Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 1,959 NHTSA owner-reported complaints for the 1998 Ford Explorer. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 1,959 · page 1 of 79
SPEED CONTROL GETS HOT TO TOUCH. ALL TOP FACING HAS MELTED OFF FROM HEAT. I WAS ON HIGHWAY AND MY STEERING WHEEL BECAME EXTREMELY HOT. MY SEAT WAS REPAIRED AFTER RECALL YEARS AGO. IT CONTINUES TO DROP LOW TO FLOOR.
MY SEAT BELT ON MY PASSENGER SIDE DOES NOT WORK HALF THE TIME. MY DOOR LOCKS DO NOT WORK RIGHT. I CAN'T GET MY WINDOW ON THE DRIVER SIDE TO GO UP AND DOWN. I HIT A TREE GOING 55 MILES AN HOUR IN MY AIRBAG DID NOT EVEN DEPLOY. I'M LUCKY I'M STILL ALIVE. THE FENDERS RUBBING UP AGAINST MY TIRE. SPEED CONTROL IS WRONG. WHENEVER I'M GOING 55 MILES AN HOUR IT SAYS 57 ACTUALLY I DON'T REMEMBER THE CORRECT DATE. BUT I'M SURE IT SHOWS I KNOW IT WAS 2017. SOMEBODY RAN ME OFF THE ROAD. MY TRUCK HIT THE TREE AND MY AIRBAG DID NOT DEPLOY. I'M LUCKY IT DIDN'T I GUESS BECAUSE DON'T AIRBAGS HAVE METAL SHARDS IN THEM IS WHAT I WAS TOLD
PARKED IN PARKING SPACE STARTED CAR PUT IN REVERSE, ENGINE ROARED, ACCELERATED IN REVERSE APPLYING BRAKES DID NOTHING , BOTH FEET ON BRAKES , TURNED WHEEL SO THAT CAR WAS NOT TO HIT PARKED CARS BEHIND US, CAR CONTINUED RACING IN REVERSE WITH CONTINUED APPLYING BRAKES, THRU IT INTO PARK CAR CONTINUED IN REVERSE , TURNED KEY OFF & CAR CONTINURED IN REVERSE UNTIL HITTING PARKED CAR WHICH STOPPED US TOTAL DISTANCE ABOUT 200 FEET, WHICH SEEMED A LOT LONGER,I FELT I DID EVERYTHING CORRECTLY MAYBE IF THROWN IN NEUTRAL BRAKES WOULD HAVE WORKED, VERY FRIGHTING HAVING NO CONTROL TO STOP
DOOR LOCKS AND WINDOWS QUIT WORKING AFTER BUYING IT. SO MANY ISSUE ..THE STEERING WHEEL CONTROL WORDS MELTED. BACK DOOR DON'T SHUT PROBABLY AND NEVER HAS SINCE BOUGHT. THIS WAS BOUGHT AS A NEW NOT USED VEHICLE. DOOR LOCKS WAS THE WORSE.THEY SOMETIMES STICK AND WON'T UNLOCK SINCE BOUGHT NEW.NEVER FIX BY BUTLER FORD IN MILLEDGEVILLE GA. OVERDRIVE SWITCH SLIPS OUT OF POSITION. DOES NOT SHOW CORRECT SPEED. I COULD GO ON AND ON
MY EXPLORER HAD BEEN PARKED IN MY DRIVEWAY FOR WELL OVER 15 HOURS WHEN I HEARD MY NEIGHBOR SCREAMING. THE SUV WAS FULLY IGNITED INTO FLAMES.JUST OUT OF NO WHERE. I WAS ABLE TO GET THE FIRE OUT WITH MY WATER HOSES BEFORE THE GOTTA DEPARTMENT SHOWED UP BUT THE ENTIRE VEHICLE IS RUINED AND HALF MY GARAGE AS WELL. THE FIRE STARTED DOWN BY THE BRAKES AND THE ENTIRE VEHICLE WAS ENGOLFED WITHIN SECONDS. OBVIOUSLY IT WAS ELECTRICAL. UPON FURTHER INVESTIGATION I BELIEVE IT WAS THE CRUISE CONTROL SWITCH MALFUNCTION. MY SUV HAD 134,000 MILES ON IT AND KEPT IN IMMACULATE CONDITION. I WILL DOWNLOAD THE FIRE DEPARTMENTS REPORT ONCE TO GET IT. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT
I WAS DRIVING MY TRUCK AND ONE DAY IT STARTED ACTING WEIRD. MY STEREO STARTED SHUTTING OFF AND COMING IN BY ITSELF. A COUPLE DAYS LATER I WAS DRIVING AND MY STEREO AND INFORMATION CENTER WENT OUT AND CAME BACK ON. MY TRUCK WILL ONLY GO ABOUT 30MPS CAUSE IT WON'T SHIFT EITHER. COUPLE DAYS AGO IT STARTED BACK FIRING. WHAT COULD BE THE PROBLEM.
I WAS GOING DOWN CLINTON KEITH IN MURRIETA WHEN ALL OF A SUDDEN MY TRANSMISSION WOULD NOT SHIFT PASSED 3RD. IT WAS WORKING FINE THE DAY BEFORE. SO I TOOK IT SLOW BACK HOME AND THE CLOSER I GOT HOME THE TRANSMISSON STARTED SLIPPING GEARS.
GAS PEDAL BRACKET WELDING BROKE WHILE DRIVING AND GAS PEDAL IS NOW JUST DANGLING - CHECKED ON INTERNET AND THERE ARE A LARGE AMOUNT OF COMPLAINTS ABOUT SAME THING - SHOULD BE A RECALL
FRONT PASSENGER DOOR LOCK AND LATCH STUCK AND UNABLE TO OPEN DOOR FROM EITHER INSIDE OR OUTSIDE. OCCURS BOTH STATIONARY AND IN MOTION.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. WHILE THE VEHICLE WAS IN OPERATION, THE ACCELERATOR PEDAL BECAME DETACHED. THE CONTACT ACTIVATED THE HAZARD LIGHTS AND DROVE HOME WITH CAUTION. THE DEALER (PHIL LONG FORD AT CHAPEL HILLS, 1565 AUTO MALL LOOP, COLORADO SPRINGS, CO 80920, (719) 387-1099) WAS NOTIFIED, BUT COULD NOT DIAGNOSE THE CAUSE OF THE FAILURE. THE DEALER AND MANUFACTURER INDICATED THAT THERE WAS NO RECALL TO PROVIDE A REMEDY. THE CONTACT WAS UNCERTAIN THAT IF THE PART WERE REPLACED, THE FAILURE WOULD RECUR. THE FAILURE MILEAGE WAS NOT AVAILABLE.
I HAVE 1998 FORD EXPLORER AND I NOTICED TRYING TO UNLOCK THE DOOR AUTOMATICALLY THAT IT WOULD STICK SOMETIMES. SOMETIMES BECALE ALWAYS AND NOTICED THE PASSENGER DOOR NEVER WOULD UNLOCK. THEN ONE DAY PARKED I TRIED TO OPEN PASSENGER DOOR AND IT WOULDNT OPEN. I HAD TO OPEN IT FROM THE INSIDE. NOW IT WONT OPEN FROM THE INSIDE. THE DOOR IS TOTALLY NON FUNCTIONAL. DOOR LATCH ISSUE I DONT KNOW BUT HAVE READ MANY COMPLAINTS OF THE SAME. ALSO DRIVER DOOR LOCK WILL SOMETIMES STICK, THE DOOR OPEN BUT WHEN CLOSING IT IT NEVER WANTS TO SHUT ALL THE WAY THE FIRST TIME OR THE 2ND IT TAKES A FEW TIMES TO GET THE DOOR TO COMPLETELY CLOSE BUT THE PASSENGER DOOR IS A LOSS NO ONE CAN RIDE IN IT. SEEN MANY OTHER COMPLAINTS OF THE SAME PROBLEM FORD SHOULD HAVE TO FIX THIS ISSUE THEY KNOW ABOUT
REAR END ROARS AND SPEEDOMETER QUIT WORKING
WHEN I STEPPED ON THE GAS PEDAL AND STARTED TO PROCEED THROUGH AN INTERSECTION, I LOST ALL POWER AND HAD TO ROLL OR COAST VERY SLOWLY THROUGH THE INTERSECTION AND STOP ON THE OTHER SIDE IN A DANGEROUS POSITION IN TRAFFIC WHEN I COULD COAST NO FURTHER. THE GAS PEDAL BRACKET HAD COMPLETELY BROKEN OFF THE FIREWALL AND WAS LAYING ON THE FLOOR. THE BRACKET HAD BEEN ATTACHED BY THREE SPOT WELDS. SOME OTHER PEOPLE STOPPED TRAFFIC AND PUSHED ME TO A SAFE PLACE TO PARK. THE FORD DEALER PARTS' DEPARTMENT HAS NO PARTS TO FIX IT AND SUGGESTED WE BUY SOME BOLTS SOMEWHERE AND REATTACH IT OURSELVES SOMEHOW. TO COMPLETELY LOSE POWER WITHOUT WARNING WAS EXTREMELY DANGEROUS! THANK GOD I WAS IN A CONTROLLED INTERSECTION AND NOT TURNING LEFT ACROSS ONCOMING TRAFFIC OR IT COULD HAVE TURNED OUT MUCH WORSE. READING ONLINE BLOGS AND COMMENTS SHOWS THIS PROBLEM OF THE GAS PEDAL BRACKET FALLING OFF FORD PRODUCTS AND LOSING POWER IS NOT UNCOMMON.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. WHILE DRIVING 5 MPH, THE STEERING ROD FELL OFF AND CAUSED THE STEERING TO FAIL. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 160,000.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. WHILE DRIVING 30 MPH, THE SPEEDOMETER, WINDSHIELD WIPERS, INTERIOR LIGHTS, AND FOUR WHEEL DRIVE FAILED. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE HESITATED TO START AND SMOKED APPEARED ON NUMEROUS OCCASIONS. IN ADDITION, THE OVERHEAD LIGHTS IN THE VEHICLE DID NOT WORK AND THE BATTERY HAD A SHORTAGE. THE CONTACT STATED THAT THE SERVICE ENGINE LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 200,000.
