1999 Ford Econoline Owner Complaints

TL* THE CONTACT OWNS A 1999 FORD ECONO RV S-DUTY EQUIPPED WITH A SAMSUNG MICROWAVE, MODEL MR5493G. THE CONTACT STATED THAT THE FAILURE WAS IDENTICAL TO OVEN CIRCUIT RECALL NUMBER: 03E044400. A NEIGHBOR ADVISED THE CONTACT THAT THE RV WAS ON FIRE. THE CONTACT OBSERVED THAT THE MICROWAVE CAUSED THE FIRE AND SHE EXTINGUISHED IT WITHOUT NOTIFYING THE FIRE DEPARTMENT. THE CONTACT SUSTAINED AN EXTENSIVE BURN ON HER LEG, BUT DID NOT SEEK MEDICAL ATTENTION. SAMSUNG ADVISED HER THAT THEY HAD NO PARTS TO REPAIR THE MICROWAVE ALTHOUGH IT WAS DAMAGED BEYOND REPAIR. THE MANUFACTURER ALSO STATED THAT THERE WERE NO AUTHORIZED RV DEALERS IN HER AREA TO REPLACE THE MICROWAVE. THE MICROWAVE WAS THE ORIGINAL EQUIPMENT IN THE RV AND IT WAS MOUNTED ON THE CEILING OF THE RV. THE FIRE BURNED A HOLE IN THE CEILING AND CAUSED DAMAGE TO THE CABINETS. THE CONTACT HAD NOT DRIVEN THE RV SINCE THE FIRE OCCURRED DUE TO THE SAFETY RISK AND THE HOLE IN THE CEILING. THE SERIAL AND PART NUMBERS WERE UNKNOWN. *TT

NHTSA ID

11075263

Incident

May 17, 2017

VAN IS LEAKING FUEL WHEN I ATTEMPT TO FILL THE TANK.

NHTSA ID

10865511

Incident

May 17, 2016

Mileage

130,800 mi

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT STATED THAT THERE WAS A STRONG ODOR COMING FROM THE VEHICLE. THE CONTACT DISCOVERED THAT THERE WAS PROPANE LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE MAIN PROPANE TANK NEEDED TO BE LIFTED OFF THE SPRING. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000. UPDATED 4/7/15*CN THE CONSUMER STATED THE MANUFACTURER PUT PROPANE/LIPI GAS LINES AROUND THE BACK TIRES. THE GAS LINES HAVE NO STRONG PROTECTIVE SHIELDS AROUND THEM. THE LIPI GAS LINE WAS SITTING ON TOP OF THE REAR LEAF SPRING. UPDATED 11/4/2015 *JS

NHTSA ID

10650324

Incident

Oct 10, 2014

Mileage

83,000 mi

TL* THE CONTACT OWN A 1999 FORD ECONOLINE 350 EQUIPPED WITH KELLY TIRES, TIRE LINE: SAFARI LT, TIRE SIZE LT23585R16. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, A LOUD BANGING NOISE AND THE SOUND OF METAL BEING DRAGGED ON THE GROUND WAS HEARD FROM OUTSIDE OF THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD. THE CONTACT NOTICED THAT THE FRONT PASSENGER'S SIDE TIRE EXPLODED. THE VEHICLE WAS TOWED TO THE RESIDENCE. THE DEFECTIVE TIRE HAD NOT BEEN REPLACED.THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 300,000. THE TIRE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10630972

Incident

Sep 4, 2014

Mileage

300,000 mi

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT STATED THAT A STRONG GASOLINE FUEL ODOR EMITTED INSIDE THE VEHICLE. THE ODOR HAD BEEN PRESENT SINCE THE DAY OF PURCHASE AND THE DEALER ATTEMPTED TO LOCATE THE SOURCE BUT TO NO AVAIL. THE CONTACT LATER DISCOVERED THAT THE FUEL TANK WAS FRACTURED AND LEAKING FUEL. THE FUEL TANK WAS NOT REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 218,000.

NHTSA ID

10542625

Incident

Apr 1, 2000

Mileage

20,000 mi

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE RV. THE CONTACT STATED THAT FUEL WAS LEAKING FROM THE FUEL TANK. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THERE WAS A METAL STRAP CUTTING INTO THE FUEL TANK. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 78,916. *TR

NHTSA ID

10537319

Incident

Aug 26, 2013

Mileage

78,916 mi

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE E250 VAN. THE CONTACT STATED THAT AFTER REFUELING TO CAPACITY, THE FUEL FILLER SHUT OFF FAILED, CAUSING GASOLINE FUEL TO SPILL BACK OUT ONTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 116,000.

NHTSA ID

10489083

Incident

Dec 17, 2012

Mileage

116,000 mi

TL* THE CONTACT OWNS A 1999 FORD ECONOLINE E150. THE CONTACT STATED WHENEVER REFUELING, THE FUEL LEAKED ONTO THE GROUND. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 01V114000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY); HOWEVER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. UPDATED 12/21/12*LJ UPON INSPECTION, THE RUBBER GAS FILLER HOSE TO THE GAS TANK WAS CRACKED, WHICH CAUSED FUEL TO LEAK WHEN FILLING THE TANK. THE REPAIR COST WAS $ 300. UPDATED 01.09.13

NHTSA ID

10484521

Incident

Nov 3, 2012

Mileage

135,000 mi

MY FORD E350 1999 MADE A LOUD FLAPPING NOISE AS I WAS LEAVING MY HOME. I PULLED RIGHT BACK INTO THE DRIVEWAY AND SHUT OFF THE ENGINE. I FOUND OUT THAT THE #2 SPARK PLUG HAD COMPLETELY BLOWN OUT OF THE CYLINDER HEAD. THIS HAS NEVER HAPPENED ON ANY VEHICLE I HAVE EVER OWNED. I TAKE GOOD CARE OF MY VEHICLES. I AM A MECHANIC, AND FORMER JET ENGINE MECHANIC ALSO. MY OBDII CONFIRMED A MISFIRE ON CYLINDER #2 THAT IS HOW I LOCATED WHICH PLUG IT WAS. FORD SAID IT WOULD COST $260 TO LOOK AT IT, AND UP TO $1700 IF THEY COULD REPAIR IT. PLUS TOWING. I ASKED HOW MUCH A NEW ENGINE WOULD COST SINCE THE VAN IS IN EXCELLENT CONDITION. FORD SAID IT WOULD COST $7,200 FOR A NEW ENGINE. THIS VAN HAS COST MORE FOR REPAIRS THAN ANY VEHICLE I HAVE OWNED IN MY LIFE. I AM 62. AIR CONDITIONING COMPRESSOR $700.00 COIL ON SPARK PLUG $130 ABS BRAKE SENSOR $138.00 FLEX PLATE AND FLYWHEEL $700.(CAUSED BY LOOSE IGNITION SWITCH) EGR BLACK BOX $400 REPLACEMENT. FORD WANTED $100.00 TO CHANGE MY FUEL FILTER. I WENT TO THE STORE AND BOUGHT THE SPECIAL WRENCH FOR $16 ,DID IT MYSELF IN 15 MINUTES. RECALL FOR WIRING NEAR THE MASTER CYLINDER THAT COULD CATCH FIRE, 1/2 DAYS WAGES LOST. IT TOOK ME 4 HOURS TO CHANGE SPARK PLUGS. IT WAS THE WORST DESIGN I HAVE EVER SEEN. A NIGHTMARE TO GET TO THE SPARK PLUGS. I SOLD THE VAN FOR $500 TONIGHT. GLAD THE NIGHTMARE IS OVER. *TR

NHTSA ID

10433618

Incident

Oct 28, 2011

Mileage

197,540 mi

THE SPARK PLUG EJECTED FOR THE SECOND TIME IN TWO WEEKS AND THIS TIME HAD A SMALL FIRE THAT WAS PUT OUT RIGHT AWAY THAT COULD HAVE BEEN REAL TROUBLE AS WE HAD 9 PEOPLE IN THE MOTORHOME AT THE TIME. *TR

NHTSA ID

10423894

Incident

Sep 5, 2011

Mileage

76,589 mi

WELL IT GOES LIKE THIS, NEW PLUGS AND COIL PACKS WHERE INSTALLED AT DEAN ARBOUR FORD IN PINCONNING MICHIGAN IN MY 1999 E350 ECONOLINE VAN. SO THE ISSUE AT HAND FROM WHAT I HAVE READ ABOUT WAS IMPROPER INSTALLATION OF SAID PLUG OR PLUGS FROM WHAT I HAVE READ IN ANSWERS.COM FROM WHAT FORD MOTOR COMPANY HAS SAID THAT IT IS IMPROPER INSTALLATION OR OVER TIGHTENING, NOT TORQUED PROPERLY. WELL IF THIS WAS THE ISSUE AT HAND THEN THEY ARE NOT PROPERLY TRAINING THEIR TECH'S, WHICH I DO NOT SEE THAT BEING THE ISSUE AT HAND. IT IS AS I SEE, POORLY DESIGNED AS TO THE SAME ISSUE HAPPENING TO SO MANY OTHERS. WHICH I SEE THEY SHOULD BE HELD ACCOUNTABLE FOR THE DESIGN FLAW. MY EXPERIENCE WITH MY PROBLEM AT HAND WAS NOT UNDER HEAVY LOAD, I WAS AT A STOP SIGN AND WENT TO PROCEED. WHAT HAPPENED AFTER THAT WAS STEPPING ON THE GAS SLOWLY TO MOVE FORWARD AND BANG, AND I MEAN (BANG). IT KEEP POPPING UNTIL I SHUT IT DOWN IGNITING AS THAT CYLINDER IN ROTATION CAME TO THAT FIRING ORDER FOR THAT CYLINDER. EVERYTHING THAT I HAVE READ INDICATES THAT THE CYLINDER ON THE PASSENGER SIDE OF A 5.4 TRITON HEAD 2ND ONE FROM THE BACK FORWARD IS THE ONE THAT IS FAMOUS FOR EJECTING FROM THE HEAD. RIGHT ABOVE THE PLUG IS THE COIL PACK AND ABOVE THAT IS THE FUEL RAIL WHICH INTERN WHEN THE PLUG EJECTED ITSELF COULD HAVE BEEN VERY HAZARDOUS. THE POPPING WAS THE PLUG SPARKING, WHICH WAS IGNITING THE FUEL PUMPED INTO THE CYLINDER BY THE INJECTOR. THIS COULD HAVE BEEN A VERY EXPLOSIVE SITUATION MEANING (FIRE). WITH THE LUCK OF THE DRAW I WAS NOT LIKE SOME OF THE UNLUCKY ONES THAT HAVE CAUSED A FIRE FROM THE EJECTION OF THE SPARK PLUG. WITH THE COMPLAINTS THAT HAVE ARISED FROM THIS ISSUE THE FORD MOTOR COMPANY SHOULD BE HELD ACCOUNTABLE FOR THIS KNOWN PROBLEM, BEFORE SOMEONE LOOSES THEIR LIFE FROM THIS KNOWN ISSUE. YOU WOULD THINK THAT FORD WOULD WANT TO ADDRESS THIS KNOWN ISSUE FOR LIABILITY REASONS, BEFORE THE UNKNOWN HAPPENS. LOSS OF LIFE, YOU CAN'T REPLACE IT, BUT YOU CAN REPLACE OR ADDRESS THE ISSUE. *TR

NHTSA ID

10398301

Incident

Apr 27, 2011

Mileage

170,000 mi

1999 FORD ECONOLINE 150, UNIT 1 WAS TRAVELING EASTBOUND AT MILE POST 122 IN THE CENTER LANE. UNIT 1 LOST ITS LEFT REAR TIRE AND PULLED OFF ONTO THE NORTH BERM BEFORE COMING TO REST. *BF THE LEFT REAR TIRE SHEARED OF THE AXLE. THE PLASTIC MOLDING AROUND THE WHEEL BROKE OFF AROUND THE WHEEL WELL AND THE PLASTIC MOLDING UNDER THE VEHICLE CRACKED. THERE WAS MINOR DAMAGE DUE TO THE TIRE SEPARATING FROM THE AXLE. (OHIO TRAFFIC CRASH REPORT # 10-0235-90) *JB UPDATED 05/11/11* BF

NHTSA ID

10398952

Incident

Mar 28, 2011

OIL LEAKING FROM UNDER HEAD (GASKET) ONTO EXHAUST MANIFOLD. *TR

NHTSA ID

10302358

Incident

Jan 25, 2010

Mileage

36,103 mi

HAVE A FORD 1999 ECONOLINE VAN WITH A TRITON ENGINE, HAVE SO FAR BLOWN X3 SPARKPLUGS, ALL FIXED. *TR

NHTSA ID

10287322

Incident

Aug 15, 2007

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT NOTICED THAT THE CONVERSION SEAT RECLINES TO AN UNSAFE POSITION. UPON FURTHER INSPECTION, HE NOTICED STRUCTURAL DAMAGE DUE TO METAL FATIGUE. THE EQUIPMENT MANUFACTURER WAS DELEGATE. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSUME ANY RESPONSIBILITY FOR THE REPAIR OF THE SEAT. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 75,000. UPDATED 06/27/09 *BF UPDATED 06/23/09.*JB

NHTSA ID

10270083

Incident

Feb 10, 2009

Mileage

75,000 mi

I WAS DRIVING FROM NEW YORK TO PHILADELPHIA WHEN I ALMOST GOT HOME THE CAR CAUGHT ON FIRE ON THE BACK OF THE CAR WHERE THE WHEEL ARE, ON MY PASSENGER SIDE. *TR

NHTSA ID

10252371

Incident

Jun 28, 2008

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT STATED THAT GASOLINE IS LEAKING FROM THE VEHICLE. HE FURTHER STATED THAT THERE WAS A MALFUNCTION WITH THE INSULATED PADS THAT PROTECT THE GAS TANK FROM BEING DAMAGED. THE PADS ARE RUBBING METAL TO METAL AND CAUSE THE GAS TANK TO CRACK AND LEAK FUEL. THE LEAK WAS DISCOVERED WHEN SHE SMELLED GASOLINE WHILE DRIVING. AN AUTO REPAIR SHOP CONFIRMED THE FAILURE. THE FORD MANUFACTURER STATED THAT THERE WAS NO RECALL FOR THIS FAILURE AND REFUSED TO MAKE ANY REPAIRS. THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10247562

Incident

Oct 6, 2008

1999 FORD ECONOLINE 250 SPARK PLUG BLEW OUT. CONSUMER STATES THAT THIS IS NOT A NORMAL WEAR ITEM. HE HAS HAD ALL WORK DONE BY FORD. FORD WILL NOT COVER THE REPAIR COST. HE STATES THAT IF SOMETHING IS WRONG IT IS FORD'S FAULT. *KB

NHTSA ID

10224009

Incident

Jan 1, 1901

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING FAILED AND THE CONTACT PULLED OFF THE ROAD. HE PURCHASED A NEW VACUUM PUMP AND REPAIRED THE VEHICLE. MILEAGE WAS 34,000 AND FAILURE MILEAGE WAS 30,000. UPDATED 04/22/08. *LJ

NHTSA ID

10223140

Incident

Jul 2, 2006

Mileage

30,000 mi

1999 FORD ECONOLINE WITH SPEED CONTROL RECALL. CONSUMER STATES THAT THE DEALER ONLY DEACTIVATED THE SPEED CONTROL SWITCH BUT DID NOT REPLACE IT. HE WAS TOLD THAT THE PARTS SHOULD BE IN AROUND THE SECOND QUARTER OF THE YEAR. *KB

NHTSA ID

10220591

Incident

Jan 1, 1901

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT RECEIVED A FORD SAFETY RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN AUGUST OF 2007. THE SPEED CONTROL WAS DISCONNECTED AT THAT TIME, AND HE HAS BEEN INFORMED EVERY MONTH THEREAFTER THAT THE PART WILL NOT BE AVAILABLE UNTIL THE FOLLOWING MONTH. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER AND PURCHASE DATE WERE UNKNOWN. THE CURRENT MILEAGE WAS 76,600.

NHTSA ID

10218110

Incident

Aug 15, 2007

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT RECEIVED A FORD SAFETY RECALL NOTICE FOR THE VEHICLE SPEED CONTROL IN AUGUST OF 2007. HE CHECKED WITH FORD EVERY THREE WEEKS AFTER THE VEHICLE SPEED CONTROL WAS DISCONNECTED AND WAS INFORMED EACH TIME THAT THE PART WOULD BE AVAILABLE THE FOLLOWING MONTH. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 105,500. UPDATED 03-04-08 *BF

NHTSA ID

10218109

Incident

Aug 15, 1999

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT RECEIVED A NOTICE FOR RECALL NUMBER 05S28 (VEHICLE SPEED CONTROL: CRUISE CONTROL). THE VEHICLE SPEED CONTROL WAS DISCONNECTED, BUT THE PARTS ARE STILL UNAVAILABLE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 103,000. UPDATED 02-06-08. *KB THE CONSUMER STATED THE WAIT TIME FOR THE VEHICLE TO BE REPAIRED IS TOO LONG. UPDATED 02/06/08 *TR

NHTSA ID

10214170

Incident

Aug 2, 2007

TL*THE CONTACT OWNS A 1999 FORD ECONOLINE. THE CONTACT RECEIVED A RECALL NOTICE FOR THE VEHICLE SPEED CONTROL (NHTSA CAMPAIGN ID NUMBER 07V336000). THE DEALER DISCONNECTED THE CRUISE CONTROL AND STATED THAT THE PART WOULD BE UNAVAILABLE UNTIL MAY OR JUNE OF 2008. THE CONTACT FELT THAT THE WAIT TIME FOR THE PART WAS EXCESSIVE. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 67,000. UPDATED

NHTSA ID

10210696

Incident

Aug 1, 2007

1999 FORD ECONOLINE WITH SPEED CONTROL RECALL. CONSUMER STATES THAT DEALER TOLD HIM THE PARTS WERE NOT AVAILABLE TO MAKE REPAIR. *KB THE DEALER OFFERED TO DISCONNECT THE CRUISE CONTROL, BUT THE CONSUMER DECLINED BECAUSE HE DIDN'T FEEL THAT WAS AN ACCEPTABLE SOLUTION TO THE PROBLEM. (LAWYER WROTE IN ON BEHALF OF CONSUMER).*JB

NHTSA ID

10210593

Incident

Jan 1, 1901