2015 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2015 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)337.5%
- Other / unspecified225.0%
- Engine112.5%
- Fuel system112.5%
- Suspension112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
THIS IS A SCHOOL BUS. WHEN STOPPED AT A STOP SIGN THE SCHOOL BUS WOULD NOT ENGAGE IN ANY GEAR, FORWARD OR REVERSE. THE SCHOOL BUS HAD TO BE TOWED TO THE FORD DEALERSHIP WHERE THEY FOUND THAT THE COAST CLUTCH DRUM, RETURN SPRING, PISTON AND ONE WAY CLUTCH NEEDED TO BE REPLACED. THIS IS THE 4TH SCHOOL BUS WE HAVE HAD THIS ISSUE WITH.
TL* THE CONTACT OWNS A 2015 FORD E-350. WHILE OPERATING THE VEHICLE, THE "SERVICE VEHICLE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (MORRIS BUFFALO FORD, 702 E. HIGHWAY 55, BUFFALO MN) WHERE IT WAS DIAGNOSED THAT THE CLUTCH CYLINDER WELL INSIDE THE TRANMISSION WAS CRACKED AND THE TRANSMISSION NEEDED TO BE REBUILT. THE MANUFACTURER WAS NOTIFIED AND NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 65,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the rear wheels were cracked. The contact was concerned about driving the vehicle. The failure mileage was approximately 80,329.
THE TIRE THREAD SHREDDED OFF OF BOTH SIDES OF THE WHEEL WHILE DRIVING, DAMAGING MUD FLAPS, ETC. 2015 JAYCO GREYHAWK RV (FORD 450 CHASIS). MILEAGE WAS ONLY 25000 MILES. OTHER TIRES APPEAR TO ALREAY DISPLAY SOFT SPOTS AND CRACKING - ESPECIALLY NEAR THE THREAD, VEHICLE IS GARAGE WHEN NOT IN USE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE VEHICLE JERKED AND FAILED TO START AS THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,020.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2015 FORD E-450. WHILE DRIVING AT 55 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE AND THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TECHNICIAN WAS ABLE TO RESTART THE VEHICLE BUT WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE FUEL MODULE NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED; HOWEVER, THE CONTACT STATED THAT SHORTLY AFTER THE REPAIR, THE VEHICLE JERKED AND FAILED TO START AS THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS UNABLE TO BE DIAGNOSED OR REPAIRED THE VEHICLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 2,020.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
The contact rented a 2015 Ford E-450. The contact stated that while driving, the vehicle was shaking in the rear. The contact had to maintain an approximate speed of 40 MPH to control the vehicle. The fuel warning light was illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact stated that the rear wheels were cracked. The contact was concerned about driving the vehicle. The failure mileage was approximately 80,329.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .