2006 Ford E550 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Ford E550, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine125.0%
- Fuel system125.0%
- Seat belts125.0%
- Transmission125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
2006 F550 LOSING POWER, METAL SHAVING IN FUEL LINE, VIOLENT LEAKING EGR VALUE, NO POWER HARD TO START. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2006 F550 LOSING POWER, METAL SHAVING IN FUEL LINE, VIOLENT LEAKING EGR VALUE, NO POWER HARD TO START. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2006 FORD E550. WHILE ACCELERATING FROM A STOP AT 25 MPH, THE CONTACT WAS STRUCK BY ANOTHER VEHICLE ON THE DRIVER SIDE. THE CONTACT THEN DROVE INTO ONCOMING TRAFFIC AND CRASHED HEAD ON INTO ANOTHER VEHICLE. AFTERWARDS, THE VEHICLE STRUCK A LARGE SIGN. WHEN THE VEHICLE FINALLY STOPPED, THE CONTACT NOTICED THAT THE SEAT BELT ANCHORAGE HAD BECOME LOOSE AND THE SEAT BELT WAS RESTING IN HIS LAP. THE SEAT BELT HAD PREVIOUSLY BEEN REPAIRED. A POLICE REPORT WAS FILED. THE WEATHER WAS SUNNY AND DRY. THE CURRENT AND FAILURE MILEAGES WERE 12,500.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2006 FORD LC F-550. THE CONTACT STATED WHEN DRIVING AT ANY SPEED OF AT LEAST 40 MPH, THE VEHICLE WOULD INDEPENDENTLY SHIFT INTO NEUTRAL. THE DEALER PERFORMED A DIAGNOSTIC YET WAS UNABLE TO DUPLICATE OR PRODUCE ANY FAILURE CODES FOR THE VEHICLE. THE FAILURE PERSISTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 300 AND THE CURRENT MILEAGE WAS 32,000. UPDATED 09/24/10. *LJ UPDATED 09/24/10
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .