2022 Ford E350 Problems

Received a notice on a "Customer Satisfaction Program 24N03" Instead of issuing a recall for the Hydroboost power steering pressure and jumper lines they instead extended the warranty. People have had their braking and power steering go out while driving and this is simply unsafe and unacceptable. They need to replace their faulty "quick connector" to a hard connector before people are injured. My dealership refuses to do this as it is not a recall. Thank you for your consideration

The contact owns a 2022 Ford E-350. The contact stated while driving 60 MPH and depressing the brake pedal, the vehicle failed to stop as needed. There was no warning light illuminated. The contact desperately depressed on the brake pedal and the vehicle eventually came to a complete stop. The vehicle was towed to the dealer and the mechanic stated that the power steering pump needed to be replaced, and that the vehicle was previously repaired under NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The vehicle was repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 12,361.

The contact owns a 2022 Ford E-350. The contact stated while driving 60 MPH and depressing the brake pedal, the vehicle failed to stop as needed. There was no warning light illuminated. The contact desperately depressed on the brake pedal and the vehicle eventually came to a complete stop. The vehicle was towed to the dealer and the mechanic stated that the power steering pump needed to be replaced, and that the vehicle was previously repaired under NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The vehicle was repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 12,361.

The contact owns a 2022 Ford E-350. The contact stated that while driving approximately 65 MPH, the steering wheel became stiff and the vehicle would pull in either direction. Additionally, there was an abnormal odor inside the cabin of the vehicle. The contact then noticed that the brake pedal had to be pressed very hard in order to stop the vehicle. After stopping to inspect under the hood, the contact discovered a power steering fluid leak in the engine compartment. The vehicle was driven to the local dealer who diagnosed that the power steering pressure line had detached. The vehicle was not yet repaired. The manufacturer was not yet notified of the failure. The contact indicated that the vehicle was previously repaired under the NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The failure mileage was 6,300.

open recall for paint peeling on the gas tank, could cause a fire. No Ford dealers in my area can take care of the problem.: I am writing to file a formal complaint regarding a Ford dealership’s failure to properly support and address a safety recall on my vehicle. As you know, safety recalls are issued to protect consumers and ensure that potentially dangerous vehicle defects are corrected promptly and at no cost to the vehicle owner. When a dealership fails or refuses to properly handle a recall repair, it raises serious safety and compliance concerns. Despite bringing my vehicle to the dealership regarding the recall, the issue has not been properly addressed. I am requesting that this matter be reviewed and that appropriate action be taken to ensure the recall repair is handled in accordance with federal safety requirements. For reference, my vehicle information is as follows: Vehicle Make/Model: Ford VIN: [XXX] ___________Recall Number (if known): ___gas tank peeling______________Dealership Name & Location: ____5 dealerships in my area_____________ Date of Visit: __called all dealers so did ford customer support_________________ I respectfully request assistance in ensuring that the recall repair is completed properly and without further delay. Thank you for your attention to this matter. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On August 2, 2024 I was driving my 2022 Ford F-350 7.3L on the interstate when I experienced sudden loss of power, engine was sputtering, obviously not getting fuel in my opinion. Engine eventually quit, and I came to rest on the side of I 20/59. No check engine light or other warning lights were ever illuminated during this episode. After 10-15 minutes of attempting to start, the engine finally restarted and I continued approx. 50 miles to my home with no further issues. On Aug. 14, I took my F-350 to Town and Country Ford in Bessemer, AL. Their Service Dept ran several diagnostics, tested fuel pressure, ethanol content, checked for misfire issues and road tested. No problems were found. Odometer at the time was 26,183. In July 2025 I received a Recall Notice from Ford (NHTSA Recall 25V455) for possible loss of fuel pressure due to fuel pump failure. Today (December 8, 2025) I attempted to contact Ford to get an update on the Recall, was provided no updated information (automated system only, live person was not an option). Also contacted Town and Country Ford Service Dept. for any knowledge they may have, which was none as well. I do not drive the truck every day, primarily due to not wishing to get stranded far from a repair facility (current odometer 38,000). I am filing this complaint to hopefully expedite Ford's response to a problem they have been aware of for over a year if not longer, and certainly since July 2025. The absence of any updates is infuriating for an issue that could become catastrophic.

Hello, when I start my vehicle and leave it in park and idle the transmission makes a mechanical clicking noise. I went under the truck to try to find the source of the noise. When I was underneath I found that when the clicking noise is active the drive line coming out the rear of the transmission is trying to turn. It is rocking back and forth. This is what the clicking noise is. I tried it with the vehicle in Neutral also. Same result. The transmission is sending power to the driveline while in park and neutral. I have a video I can submit but this form won’t let me include a video. If you response to me through email I will attach it there

The car was put into Park. The driver got out to check the position of the vehicle in the parking space. While looking at the passenger side of the RV, the vehicle began to power in reverse. It knocked over and injured the driver and ran into a fence. The passenger reached over to stop the vehicle just before it ran into two other people.

failures of Ford engine 7 .3L VS 350 and we have 67000 there have been multiple cases of this engine ceasing at this mileage,. The warranty should be 100,000 especially if its a fleet vehicle and used for purposes like fedex.