RoadVitals

2000 Ford E-Series Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
6
Latest Jul 8, 2025
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Dec 20, 1999

What this page shows

Our database holds 6 NHTSA owner-reported complaints for the 2000 Ford E-Series. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–6 of 6

Other / unspecifiedSuspension
Filed Jul 8, 2025

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID
11671852
Incident
May 28, 2025
Tires & wheels
Filed Oct 10, 2014

ONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY. *TR

NHTSA ID
10643893
Incident
Oct 9, 2014
Mileage
80,210 mi
EngineFuel system
Filed Oct 20, 2006

I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT. *NM

NHTSA ID
10171394
Incident
Oct 19, 2006
Mileage
110,000 mi
Body & structure
Filed May 23, 2005

DT: PROBLEMS WITH THE FRAMES ; CRACKS IN THE FRAMES; RECEIVED A SVC. BULLETIN AND AN ARTICLE BY THE NATIONAL AMB. ASSOC. TO REPORT THIS

NHTSA ID
10121938
Incident
May 1, 2004
Mileage
176,472 mi
Heating & air conditioningDriver assistance
Filed Mar 23, 2005

MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.*AK

NHTSA ID
10114549
Incident
Mar 1, 2004
Mileage
65,000 mi
Brakes
Filed Dec 20, 1999

BRAKE LIGHT ON THE DASH ILLUMINATES INTERMITTENTLY. NLM

NHTSA ID
550038

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .