2016 Ford E350 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Ford E350, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)240.0%
- Body & structure120.0%
- Brakes120.0%
- Interior & seats120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
The contact owns a 2016 Ford E-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who related the failure to Ford Campaign Number:19B40 (Coast Clutch Cylinder and One-Way Clutch Replacement). The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.
THE AUTOMATIC TRANSMISSION SHIFTER CONTROL CABLE CONTACTS THE PARKING BRAKE PEDAL ASSEMBLY, THEREFORE WHEN APPLYING/RELEASING THE PARKING BRAKE THE CABLE IS GETTING CHAFFED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE ECONOLINE VAN FOR THE EXHAUST ODOR, WHEN WE FIRST TESTED THE VEHICLE IN THE SHOP WITH THE VEHICLE RUNNING (NO EXHAUST HOSE ON THE TAILPIPE) THE CO DETECTOR READ 49 PPM AFTER ABOUT 15 MINUTES. WHEN WE TESTED THE SECOND TIME, THE VEHICLE WAS IN THE SAME SPOT BUT A EXHAUST HOSE RUN FROM THE TAILPIPE TO OUTSIDE THE SHOP AND THE CO DETECTOR READ 9 PPM AFTER ABOUT 15 MINUTES. THE THIRD TEST, THE VEHICLE WAS OUTSIDE AND AFTER ABOUT 15 MINUTES THE CO DETECTOR READ 0 PPM AND WE ALSO TESTED IN THE UTILITY BODY WHICH READ 0 PPM. WE KNOW THAT THE VEHICLE IS NOT LEAKING EXHAUST, ANY "EXHAUST ODOR" OR CO MEASURED IN THE CABIN OF THE VEHICLE IS MOST LIKELY FROM THE EXHAUST SURROUNDING THE VEHICLE AND ENTERING THROUGH THE POROUS UTILITY BODY. *DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE PARKING BRAKE CABLE IS ROUTED THROUGH THE LEFT FRONT WHEEL AREA IN SUCH A WAY THAT THE TIRE CONTACTS IT DURING NORMAL STEERING/SUSPENSION MOVEMENTS AND IS CHAFFING THE CABLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
VEHICLE IS UPFIITTED BY MORGAN OLSON WITH SEATS BY FREEDMAN SEATING. THE PIN THAT HOLDS THE SEAT PEDESTAL TO THE SEAT BASE FALLS OUT AND THE SEAT FALLS TO ITS LOWEST POSITION WITHOUT WARNING. THIS HAS HAPPENED TO SEVERAL OF OUR FLEET TRUCKS. THE DETENT BALL SPRING IS TO WEAK. WE HAVE MODIFIED 2 OF OUR VEHICLES BY DRILLING OUT THE BALL AND INSTALLING HAIRPIN CLIPS. ON THE OTHERS WE HAVE INSTALLED A ZIP-STRIP THROUGH THE PIN RING WHILE WAITING FOR INSTRUCTION FROM MORGAN OLSON CONCERNING A AUTHORIZED REPAIR. HAVE MADE SEVERAL ATTEMPTS TO OBTAIN FEEDBACK OVER THE COURSE TO 2 YEARS, BUT HAVE NOT RECEIVED ANY INSTRUCTION AS TO HOW THIS ISSUE IS BEING HANDLED. THE SEAT FELL WHILE THE VEHICLES WERE IN MOTION IN EVERY INCIDENT, STARTLING THE DRIVER.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .