2003 Ford Explorer Sport Owner Complaints

WAS CLOSING BACK HATCH AND GLASS WINDOW LITERALLY EXPLODED! VEHICLE WAS PARKED IN MY YARD.

NHTSA ID

11385770

Incident

Dec 30, 2020

Mileage

137,800 mi

THE TRANSMISSION IS SHOT I CANT PUT IT IN GEAR AND ME AND MY HUSBAND WERE ALMOST KILLED BUT WERE ABLE TO PUT IT IN 2ND GEAR TO ROLL IT TO THE SHOP. THE 4WHEEL DRIVE GOT STUCK IN 4 WHEEL LOW AND WOULD NOT SHIFT AT ALL. WHEN WE TURNED THE CAR ON IT WOULD REV UP TO 5 BUT ONLY GO 2 MILES AN HOUR.

NHTSA ID

11289611

Incident

Dec 15, 2019

Mileage

133,000 mi

"TAKATA RECALL" AIRBAG LIGHT KEEPS BLINKING WITH THE SEAT BELT NOISE. CHANGED THE LIGHT BULB FROM THE DASH BOARD AND NOW THE AIRBAG LIGHT STAYS ON BUT WILL NOT CONNECT WITH MILEAGE.

NHTSA ID

11230012

Incident

Jul 1, 2019

BODY MOUNTS DETERIORATED CRUMPLED.BODY DOWN ON FRAME CAUSING IRREGULAR RIDE CONTROL

NHTSA ID

11143472

Incident

Sep 1, 2018

Mileage

77,000 mi

CAR HAS AN INTERMITTENT PROBLEM AND WILL STALL AND BOTH HIGH AND LOW SPEEDS, OR WHEN IDLING. WHEN THIS HAPPENS AND POWER ASSIST FAILS, IT'S ALMOST IMPOSSIBLE TO STEER OR TO BRAKE POSING A SERIOUS RISK TO SAFETY. THIS FIRST STARTING HAPPENING ABOUT ONCE A WEEK LAST NOVEMBER, AND NOW IT'S PRETTY OFTEN. STOPPED DRIVING THE CAR, EXCEPT TO TEST DRIVE AS WE'RE TRYING TO FIND THE SOURCE OF THE PROBLEM. WE THINK IT'S EITHER THE FUEL OR VACUUM SYSTEM AND ARE CONTINUING TO NARROW DOWN THE PROBLEM. I AM NOT SURE IF BRAKING WILL WORK AT ALL WHEN IT FAILS, AS FORTUNATELY IT HASN'T STALLED GOING DOWNHILL. I PUT ALL MY STRENGTH INTO BOTH BRAKING AND STEERING (I'M A PRETTY STRONG WOMAN) TO GET IT TO SAFETY. IT MAY SIMPLY BE STOPPING DUE TO INERTIA.

NHTSA ID

11063921

Incident

Nov 22, 2017

Mileage

167,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING 50 MPH, A LOUD NOISE WAS HEARD WHEN THE SUN ROOF EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10946504

Incident

Jan 19, 2017

Mileage

130,000 mi

REAR LIFTGATE WINDOW ON MY 2003 FORD EXPLORER SPORT EXPLODED INTO A MILLION PIECES. THE VEHICLE WAS PARKED IN MY DRIVEWAY AND I WENT TO OPEN THE DOOR AND IT JUST EXPLODED.

NHTSA ID

10934774

Incident

Dec 12, 2016

Mileage

84,500 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING APPROXIMATELY 25 MPH, A NOISE EMERGED FROM THE REAR HATCH WINDOW. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE PIECE THAT HELD THE WINDOW IN PLACE WAS FRACTURED. THE VEHICLE WAS REPAIRED FOR THE SAME FAILURE IN MARCH OF 2015. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 159,149.

NHTSA ID

10886191

Incident

Jul 18, 2016

Mileage

159,149 mi

I HAD JUST PUT A BAG OF GROCERIES IN THE BACK, WAS CLOSING THE REAR GLASS HATCH WHEN IT EXPLODED ABOUT 1/3 OF THE WAY DOWN. VERY LOUD NOISE, AND TINY GLASS PIECES SHATTERED ACROSS 3 PARKING SPOTS, INTO AND ALL AROUND OUR VEHICLE, INCLUDING THE GROCERIES WHICH I DISCARDED. THIS CAR IS NOT INCLUDED IN THE RECALL.

NHTSA ID

10870103

Incident

May 15, 2016

Mileage

98,200 mi

REAR LIFTGATE WINDOW COMPLETELY SHATTERED. VEHICLE WAS PARKED AND BEEN SO FOR 3 HOURS. TEMPERATURE WAS ABOUT 60 DEGREES. THERE WAS NO VISIBLE CRACKS OR OTHER DEFECTS. WAS WITNESSED BY SEVERAL PEOPLE. DID NOT JUST CRACK OR BREAK. IT SHATTERED INTO THOUSANDS OR PIECES. WAS NOT BEING OPENED OR CLOSED. VEHICLE WAS COMPLETELY STATIC

NHTSA ID

10764283

Incident

Sep 15, 2015

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING AT AN UNKNOWN SPEED, THE BODY MOUNT EMITTED AN ABNORMAL NOISE AND WAS DETERIORATING. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

NHTSA ID

10733701

Incident

Apr 13, 2015

Mileage

150,000 mi

I BOUGHT MY FORD EXP.SPORT TRAC IN 2005 WITH A FEW MILES ON IT. I SOON FOUND OUT THAT IT HAD A FEW PROBLEMS WITH IT'S INTERIOR LIGHTING. THEN IT WAS THE DOOR LOOKS, THEN IT WAS THE RADIO GOING ON AND OFF BY ITSELF. THEN THE WINDOWS WENT UP AND DOWN ON THERE OWN. NOW THE AC COMES ON AND OFF WHILE IN THE OFF POSITION. AS OF TODAY KNOW ONE KNOWS WHAT AS GOTTEN INTO MY TRUCK AND WHEN I ADJUST MY STEERING WHEEL DONE THE TURNING LIGHTS DONT WORK AND I HAVE EVEN RECEIVED A TICKET FOR IT.

NHTSA ID

10730856

Incident

Feb 23, 2005

Mileage

23,769 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT EQUIPPED WITH MICHELIN CROSS TERRAIN TIRES, SIZE: P235/70/R16. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR PASSENGER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE ALL FOUR TIRES WERE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE OF THE TIRE AND VEHICLE WAS 35,000. UPDATED 2/24/15*CN UPDATED 03/02/15*JB

NHTSA ID

10668655

Incident

Dec 6, 2014

Mileage

35,000 mi

I WAS DRIVING AT APPROX 55MPH AND THE STEERING COLUMN LOCKED UP AND I WAS UNABLE TO CONTROL THE VEHICLE, IT AUTOMIATCALLY PULLED TO THE LEFT AND CAUSING MY VECHICLE TO ROLL SEVERAL TIMES. (3-5 TIMES) VEHICLE IS NOW TOTALLED. I RECEIVED MEDICAL ATTENTION AT THE SCENE AND I'M UNDER OBSERVATION FOR THE NEXT 48 HOURS. I'M HIGHLY CONCERNED DUE TO THE LEVEL OF OTHER VEHICLES THAT ARE MY SAME MAKE AND MODEL THAT HAVE HAD THIS SAME ISSUE. PLEASE ADVISE ASAP. THANK YOU IN ADVANCE FOR YOUR HELP. *TR

NHTSA ID

10648704

Incident

Oct 19, 2014

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE HATCHBACK HINGES FRACTURED AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE); HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

NHTSA ID

10622010

Incident

Aug 12, 2014

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE LIFT GATE GLASS DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE) DUE TO THE VEHICLE BEING A TWO DOOR AND NOT A FOUR DOOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

NHTSA ID

10618178

Incident

Jun 24, 2013

Mileage

100,000 mi

WAS DRIVING THE VEHICLE WHEN I NOTICED SMOKE COMING OUT FROM UNDER THE HOOD. I PULLED OVER AS QUICK AS POSSIBLE INTO A STRIP MALL PARKING LOT. BEFORE I GOT OUT FLAMES WERE COMING OUT OF THE ENGINE COMPARTMENT. I RAN INTO A STORE AND GOT A FIRE EXTINGUISHER TO TRY AND PUT OUT THE FIRE. I FAILED, AS THE WHOLE FRONT OF THE EXPLORER WAS IN FLAMES AS WELL AS THE INTERIOR. THE VEHICLE IS A TOTAL LOSS. THE FIRE DEPARTMENT PUT IT OUT. I HAD THE VEHICLE FOR 7 WEEKS. THE USED DEALER WILL NOT TAKE ANY RESPONSIBILITY. SHOULD THEY? I PURCHASED THE VEHICLE ON MAR. 3,2014 AT OC AUTO EXPO IN WESTMINSTER, CA. *TR

NHTSA ID

10584719

Incident

Apr 16, 2014

Mileage

103,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE REAR HATCH BACK WINDOW PIN BECAME FRACTURED AND CAUSED THE SPRING AND THE WINDOW TO SEPARATE FROM THE FRAME. THE DEALER PREVIOUSLY REPLACED THE HATCH BACK PIN HOWEVER THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 145,000.

NHTSA ID

10563007

Incident

Jan 1, 2012

Mileage

110,000 mi

ON THE MORNING OF 1/29/14 I WAS AT THE MARKET ,CAME OUT TO LOAD MY ITEMS INTO THE VEHICLE , OPENED THE REAR LIFT GATE AT ABOUT THE 1/3 OPEN POINT THE GLASS EXPLODED INTO A MILLION PIECES . WHICH IN TURN SENT SHARDS OF GLASS INTO MY FACE ,HANDS , HEAD AND EYES . THEY WERE MINOR INJURIES BUT I'M STILL EXTRACTING GLASS FROM MY HEAD AND HANDS AND THERE IS STILL GLASS EMBEDDED IN MY HANDS . I HAVE AN APT WITH MY DR ONLY BECAUSE THERE IS GLASS IN MY EYES. MY MOTHER WAS WITH ME BUT SHE WAS AT THE SIDE OF THE VEHICLE SO SHE DIDN'T GET NAILED .I HAVE NEVER SEEN A WINDOW EXPLODE LIKE THIS, THIS IS A SERIOUS HAZARD AND NEEDS TO BE RECALLED ASAP BEFORE IT KILLS SOMEONE , THE POWER OF THE FLYING GLASS WAS UNREAL SOME OF IT WENT THROUGH 3 -12 PACKS OF SODA WITH EASE. ALSO I HAVE NO RESOURCES TO GET A NEW WINDOW AS THEY ARE AROUND 700 DOLLARS . SO THIS IS WHAT I GET FROM FORD FOR BEING A LOYAL CUSTOMER ? *TR

NHTSA ID

10562975

Incident

Jan 29, 2014

Mileage

142,000 mi

I WAS DRIVING IN SEMI WET CONDITIONS, GOING DOWNHILL AND ENGAGED THE OVERDRIVE OFF BUTTON. THE VEHICLE STARTED TO SHIMMY AND SHAKE, THEN FISH TAILED, RESULTING IN ME HITTING AN EMBANKMENT AND FLIPPING THE VEHICLE. NEITHER AIRBAG DEPLOYED! I WAS ABLE TO CRAWL OUT OF THE WRECK BUT THE TRUCK WAS TOTALED. THIS IS THE SECOND TIME THE VEHICLE DID THE EXACT SAME THING (EXCEPT THE CRASH), IN THE SAME WEATHER CONDITIONS. THE FIRST TIME, I WAS ABLE TO GET THE VEHICLE UNDER CONTROL. *TR

NHTSA ID

10557427

Incident

Dec 26, 2013

Mileage

133,000 mi

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT NOTICED THAT THE REAR LIFT GATE HINGES WERE LOOSE. THE CONTACT REMOVED THE REAR GLASS WINDOW SO IT WOULD NOT FALL OFF OF THE VEHICLE. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOTIFIED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

NHTSA ID

10551074

Incident

Nov 5, 2013

Mileage

170,000 mi

WINDOW FEEL AND SHATTERED INTO A MILLION PIECES. AFTER CONTACTING MY INSURANCE TO HAVE THE GLASS REPLACED I FOUND OUT THE REASON FOR THE INCIDENT WAS DUE TO A FAULTY HINGE. I WAS TOLD BY THE GLASS COMPANY THAT THE HINGE FAILED DUE TO ELECTROLYSIS (TWO DIFFERENT METALS REACTING WITH EACH OTHER). I FEEL THIS IS THE SAME ISSUE THAT HAPPENED WITH FORD RECALL MANUFACTURER CAMPAIGN NUMBER: 04S20, HOWEVER MY VIN DOES NOT PULL UP THIS ISSUE CODE AND THEREFORE I AM NOT RECEIVING ASSISTANCE FROM FORD WITH THIS MANNER. AFTER DOING RESEARCH ONLINE I HAVE FOUND MANY OTHER OWNERS OF MY SAME MAKE AND MODEL WHO HAVE EXPERIENCED THE SAME ISSUE. I FEEL THIS NEEDS TO BE OFFICIALLY ADDRESSED AS I WAS DRIVING WHEN MY GLASS FELL, BUT WAS FORTUNATE THAT THERE WAS NO ONE BEHIND ME WHEN IT HAPPENED. OTHERWISE I AM 100% POSITIVE IT WOULD HAVE CAUSED AN ACCIDENT. *TR

NHTSA ID

10547365

Incident

Oct 7, 2013

Mileage

133,000 mi

LEFT REAR LIFTGATE HINGE FAILED/BROKE; LIFTGATE GLASS ALMOST FELL OFF COMPLETELY (BUT WAS STILL PARTIALLY ATTACHED VIA RIGHT HINGE). THIS HAPPENED WHEN VEHICLE WAS PARKED. NO OBVIOUS SIGNS OF "WEAR AND TEAR"; LIFTGATE HINGE HAD BEEN USED NORMALLY FOR SEVERAL YEARS. MANY OTHER NHTSA REPORTS LIST THIS DEFECT (04V442000). FORD ISSUED A RECALL SEVERAL YEARS AGO (04S20), BUT IT ONLY COVERS A VERY SPECIFIC AND LIMITED RANGE OF VIN NUMBERS; MINE WAS EXCLUDED. MANY OTHER 2003 FORD EXPLORER SPORT OWNERS REPORT THE SAME PROBLEM, YET NOTHING HAS BEEN DONE TO REMEDY THIS PROBLEM OR COMPENSATE THE AFFECTED OWNERS FOR THEIR LOSSES. I HAD TO PAY "OUT OF POCKET" AT A LOCAL PRIVATE SHOP TO GET MY HINGE REPAIRED. *TR

NHTSA ID

10547344

Incident

Jul 30, 2013

Mileage

99,000 mi

SEVERE CLANKING/BANGING NOISE IN PASSENGER REAR. REPLACED SHOCKS. NOISE WORSENED. RESEARCHED AND FOUND NUMEROUS COMPLAINTS REGARDING BODY MOUNTS WITH FORD EXPLORER SPORT VEHICLES. UPON INVESTIGATION - REACHING UP UNDER VEHICLE FOUND NO "BODY INSULATOR LEFT ON PASSENGER SIDE REAR AND ON DRIVER REAR THE INSULATOR CRUMBLED LIKE DIRT AND FINE POWDER. THE BODY MOUNTS APPEARED TO BE MANUFACTURED OF A FOAM LIKE MATERIAL - SUBSTANDARD AT BEST! REPLACEMENT PARTS MUST BE PURCHASED THROUGH FORD SINCE NO OTHER AFTERMARKET PARTS ARE AVAILABLE. PARTS ONLY (THAT BEING ABLE TO SALVAGE THE BOLTS AND SLEEVES) AND PURCHASE THE TWO PAIR OF INSULATORS ONLY - $680.00. THE SAME MATERIAL THAT FAILED AND SHOULD NOT. THERE ARE VEHICLES ON THE ROAD WITH BODY MOUNTS FOR 40 TO 50 YEARS. THIS IS A MANUFACTURER'S RESPONSIBILITY AND THE COST FOR THESE PARTS IS THIEVERY. IT IS UNSAFE TO OPERATE A VEHICLE WITHOUT REPAIRING DEFECTIVE BODY MOUNTS DUE TO THE POSSIBILITY OF BODY ROLL OR OTHER LOSS OF CONTROL. SINCE THE MOUNTS SHOULD NOT FAIL THROUGHOUT THE LIFE OF THE VEHICLE I SINCERELY REQUEST AN INVESTIGATION BE LAUNCHED INTO THE MULTIPLE COMPLAINTS BEING FILED FOR THE YEARS 2001-2003 FORD EXPLORER SPORT BODY MOUNTS. *TR

NHTSA ID

10532641

Incident

Jul 1, 2013

Mileage

106,000 mi

REAR LIFT GATE PANEL CRACKED WHILE VEHICLE WAS PARKED. CONCERNS WITH UNSTABLE REAR GLASS, ABILITY OF HATCH TO REMAIN CLOSED AND OPERATION OF REAR WIPER. GLASS INSTABILITY A CONCERN WHILE DRIVING AND WHEN USING LIFTGATE. PRIOR INJURIES HAVE BEEN REPORTED. *TR

NHTSA ID

10504778

Incident

Mar 24, 2013

Mileage

120,000 mi