2007 Ford E-450 Owner Complaints

WHILE ON A TRIP AND WHILE RETURNING HOME THE R/R INSIDE TIRE TREAD SEPARATED CAUSING THE VEHICLE TO SWAY. I WAS TRAVELING ON HIGHWAY 231, A 4 LANE HIGHWAY,. I WAS TRAVELING 65MPH AT THE TIME OF THE TIRE FAILURE. I WAS ABLE TO PULL INTO THE FLORIDA WELCOME CENTER LOCATED ON THE FLORIDA ALABAMA LINE. I HAD TO CALL SOMEONE OUT TO CHANGE THE TIRE. AFTER RETURNING HOME TO PANAMA CITY, FLORIDA I TOOK THE VEHICLE AND TIRE BACK TO PEP BOYS TO HAVE IT REPLACED. I ADVISED THE SERVICE WRITER THAT I HADE PURCHASED ROAD HAZARD INSURANCE WHEN I PURCHASED THE TIRES AND ADVISED HIM AS TO WHAT HAPPENED AND HE ADVISED ME THAT TIRE SEPARATION WAS NOT A ROAD HAZARD AND THAT I WOULD HAVE TO PAY 50.00 DOLLARS TO HAVE THE TIRE REPLACED. THE TIRES I BOUGHT FOR MY MOTOR HOME WERE DEFINITY DAKOTA H/T LT 225 75R 16. THE SERVICE WRITER ADVISED ME THAT THEY NO LONGER SOLD THIS TIRE AND REPLACED IT WITH A COOPER TIRE. THEY PUT THE TIRE THAT WAS ON THE R/R OUTSIDE AT THE TIME OF THE INSIDE TIRE FAILURE ON THE INSIDE OF THE WHEEL AND PUT THE NEW TIRE ON THE OUTSIDE. NOW I AM HAVING PROBLEMS WITH THE R/R INSIDE TIRE NOT HOLDING AIR. I FEEL THAT THESE TIRES ARE NOT SAFE TO USE ON ANOTHER TRIP. THE SERVICE WRITER DID NOT LOOK TO CONCERNED ABOUT THE PROBLEM.

NHTSA ID

11040278

Incident

Oct 9, 2017

Mileage

9,000 mi

PURCHASED 4 MASTER CRAFT COURSER LT225/75R16 ON 6/30/10 ON MY 30 FT CLASS C M/H WITH 18860 MILES. SO FAR THIS YEAR 2014 I HAVE HAD 3 TIRES FAIL WITH CORD SEPARATION. THE FIRST WAS ON 5/29/14 TRAVELLING TO NC. THE SECOND FAILURE WAS ON 7/25/14 WHERE THE TREAD SEPARATED FROM THE TIRE. THE THIRD OCCURRED ON 11/21/14 WHERE THE ENTIRE TREAD CAME OFF THE TIRE JUST LIKE A RECAPPED TIRE. I CURRENTLY HAVE 38000 MILES ON M/H. IT IS STORED UNDER COVER AND THE TIRES ARE COVERED WHEN IN STORAGE. ALL THREE FAILURES OCCURRED WHILE DRIVING ON HIGHWAYS AND WAS ABLE TO PULL OVER SAFELY AND WITHOUT ANY DAMAGE TO MY VEHICLE OR OTHERS. *TR

NHTSA ID

10662935

Incident

May 28, 2014

Mileage

30,000 mi

EMPLOYEES WERE DRIVING TRUCK ON A LEVEL ROAD, AND IT RAPIDLY LOST POWER. THEY STOPPED AND CALLED ME, AND I TOLD THEM TO CHECK A NUMBER OF THINGS. EVERYTHING LOOKED OK. BROUGHT THE VEHICLE TO FORD DEALER, AND WAS INFORMED THAT THE FUEL TANK WAS RUSTED/RUSTING ON THE INSIDE. THEY ADVISED ME THAT THE TANK, SENDING UNIT, AND FUEL PUMP NEEDED TO BE REPLACED, BEFORE THEY COULD SEE IF THE INJECTORS, FUEL LINES, AND TURBO WERE DAMAGED. I CHECKED ON THE INTERNET BEFORE AUTHORIZING THE REPAIRS, AND WAS ASTOUNDED BY THE AMOUNT OF PEOPLE THAT HAD THE SAME EXACT ISSUES. THE TANKS ARE DEFECTIVE, AND DELAMINATE, THEREFORE CLOGGING THE FUEL SYSTEM. THEY REPAIR BILL THAT I WAS QUOTED BEFORE WE EVEN GOT TO THE ENGINE, WAS $3700.00+TAX!!!. THIS IS UNREAL THAT THE NHTSA HAS NOT FORCED A RECALL YET. DOES SOMEONE HAVE TO DIE FIRST? SOME PEOPLE REPORTED REPAIR BILLS OF $11,000+!! I AM A SMALL BUSINESS OWNER. I PAID $45,000.00 FOR THIS VEHICLE, MAINTAINED IT RELIGIOUSLY. THE TRUCK ONLY HAS 66,000 MILES ON IT. THERE HAVE BEEN NUMEROUS COMPLAINTS TO THE NHTSA, AND IT HAS BEEN REPORTED THAT THIS HAS BEEN KNOWN ABOUT FOR SOME TIME. THERE ARE ALSO SOME CLASS ACTION LAWSUITS THAT ARE IN PLACE. I CANNOT AFFORD THIS REPAIR. I WILL GET A PETITION GOING TO ASK THE NHTSA TO RECALL THESE VEHICLES. IF THE NHTSA KNOWS THAT THERE IS A PROBLEM, AND SOMEONE HAS AN ACCIDENT AND KILLS SOMEONE, WOULD THAT NOT HAVE THE NHTSA SHOULDER SOME BLAME? IS THIS ANOTHER COVER UP LIKE THE GENERAL MOTORS IGNITION RECALL? I URGE YOU TO PLEASE RECALL THESE AFFECTED VEHICLES. FORD KNOWS THAT THERE IS A PROBLEM, AND THEY IMMEDIATELY BLAME IT ON FUEL. I HAVE 6 TRUCKS THAT ALL RUN ON DIESEL. THE ONLY ONE THAT HAS THIS PROBLEM IS THIS VEHICLE. I WOULD LIKE SOMEONE FROM THIS AGENCY TO CONTACT ME ASAP. THIS TRUCK IS A MAIN SOURCE OF INCOME FOR ME AND MY EMPLOYEES, AND IT I SITTING AT A DEALER FOR 5 DAYS SO FAR. *TR

NHTSA ID

10609885

Incident

Jul 1, 2014

Mileage

66,000 mi

LEAK IN MOLDED FUEL LINE WHERE LINE CHANGES FROM HOSE TO PIPE. NOT A WEAR ITEM, SAFETY ISSUE. FUEL LINE IS LOCATED OVER EXHAUST MANIFOLD, FUEL LEAK DETECTED BEFORE ADDITIONAL DAMAGE OCCURRED. *TR

NHTSA ID

10466456

Incident

Jun 1, 2012

Mileage

32,000 mi

RADIATOR FAILURE OF TOP HEADER SEAL WITH ANTIFREEZE BLOWING BACK OVER PASSENGER SIDE OF THE ENGINE CREATING A POSSIBLE FIRE HAZARD. *TR

NHTSA ID

10344209

Incident

Jun 23, 2010

Mileage

14,000 mi

2007 FORD E450 VAN, DRIVER LIFTED SHIFT LEVER TOWARDS PARK. THE DRIVER THOUGHT THE LEVER WAS IN PARK AND EXITED THE VEHICLE. THE LEVER DROPPED TO REVERSE AND THE VEHICLE RAN THE OVER DRIVER. *BF THE VEHICLE HAS A BRAKE INTERLOCK, IF THE SHIFT LEVER IS PUSHED HARD ENOUGH, IT WILL SHIFT INTO PARK. IF THE SHIFT LEVER IS PUSHED, BUT NOT HARD ENOUGH, THE SHIFT INDICATOR HANGS UP BETWEEN PARK AND REVERSE. (THE VEHICLE IS OWNED BY U-HAUL) *JB

NHTSA ID

10341188

Incident

Jun 22, 2010

FIRE FROM ABS UNIT. *TR

NHTSA ID

10310788

Incident

Dec 14, 2009

Mileage

30,477 mi

FIRE FROM ABS BRAKE UNIT. *TR

NHTSA ID

10310783

Incident

Dec 8, 2009

Mileage

24,536 mi

TL*THE CONTACT OWNS A 2007 FORD E-450. WHENEVER THE CONTACT DROVE THE VEHICLE AT ANY SPEED HE NOTICED THAT THE BRAKES BEGAN TO OVERHEAT AND LOCK. THE DEALER STATED THAT THE FAILURE COULD NOT BE SERVICED OR REPRODUCED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 40000. UPDATED 2/22/10 *CN UPDATED 07/07/10.*JB

NHTSA ID

10300398

Incident

Oct 15, 2009

Mileage

40,000 mi

UNDER NORMAL OPERATING CONDITIONS WE HAVE HAD TWO ENGINES (V-10, 6.8L) THROW A SPARK PLUG, STRIPPING OUT THE THREADS. BOTH VEHICLES HAD BEEN ON THE ROAD FOR ABOUT AN HOUR AND UPON LEAVING A STOPLIGHT BLEW THE PLUGS, CAUSING LOST OF POWER, RAW FUEL SMELL, LEADING TO THE VEHICLES BEING TOWED TO THE REPAIR SHOP. 2005 FORD E-450, CYLINDER #3, @ 193,096 MILES ON ENGINE; HORIZON FORD IN SEATTLE RECOMMEND REPLACING ENGINE, REPLACED WITH FORD RE-MANUFACTURED ENGINE. 2007 FORD E-450, CYLINDER #3, @ 150,039 MILES ON ENGINE; REPAIRED UNDER FORD TSB 07-21-2 WITH INSERT. *TR

NHTSA ID

10300314

Incident

Dec 17, 2009

Mileage

150,039 mi

TL*THE CONTACT OWNS A 2007 FORD E450. THE CONTACT RECEIVED A RECALL NOTICE FOR THE FUEL SYSTEM AND EXTERIOR LIGHTING IN FEBRUARY OF 2009 AND IMMEDIATELY CALLED THE DEALER. SHE WAS INFORMED THAT BECAUSE THE COMPANY WAS EXPERIENCING FINANCIAL DIFFICULTIES, THEY WOULD CHARGE HER $300 PER REPAIR. IF THE VEHICLE IS NOT REPAIRED, A CATASTROPHIC FAILURE COULD OCCUR. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE NHTSA CAMPAIGN ID NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 1,500.

NHTSA ID

10265621

Incident

Feb 14, 2009

Mileage

1,500 mi

DRIVER AND PASSENGER AIRBAGS DID NOT DEPLOY DURING AUTO ACCIDENT, DAMAGE TO RIGHT FRONT END AND RIGHT FENDER.RIGHT WHEEL AND BRKAE ASSEMBLY COMPLETLY DETACHED FROM AUTOMOBILE.DASHBOARD CAME APART. *CN

NHTSA ID

10213731

Incident

Oct 8, 1997

Mileage

42,000 mi