2000 Ford E-Series Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Ford E-Series, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure111.1%
- Brakes111.1%
- Heating & air conditioning111.1%
- Driver assistance111.1%
- Engine111.1%
- Fuel system111.1%
- Other / unspecified111.1%
- Suspension111.1%
- Tires & wheels111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
DT: PROBLEMS WITH THE FRAMES ; CRACKS IN THE FRAMES; RECEIVED A SVC. BULLETIN AND AN ARTICLE BY THE NATIONAL AMB. ASSOC. TO REPORT THIS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
BRAKE LIGHT ON THE DASH ILLUMINATES INTERMITTENTLY. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
MY CRUISE CONTROL NO LONGER WORKS ON MY 2000 FORD ECONOLINE. ALSO, I HAD TO REPLACE ME REAR AIR CONDITIONER LINES, THEY RUSTED OUT.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
I HAVE A 2000 FORD EXPEDITION THAT WHEN DRIVING, AS SOON AS THE LOW FUEL LIGHT COMES ON, THE ENGINE SHUTS OFF. I HAD SEVERAL OCCASIONS WHEN I AM LESS THAN A MILE FROM A GAS STATION, AND THE TRUCK HAS TROUBLE MAKING IT TO THE GAS STATION. THERE ARE SEVERAL INSTANCES WHEN MY SUV IS PARKED UP HILL AND IT HAS MORE THAN A QUARTER TANK OF GAS, AND IT HAS A HARD TIME STARTING. I HAVE TO PUT IT ON NEUTRAL, LET IT ROLL BACKWARDS AND PUT IT ON LEVEL SURFACE BEFORE IT CAN START AGAIN. RECENTLY IT HAS STARTED SHUTTING OFF WHEN I DRIVE, WITH A REASONABLE AMOUNT OF FUEL. ALSO THE SERVICE ENGINE HAS COME ON, IT RUNS ROUGH. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS SUV. ON SEVERAL OCCASIONS, I HAVE COME CLOSE TO GETTING REAR ENDED AND OR GETTING STRANDED. I ALSO OWN A GMC TRUCK, AND WHEN THE LOW FUEL LIGHT COMES ON, I CAN STILL DRIVE THIS TRUCK FOR MORE THAN 15 MILES. I HAVE PERFORMED ALL MAINTENANCE SERVICES ON THIS VEHICLE, AND IT HAS NOT SHUT OFF ON ME EVER. THIS IS A COMPARISON ONLY. I AM TAKING MY 2000 FORD EXPEDITION TO GET SCANNED FOR PROBLEM CODES TOMORROW AND FIND OUT WHAT THE PROBLEMS ARE. I JUST WANTED TO KNOW IF THERE ARE OR HAVE BEEN COMPLAINTS OF THIS NATURE, AND IF THERE IS , WHY HAS FORD NOT MADE AN ANNOUNCEMENT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder in a dangerous situation. The second tire separation happened two days later, again involving a rear tire. Fortunately, it was a slower separation and didn’t cause structural damage, but it further endangered our family and disrupted our trip. We believe these tires were not in a safe condition when the vehicle was rented to us. One of the separated tires showed severe dry rot and age. We had to pay for a replacement tire out-of-pocket during the first incident. The RV company has not responded to our compensation request. These issues could have resulted in serious injury or fatality, and we are filing this report so NHTSA can investigate if this vehicle or others of its kind have similar tire issues. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
ONE OF OUR VANS' BCT JB42 FRONT TIRE BLEW UP LEAVING FROM A PARKED AREA WITHOUT GOING OVER ANY SHARP OBJECTS OR CURVES. FORTUNATELY NO ONE WAS HURT BUT IT COULD HAVE CAUSED A HUGE ACCIDENT ON THE ROAD. I CHECKED FOR RECALL ON THIS TIRE BUT IT WAS NOT... I WILL NOW HAVE TO REPLACE 12 OF THESE TIRES ON MY OTHER VEHICLES BECAUSE I CAN'T TAKE ANY MORE CHANCES WITH THESE TIRES ALTHOUGH THEY ARE IN DECENT CONDITIONS... I THINK SOMEONE NEEDS TO CHECK INTO THIS TIRE MODEL FOR FUTURE SAFETY. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .