RoadVitals

1991 Ford E350 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
19
Latest Jul 9, 2002
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
11
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
2

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1991 Ford E350, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes733.3%
  • Engine29.5%
  • Driver assistance29.5%
  • Tires & wheels29.5%
  • Electrical29.5%
  • Transmission14.8%
  • Visibility14.8%
  • Fuel system14.8%
  • Interior & seats14.8%
  • Steering14.8%
  • Suspension14.8%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

7
reports

From owner reports, verbatim

DEALER REFUSED RECALL REPAIR ON BRAKE LINE DUE TO VIN.

NHTSA ID 517529 · filed May 28, 1997

DEFECT IN BRAKE SYSTEM OF MOTOR HOME.

NHTSA ID 516588 · filed Apr 18, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

2
reports

From owner reports, verbatim

WHILE DRIVING IN THE MIDDLE OF HIGHWAY MOTOR WILL QUIT. CONSUMER MANAGES TO GET IT TO THE SIDE. *AK

NHTSA ID 869236 · filed Aug 31, 2000

ENGINE STALLS.

NHTSA ID 524059 · filed Oct 28, 1997

Too few reports in this category for a page of its own — they appear in the full complaint list.

Driver assistance

Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.

2
reports

From owner reports, verbatim

DEFECT IN BRAKE SYSTEM OF MOTOR HOME.

NHTSA ID 516588 · filed Apr 18, 1997

INTERMITTENTLY THE FUEL THROTTLE STICKS CAUSING EXCESSIVE IDLING OF THE ENGINE WHEN TRYING TO STOP VEHICLE. TT

NHTSA ID 976419 · filed Dec 11, 1995

Too few reports in this category for a page of its own — they appear in the full complaint list.

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

2
reports

From owner reports, verbatim

THE RIGHT REAR TIRE, (KELLY-SPRINGFIELD LT235.85R16, LOAD RANGE E, DOT# PJOR BPKV 193) FAILED, CAUSING THE VEHICLE TO LEAVE THE ROADWAY AND OVER TURN SEVERAL TIMES. *JG. (ALABAMA UNIFORM TRAFFIC ACCIDENT REPORT)

NHTSA ID 566497 · filed Jul 9, 2002

THIS WAS THE INBOARD TIRE OF A PAIR ON THE RIGHT REAR OF THE VEHICLE. WHILE TRAVELING ON INTERSTATE 70 EASTBOUND OUT OF KANSAS CITY IT EXPLODED, SPLITTING THE STEEL BELTS CROSSWISE. EXCEPT FOR THE AREA OF THE BLOWOUT THE TIRE REMAINED RELATIVELY INTACT AND DID NOT SEPARATE. THE AMBIENT TEMPERATURE AT THE TIME WAS APPROXIMATELY 85 DEGREES F. NO ROAD HAZZARDS WERE OBSERVED OR FELT PRIOR THE THE EXPLOSION. TIRE PRESSURES HAD BEEN CHECKED 30 MILE EARLIER AND WERE 60-65 PSI PER VEHICLE MANUAL. PROTRUDING BELTS STRUCK THE SEWAGE HOLDING TANK KNOCKING A CORNER OUT OF IT AND SPILLING CARGO ON THE HIGHWAY. VEHICLE WAS BROUGHT TO A STOP ON OUTBOARD TIRE WITHOUT ACCIDENT.TIRE WAS PURCHASED ON 8/5/99 IN TEMPLE TEXAS FROM FIRESTONE STORE #007196-4361, HAD APPROXIMATELY 6000 MILES ON IT OVER SOME EXTREMELY HOT ROADS. A REPLACEMENT TIRE (COOPER TIRE) WAS PURCHASED FROM HIGGINSVILLE TIRE SERVICE HIGGINSVILLE MO 64037 660-584-2504. HIGGINSVILLE DEALER EXAMINED TIRE AND SAID THAT HE COULD NOT IDENTIFY ANY TRAUMA IN AREA OF BLOWOUT AND PRESUMABLY GAVE CREDIT BASED ON 70 PERCENT TREAD WEAR(WHICH SEEMED EXCESSIVE TO ME). NO CREDIT WAS DOCUMENTED ON THE INVOICE BUT TIRE WAS CHEAPER THAN I WOULD HAVE EXPECTED AND CHEAPER THAN THE ONE THAT BLEW UP. (TIRESIZE: 215/85/R16)( DOT NUMBER: TIRE SIZE: 215/85/R16 )

NHTSA ID 733017 · filed Sep 30, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Electrical

Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.

2
reports

From owner reports, verbatim

ELECTRICAL FIRE, ORINATING IN THE GAS TANK, WIRES NOT BEING FUSED. *AK

NHTSA ID 518861 · filed Aug 15, 1997

EXPERIENCED A FIRE IN THE STARTER SOLENOID UNDER HOOD AND DASH. *AK

NHTSA ID 983215 · filed Apr 22, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

I HAVE HAD THE VEHICLE AND PARTS TO TWO DIFFERENT TRANSMISSION SHOPS AND BOTH HAVE TOLD ME THAT THIS NEVER SHOULD HAVE HAPPENED. BOTH THE DRUM AND SHAFT OF THE TORQUE CONVERTER HAVE STRIPPED. I STILL HAVE THE PARTS AND WOULD BE WILLING TO SHARE THEM WITH FORD IF A SETTLEMENT IS POSSIBLE.

NHTSA ID 713316 · filed Oct 14, 1999

Too few reports in this category for a page of its own — they appear in the full complaint list.

Visibility

Reports naming windshields, glass, wipers, defrosters and mirrors.

1
report

From owner reports, verbatim

REAR HEATER PIPES ARE RUSTED, HOT WATER SPRAYS OUT FROM UNDER VEHICLE. *AK

NHTSA ID 981008 · filed Mar 20, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

FUEL PUMP FAILED CAUSING VEHICLE TO SHUT DOWN ON SEVERAL OCCASIONS. *SLC

NHTSA ID 555526 · filed Oct 3, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

REAR DUAL DOORS FAILED TO REMAIN SHUT DUE TO LATCH MECHANISM RUSTING AND CORRODED. CONTINUE WITH DESCRIPTION. TT

NHTSA ID 965079 · filed May 10, 1995

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

TILT STEERING WHEEL WILL NOT STAY IN THE UPWARD POSITION. TT

NHTSA ID 977295 · filed Jan 3, 1996

Too few reports in this category for a page of its own — they appear in the full complaint list.

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

1
report

From owner reports, verbatim

CALIPER STICKS.

NHTSA ID 484034 · filed Jul 8, 1995

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .