Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 73 NHTSA owner-reported complaints for the 1995 Ford Econoline. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 73 · page 1 of 3
TL*THE CONTACT OWNS A 1995 FORD ECONOLINE VAN. THE CONTACT STATED THAT THERE WAS A BURNING SMELL COMING FROM THE WHEEL WELL IN THE BRAKES. THE VEHICLE WAS TAKEN TO A MECHANIC SHOP WHERE THEY REPLACED THE CALIPERS, ROTORS , AND BRAKES PADS. THE CONTACT STATED THAT HE CAN STILL SMELL SOMETHING BURNING. THE FAILURE MILEAGE WAS 110,000.
TL*THE CONTACT OWNS A 1995 FORD 250 ECONOLINE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS IN PARK, IT WOULD MOVE IN REVERSE INSTEAD OF STOPPING. THE VEHICLE IS BEING DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS 68,000.
1995 FORD E150 BASED CONVERSION VAN HAS HAD THE BRAKING SYSTEMS/ABS HYDRAULIC CONTROL UNIT REPLACED TWICE IN LESS THAN 83000 MILES. BOTH REPLACEMENTS WERE DONE AT FORD DEALERS AND COPIES OF BOTH INVOICES CAN BE PROVIDED. SINCE THIS FAILURE DISABLES THE ABS SYSTEM AND PRODUCES A HOPPING IN THE REAR WHEELS I THINK THIS IS A HAZARD THAT NEED TO BE LOOKED INTO. *TR
TL* THE CONTACT OWNS A 1995 FORD ECONOLINE. WHILE DRIVING APPROXIMATELY 35 MPH THE "ABS" WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION, AND THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 900. THE CURRENT MILEAGE WAS 108,000. UPDATED 1/25/10 *CN UPDATED 01/26/10.*JB
TL*THE CONTACT OWNS A 1995 FORD F150 ECONOLINE. THE CONTACT RECEIVED A SAFETY RECALL NOTICE IN FEBRUARY OF 2008 REGARDING THE VEHICLE SPEED CONTROL: CRUISE CONTROL. FORD STATED THAT THE PART WAS UNAVAILABLE AND ADVISED THE CONTACT TO DISCONNECT THE CRUISE CONTROL HIMSELF. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND RECALL NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 91,000. UPDATED 5/13/08 *CN
TL*THE CONTACT OWNS A 1995 FORD ECONOLINE. AFTER HAVING THE WIRING HARNESS INSTALLED DUE TO THE RECALL, THE VEHICLE'S HORN AND CRUISE CONTROL FAILED. THE CONTACT STATED THAT PRIOR TO THE INSTALLATION THERE WERE NO FAILURES WITH THESE TWO COMPONENTS. HE RECEIVED ANOTHER RECALL NOTICE AND TOOK THE VEHICLE IN FOR SERVICE. THE DEALER STATED THAT THE REPAIR HAD PREVIOUSLY BEEN PERFORMED. THE CONTACT ALSO NEEDED THE DEALER TO INSPECT THE ABS BECAUSE THE WARNING LIGHT ILLUMINATED INTERMITTENTLY WHILE DRIVING VARIOUS SPEEDS. THE CONTACT HAD TO SHUT OFF THE VEHICLE AND RESTART IT IN ORDER FOR THE LIGHT TO DIM. THE REPAIRS WOULD COST APPROXIMATELY $1,200 - $2,000 FOR PARTS, NOT INCLUDING LABOR. THE FAILURE AND CURRENT MILEAGES WERE 20,000. UPDATED 04/11/08 *TR
DT*: THE CONTACT STATED WHILE COMING DOWN A RAMP AND APPROACHING THE STOP SIGN AT 45MPH, THE ENGINE MADE A LOUD NOISE. THE NOISE APPEARED TO COME FROM UNDERNEATH THE HOOD IN THE ENGINE COMPARTMENT. THE VEHICLE WAS DISPLAYED THAT IT WAS GOING TO STALL AND THEN STALLED. AN ATTEMPT WAS MADE TO RESTART THE VEHICLE HOWEVER IT WOULD NOT RESTART. THE VEHICLE WAS TOWED TO THE SERVICE DEALER WHO DETERMINED THAT THE TIMING GEAR WAS FRACTURED. THE SERVICE DEALER REPLACED THE TIMING GEAR. SHORTLY AFTER THE REPAIR, THE LOUD NOISE UNDERNEATH THE HOOD RETURNED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO PERFORMED DIAGNOSTIC TESTING AND RECOMMENDED THAT A NEW CAMSHAFT BEARING BE INSTALLED. THE MANUFACTURER WAS NOT NOTIFIED.
