2022 Ford E350

The Office of Defects Investigation (ODI) opened Recall Query (RQ) 24003 on February 27, 2024, to evaluate the scope and remedy effectiveness of NHTSA recall 24V097. On February 16, 2022, Ford Motor Company (Ford) issued a safety recall, NHTSA recall 22V089, for certain 2021-2022 Ford E-350 and E-450 vehicles equipped with dual rear wheels. According to the filing, specific hydraulic lines could leak resulting in a sudden loss of power steering and power brake assist, increasing the risk of a crash. The remedy involved a dealer inspection of the lines and their replacement as necessary. Only vehicles that failed the inspection received updated parts. On February 9, 2024, Ford issued a new recall, NHTSA recall 24V097, to replace the specific hydraulic lines on any vehicle that had not yet been inspected and on any vehicle which had passed inspection within the previous twelve months. However, vehicles which had passed the inspection more than twelve months ago would not be included within the scope of the new recall, as Ford deemed them to have a low likelihood of failure. ODI opened this RQ to better understand Ford's scoping of recall 24V097, specifically concerning the inspected-only vehicles not included in the new recall filing. ODI sent Ford an information request letter on April 18, 2024. Ford responded, in full, on May 31, 2024. ODI reviewed Ford's data which showed that the vehicles not included in the new recall had a predicted failure rate of less than 0.25% within 10 years from the date of inspection. By comparison, the vehicles included in the new filing have had a failure rate of approximately 2% prior to being recalled again. ODI analysis of complaint and warranty data further supports Ford's assessment that vehicles that passed inspection more than twelve months prior to recall 24V097 are unlikely to experience the defect condition. ODI is closing this RQ without a manufacturer action. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

open recall for paint peeling on the gas tank, could cause a fire. No Ford dealers in my area can take care of the problem.: I am writing to file a formal complaint regarding a Ford dealership’s failure to properly support and address a safety recall on my vehicle. As you know, safety recalls are issued to protect consumers and ensure that potentially dangerous vehicle defects are corrected promptly and at no cost to the vehicle owner. When a dealership fails or refuses to properly handle a recall repair, it raises serious safety and compliance concerns. Despite bringing my vehicle to the dealership regarding the recall, the issue has not been properly addressed. I am requesting that this matter be reviewed and that appropriate action be taken to ensure the recall repair is handled in accordance with federal safety requirements. For reference, my vehicle information is as follows: Vehicle Make/Model: Ford VIN: [XXX] ___________Recall Number (if known): ___gas tank peeling______________Dealership Name & Location: ____5 dealerships in my area_____________ Date of Visit: __called all dealers so did ford customer support_________________ I respectfully request assistance in ensuring that the recall repair is completed properly and without further delay. Thank you for your attention to this matter. Sincerely, [XXX] [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11724182

Incident

Mar 3, 2025

On August 2, 2024 I was driving my 2022 Ford F-350 7.3L on the interstate when I experienced sudden loss of power, engine was sputtering, obviously not getting fuel in my opinion. Engine eventually quit, and I came to rest on the side of I 20/59. No check engine light or other warning lights were ever illuminated during this episode. After 10-15 minutes of attempting to start, the engine finally restarted and I continued approx. 50 miles to my home with no further issues. On Aug. 14, I took my F-350 to Town and Country Ford in Bessemer, AL. Their Service Dept ran several diagnostics, tested fuel pressure, ethanol content, checked for misfire issues and road tested. No problems were found. Odometer at the time was 26,183. In July 2025 I received a Recall Notice from Ford (NHTSA Recall 25V455) for possible loss of fuel pressure due to fuel pump failure. Today (December 8, 2025) I attempted to contact Ford to get an update on the Recall, was provided no updated information (automated system only, live person was not an option). Also contacted Town and Country Ford Service Dept. for any knowledge they may have, which was none as well. I do not drive the truck every day, primarily due to not wishing to get stranded far from a repair facility (current odometer 38,000). I am filing this complaint to hopefully expedite Ford's response to a problem they have been aware of for over a year if not longer, and certainly since July 2025. The absence of any updates is infuriating for an issue that could become catastrophic.

NHTSA ID

11703778

Incident

Aug 2, 2024

failures of Ford engine 7 .3L VS 350 and we have 67000 there have been multiple cases of this engine ceasing at this mileage,. The warranty should be 100,000 especially if its a fleet vehicle and used for purposes like fedex.

NHTSA ID

11615330

Incident

Jul 18, 2024

Received a notice on a "Customer Satisfaction Program 24N03" Instead of issuing a recall for the Hydroboost power steering pressure and jumper lines they instead extended the warranty. People have had their braking and power steering go out while driving and this is simply unsafe and unacceptable. They need to replace their faulty "quick connector" to a hard connector before people are injured. My dealership refuses to do this as it is not a recall. Thank you for your consideration

NHTSA ID

11604757

Incident

Jul 26, 2024

Hello, when I start my vehicle and leave it in park and idle the transmission makes a mechanical clicking noise. I went under the truck to try to find the source of the noise. When I was underneath I found that when the clicking noise is active the drive line coming out the rear of the transmission is trying to turn. It is rocking back and forth. This is what the clicking noise is. I tried it with the vehicle in Neutral also. Same result. The transmission is sending power to the driveline while in park and neutral. I have a video I can submit but this form won’t let me include a video. If you response to me through email I will attach it there

NHTSA ID

11596431

Incident

Jun 24, 2024

The car was put into Park. The driver got out to check the position of the vehicle in the parking space. While looking at the passenger side of the RV, the vehicle began to power in reverse. It knocked over and injured the driver and ran into a fence. The passenger reached over to stop the vehicle just before it ran into two other people.

NHTSA ID

11532627

Incident

Jul 14, 2023

The contact owns a 2022 Ford E-350. The contact received notification of NHTSA Campaign Number: 22V925000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was contacted, and an appointment was scheduled; however, the contact was informed that the recall could not be performed and advised to contact a different dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11524640

Incident

Dec 22, 2022

The contact owns a 2022 Ford E-350. The contact stated while driving 60 MPH and depressing the brake pedal, the vehicle failed to stop as needed. There was no warning light illuminated. The contact desperately depressed on the brake pedal and the vehicle eventually came to a complete stop. The vehicle was towed to the dealer and the mechanic stated that the power steering pump needed to be replaced, and that the vehicle was previously repaired under NHTSA Campaign Number: 22V089000 (Steering, Service Brakes, Hydraulic). The vehicle was repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was 12,361.

NHTSA ID

11521237

Incident

Mar 31, 2023

Mileage

12,361 mi

This article supersedes TSB 25-2572 to update the Parts List to correct the part number LC3Z-6006-L to LC3Z-6781-A, remove the flex plate bolts AL3Z-6379-BA from the parts list as these bolts are in kit LC3Z-6781-A, update the claim quantity of the part number W709771-S440 to 9 pieces (F-650/F750-Engine Replacement), W706447-S437 and W715068-S437 to 4 pieces, W712861-S439 to 8 pieces(F-Super Duty Pickup And Chassis Cab-Engine Replacement) / 8 pieces (F-53 Motorhome/F-59 Stripped Chassis Cab/F-650,F750 Engine Replacement) / W714286-S442 to 4 pieces (F-Super Duty Pickup And Chassis Cab-Camshaft and Tappet Repair / F-Super Duty Pickup And Chassis Cab-Engine Replacement), include LC3Z-6020-A for the Engine replacement lists, include 1 fuel injector seal kit to the Camshaft and Tappet repair lists, include 4 pieces of W520114-S440 to the E Series-Camshaft and Tappet Repair list, and update the engine oil part numbers XO-5W30-Q1SP and CXO-5W30-LSP6. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing ro

Advance Notice – Customer Satisfaction Program 25N17 Certain 2015-2025 Model Year Multiple Vehicle Lines Rear View Camera Replacement If Required After Dealer Evaluation

Some 2021-2026 F-150 vehicles equipped with a 5.0L/5.2L engine, 2021-2025 F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis vehicles equipped with a 6.8L/7.3L engine and 2021-2025 E-Series/F-650/F-750 vehicles equipped with a 7.3L engine may exhibit a rattle/scraping noise upon startup that may remain after the engine is running. Workshop Manual (WSM),

Ford and Lincoln vehicles equipped with wired keyless entry keypad systems and accessory wireless keyless entry keypad systems may or may not come with a wallet card containing the master code. Unlike the integrated wired keypad, the accessory wireless keypad master code cannot be retrieved from the vehicle using a diagnostic scan tool or from the label printed on the body control module (BCM). The Factory Keyless Entry Code application within the diagnostic scan tool will not provide an applicable master code for the accessory wireless keypad. If the wallet card for an accessory keypad is not available, the "Wireless RF Keypad Diagnosis Guide" can be referenced and provides direction on how to retrieve the master code. This guide is located under the Workshop Manual tab > Accessories > Installation > Wireless RF Keypad Diagnosis Guide > PPT C > Step C2.<br /><br /> Note: The only available keypad for some vehicles from the assembly plant is the accessory wireless keyless entry keypad. The integrated wired keypad cannot be installed on vehicles not equipped from the factory with a wired keyless entry k

This article supersedes TSB 25-2322 to update the Service Procedure, Labor Operations and Parts List. Some of the vehicles listed in the Model statement above may exhibit an upper engine ticking or tapping noise at idle. Customers may also report experiencing rough engine performance, engine misfire, or a malfunction indicator lamp (MIL) with diagnostic trouble code (DTC) P0301-P0308 in the powertrain control module (PCM). This may be due to camshaft and/or valve tappet having excess wear within the engine assembly.

Some 2021-2025 Expedition/Navigator/F-150/F-Super Duty/F-53 Motorhome/F59 Commercial Stripped Chassis/F-650/F-750/Transit vehicles equipped with a 2.7L/3.5L (non hybrid)/6.8L/7.3L engine and 2021-2026 E-Series may exhibit a rattle/scraping noise from the bellhousing area on start-up. Workshop Manual (WSM), Section 303-00 Engine System - General Information > Diagnosis and Testing and 303-06 > Starting System has been updated to address this condition. Additionally, WSM, Section 303-01 > Removal and Installation > Engine to Transmission Spacer Plate has been added to address this condition. Refer to the revised WSM sections for normal diagnosis.