2024 Ford E-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Ford E-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine240.0%
- Other / unspecified240.0%
- Steering120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
Lifters in engine is going out. Ford has made a TSBs for repair because lifters and camshaft was made by a third party and they are defect. Here is Technical Service Bulletin (TSB 25-2200). Vehicle is available for inspection. It was put at risk because vehicle could loose power at any time and potential crash into another car. The problem has been reproduced in 4 different Ford vehicles. Has not been inspected by manufacturer or others. No warning lights were present.
The brand new JAYCO GREWHAWK is making a whining sound from the chassis. I have not even driven it more than 50 miles. this vehicle needs to be recalled for whatever chassis issues or it could be transmission issues. I will take it back to FORD but this is really bad on ford to sell brand new RVs with such whining sound coming from the chassis. Please alert the new owners about the issues . thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
On two separate occasions, the vehicle's left rear wheel studs have broken off clean with the hub and both rear dual wheels departed the vehicle while in motion. This issue was reported to the local FORD dealer and they reported that they do not know why this is happening. This has happened to five (5) of our other vehicles as well. I am a fleet manager for an EMS service and we have a total of ten (10) of these Ford chassis. The wheels coming off present a hazard to oncoming traffic not to mention the safety of our team members and patients being transported on our ambulances. We sent the vehicle to Kilgore Ford in Kilgore, Texas and they advised they are not sure how this keeps happening. There were no warning lamps that gave the driver a warning that something was wrong until the truck started vibrating and the wheels came off. All of our vehicles, including these FORD Chassis', undergo Preventative Maintenance every 5,000 miles and we check torque on these FORD chassis' because of these continued failures. Our torque wrenches are checked annually for calibration and we utilize the FORD Diagnostic Software and FORD Torque Specification which are followed on every preventative service.
On two separate occasions, the vehicle's left rear wheel studs have broken off clean with the hub and both rear dual wheels departed the vehicle while in motion. This issue was reported to the local FORD dealer and they reported that they do not know why this is happening. This has happened to five (5) of our other vehicles as well. I am a fleet manager for an EMS service and we have a total of ten (10) of these Ford chassis. The wheels coming off present a hazard to oncoming traffic not to mention the safety of our team members and patients being transported on our ambulances. We sent the vehicle to Kilgore Ford in Kilgore, Texas and they advised they are not sure how this keeps happening. There were no warning lamps that gave the driver a warning that something was wrong until the truck started vibrating and the wheels came off. All of our vehicles, including these FORD Chassis', undergo Preventative Maintenance every 5,000 miles and we check torque on these FORD chassis' because of these continued failures. Our torque wrenches are checked annually for calibration and we utilize the FORD Diagnostic Software and FORD Torque Specification which are followed on every preventative service.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The brand new JAYCO GREWHAWK is making a whining sound from the chassis. I have not even driven it more than 50 miles. this vehicle needs to be recalled for whatever chassis issues or it could be transmission issues. I will take it back to FORD but this is really bad on ford to sell brand new RVs with such whining sound coming from the chassis. Please alert the new owners about the issues . thank you, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .