2005 Ford Expedition Engine Problems

Engine Missing

NHTSA ID

11576940

Incident

Mar 12, 2024

The contact owns a 2005 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle made an abnormal sound. The vehicle was taken to an independent mechanic, where the contact was notified of an engine misfire. The spark plugs were replaced. Additionally, the contact stated while driving 55 MPH, the brake pedal became stiff, and the vehicle failed to immediately stop. Additionally, the vehicle made an abnormal sound and stalled. The vehicle was taken to an independent mechanic, who informed the contact that the spark plugs, and the engine needed to be replaced. The manufacturer was made aware of the failure and referred the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 89,000.

NHTSA ID

11531329

Incident

Dec 18, 2013

Mileage

89,000 mi

ENGINE MAKES RATTLING NOISE AND MISSING BADLY

NHTSA ID

11269009

Incident

Nov 1, 2016

Mileage

30,000 mi

MY CAR AT TIMES WILL GIVE A HARD START. TURNING, BUT NOT FULLY TURNING OVER OR GIVES OFF A SOUND THAT I CAN ONLY DESCRIBE AS AN ELEPHANT TRUMPETING. WHEN IT DOES START AT TIMES IT WILL SHUT COMPLETELY OFF JUST AS FAST. IT HESITATES TO PICK UP ADEQUATE SPEED AND WILL STUMBLE OR JERK, AND WHEN PUT IN REVERSE IT WILL COMPLETELY STALL OUT. I'VE HAD A NEW BATTERY INSTALLED, AND THE SPARK PLUGS AND BOOTS HAVE BEEN CHANGED, BUT TO NO AVAIL.

NHTSA ID

11222664

Incident

May 4, 2019

Mileage

152,600 mi

THE CAR TURNS OFF. I NEED TO PUT THE CAR IN PARK WAIT A FEW MINUTES THEN TURN THE CAR BACK ON AND IT WORKS. THE BAD THING IS IT CAN HAPPEN AT ANY TIME.

NHTSA ID

11203403

Incident

Apr 23, 2019

Mileage

186,609 mi

I WAS DRIVING AND ALL OF A SUDDEN STEERING WHEEL LOCKED AND MY CAR LITERALLY SHUT OFF WHILE I WAS DRIVING.. I COASTED TO THE SIDE AND I TURNED OFF CAR.. TRIED TO TURN IT BACK ON AND IT KEPT CRANKING AND I KEPT DOING IT LIKE 5 TIMES UNTIL IT STARTED BACK UP. SURE IT IS A 2005, BUT IT HAS BEEN GIVING ME PROBLEMS SINCE I GOT IT, NOW IT IS WORSE. I DON'T BELIEVE IT IS WEAR AND TEAR I ACTUALLY REPLACED THE WHOLE ENGINE 4 YEARS AFTER I BOUGHT MY CAR WHICH IS RIDICULOUS TO BEGIN WITH. IF MY CAR BURNS UP WHILE I AM DRIVING I WILL REALLY MAKE A STINK..

NHTSA ID

11063196

Incident

Jan 14, 2018

Mileage

200,000 mi

VEHICLE VIBRATES BADLY ESPECIALLY AT HIGHWAY SPEEDS. VIBRATION IS SO BAD, THE VEHICLE ROCKS SIDE-TO-SIDE WHILE DRIVING. DRIVING AT HIGHWAY TURNPIKE SPEED OF 75MPH, VEHICLE ENGINE BEGAN TO SURGE AND THEN COMPLETELY SHUT DOWN. OIL PRESSURE GAUGE INDICATED LOW OIL PRESSURE AND VEHICLE WOULD NOT START. VEHICLE STILL HAD ELECTRICAL FUNCTION BUT ENGINE NO LONGER WOULD TURN OVER. CHECKED ENGINE OIL LEVEL AND HAD ENGINE OIL. CALLED HIGHWAY PATROL AND HAD TO HAVE THE VEHICLE TOWED. *TR

NHTSA ID

10948179

Incident

Jan 28, 2017

Mileage

214,200 mi

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED ABNORMALLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10935483

Incident

Oct 10, 2016

Mileage

120,000 mi

THIS CAR JUST NUMEROUS OF PROBLEM..... WHO EVER BUILT THIS CAR DID NOT HAVE A GOOD JOB OF DOING IT

NHTSA ID

10928624

Incident

Nov 27, 2016

MY ENGINE SAID FAIL SAFE MODE. MY SPARK PLUGS GOT STUCK IN ENGINE COSTING ME 1000 TO FIX.

NHTSA ID

10881950

Incident

Jun 30, 2016

Mileage

112,000 mi

MY 2005 EXPEDITION IS MAINTAINED NORMALLY AND SPARK PLUGS CHANGED AND THE ENGINE WILL EITHER CUT OFF OR SLOW DOWN TO ABOUT 30 MILES AN HOUR WHILE I AM ON THE HIGHWAY WITH A ERROR MESSAGE FAIL SAVE MODE. MOST TIMES WHEN I SHUT OFF THE ENGINE AND RESTART IT TURNS OVER BUT DOESN'T STAY ON. TOTALLY UNSAFE FOR ME AND MY FAMILY. PLEASE RESEARCH AND RECALL WHAT THE ISSUE IS! THIS ISSUE HAS STARTED ABOUT 4 YEARS AFTER WE PURCHASED THE VEHICLE AND HAS BEEN HAPPENING MAYBE ONE TO TWO TIMES A MONTH SINCE.

NHTSA ID

10876578

Incident

Jun 25, 2016

Mileage

120,000 mi

FOR MANY TIME THAT MY EXPEDITION HAS STALLED BECAUSE OF THE THROTTLE BODY FAILING. THE ENGINE GOES INTO SAFE MODE AND STALLS AND STOPS, THI IS VERY DANGER SITUATION

NHTSA ID

10873914

Incident

Jun 1, 2016

I HAVE A 2005 FORD EXPEDITION AND HAVE MAINTAINED MY VEHICLE MAINTENANCE AND ONLY HAVE 124,000 MILES ON THIS VEHICLE. IT CONTINUES TO SHUT OFF THE ENGINE AND CODE FAIL SAFE MODE ON CODE APPEAR AND WHEN I'M DRIVING ON THE HIGHWAY IT IS DANGEROUS. AFTER READING SO MANY COMPLAINTS THIS IS UNSAFE. ALSO, THE COMPUTER ISSUES WITH LOCKING DOORS, FAILURE OF THE TRANSMISSION (WHICH I HAD TO REPLACE) SUCH A DISAPPOINTMENT OF A VEHICLE. FORD SHOULD RECALL ENGINE AND COMPUTER ISSUES. I PURCHASED THIS VEHICLE BRAND NEW $50,000 + AND HAVE NOT BE ABLE TO DEPEND ON THE STABILITY SINCE I'VE HAD IT.

NHTSA ID

10852059

Incident

Mar 1, 2016

Mileage

20 mi

MY FORD EXPEDITION, WHILE DRIVING AT 40 MILES AN HOUR LOST POWER. THIS IS THE 3RD TIME IN 2 YEARS IT HAS HAPPENED. ON THE INFO CENTER IT STATED ENGINE FAIL SAFE MODE. THE THREE TIMES IT HAS HAPPENED HAS BEEN ON BACK ROADS.I CONSIDER THIS A VERY UNSAFE CONDITION . MY DEALER LOOKED AT IT THE FIRST TWO TIMES AND SAID THERE WERE NO CODES, THAT I WOULD NEED TO BRING IT IN SOONER. BUT THERE ARE NO LASTING RESULTS, AND IT STARTS RIGHT BACK UP.