ONLY GOT MY SERVICE DOG OUT, THANK GOD I WAS IN A GLASS FRONT RESTRAUNT. CD PLAYER CAUGHT THE DASH ON FIRE AND BURNED THE TRUCK COMPLETELY UP. TRUCK WAS PARKED AND OFF FOR 20 MIN.
SO SINCE MY DAUGHTER BOUGHT THE FORD A BRAKE LINE THAT'S CONNECTED TO THE CALIPER GETS STRETCHED AND BENT AND IT BREAKS ABOUT EVERY 6 TO 7 MONTHS. I FEEL AS IF IT'S A DESIGN FLAW.I CAN'T AFFORD TO PUT A NEW BRAKE LINE ON EVERY TIME IT BREAKS. I CALLED A DEALERSHIP AND THE MECHANIC THERE SAID ONCE EVERY 5 YEARS HE REPAIRS THE LINES, I DON'T BELIEVE THAT. THE TURNING OF THE TIRES STRETCHES THE LINE AND IT WEARS IT DOWN AND THEN THE LINE LEAKS AND CRACKS.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE FELT AS THOUGH IT WOULD TIP OVER AND SWAYED WHEN DRIVING APPROXIMATELY 70-75 MPH. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUSPENSION MALFUNCTIONED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT WHEN THE VEHICLE WAS PARKED, THE FRONT PASSENGER SIDE DOOR DID NOT OPEN FROM THE INSIDE OR OUTSIDE. THE CONTACT STATED THAT THE PASSENGER HAD TO CLIMB OVER AND GO OUT OF THE FRONT DRIVER'S SIDE DOOR. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 220,000. UPDATED 7/1/15*CN
THE CRUISE SENSOR ON TOP OF THE BRAKE MASTER CYLINDER STAY HOT ALL THE TIME AND IT KEEPS BLOWING MY NUMBER 13 FUSE THAT GOES TO THE BRAKE LIGHTS AND WHEN I PUT A NEW FUSE IN. THE CRUISE SENSOR STARTS SPARKING AN SMOKING REALLY BAD IM A PHRASE THAT IT'S GOING TO CATCH FIRE SOON. *TR
AS I WAS MERGING ONTO THE HIGHWAY ONTO THE ON RAMP LIKE ANY OTHER MORNING GOING TO WORK I BEGAN TO YIELD AS THERE WAS TRAFFIC COMING IN MY DIRECTION. AS I BEGAN TO YIELD MY CAR FLIPPED OVER AS IF SOMEONE PURPOSELY TILTED THE VEHICLE OVER. THE AIR BAGS DID NOT DEPLOY THE CAR ROLLED OVER ONTO MY LEFT ARM AND LEG BREAKING MY ANKLE AND CAUSING MANY OTHER INJURIES AND DISTRESS. *TR
TL*THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 55 MPH, THE VEHICLE ERUPTED INTO FLAMES COMING FROM THE ENGINE COMPARTMENT INTO THE INTERIOR OF THE VEHICLE. THE CONTACT WAS ABLE TO MERGED OVER AND EXIT THE VEHICLE AS THE FLAMES WERE EXTENSIVE AND THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES. THE VEHICLE WAS TOWED TO A YARD. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 98V060000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.
UNKNOWN SPEED AND UNKNOWN MILES ON VEHICLE AND CENTER CONSOLE HAD TO BE REPLACED WITH ELECTRIC ISSUE OF 4 WHEEL DRIVE STILL NOT WORKING
TL* THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT THE HIGH BEAMS WARNING LIGHT ILLUMINATED CONTINUOUSLY EVEN AFTER THE ENGINE WAS SHUT OFF. THE FAILURE RECURRED WHENEVER THE ENGINE WAS STARTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE TECHNICIAN DIAGNOSED THAT THE HEADLIGHT MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS UNAVAILABLE.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .