2001 Ford Explorer Sport Problems

AS MANY OTHER OWNERS OF THE FORD EXPLORER SPORT HAVE COMPLAINED ABOUT, THERE IS A VERY LOUD BANGING COMING FROM THE REAR END OF MY SUV WHENEVER I DRIVE OVER EVEN THE SLIGHTEST BUMP OR ROUGH ROAD. I HAVE REPLACED THE SHOCKS BUT IT DID NOT MAKE ANY DIFFERENCE TO THIS PROBLEM. IT STILL IS SO LOUD AND THE RIDE REMAINS VERY ROUGH. I NOW UNDERSTAND THAT THE BODY MOUNT BUSHINGS HAVE DETERIORATED AND WILL NEED TO BE REPLACED TO IMPROVE THE RIDE AND MAKE THE VEHICLE SAFE TO DRIVE AGAIN. *TR

2001 FORD EXPLORER SPORT. DURING NORMAL DRIVING, A REAR RATTLE/ BANGING NOISE WOULD OCCUR WHEN GOING OVER ROUGH ROAD OR OVER BUMPS. THIS HAS PROGRESSIVELY GOTTEN WORSE OVER TIME. INVESTIGATION AND INSPECTION OF THE VEHICLE HAD REVEALED THAT ALL THE BODY/FRAME MOUNT BUSHINGS HAVE DETERIORATED TO THE POINT THAT THEY WERE CRUMBLING, LEAVING NO SUPPORT/CUSHION BETWEEN BODY AND FRAME. THIS COULD POTENTIALLY MAKE THE VEHICLE UNSAFE AS THERE WOULD BE NO SUPPORT FOR THE BODY, CAUSE EXCESSIVE BODY MOVEMENT AND A SHIFT IN THE VEHICLE WEIGHT DYNAMICS. THIS ISSUE HAS ALREADY BEEN REPORTED IN SEVERAL VEHICLE SAFETY COMPLAINTS PRIOR TO MINE. *TR

2001 FORD EXPLORER SPORT. DURING NORMAL DRIVING, A REAR RATTLE/ BANGING NOISE WOULD OCCUR WHEN GOING OVER ROUGH ROAD OR OVER BUMPS. THIS HAS PROGRESSIVELY GOTTEN WORSE OVER TIME. INVESTIGATION AND INSPECTION OF THE VEHICLE HAD REVEALED THAT ALL THE BODY/FRAME MOUNT BUSHINGS HAVE DETERIORATED TO THE POINT THAT THEY WERE CRUMBLING, LEAVING NO SUPPORT/CUSHION BETWEEN BODY AND FRAME. THIS COULD POTENTIALLY MAKE THE VEHICLE UNSAFE AS THERE WOULD BE NO SUPPORT FOR THE BODY, CAUSE EXCESSIVE BODY MOVEMENT AND A SHIFT IN THE VEHICLE WEIGHT DYNAMICS. THIS ISSUE HAS ALREADY BEEN REPORTED IN SEVERAL VEHICLE SAFETY COMPLAINTS PRIOR TO MINE. *TR

ALL BODY BUSHINGS WERE DEFECTIVE AND HAD TO BE REPLACED. THE BUSHINGS WERE DESICCATED AND HAD CRUMBLED AWAY. THIS MADE THE VEHICLE UNSAFE WHEN CORNERING AS THERE WAS NOTHING TO SUPPORT THE WEIGHT OF THE BODY BETWEEN IT AND THE FRAME CAUSING EXCESSIVE MOVEMENT AND COMPROMISE OF CENTER OF GRAVITY. ACCORDING TO THE MECHANIC WHO REPLACED MY BUSHINGS, HE HAD SEEN THIS DEFECT ON ALL THE VEHICLES OF THIS MAKE AND MODEL YEAR. HE SAID THAT IT WAS NOT A PROBLEM ON THE 1998 FORD EXPLORER SPORT. I WENT TO A LOCAL JUNK YARD AND LOOKED AT SEVERAL FORD EXPLORER SPORTS AND NOTICED THE SAME DEFECT ON ALL THE 2001 MODEL YEARS. THE 1998 MODEL YEAR HAD BUSHINGS THAT WERE STILL IN GOOD CONDITION. *JS

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACTED WAS DRIVING 35 MPH WHEN WHITE SMOKE EMITTED FROM THE FENDER OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND DISCOVERED FLAMES WERE COMING FROM UNDER THE HOOD. THE VEHICLE WAS DESTROYED. THE POLICE AND FIRE DEPARTMENTS WERE CONTACTED AND REPORTS WERE FILED. THE FAILURE CAUSED NO INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 126,000.

AT 2100-2300 RPM ON ACCELERATION A PINGING SOUND IS HEARD THAT SOUNDS LIKE SPARK KNOCK (DETONATION). THE ACTUAL CAUSE IS FROM DEFECTIVE TIMING CHAIN GUIDES WHICH ALLOWS SLACK IN THE TIMING CHAINS (4.0 ENGINES HAS ONE IN FRONT AND ONE IN REAR) AND IS CAUSING IT TO RATTLE AND EAT AWAY AT THE GUIDES. THIS IS COMMONLY KNOWN AS THE "RATTLE OF DEATH" ON THE FORD 4.0 ENGINES BECAUSE ONCE THE PLASTIC ON THE GUIDES GETS EATEN AWAY BY THE LOOSE TIMING CHAIN, IT EATS INTO THE METAL SUPPORT AND CREATE METAL SHAVINGS THROUGHOUT THE ENGINE WHICH WILL CAUSE FAILURE, IF THE CHAIN DOES NOT FALL OFF FIRST. THIS IS A WELL KNOWN AND WELL DOCUMENTED PROBLEM DUE TO CHEAP TIMING CHAIN GUIDES. *TR

DRIVER SEAT BOLT

2001 FORD EXPLORER SPORT - OVERALL GOOD CONDITION - COMPLAINT INVOLVES FAILURE OF BOTH DOOR POWER LOCKS/HANDLE MECHANISMS. DRIVERS DOOR TOTALLY FAILED AND REPAIRS MADE AT AUTO SHOP, BUT MECHANISM QUICKLY FAILED AGAIN. EXPENSIVE REPAIR. - PASSENGER DOOR LOCK ALSO MALFUNCTIONING MILDLY BUT STILL OPERABLE FOR THE TIME BEING. APPEARS READY TO FAIL HOWEVER SINCE THIS WAS SAME PRIOR SYMPTOM OF THE OPPOSITE DOOR. NO INFORMATION LOCATED ON RECALL FROM FORD PREVIOUSLY FOR THIS PROBLEM. *TR

THE GUY BEFORE ME (AND MANY BEFORE HIM) EXPERIENCED THE SAME ISSUES I AM CURRENTLY EXPERIENCING WITH MY 2001 FORD EXPLORER SPORT: O/D OFF LIGHT BEGINS FLASHING, FEELING LOSS OF POWER AND HARD SHIFTING, ESPECIALLY WHEN TRYING TO GO FROM A COMPLETE STOP. TURN OFF VEHICLE, THEN RESTART PROBLEM GOES AWAY. THIS HAPPENS RANDOMLY, BUT MORE OFTEN IN COLD WEATHER. NOTHING COMING UP ON DIAGNOSTIC. *TR

2001 FORD EXPLORER SPORT. O/D OFF LIGHT BEGINS FLASHING, FEELING LOSS OF POWER AND HARD SHIFTING, ESPECIALLY WHEN TRYING TO GO FROM A COMPLETE STOP. TURN OFF VEHICLE, THEN RESTART PROBLEM GOES AWAY. THIS HAPPENS RANDOMLY, BUT MORE OFTEN IN COLD WEATHER. NOTHING COMING UP ON DIAGNOSTIC. *TR

MY PURCHASED NEW $30,000 2001 FORD 2 DOOR EXPLORER SPORT DIES OFTEN CAUSING NO BRAKES OR STEERING. IN 2001, IT DIED AND ROLLED OVER WITH NO STEERING OR BRAKES WHEN MY WIFE WAS DRIVING HOME, LEAVING HER STRANDED UPSIDE DOWN. FORD WOULD NOT RESPOND AND LOCAL DEALERS WOULD NOT OR COULD NOT SOLVE THE PROBLEM. IT STILL DIES AND ALL RECALLS WERE PRESUMABLY DONE, INCLUDING THE FIRESTONE TIRES WHICH WERE THE BEST PART OF THE VEHICLE. NUMEROUS LETTERS TO FORD WERE NEVER ACKNOWLEDGED. I WOULD LIKE TO HAVE A REFUND ON THIS VEHICLE. CAN YOU HELP ME? *TR

WHILE DRIVING ON A HEAVILY TRAVELED ROAD, DRIVER 2 CARS AHEAD OF ME CAME TO A DEAD STOP. VEHICLE IN FRONT OF ME HIT BRAKES HARD, I ALSO HIT MY BRAKES HARD, ON WET PAVEMENT. THE ANTI-LOCK BRAKE SYSTEM DID NOT KICK IN, AND THE BRAKES LOCKED UP.MY CAR SLID INTO THE REAR END OF DRIVER IN FRONT OF ME DOING EXTENSIVE DAMAGE TO THE FRONT END OF MY VEHICLE. AS I HAD JUST COME THROUGH A TRAFFIC LIGHT, I WAS NOT GOING MORE THAN ABOUT 25 MILES PER HOUR. THE WET PAVEMENT CAUSED MY CAR TO SKID QUITE A WAYS. THE DAMAGE TO MY VEHICLE INCLUDED THE ENTIRE BUMPER COVER BUCKLING, BOTH OF MY HEADLIGHTS AND TURN SIGNALS WERE DAMAGED AND BROKEN OUT. NONE OF THE COMPONENTS WERE PUSHED BACK INTO THE ENGINE COMPARTMENT. NEITHER THE DRIVER SIDE OR PASSENGER SIDE FRONT AIR BAGS DEPLOYED. MY PASSENGER WAS JOLTED FORWARD AND ALMOST HIT THE WINDSHIELD DESPITE HAVING SEAT BELT ON. I WAS JOLTED FORWARD AS WELL WITH SEAT BELT ON, AND MY CHEST HIT THE STEERING WHEEL.

CRUISE CONTROL ON AND SET DO NOT WORK ON ANY ROAD. VEHICLE MOVING ON ANY ROAD OR STANDSTILL.

MY WIFE WAS DRIVING ON A RESIDENTIAL ROAD AROUND 30 MPH WHEN SHE ATTEMPTED TO BRAKE. SHE WAS UNABLE TO STOP THE VEHICLE BY BRAKING. SHE SAID THE TRUCK WAS BUCKING WILDLY AS THOUGH IT WAS ATTEMPTING TO MAINTAIN IT'S 30 MPH SPEED. SHE PUT IT IN NEUTRAL AND PULLED OVER YET THE TRUCK CONTINUED TO IDLE AS THOUGH IT WERE DRIVING 30 MILES PER HOUR. SHE TURNED THE VEHICLE OFF. I ARRIVED 15 MINUTES LATER AND WITHOUT TOUCHING THE GAS PEDAL TURNED THE VEHICLE ON AND IT IMMEDIATELY REV'D AS SHE DESCRIBED SO I SHUT IT OFF. I THEN PUMPED THE GAS PEDAL (WITH THE TRUCK IN THE OFF POSITION) ASSUMING IT MAY BE STUCK THEN RESTARTED THE VEHICLE. IT STARTED AND SUBSEQUENTLY DROVE NORMALLY. I TOOK IT TO MY MECHANIC AND HE DISCOVERED NOTHING. NOTHING IN THE COMPUTER HISTORY AND NOTHING WRONG WITH THE SPEED SYSTEM (PEDAL, CABLE, THROTTLE, THROTTLE BODY...) I DID SOME RESEARCH ON-LINE AND DISCOVERED AN NHTSA REPORT (NHTSA ACTION NUMBER : PE05037) OF A POSSIBLE BAD SPEED CONTROL CABLE FOR THIS VEHICLE WHERE THE TEFLON COVER COULD COMES OFF AND BIND AT THE GAS PEDAL HOLDING THE PEDAL OPEN AND UNABLE TO RETRACT. WE ATTEMPTED TO LOCATE THE REPLACEMENT CABLE ONLY TO FIND THAT FORD NO LONGER MAKES THE ORIGINAL OR THE REPLACEMENT WHICH WE FIND UTTERLY UNBELIEVABLE. NO MORE EXIST ANYWHERE IN THE US. I CAN FIND PARTS FOR MY 1992 FORD MUSTANG EASIER. NOT SURE WHY THEY STOPPED MAKING THE CABLE WHICH MAKES THIS MORE INTERESTING. MY NEXT STEP IS TO HAVE MY MECHANIC REMOVE THE CABLE TO SEE IF THERE IS A TEFLON BUILD UP NEAR THE GAS PEDAL. NOTE: WE HAVE NO CLEAR PROOF THAT THE CABLE IS THE ISSUE YET AT THIS POINT THE FACT THAT IT CLEARED WHEN I PUMPED THE GAS PEDAL WITH THE VEHICLE IN THE OFF POSITION LEAVES SUSPICION THAT THIS COULD BE THE SAME ISSUE NOTED IN THE NHTSA PE05037 REPORT. *TR