NHTSA ID

10748973

Incident

Apr 13, 2012

Mileage

65,000 mi

MY 15 YEAR OLD SON AND MY LIFE WERE PLACED IN SERIOUS DANGER, BY THE GROSS NEGLIGENCE AND DECEPTIVE BUSINESS PRACTICES PROMOTED BY THE FORD MOTOR COMPANY, REGARDING SCAN CODE P2106. SINCE AS EARLY AS FEBRUARY 26, 2013 FORD MOTOR COMPANY WAS MADE AWARE OF A DANGEROUS DEFECT CONCERNING THE MECHANICAL AND ELECTRICAL COMPONENTS OF THEIR MANUFACTURED PRODUCT RELEASED TO THE CONSUMER PUBLIC FOR PROFIT. THE VEHICLES ARE FORD TRUCKS, MANUFACTURED FROM 2003 - 2008, WITH THE V8 5.4 L ENGINE. PUBLIC RECORD REVEALS CASE NO. 12-7222, JASON SCHMIDT, (PLAINTIFF) VS. FORD MOTOR COMPANY, (DEFENDANT) FILED IN THE UNITED STATES DISTRICT COURT FOR THE EASTERN DISTRICT OF PENNSYLVANIA, THAT FORD MOTOR COMPANY IS WELL AWARE OF THIS ISSUE. I BELIEVE THAT FORD MOTOR COMPANY HAS MADE NO ATTEMPTS TO INFORM FORD DEALERSHIP OWNERS, THE FORD DEALERSHIP MANAGERS OR FORD SERVICE REPAIR SHOP MANAGERS AT THE FORD DEALERSHIPS AND CONSUMERS WHO HAD ALREADY PURCHASED THEIR MANUFACTURED PRODUCT OF THE ISSUE. THIS ISSUE IS VERY DANGEROUS, I WAS TRAVELING 70 MPH, WITH MY SON IN THE TRUCK. FORD MOTOR COMPANY HAS GONE ON RECORD, VIA TELEPHONE CONVERSATION, EXPLAINING TO ME THAT; "FORD MOTOR COMPANY HAS NO CONTROL OVER HOW INDIVIDUAL DEALERSHIPS FUNCTION OR OPERATE THEIR ESTABLISHMENT PLACES OF BUSINESS, SORRY. BUT I CAN TAKE A COMPLAINT AND BE SURE THAT THE DEALERSHIP RECEIVES IT AND PROVIDE YOU WITH A COMPLAINT NUMBER". FLAMMER FORD, SPRING HILL, FL REPLACED A PART AND NEGLECTED TO TEST DRIVE THE TRUCK, RELEASED THE VEHICLE TO ME AND THE PART REPLACED WAS NOT WHAT WAS WRONG WITH THE TRUCK. I HAD MY TRUCK TOWED TO AUTONATION FORD IN BROOKSVILLE, FL FOR THE SAME ISSUE (P2106 CODE), THEY DID THE SAME THING, WITHOUT REPLACING A THING. ONLY THIS TIME, WHILE DRIVING ON A HIGHWAY, MY TRUCK AND THE LOST ALL POWER. MY TRUCK IS BACK AT AUTONATION FORD IN NEED OF A NEW TRANSMISSION.

NHTSA ID

10748773

Incident

Jul 30, 2015

Mileage

147,024 mi

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION.....UPDATED 08/25/15 *BF

NHTSA ID

10730287

Incident

Nov 18, 2014

Mileage

111,520 mi

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE THROTTLE BODY SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,800.

NHTSA ID

10693800

Incident

Mar 10, 2015

Mileage

121,800 mi

SINCE PURCHASING THE EXPEDITION IN DECEMBER 2014, I'VE HAD SEVERAL INCIDENTS OF "CHECK ENGINE THROTTLE" WARNINGS AND THE ENGINE SHUT DOWN, SUDDENLY. THIS SEEMS TO ALSO HAVE A SECONDARY ISSUE OF THE TRUCK HESITATING/SPUTTERING AROUND 40-50MPH. THE VEHICLE HAS SHUT DOWN ON ME IN CITY TRAFFIC QUITE A FEW TIMES AND ONCE ON AN EXIT RAMP OF THE HIGHWAY. THIS IS A VERY DANGEROUS SITUATION TO EXPERIENCE. THE DEALER MENTIONED POSSIBLE SPARK PLUG ISSUES. WHEN THE "CHECK ENGINE" ICON FINALLY CAME ON, I HAD IT READ BY THE DEALER AND AN INDEPENDENT MECHANIC. THE CODE IS A P2104. THE DEALER NEVER GOT BACK TO ME ON A REMEDY FOR THIS. THE MECHANIC SAYS THE ELECTRONIC THROTTLE CONTROL MUST BE REPLACED AND COULD BE THE CAUSE OF BOTH ISSUES. BOTH HAVE BEEN REPORTED TO THE DEALER BEFORE THEIR WARRANTY EXPIRED. I'M FINDING THE REPAIR COULD COST ABOUT $700. AN ISSUE OF THE ENGINE SHUTTING OFF, REGARDLESS OF SPEED, WHILE DRIVING IS VERY DANGEROUS. THE TRUCK MUST BE PLACED IN PARK, TURNED OFF, THE RE-STARTED BEFORE CONTINUING MY DRIVE. THE SCARIEST WAS UPON AN EXIT RAMP OF THE HIGHWAY AT APPROXIMATELY 30MPH. *TR

NHTSA ID

10693758

Incident

Mar 10, 2015

Mileage

150,000 mi

THIS IS THE 4TH TIME IN 5 WEEKS THAT MY CAR HAS SHUT DOWN WHILE DRIVING AND IT SAYS "ENGINE FAIL SAFE MODE". IT HAS BEEN IN THE SHOP AFTER THE FIRST 3 INCIDENTS AND DIFFERENT THINGS HAVE BEEN DONE TO IT. I JUST GOT IT OUT OF THE SHOP AND IT HAPPENED THE 4TH TIME. SO IT'S GOING BACK TO SHOP. I HAVE BEEN FORTUNATE, AND HAVE NOT BEEN IN A ACCIDENT AS A RESULT OF IT SHUTTING DOWN. LOOKING ONLINE IT'S AMAZING HOW MANY PEOPLE HAVE EXPERIENCED THIS SAME ISSUE. WHY HAS FORD OR NHTSA NOT DONE SOMETHING ABOUT THIS? WILL IT TAKE SOMEONE GETTING KILLED BEFORE THEY TAKE ACTION? *TR

NHTSA ID

10691203

Incident

Feb 27, 2015

Mileage

176,000 mi

WHILE DRIVING THE VEHICLE WENT INTO A HEAVY VIBRATION FROM THE MOTOR AND THE SMELL OF RAW FUEL WAS PRESENT. AFTER TURNING OFF THE VEHICLE IT WOULD NOT START. THE VEHICLE WAS TOWED TO THE FORD DEALER AND THE DEALER STATED THAT A FUEL INJECTOR BECAME STUCK OPEN. THE INJECTOR FILLED THE CYLINDER WITH FUEL AND CAUSED THE ENGINE TO BLOW UP (SEVERE DAMAGE). IT WAS FOUND THAT THIS OCCURRED ON FORD EXPEDITIONS NUMEROUS TIMES AND FORD EXTENDED THE WARRANTY TO 11 YEARS, 120,000 MILES AND MY SCARY EXPERIENCE OCCURRED AT 129,000. I PREVIOUSLY REPLACED THE MOTOR AT MY OWN EXPENSE 2 YEARS PRIOR AND FORD DID NOT REPLACE THE INJECTORS OR NOTIFY ME OF AN INJECTOR ISSUE. FORD IS STATING THAT THEY WILL NOT HONOR THE WARRANTY AND THE ENGINE DAMAGE WAS CAUSED BY THE INJECTOR THAT WAS NOT REPLACED. IT WAS FOUND THAT FORD WAS AWARE OF THE INJECTOR ISSUE SINCE 2007. I'M NOT SURE THESE ISSUE ARE GETTING REPORTED. *TR

NHTSA ID

10681481

Incident

Jan 13, 2014

Mileage

129,000 mi

WHILE DRIVING ALONG AT 55 MPH ENGINE SHUT DOWN. NO POWER BRAKES, STEERING, ETC. INDICATOR MESSAGE ON DASHBOARD SAID "CHECK ELECTRONIC IGNITION". REPAIR COST $ 724.19. *TR

NHTSA ID

10681465

Incident

Apr 16, 2013

Mileage

125,000 mi

VEHICLE CHECK ENGINE LIGHT STAYS ON. VEHICLE TURNS OFF WHEN SITTING IDLE. BROUGHT VEHICLE TO DEALERSHIP AND THEY SAID THEY FIXED IT, BUT AFTER LEAVING THE DEALERSHIP AND PAYING A LARGE BILL THE CHECK ENGINE LIGHT CAME BACK ON AND STILL CUTS OFF WHEN JUST SITTING IDLE IN "DRIVE". SCARED THAT THIS CAN CAUSE AN ACCIDENT IF SOMEONE BEHINDS ME DOESN'T REALIZE THAT MY VEHICLE CUTS OFF. *TR

NHTSA ID

10681015

Incident

Aug 30, 2014

Mileage

144,239 mi

I HAVE HAD AN ENGINE CHECK LIGHT AND NO ONE CAN FIND THE PROBLEM. SOME MECHANICS TELL ME ITS ONE THING AND THE OTHERS SOMETHING ELSE. TOOK TO A.V FORD AND QUICKLANE IN NORTH HOLLYWOOD. MY TRUCK STAYED SEVERAL DAYS AT SHOP AND STILL CANT FIND PROBLEM. MECHANIC EVEN CALLED DETROIT PLANT TO GET ADVISE. STILL NOT RESOLVED. PAID TOO MUCH JUST TRYING TO FIGURE THE PROBLEM. HAS THERE BEEN ANY ISSUES BROUGHT TO YOU ABOUT ENGINE LIGHT ON FOR FORD TRUCKS. I HAVE DOCUMENTS OF VISITS TO MECHANICS IF YOU GUYS NEED THEM. *TR

NHTSA ID

10678972

Incident

Feb 18, 2012

Mileage

171,745 mi

FOR THE 3RD TIME IN THE PAST YEAR I AM DRIVING DOWN THE ROAD AT ABOUT 40 MPH - ENGINE LIGHTS COMES ON, MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" COMES ON - I HAVE NO POWER, I COAST TO THE SIDE LANE TURN ON HAZARD LIGHTS, TURN KEY TO OFF POSITION. RESTART THE CAR (TAKES A COUPLE OF TRIES) AND CONTINUE - THIS IS EXTREMELY DANGEROUS AND SHOULD BE ADDRESSED BY FORD ( I HAVE REPORTED THIS ISSUE) LOOKING ON LINE AND ON ONE SITE HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPEDITION/2005/ENGINE/VEHICLE_SPEED_CONTROL.SHTML THERE ARE 52 COMPLAINTS WITH THE SAME ISSUE. THERE ARE MANY OTHER SITES REPORTING THE SAME EXACT PROBLEM. I AM TAKING MY VEHICLE TO THE DEALER TOMORROW - WHAT ELSE SHOULD I BE DOING TO RESOLVE THIS ISSUE. - IT'S APPARENT THAT MANY OTHER PEOPLE ARE HAVING THIS SAME EXACT ISSUE- DOES IT TAKE SOMEONE DYING TO GET THE CAR MANUFACTURERS TO LISTEN TO THEIR CUSTOMERS? *TR

NHTSA ID

10659429

Incident

Nov 19, 2014

Mileage

90,000 mi

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION. *TR

NHTSA ID

10659173

Incident

Nov 18, 2014

Mileage

111,520 mi