2005 Ford Escape Fuel system Problems

I had the hybrid battery replaced by Bill Brandt Ford in Brentwood California. A few days after having it replaced. The car broke down on a very dangerous highway. I had the car towed back to Bill Brandt Ford. They replaced the hybrid battery again. I received the car back on May 9. The car just broke down again today. Roughly Bill Brandt Ford had my car for over 250 days. I found a recall one for S as in Sam 19 for my vehicle when I type in the Vin number it says that it doesn’t pertain to my car. But when I look at the recall issue, my car is having the exact same problems. Now I need to have the car towed back yet again to the dealership. Any help would be greatly appreciated. I have over $3000 invested in this car now with Bill Brandt Ford and they’ve had it longer than I’ve had it.

NHTSA ID

11524932

Incident

Jun 1, 2023

Stalled out while driving down hwy. At 70 mph. Cars swirved and I almost got hit from behind due to my vehicle just cutting out. No warning lights came on it just shut off battery light n engine light then came on after vehicle lost power and I had to get off road without causing an accident which almost occurred due to the speed and area I was driving at time vehicle cut out I still have not figured out why it just cut out. Very dangerous all around.

NHTSA ID

11521932

Incident

May 5, 2023

Drove vehicle to drop off dog at sitters, started vehicle began to make u-turn and vehicle stalled. Attempted to restart, cranks but won't run. Recently purchased from used car dealer, new battery was installed, no trouble up to this point. Began checking usual problems, fuel delivery, crank pos.sensor, cam pos sensor, have no spark. Upon further research this appears to be faulty coils, spark plugs and pcm from factory but no recall has been employed. Possibility of collision during u-turn very likely. Loss of power to all systems could cause extreme risk to life at higher speeds. Ford Motor Company is aware of this problem, with the high number of similar problems in the NHTSA data base it is impossible for them not to know. The NHTSA should force Ford to fix this. If you make a product that can be dangerous if faulty, you are responsible to the public to do the right thing. I think that if the governmental agency responsible for traffic safety won't do their job then a class action lawsuit should be started. I bet I could find a good lawyer in the SF Bay area.

NHTSA ID

11491442

Incident

Oct 27, 2022

MY 2005 FORD ESCAPE V6 STALLS OUT SKIPS SPUTTERS AND MY TRUCK JERKS REALLY BAD THEN ANTI THEFT SYMBOL ON DASHBOARD COMES ON AND TRUCK SWITCHES OFF AND BACK ON IN THE MIDDLE OF HIGHWAY WITH TRAFFIC WHILE DRIVING DOWN THE ROAD .VERY DANGEROUS.ALSO MAKING A THUMPING NOISE FROM IN THE AIR INTAKE.GAS PEDAL CABLE WIRE BROKE .SO MANY PROBLEMS WITH THIS VEHICLE.I BELIEVE THERE ARE SEVERAL RECALLS.PLEASE LET ME KNOW SO THE FORD COMPANY CAN FIX WHATEVER IT IS THAT MAY BE UNDER RECALL. THANKS!

NHTSA ID

11387642

Incident

Nov 3, 2020

Mileage

237,000 mi

ENGINE STARTS UP FINE AND IDLES WITH NO PROBLEMS. WHILE DRIVING, VEHICLE IN MOTION, THE ENGINE WILL STALL AND START OVER AND OVER OR WILL STALL OUT COMPLETELY. THIS HAS ONLY HAPPENED AT SPEEDS OF 35MPH+ AND HAS HAPPENED AT INTERSTATE SPEEDS CAUSING A VERY POTENTIALLY DANGEROUS AND LIFE THREATENING CONDITION.

NHTSA ID

11092680

Incident

May 2, 2018

Mileage

180,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V777000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE RECALL REPAIR WAS EXCEEDING A REASONABLE AMOUNT OF TIME. THE CONTACT CALLED THE DEALER (BRENENGEN FORD, 615 BLACK RIVER STREET, SPARTA, WI 54656) AND WAS INFORMED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11089687

Incident

Apr 23, 2018

GAS PEDAL GETTING STUCK/NOT WORKING OFF AND ON FOR LAST YEAR; GASKET WAS REPLACED, NOW RECENTLY STICKING AGAIN. TODAY, WAS ON ARTERIAL WHEN PEDAL STUCK, LUCKILY NO TRAFFIC AS FOR SEVERAL MINUTES VEHICLE WOULD NOT MOVE. GOT PEDAL UNSTUCK AFTER SEVERAL TRIES AND LIFTING WITH TOE, SO WAS ABLE TO GET HOME. CAR IN SHOP NOW. DANGEROUS!

NHTSA ID

10995693

Incident

Jun 17, 2017

Mileage

137,000 mi

WHEN THE VEHICLE STOPS, ENGINE SHUTS DOWN. IF I START IT AGAIN IT TURNS ON JUST FINE BUT EVERYTIME I STOP AT A LIGHT OR AT TRAFFIC, THE ENGINE STALLS. WENT TO THE FORD DEALER AND THEY CANT TELL WHAT IS HAPPENING BECAUSE THERE IS NO CHECK ENGINE LIGHT TURNED ON. THEY CHECKED IT AND EVERYTHING WAS FINE, BATTERY, OILS. THEY SAY THERE IS A RECALL FOR THE THROTTLE POSITION SENSOR BUT THE DEADLINE FOR THIS WAS ON JANUARY 2015. NOW FORD WONT REPAIR MY VEHICLE BECAUSE IT HAS MORE THAN 10 YEARS OLD (IT HAS LESS THAN 116,000 MILES).

NHTSA ID

10986272

Incident

May 17, 2017

Mileage

116,000 mi

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

NHTSA ID

10873770

Incident

Jun 7, 2016

Mileage

164,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SPUTTER, HESITATE, AND SHUT OFF. THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL SYSTEM WAS FAULTY. THE FUEL PUMP AND FUEL FLOW INDICATOR AND SENSORS WERE ALL REPLACED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.

NHTSA ID

10865741

Incident

May 1, 2016

Mileage

115,000 mi

BOUGHT MY 05 XLT ESCAPE LAST MAY 2015 AND ALL OF A SUDDEN IT STARTED TO SHUDDER STALL WHILE IDLING AND JUST COMPLETELY DIE WHEN I WAS DRIVING ON THE HIGHWAY! GOT THE CODES READ AND IT SAID I HAD A MISFIRE ON CYLINDER 2, SO I PUT NEW COILS AND SPARK PLUGS IN IT BUT IT'S STILL NOT WORKING! STILL DOING A MISFIRE AND IT'S RUNNING BAD WHEN IT DECIDES TO CRANK UP! NOW IT'S NOT EVEN DRIVABLE.

NHTSA ID

10846378

Incident

Feb 20, 2016

Mileage

152,000 mi

DROVE FROM WASHINGTON STATE TO UTAH ON FAMILY VACATION 14NOV15. FILLED UP WITH GAS IN BOISE, I.D. AND 1 MILE INTO THAT DRIVE FELT A SURGE AND THEN SLIGHT LOSS OF POWER DRIVING AT 70MPH. THEN IT WAS FINE. WHEN WE GOT INTO SPANISH FORK, UT. WE HAD A LOSS OF POWER WHEN WE CAME OFF THE HIGH WAY AND CONTACTED OUR FRIEND WHO'S DAD OWNS HIS OWN MECHANIC SHOP K&K AUTO IN SPANISH FORK, UT. HE GOT THE CODES CLEARED AND SAID THE CODES WERE NOT MAKING ANY SENSE AS TO THE POSSIBLE LOSS IN POWER. THE VEHICLE RAN REAL GOOD AFTER GETTING CODES CLEARED. THE NEXT MORNING WE HEADED OUT ON I15 ON OUR TRIP TO OUR VACATION DESTINATION AND IT DID IT AGAIN AS WE GOT ON THE HIGH WAY, I USE AN INJECTOR CLEANER IN CASE THAT WAS THE PROBLEM AS MY FRIENDS DAD HAD SUGGESTED. WE GOT TO FILLMORE, UT. AND WE LOSS TOTAL POWER AND STEERING CONTROL. WE COASTED OFF ONTO AN EXIT RAMP THERE WE WERE ABOUT TO PASS WHEN IT HAPPENED. HAD OUR VEHICLE TOWED TO THE ONLY MECHANIC OPENED AT THE TIME ON A SATURDAY AFTERNOON. HE SAID THE SAME THING ABOUT THE CODES. THEN HE SAID WE HAD A BAD CATALACK-CONVERTER. WE HAD IT TOWED BACK TO OUR FRIENDS DADS SHOP AN HOUR AND A HALF NORTH. THE NEXT DAY HE SAID HE THINKS IT MAY BE THE COILS BUT THE CODES SAY ALL OF THEM. SO WE HAD HIM TAKE IT TO FORD IN PROVO, UT WHILE WE RENTED A CAR AND HAD SOME OF OUR VACATION, MOST OF IT WE MISSED SPENDING DAYS WAITING ON A WORD FROM FORD SERVICE AFTER WE GOT IN FROM OUR COUPLE OF DAYS WE DID GET IN OF OUR VACATION. WE THOUGHT THEY WERE GOING TO DO THE WORK WHILE WE WERE GONE, BUT NO. NOW WE ARE HOME AFTER PAYING $730.- FOR INJECTORS AND A NEW COIL. (I THOUGHT) THEY STILL HAVE OUR VEHICLE IN THE BAY GETTING NEW CATALACK CONVERTERS PUT ON(BOTH) AND IS AN ADDITIONAL $1900.- PLUS TO MAKE IT WORSE THEY CALLED TODAY AND SAID ALL THE COILS HAVE TO BE REPLACED. I THOUGHT THAT WAS DONE, APPARENTLY NOT, AND THIS IS NOT RARE FOR 2005 ESCAPES, OH.

NHTSA ID

10807654

Incident

Nov 15, 2015

Mileage

67,200 mi

WHEN DRIVING CAR SHUTS OFF. CAR STARTS IN PARK WHEN PUT IN GEAR SHUTS OFF. DRIVING ON HIGHWAY WHEN SLOWED DOWN IN TRAFFIC CAR SHUT OFF, AND WOULD WOULD START IN PARK BUT SHUT OFF WHEN PUT IN GEAR

NHTSA ID

10783560

Incident

Oct 18, 2015

Mileage

1,650,000 mi

THE ACCELERATOR PEDAL WILL NOT GO DOWN/FORWARD AT FIRST (ONCE LASTED ABOUT 45 MINUTES) ON COLD MORNINGS. WHY HASN'T THIS YEAR/MAKE/MODEL BEEN RECALLED LIKE 2006? I'VE BEEN LATE FOR WORK SEVERAL TIMES BECAUSE OF THIS. I LOVE THE CAR OTHERWISE.

NHTSA ID

10731328

Incident

Dec 23, 2014

Mileage

109,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. AFTER DRIVING OVER A BUMP, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR SHOCK TOWERS WERE RUSTED. IN ADDITION, THE CONTACT STATED THAT A FUEL ODOR EMITTED INSIDE THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 74,000.

NHTSA ID

10726490

Incident

Jun 20, 2015

Mileage

74,000 mi

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 70 MPH, AN UNKNOWN WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE CONTACT RESTARTED THE VEHICLE, BUT THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE REPLICATED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10682797

Incident

Sep 15, 2014

FIRST OCCURRENCE OF PROBLEM: 48800 MILES, 5/2012. ENGINE LIGHT ON AND ENGINE MISFIRING. FORD DEALERSHIP DETERMINED FAULTY IGNITION COIL IN # 6 CYLINDER. REPLACED IGNITION COIL AND SPARK PLUG. $295 SECOND OCCURRENCE OF PROBLEM: 74,400 MILES, 11/2013. ENGINE LIGHT ON AND ENGINE MISFIRING. MECHANIC REPLACED SPARKPLUGS IN CYLINDERS # 1-3 ALL AT ONCE SINCE IT IS DIFFICULT TO ACCESS THOSE. $276 ADDITIONAL OCCURRENCES OF SAME PROBLEM: UPON MISFIRING IN 2014 I BOUGHT A CODE READER WHICH INDICATED CYLINDER #5 MISFIRE - REPLACED IGNITION COIL AND SPARK PLUG. MORE MISFIRING INDICATED CYLINDER #4 MISFIRE - REPLACED IGNITION FOIL AND SPARK PLUG. MAJOR PROBLEM UPDATE. 2/2/2015 - TRAVELLING 55 MPH CAR SHUTS OFF, ALL WARNING LIGHTS COME ON, COAST TO SHOULDER. RESTART CAR, SEEMS FINE, NO WARNING LIGHTS. AGAIN CYLINDER # 4 MISFIRING - REPLACED SPARK PLUG. MY RESEARCH INDICATES THE ECM/PCM MAY BE DAMAGED AND THAT THIS IS A VERY FREQUENT PROBLEM WITH THIS CAR, OFTEN MANIFESTING AFTER THE WARRANTY EXPIRES/RECALL MILEAGE, AND COSTS $2000-$3000 OR MORE. I DON'T WAN'T TO PAY TO HAVE IT FIXED BECAUSE MANY PEOPLE HAVE HAD THE PCM FRIED MULTIPLE TIMES BUT I'M SCARED IT WILL SHUT DOWN WHILE DRIVING AGAIN AND THINK THIS SHOULD BE COVERED BY A RECALL. MANY PEOPLE ARE HAVING THIS PROBLEM AND IT APPEARS TO BE CAUSED BY FORD ENGINEERING. PLEASE HELP FORCE A RECALL OR PROVIDE ME WITH INFORMATION FOR A CLASS ACTION LAWSUIT. *JS

NHTSA ID

10682008

Incident

May 5, 2012

Mileage

48,881 mi

VEHICLES GAS PEDAL GETS STUCK UP AND CANNOT BE DEPRESSED AT ALL WHILE CAR IS ON AND I AM DRIVING. IT HAPPENED THIS WEEK SEVERAL TIMES ON VERY COLD DAYS. WHILE DRIVING OR WHILE STOPPED AT LIGHT AND TRYING TO GO I CANNOT DEPRESSED THE PEDAL, EVEN WHEN PUSHING HARD. EVENTUALLY IT DEPRESSED FOR ME AFTER SEVERAL TRIES. VEHICLE GAS PEDAL HAS ALSO GOTTEN STUCK DOWN TWICE PREVIOUSLY WITH CAR ACCELERATING UNCONTROLLABLY, WHICH HAPPENED FOR ALMOST A MINUTE THEN IT POPPED UP - RESULTED IN NEAR COLLISION { THANK GOODNESS ITS A MANUAL TRANSMISSION]. I HAVE READ IN MANY ON-LINE DISCUSSION BOARDS OF MANY OTHER INDIVIDUALS HAVING THEIR GAS PEDAL ON FORD ESCAPES STICK UP OR DOWN ALSO. *TR

NHTSA ID

10670728

Incident

Jan 5, 2015

Mileage

173,200 mi

AFTER TOTALING A 2004 ESCAPE, I PURCHASED ANOTHER 2005 ESCAPE BECAUSE I LOVED IT. WELL NOT SO MUCH ANYMORE. I BOUGHT THE VEHICLE FROM A DEALERSHIP IN SEPTEMBER 2012. ONLY THREE SHORT MONTHS LATER I STARTED HAVING THE EXACT SAME PROBLEM I AM READING IN ALL COMPLAINTS. I TRIED TO PUSH ON THE GAS AND NOTHING. IT WAS MISFIRING BAD. I THEN TOOK IT TOO A SHOP AND THEY TOLD ME COILS 1, 3, AND 5 WERE OUT AND NEEDED TO BE REPLACED. THE DEALERSHIP WANTED CLOSE TOO $2,000 TO REPAIR IT. I WAS FURIOUS BECAUSE I HAD BOUGHT MY 2004 FROM THE SAME DEALERSHIP AND MY FAMILY ALONE HAD PURCHASED A TOTAL OF 6 VEHICLES FROM THE DEALERSHIP. I WAS A LOYAL CUSTOMER AND WAS NOT GOING TO PAY TO HAVE IT FIXED. SO THEY SPLIT THE COST OF $1000 WITH ME. NOW IT IS ACTING UP AGAIN AND I'VE REPLACED THE FUEL FILTER AND THE THERMOSTAT BC THAT'S WHAT THE COMPUTER SAID ONLY FOR IT TO STILL NOT BE RUNNING. I AM A SINGLE MOTHER, COLLEGE STUDENT, AND SERVER AND IT'S 2 DAYS BEFORE CHRISTMAS SO I AM VERY DISAPPOINTED! FIX THE PROBLEM FORD!! *TR

NHTSA ID

10668090

Incident

Dec 4, 2012

Mileage

86,000 mi

GAS PEDAL STICKS, ESPECIALLY IN COLD WEATHER. *TR

NHTSA ID

10655293

Incident

Oct 11, 2014

Mileage

120,000 mi

DRIVING HM FROM WK, 5FWY CAR STALL COAST TO THE SIDE CALLED AAA TO BE TOWED TO EF1 MOTORSPORTS INC. I WAS INFORMED THAT THIS WAS A MANUFACTURE PROBLEM FOR THIS YEAR SUV 2005. THE WRONG COMPUTER SYSTEM WAS INSTALLED THE COST TO REPAIR $1443.06. I WOULD LIKE A REFUND. *TR

NHTSA ID

10628601

Incident

Jul 22, 2014

I TURNED A CORNER AND WAS ONLY GOING 20 MPH WHEN THE VEHICLE WENT DEAD. I HAD NO CONTROL SO LUCKILY I WASN'T GOING FAST. I STOPPED THE VEHICLE. I HAD TO GET IT TOWED. ONE MECHANIC SAID MY COILS AND SPARK PLUGS WERE BAD BECAUSE OF THE FUEL RAIL PRESSURE SENSOR MALFUNCTION. SECOND OPINION - THE PCM NEEDED TO BE REPROGRAMMED OR REPLACED. THIRD OPINION - ALL OF THE ABOVE. IT COSTS $1900 AND TWO TOW BILLS ($275). THE ENGINE LIGHT HAD BEEN ON FOR SEVERAL MONTHS. THE ONLY CODE WAS THE FUEL RAIL PRESSURE SENSOR HIGH INPUT (P0193 GENERIC). *TR

NHTSA ID

10593745

Incident

Apr 28, 2014

Mileage

139,400 mi

TWO REGULAR ONGOING ISSUES......WHEN DRIVING, IF FOOT IS TAKEN OFF GAS PEDAL TO EASE UP SPEED, GAS PEDAL THEN STICKS AS IF SOMETHING IS BLOCKING IT (NOTHING IS BLOCKING), NO AMOUNT OF PRESSING WILL MOVE IT, AFTER SOME SECONDS OR A MINUTE, IT WILL FUNCTION AGAIN. HAPPENS MOST OFTEN WHEN COLD, OR WHEN JUST STARTING OUT. CAR CONTINUES TO DECELERATE UNTIL THE GAS PEDAL BEGINS TO FUNCTION AGAIN. SECOND ISSUE.......ENGINE LIGHT WITH CODE P0455 IS ON MOST OF THE TIME, GAS CAP LOOSE LIGHT WILL ALSO COME ON , REPLACING GAS CAP DID NOT HELP. *TR

NHTSA ID

10583684

Incident

Apr 9, 2014

Mileage

63,000 mi

I WAS DRIVING MY FORD ESCAPE 2005 AND IT COMPLETELY SHUTS OFF, THE STEERING WHEEL GOT VERY HARD!!! IT WAS VERY DIFFICULT TO STEER, *TR

NHTSA ID

10576556

Incident

Apr 1, 2014

Mileage

183,000 mi

WE FIRST EXPERIENCED THE STICKING GAS PEDAL IN MAYBE 2008. WE BROUGHT IT TO HAWK FORD IN OAK LAWN, ILL AND THEY SAID THERE WAS NOTHING WRONG WITH OUR TRUCK.. THIS PROBLEM CONTINUED ON AND OFF FOR YEARS. THE LAST STRAW WAS WHEN MY HUSBAND HAD TO DRIVE APPROXIMATELY 50 MILES WITH HIS FOOT ON THE BRAKE AND THE GAS PEDAL TO GET TO OUR HOUSE. I HAD PREVIOUSLY REPORTED THIS LIFE-THREATENING SITUATION TO YOUR DATABASE A FEW YEARS AGO. I FOLLOWED UP WITH SEVERAL LETTERS/E-MAILS TO FORD, ALL OF WHICH WERE UNSYMPATHETIC AND MET WITH VEILED SARCASM AND LACK OF INTEREST. I STILL WONDER HOW THEY SLEEP AT NIGHT KNOWING THIS TERRIBLE AND DANGEROUS DEFECT IS REAL. *TR

NHTSA ID

10569179

Incident

Sep 1, 2008

Mileage

64,000 mi