MY WIFE WAS DRIVING HOME FROM WORK DURING AN ICE STORM AND LOST CONTROL OF HER 2001 FORD EXPLORER SPORT SUV AND STRUCK A TREE. SHE WAS TRAVELING APPROXIMATELY 25 MPH AT THE TIME OF THE ACCIDENT. NO AIR BAGS DEPLOYED DURING THE HEAD ON COLLISION WITH THE TREE. THE VEHICLE WAS TOTALED BY THE INSURANCE COMPANY AND IT SUSTAINED MAJOR SHEETMETAL AND FRAME DAMAGE. THE RADIATOR WAS PUSHED IN AND DESTROYED. *TR

WHILE DRIVING ON A HEAVILY TRAVELED ROAD, DRIVER 2 CARS AHEAD OF ME CAME TO A DEAD STOP. VEHICLE IN FRONT OF ME HIT BRAKES HARD, I ALSO HIT MY BRAKES HARD, ON WET PAVEMENT. THE ANTI-LOCK BRAKE SYSTEM DID NOT KICK IN, AND THE BRAKES LOCKED UP.MY CAR SLID INTO THE REAR END OF DRIVER IN FRONT OF ME DOING EXTENSIVE DAMAGE TO THE FRONT END OF MY VEHICLE. AS I HAD JUST COME THROUGH A TRAFFIC LIGHT, I WAS NOT GOING MORE THAN ABOUT 25 MILES PER HOUR. THE WET PAVEMENT CAUSED MY CAR TO SKID QUITE A WAYS. THE DAMAGE TO MY VEHICLE INCLUDED THE ENTIRE BUMPER COVER BUCKLING, BOTH OF MY HEADLIGHTS AND TURN SIGNALS WERE DAMAGED AND BROKEN OUT. NONE OF THE COMPONENTS WERE PUSHED BACK INTO THE ENGINE COMPARTMENT. NEITHER THE DRIVER SIDE OR PASSENGER SIDE FRONT AIR BAGS DEPLOYED. MY PASSENGER WAS JOLTED FORWARD AND ALMOST HIT THE WINDSHIELD DESPITE HAVING SEAT BELT ON. I WAS JOLTED FORWARD AS WELL WITH SEAT BELT ON, AND MY CHEST HIT THE STEERING WHEEL.

THIS HAS OCCURRED MULTIPLE TIMES SINCE I'VE HAD THE VEHICLE. I KNOW ENOUGH ABOUT VEHICLES TO KNOW THIS IS NOT NORMAL IN THE EARLY YEARS OF 125,000 MILES AND ROUTINE MAINTENANCE. WHEN I ACCELERATE FROM A STOPPED POSITION THE RPM'S GO UP TO ABOUT 3,000 OR SO BUT THE VEHICLE DOES NOT ACCELERATE. THE O/D LIGHT WILL FLASH AND THE VEHICLE, WHEN IT DOES ACCELERATE, IS "SLUGGISH". WHEN I PULL OVER AND TURN OFF THE VEHICLE, THEN TURN IT BACK ON, IT SEEMS TO RESET THE LIGHT SO THAT IT IS NO LONGER ILLUMINATED BUT EVENTUALLY THE ISSUE WITH THE LACK OF ACCELERATION COMES BACK WITHIN THE NEXT FEW MILES AND USUALLY IS A PROBLEM BETWEEN 1ST AND 2ND GEAR. IT HAPPENS LIKE CLOCK WORK WHEN I LEAVE A DRIVEWAY AND ENTER TRAFFIC WHICH PUTS ME IN FEAR OF BEING HIT BY AN ONCOMING VEHICLE. THIS IS DEFINITELY A POTENTIAL HAZARD AND IN AN ATTEMPT TO DIAGNOSE THE PROBLEM I HAVE COME ACROSS MULTIPLE ENTRIES ON "BLOGS" WITH SIMILAR SYMPTOMS THAT USUALLY BEGIN AROUND 120,000-150,000 MILES. IN MY OPINION, THE ISSUE CAUSING THE PROBLEM, AND THE POTENTIAL RISK TO MY LIFE AND OTHERS, SHOULD HAVE BEEN RECALLED YEARS PREVIOUS. THIS SEEMS TO BE TOO COMMON. VEHICLES, IN GENERAL, SHOULD NOT BE OPERATING LIKE THIS UNLESS THERE IS AN EXTREME LACK OF CARE IN REGARDS TO MAINTENANCE. ON ANOTHER NOTE... I'VE NOTICED THAT THE VARIOUS FAULTY PARTS THAT HAVE BEEN RECALLED ARE "QUICK FIXES" WHICH TRANSLATES TO ME AS "CHEAP FIXES". IF A COMPANY PRODUCES A PRODUCT THAT FAILS BEFORE IT'S TIME OR CAUSES DANGER TO IT'S CUSTOMERS, THEY SHOULD DEFINITELY ENSURE THAT THE PROBLEM BE REMEDIED. SO "MAN UP" FORD AND ADDRESS THE ISSUE- OR THE ALTERNATIVE IS TO QUIT PRODUCING GARBAGE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN I STARTED FROM A STOP LIGHT IT TOOK OFF FINE BUT SHIFTING FROM 1ST TO 2ND AND THEN INTO 3RD THE ENGINE RACED BUT WOULD NOT ACCELERATE. I PUSHED THE O/D OFF AND IT SEEMED TO FIX THE PROBLEM. THEN OVER THE NEXT FEW DAYS IT BECAME MORE FREQUENT TO THE POINT THAT I AM AFRAID TO PULL OUT INTO TRAFFIC. I WORRY THAT I WILL BE HIT BY NOT GAINING SPEED TO GET GOING. ALSO MERGING ON THE FREEWAY IS FRUSTRATING AND UNSAFE. THE O/D LIGHT FLASHES ON AND OFF ALL OF THE TIME NOW. THIS HAS HAPPENED OVER THE COARSE OF A WEEK. THIS IS AN AUTOMATIC TRANSMISSION 2WD. *TR

WHILE TRAVELING AT HIGHWAY SPEED VEHICLE'S LEFT REAR TIRE TREAD SEPARATED. DRIVER MADE AN ABRUPT STEERING INPUT THAT CAUSED LOSS OF CONTROL. VEHICLE OVERTURNED AND LEFT THE ROADWAY. DRIVER WAS SOLE OCCUPANT AND DID NOT SURVIVE. *TR

THE RIGHT REAR TIRE EXPERIENCED A TREAD SEPARATION WHILE DRIVING 60-65 MPH WITH TWO ADULTS AND TWO CHILDREN IN A 2001, FORD, EXPLORER SPORT SUV. WHILE DRIVING DRIVER NOTICED A LOUD BANGING NOISE, AND THE VEHICLE WAS LOSING STEERING CONTROL. CONSUMER PULLED THE VEHICLE OFF THE ROAD, AND NOTICED THAT TIRE CAUSE DAMAGES TO THE FUEL FILLER NECK LINE. IT WAS AN AFTER MARKET TIRE INSTALLED AT 51, 000 MILES, TIRE SIZE P235/75R15 AND DOT# 88L3L63101. THE TIRE DEALER WAS NOTIFIED.*AK

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE WINDSHIELD WIPERS, THE INTERIOR LIGHTS, AND THE SOUND FOR THE DOOR STOPPED WORKING. THE VEHICLE WAS TAKEN TO THE DEALER AND THE CONTACT WAS TOLD THAT THE GENERIC ELECTRONIC MODULE NEEDED TO BE REPLACED BUT THE VEHICLE WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN ID NUMBER: 00V072000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS 155,637 AND THE CURRENT MILEAGE WAS 158,000. *TR

VEHICLE CAUGHT FIRE. VEHICLE WAS NOT RUNNING AT THE TIME. VEHICLE DESTROYED BY FIRE. *TR

DRIVER SEAT BOLT

I WAS DRIVING AND HEARD LOUD NOISE. SOUNDED LIKE THE BACK WINDOW HATCH WAS OPEN AND VIBRATING WITH EVERY BUMP IN THE ROAD. THE HATCH WAS CLOSED, SO I LOOKED UNDER THE VEHICLE TO FIND THE BODY MOUNTS HAD COMPLETELY CRUMBLED AWAY. THE BODY OF THE VEHICLE WAS RIDING ON THE FRAME WITH NO CUSHION. THE BODY OF THE VEHICLE WAS VERY HARD TO HANDLE AND FELT AS IF IT MAY SHIFT OFF THE FRAME AT ANYTIME. *TR

---- THIS VEHICLE DOES NOT HAVE A SEAT BELT FOR A PASSENGER RIDING IN THE MIDDLE OF THE REAR SEAT. THE REAR SEAT HAS AMPLE SPACE FOR THREE FULL-SIZED ADULTS, BUT THERE IS NO SEAT BELT FOR A MIDDLE PASSENGER. THE FORD ORIGINAL SHOP MANUAL INDICATES THAT THERE ARE NOT ANY SECURE ATTACHMENT POINTS TO INSTALL A 3RD-PARTY BELT BUILT INTO THE BODY. ---- THIS IS A SAFETY HAZARD AND MAY MAKE IT ILLEGAL TO CARRY A THIRD PASSENGER IN THE REAR SEAT. NHTSA SHOULD RECALL THESE VEHICLES AND DIRECT FORD TO PROVIDE SEAT BELTS FOR A CENTER PASSENGER IN THE REAR SEAT. THANK YOU FOR YOUR CONSIDERATION. *TR

DRIVER SEAT BOLT

MY PURCHASED NEW $30,000 2001 FORD 2 DOOR EXPLORER SPORT DIES OFTEN CAUSING NO BRAKES OR STEERING. IN 2001, IT DIED AND ROLLED OVER WITH NO STEERING OR BRAKES WHEN MY WIFE WAS DRIVING HOME, LEAVING HER STRANDED UPSIDE DOWN. FORD WOULD NOT RESPOND AND LOCAL DEALERS WOULD NOT OR COULD NOT SOLVE THE PROBLEM. IT STILL DIES AND ALL RECALLS WERE PRESUMABLY DONE, INCLUDING THE FIRESTONE TIRES WHICH WERE THE BEST PART OF THE VEHICLE. NUMEROUS LETTERS TO FORD WERE NEVER ACKNOWLEDGED. I WOULD LIKE TO HAVE A REFUND ON THIS VEHICLE. CAN YOU HELP ME? *TR

WHEN TILTING THE STEERING WHEEL DOWN IT SHUTS EVERYTHING OFF. THEN, WHEN PLACING IT BACK TO THE NORMAL POSITION EVERYTHING COMES BACK ON, THE BRAKE LIGHTS/TURN SIGNALS, AND CONSUMER HEARS AN ELECTRICAL BUZZING INSIDE THE STEERING WHEEL.*AK

BRAKES, ROTORS, PADS, ARE NEW... THE EXPLORER SPORT STILL DOES NOT COME TO A FULL STOP ... (2001) MILES 4900, BRAKES GO TO THE FLOOR AND KEEPS GOING 2 TO THREE FEET MORE BEFORE IT STOPS... *TR

THERE'S NO FAILURE JUST RUDE AND LACK OF COMMUNICATION WITH WORKERS. ON 12/21/07 I TOOK MY LETTER OF THE RECALL FOR THE CRUISE CONTROL TO GRANDE TRUCK CENTER ON INTERSTATE 10 @ W.W.WHITE RD."GARY RANDALL AND FINALLY GOT THE REPLACE MENT ON 05/29/08. MR. RANDALL EXPLAINED WHAT WAS TO TAKE PLACE AFTER I ASKED HIM WHY DID THE WORKER TEAR MY CRUISE CONTROL BUTTON(THE PLASTIC) HE STATED 'NO HE SHOULD HAVE LOOKED INSIDE BUT UNDER THE HOOD-MY CRUISE CONTROL PLASTIC FELL OF AND I JUST ASSUME THAT IT WAS A PART OF THE REPLACEMENT OF THE RECALL SO I LEFT IT IN THE CAR UNTIL THE RECALL WAS DONE-TO FIND OUT THE PLASTIC WAS NOT REPLACEABLE BY THE ONE WHO BROKE/TORE/CUT IT. AFTER THE JOB WAS FINISHED THE RUDE WORKER JUST SLAMMED THE HOOD CLOSE AND WALKED AWAY-VERY RUDE. POOR REPRESENTATION OF THE FORD COMPANY-RACE HAS ALWAYS BEEN AN ISSUE WITH THESE TYPE PEOPLE THAT SHOULD NOT BE WORKING IN THE PUBLIC-NOW I WOULD LET THEM DO NOTHING ELSE TO MY VEHICLE AGAIN NOT EVEN RECALL. *TR

IF STEERING WHEEL IS NOT IN THE VERY HIGH POSITION TURN SIGNALS BLINK VERY RAPIDLY AS IF THERE WAS A PROBLEM WITH ONE OF THEM.

RIGHT TURN SIGNAL AND BRAKE LIGHT. I HAD THE EXPLORER DIAGNOSED AND THE DEALER SAID THAT IT NEEDED A MULTIFUNCTION SWITCH. I HAD THE SWITCH REPLACED AND A MONTH AND EIGHT DAYS LATER MY RIGHT SIGNAL AND BOTH LEFT AND RIGHT BRAKES LIGHTS ARE NOT WORKING. I HAD THE BULB REPLACED TWO MONTHS BEFORE THE DIAGNOSIS BECAUSE I COULDN'T UNDERSTAND WHY THE BULB KEPT GOING OUT AND THE DIAGNOSIS ON A MULTIFUNCTION WAS MADE. *NM

THIS WAS AN INCIDENT. NO CRASH, AND NO INJURY. THE IAC (IDLE AIR CONTROL) VALVE FAILED DURING START ATTEMPTS ON THE FOLLOWING VEHICLE: 2001 FORD EXPLORER SPORT, 4.0L SOHC ENGINE, MILEAGE = 39,000. THE VALVE FAILURE MODE WAS CLOSED (NO IDLE AIR) SO THE ENGINE WOULD NOT IDLE UNLESS THE PRIMARY INTAKE THROTTLE PLATE WAS HELD OPEN BY MAINTAINING PRESSURE ON THE THROTTLE. FAILURE OF ENGINE TO IDLE DURING A MOVING CONDITION MAY CAUSE LACK OF VACUUM FOR BRAKE BOOST AND UNUSUALLY HIGH BRAKE FORCES, AS THIS VEHICLE HAS A VACUUM BRAKE BOOST. FROM REVIEWING VARIOUS ON-LINE FORUMS, IT APPEARS THIS IS A COMMON PROBLEM WITH THE IAC VALVE, WHICH IS USED ON SEVERAL MODEL/YEAR/ENGINE FAMILY COMBINATIONS. *NM