ORIGINALLY IN DEC 2004 WHILE RETURNING FROM A TRIP TO ST LOUIS, MO I STARTED HAVING TROUBLE WITH MY ABS LIGHT, MY SPEEDOMETER HAND INTERMITTENTLY GOING BACK TO ZERO AND THE VEHICLE COMING OUT OF CRUISE CONTROL. IT WAS ORIGINALLY THOUGHT TO BE AN ABS BRAKE PROBLEM SO THE SPEED SENSOR AND THE ABS MODULE WERE REPLACED. THE NEXT TIME I WENT OUT ON THE ROAD FOR THE 4TH OF JULY 2005 WEEKEND, WE GOT AS FAR AS CHARLESTON, SC AND HAD TO PUT THE RV IN THE SHOP BECAUSE THE CRUISE CONTROL AND SPEEDOMETER WERE BOTH MALFUNCTIONING; THE VEHICLE WOULD COME OUT OF CRUISE AND THE SPEEDOMETER WOULD INTERMITTENTLY GO FROM THE CORRECT SPEED TO ZERO. ALSO THE TRANSMISSION SEEMED TO BE DOWNSHIFTING AND UPSHIFTING AT WILL. AFTER THAT WE BROUGHT THE VEHICLE BACK TO THE HOUSE AND PARKED IT ON THE DRIVEWAY. A COUPLE WEEKS LATER I WENT OUT TO MOVE THE VEHICLE AND GIVE IT A WASH JOB AND CLEAN IT UP A BIT. IT WOULD NOT START UPON EXAMINATION I FOUND THAT THE POWER DISTRIBUTION BOX HAD SOME MELTED RELAYS IN IT AND THE BOX ITSELF WAS MELTED MIN A COUPLE OF PLACES. WE HAD TO HAVE A DIFFERENT WIRING HARNESS INSTALLED TO GET THE VEHICLE RUNNING AGAIN. WE FELT THAT SOME OF THE GROUND WIRES HAD CAUSED A SHORT AND THAT WAS WHAT HAD MELTED THE POWER DISTRIBUTION BOX. LATER WE SAW THAT THE POWER DISTRIBUTION BOX IS LOCATED JUST BELOW THE RESERVOIR FOR THE VEHICLE BRAKE FLUID. THE LAST ITEM THAT BECAME FUNCTIONAL WAS THE CRUISE CONTROL AFTER REPLACEMENT OF THE FUSE FOR THE HORN WHICH IS LOCATED IN THE POWER DISTRIBUTION BOX. THEN I SAW WHERE FORD WAS DOING A RECALL ON THEIR CRUISE CONTROL SWITCHES FOR SEVERAL VEHICLES AND SINCE THE ECONOLINE VAN IS ONE OF THE VEHICLES THAT USES THAT CRUISE CONTROL SWITCH, I FEEL THAT THE ECONOLINE VAN SHOULD BE INCLUDED IN THE CRUISE CONTROL SWITCH RECALL. MY RV IS ON A FORD ECONOLINE E350 VAN WITH A 460 CID V8 ENGINE AND AN AUTOMATIC TRANSMISSION WITH OVERDRIVE. VIN #[XXX][XXX]. *NM UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
DT:CONSUMER SAYS THAT 8 MONTHS AGO CRUISE CONTROL DEACTIVATION SWITCH BURNT THE WIRES ON THE WIRING HARNESS. CONSUMER HAD IT FIXED AT CONSUMER'S EXPENSE. TWO AND HALF WEEKS AGO THE CRUISE CONTROL DEACTIVATION SWITCH STARTED MALFUNCTIONING AGAIN. CONSUMER NOTICED THAT FORD REPORTED ON THE NEWS AS HAVING A RECALL ON THE SAME THING. CONSUMER CONTACTED FORD, AND FORD TOLD CONSUMER THAT THIS VEHICLE WAS NOT PART OF RECALL. CONSUMER THEN HAD MECHANIC DISCONNECT THE CRUISE CONTROL DEACTIVATION SWITCH, SO THAT SHE WOULD NOT HAVE TO WORRY ABOUT FUTURE FIRE, ESPECIALLY WITH HANDICAP HUSBAND IN VAN. AFTER HAVING SWITCH DISCONNECTED THE CONSUMER FOUND THAT THIS ALSO DISABLED THE HORN. CONSUMER SAID THAT FORD WAS THE ONLY MANUFACTURER THAT HAD THE CAPABILITIES OF MAKING A HIGH TOP CONVERSION VANS WITH LOWERED FLOORS FOR POWER WHEEL CHAIRS, WHICH ARE LARGER THAN REGULAR WHEEL CHAIRS. *AK *NM
MY 1995 ECONOLINE VAN BLEW UP IN MY DRIVEWAY WHILE TURNED OFF. IT EXPLODED UNDER THE HOOD AND A HUGE FIREBALL WENT THROUGH THE CABIN. IT CAUGHT MY HOUSE AND GARAGE ON FIRE, ALONG WITH MY GIANT OAK TREE.*AK THIS IS THE SECOND ECONOLINE VAN THAT HAS BLOWN UP LIKE THIS IN THE PAST FIVE YEARS. BOTH TIMES WE WERE LUCKY; NO ONE WAS IN THE VAN AT THE TIME. THEY WOULD HAVE DIED OR BEEN SEVERELY BURNED. FORD ACCEPTS NO RESPONSIBILITY FOR THIS; THEY WERE NOT EVEN INTERESTED ENOUGH TO SEND OUT AN INVESTIGATOR.
AUTOMATIC TRANSMISSION MALFUNCTIONS, IT WILL EITHER SHIFT HARD AND LATE OR WILL GO OUT OF GEAR. DEALERSHIP REBUILT THE TRANSMISSION, BUT THE PROBLEM STILL EXISTS.*AK
THE FACTORY INSTALLED CAGE HAD BOLTS THAT WERE FASTENED TO THE SIDE WALL OF THE VAN. THE BOLTS HAD BROKEN THROUGH THE METAL, WHICH WOULD ALLOW THE CAGE TO MOVE FOWARD IN A COLLISION. JG *JB
WHILE DRIVING WAS UNABLE TO SLOW DOWN, VEHICLE WAS STOPPED WHEN IT HIT A BARN. HAD NO BRAKES. JUST HAD BRAKES CHECKED AND EVERYTHING WAS FINE. CONTACTED DEALER.*AK
WHEN VEHICLE IS STARTED AND TANK IS FULL THERE WOULD BE AN EXCESSIVE AMOUNT OF GAS FUMES PRESENT. FORD SAYS VEHICLE WAS NOT INCLUDED IN A RECALL. MECHANIC HAS FIXED VEHICLE. *AK
CONSUMER STATES THAT THE HORN IS VERY SMALL, CONSUMER STATES IF YOU DON'T HAVE THE STEERING WHEEL IN THE CORRECT POSITION YOU WON'T BE ABLE TO BLOW THE HORN. CONSUMER FEELS THIS IS UNSAFE BECAUSE HE IS UNABLE TO WARN THE NEXT DRIVER. *JB *YH
DOT#MD11 520V 344; TIRE SIZE LT245/75R16 ONE OF FOUR TIRES FAILED WITH A SIGNIFICANT SIDEWALL BULDGE NOTICED BEFORE FINAL FAILURE. SEARS REPLACED TIRE PRO-RATED FOR WEAR, BUT REPAIR PERSON SEVERELY OVER-TORQUED LUG NUTS REQUIRING REPLACEMENT OF LUG BOLTS AND NUTS. NOT CONFIDENT OF REMAINING THREE TIRES; NOR THE SERVICE PEOPLE WHO MIGHT REPLACE THE WHEELS. NOT ENOUGH SPACES ON YOUR ONLINE FORM FOR TIRE SIZE AND DOT#. MFG #? 272892GRF66 A 15 PASSENGER VAN SHOULD HAVE GOOD TIRES. (DOT NUMBER: MD11520V34 TIRESIZE: LT24575R16)
ABS CONTROL UNIT FAILED 1996 AND REPLACED. FAILED AGAIN DEC 2001 AND REPLACED FOR $761. A MULTI-TON 15 PASSENGER VAN SHOULD HAVE WORKING ABS BRAKES. WITH THE REPAIR COST, I SUSPECT MANY OWNERS ARE NOT FIXING THE DEFECTS AND IT IS UNDER-REPORTED. APPARENT PART NUMBER CHANGE SUGGESTS POSSIBILITY FORD KNOWS OF A PROBLEM AND HAS NOT REPORTED IT. NARROWLY AVOIDED MAJOR COLLISION WHEN ABS WERE INOP. *AK
STALLED WHILE MOVING BECAUSE OF BLOWN 60 AMP FUSE. AUTO SERVICE HAD TO FIND WIRE THAT SHORTED (TOOK 6 HOURS) SPLICE THAT WIRE AND COVER IT. TOTAL COST WAS $585 INCLUDING TOW.*AK
WHILE DRIVING ON HIGHWAY AT A SPEED OF 65MPH VEHICLE BEGAN TO SURGE. I ATTEMPTED TO ACCELERATE WITH THE ACCELERATOR PEDAL COMPRESSED ALL THE WAY DOWN TO THE FLOOR, BUT ENGINE DID NOT RESPOND AND EVENTUALLY STALLED AS I PULLED OF ONTO THE EMERGENCY LANE. ATTEMPTED SEVERAL TIMES TO START ENGINE, IT WOULD RUN FOR APPROXIMATELY 10 SECONDS AND SHUT DOWN. WEATHER THAT DAY WAS SUNNY WITH TEMPERATURES AT THE TIME OF TRAVEL ABOUT 90 TO 95 DEGREES FAHRENHEIT. AT THE TIME OF THE INCIDENT, I HAD DRIVEN ONLY 250 MILES OF A 730 MILE TRIP. I HAD DRIVEN THIS SAME ROUTE JUST FOUR DAYS PRIOR. I WAS TOWED TO THE LOCAL FORD DEALERSHIP RIGHT AT CLOSING TIME FOR SERVICE DEPARTMENT SO MY VEHICLE WAS NOT CHECKED OUT UNTIL THE FOLLOWING MORNING. AFTER SEVERAL HOURS OF TROUBLESHOOTING, THE MECHANICS COULD FIND NOTHING WRONG. I PROCEEDED ON MY TRIP DURING THE EARLY EVENING HOURS WITHOUT ANY PROBLEMS. THE VEHICLE IS IN PERFECT OPERATING CONDITION WITH ALL REQUIRED PERIODICAL MAINTENANCE COMPLETED BY FORD SERVICE AND THE ONLY CORRECTIVE MAINTENANCE WAS FOR A LEAKING TRANSMISSION COOLING LINE IN ENGINE COMPARTMENT. AFTER DOING SOME RESEARCH ON THE AUTO SAFETY CENTER WEB SITE, I AM A BIT SUSPICIOUS OF A POTENTIAL HIDDEN PROBLEM. *AK
WHEN BRAKES ARE ENGAGED ONLY LEFT FRONT WORKS. HAVE REPLACED PROPORTIONING VALVE, REAR WHEEL CYLINDERS, ONLY GETTING 4,000 MILES ON FRONT PADS. CHECKED FUSES RELATING TO AREA-NO PROBLEMS.
SOME OF YOUR QUESTION MAY BE UNREATED TO MY PROBLEM, I AM COMPLAING ABOUT A DEFECTIVE BOTTOM TENNSION PULLEY THAT CONTROL THE POWER STEARING AND ALL OF THE VEHICLE. WHEN THIS QUITE IT WAS LIKE DRIVING A DUCE AND A 1/2 THAT DOES NOT HAVE POWER STEARING, VERY WIDE TURN. CAME TO REST BEFORE OVERHEADING IN E. FALMOUTH MASS. WAS TOWED OFF A FRIEND LAWN AT 9 PM SUNDAY. THE WHOLE THING OCCURED AT NOON ON SUNDAY, A NEIGHBOR TO MY FRIEEND CAME TO MY AID WITH HIS CELL PHONE, I CALLED MY MOTOR CLUB AND THERE COULD NOT HELP. AROUND 7 PM I FOUND SOME ONE THAT COULD TOW IT TO MY MACHINIC - AUTO TECH IN SANDWICH, MASS WHO DID THE REPAIRING AS IT WOULD HAVE COST DOUBLE TO TAKE IT TO TANNER FORD IN S. EASTON. AS IT WAS IT COST $80 FOR THE TOW(CASH) AND I SELDOM HAVE THAT MUCH LAYING AROUND. REPAIRS WERE $387. WHICH IS REPORTED UNDER PROPERTY DAMAGE IN YOUR FORM. I AM REPORTING THIS BECAUSE HAD I BEEN ON THE INTERSTATE HEADING FOR NH OR SOME WHERE ELSE, I COULD STILL BE THERE TODAY WAITING FOR HELP. THE TENNISON PULLY SNAPPED RIGHT OFF, RENDERING FANBELT USELESS, AND DISTROYING A NEW BELT THAT HAD JUST BEEN PUT IN THE VAN IN APRIL ON THE REQUIRE MANITANCE AT 60,000/61,000. I SPENT A LOT THEN, AND NOW TO HAVE $387 + 80 = $467 HURTS. I THINK I SHOULD GET SOME HELP FROM SOMEWHERE FOR THE FLAW OF THE TENNSION UNIT. AUTO TECH IN SANDWICH 508-833-0888, AS FOR LARRY HE'LL TELL YOU WHAT HE DID. YOU KNOW THIS COULD HAVE BEEN A BIGGER DISASTER HAD I BEEN TRAVELING AT 65, AM HAPPY I WAS JUST COMING OUT OF A SIDE STREET ONTO AND OTHER STREET AND IT WAS NOT BUSY, WHEN THE THING MADE A BIG SNAP. I THOUGHT AT FIRST IT WAS A FANBELT HAD BECOME LOOSE AND NEED TO BE RE-ENSTALLED, TILL I GOT UNDER AND FOUND A MUCH WORSE PROBLEM. THANK YOU FOR A CHANCE TO SPOUT OFF AS I THISK TIS IS VERY DANGEROUS PROBLEM ND SHOULD BE LOOKED INTO ALL ALL FORD TRUCKS, ESPECIAL E150'S. YOUR TRULY CARL G. RIDEOUT PS: ON THE 3 BELT AND 2 BELT AND MOTOR BELT AM NOT SURE WHAT YOU MEAN. *AK
WHILE DRIVING 65 MPH HOOD FLEW UP AND CRACKED WINDSHIELD, HOOD LATCH HAD BROKEN.*AK
I HAVE A 1995 FORD E-150 SHERARD HI-TOP CONVERSION VAN AND JUST EXPERIENCED A SEVERE FUEL LEAK. I'M CURIOUS IF THE VEHICLE HAS EVER BEEN RECALLED BECAUSE OF THIS. THE FUEL LEAK WAS ON THE VENT LINE TO THE FILL TUBE. THE VENT LINE IS ABOUT A 3/4 INCH HOSE WITH HOSE CLAMPS. ONE END OF THE HOSE ATTACHED TO A METAL TUBE NEAR THE TOP OF THE FILL TUBE AND THE OTHER IS NEXT TO THE FILL TUBE WHERE BOTH ENTER THE FUEL TANK. THE VENT HOSE DEVELOPED A MAJOR BREAK NEAR THE TANK. UPON REMOVE OF THE HOSE I FOUND THAT THE HOSE CLAMP IS BONDED TO THE HOSE AT THIS LOCATION (THE OTHER WAS NOT). I'M A MECHANICAL ENGINEER AND IT LOOKS TO ME THAT THE BONDING PROCESS OF THE CLAMP TO THE HOSE HAS DETERIORATED THE TUBE AND SHORTENED THE LIFE OF THE HOSE. THE OTHER END OF THE HOSE THAT ATTACHED TO THE FILL TUBE WAS IN EXCELLENT CONDITION WITH NO SIGNS OF PROBLEMS. THE CLAMP WAS STAMPED WITH SOME MARKINGS INDICATING CANADA AND ALSO HAS SOME PATENT NUMBERS ON IT. I'M GUESSING THAT THEY ATTEMPTED TO BOND THE CLAMP TO THE HOSE IN THIS AREA BECAUSE IT IS A VERY TIGHT AREA TO ACCESS FOR MAINTENANCE. I'M VERY CONCERNED BECAUSE WHEN THE TANK WAS FULL AND YOU WENT UP OR DOWN AN KIND OF AN INCLINE FUEL POURED OUT OF THE TANK. WE'D BEEN SMELLING FUEL FOR A LITTLE WHILE AND THE CONDITION FINALLY DETERIORATED ENOUGHT THAT WE COULD SEE THE FUEL LEAKING UNDER THE VAN WHEN WE PARKED ON AN INCLINE.*AK
4 GOODYEAR WRANGLER WRL HT FXNW TIRES P235/75R15, DOT 7276999510, HAD BUBBLES SHAPES OF GRAPEFRUIT ON THE SIDEWALL, NO SIGNS OF CRACKS/CUTS OR LEAKS THAT COULD HAVE CAUSED AIR TO GET INTO THE TIRE. *SLC
DEEP WIDE CRACKS AROUND THE CIRCUMFERENCE OF THE TIRE 1 INCH FROM THE BEAD. I MANAGE A FLEET OF 135 VEHICLES AND ALL OF OUR FORD VANS HAVE SEVERELY CRACKED TIRES. *AK (DOT NUMBER: MD11520V24 TIRESIZE: P24575/R16)
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .