LOSS OF POWER --- HAVE TO RESTART TO GAIN POWER OCCURRED 7 TIMES ON 6/27/17 ON A 45 MILE ROUND TRIP ERRORS ON SCREEN HAPPENED TWO TIME ON 6/28 ON 4 MILE ROUND TRIP HAPPENED ONCE IN EARLY MAY WHICH I TOLD THE FORD SERVICE PERSON SEVERE SAFETY ISSUE STOPPING MID TRAFFIC REAR END COLLISION I HAD TO STOP IN THE MIDDLE OF THE LANE AND TURN IT OFF PUT IN PARK THEN START AGAIN TO GET GOING AGAIN "SERVICE ADVANCETRAC" "HILL ASSIST MODE NOT AVAILABLE" "SEE MANUAL" WRENCY SYMBOL
AS REPORTED TO DEALER : CUSTOMER STATES WHEN ACCELERATING IN LOW GEAR AND LETTING OFF THE ACCELERATOR IT WILL CONTINUE TO MAINTAIN THE RPM UNTIL YOU HIT HARD ON THE BRAKES. MY ADDED COMMENTS IS THAT 1800 RPM WHEN NORMAL HIGHWAY SPEED IS OVER 60 MPH. IN STOP AND GO TRAFFIC THE DRIVER MUST MAINTAIN BRAKE WITH LEFT FOOT AND GAS WITH RIGHT FOOT OR YOU WILL REAR END THE CAR IN FRONT OF YOU. PS DEALER PERFORMED TEST AND STATED AT THIS TIME COMPARED TO LIKE UNITS AND THEY DO THE SAME THING. I TEST DROVE A NEW TRUCK WITH SAME ENGINE AND TRANS. AS MINE AND IT DID NOT DO THE SAME THING. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
HAD TO REPLACE BRAKE PADS TWICE IN 20,000 MILES. REPLACED ROTORS DUE TO WARPING. DEALER WAS NO HELP RESOLVING ISSUE. MY NEW BRAKE PADS ON THE PASSENGER SIDE HAS WORN TO THE METAL IN 4 MONTHS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2015 FORD E-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE DECELERATED ON ITS OWN. THE FAILURE RECURRED DURING THE 1,100 MILE ROAD TRIP. THE VEHICLE HAD JUST BEEN REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 15V614000 (FORWARD COLLISION AVOIDANCE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE NEEDED TO BE REPROGRAMMED. THE FAILURE MILEAGE WAS 4,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2015 FORD E-150. WHILE DRIVING 65 MPH, THE TRANSMISSION SUDDENLY SHIFTED INTO LOWER GEARS, CAUSING LOSS OF SPEED. THE CONTACT STATED THAT AN UNKNOWN WARNING INDICATOR ILLUMINATED. THE DEALER WAS NOTIFIED OF THE FAILURE, BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 73,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
ON OR ABOUT OCT.26 MY HUSBAND WAS DRIVING TO OUR PHARMACY TO PICK UP MEDS. HE WAS DRIVING ALONE. THANKFULLY OUR GRANDCHILDREN WERE NOT WITH HIM. HE TOLD ME THE BACK WINDOW JUST EXPLODED HE TOLD ME AT FIRST HE THOUGHT IT WAS A GUN SHOT. HE PULLED OVER AND THERE WAS GLASS EVERYWHERE. FORD HAS KNOWN ABOUT THIS PROBLEM FOR QUITE SOMETIME.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .