2004 Ford Explorer Fuel system Problems

I need a new gas tank for my vehicle and Ford stopped making the gas tank for my vehicle. That is a very big safety issue. I called Ford and they were helping to find one from junkyard's I don't want one from a junkyard that I have to repair. I asked for Ford to make a gas tank or pay for them to have mine fixed right at a Ford dealership, no help. That's a big safety problem. Ford provided the contacts phone number to the junkyards but the contact doesn't want the gas tank from a junkyard who probably put holes in them to drain the gasoline out of the tank.

NHTSA ID

11570989

Incident

Feb 8, 2024

Smoke for a good 5 mins under the hood oil leeking

NHTSA ID

11533148

Incident

Jul 16, 2023

Back windows fell off track and windows fell down, cannot roll them up. AC and Heater broke and won't work at all. Fuel system is too lean. Transmission is going out Timing Chain and tensioners making loud knocking noise. Burning oil.

NHTSA ID

11518469

Incident

Jan 19, 2023

I AM HAVING ELECTRONICA ISSUES WITH MY 2004 FORD EXPLORER, THAT CONTROL LIGHTING AND SPEED OF MY VEHICLE. ALSO THE LEFT SIGNAL ARM THAT CONTROLS HIGH BEAMS, AND LIGHTING SNAPPED OFF WHILE I WAS ON THE FREEWAY ON AUGUST 5TH, 2018. THE ELECTRICAL PROBLEM STARTED IN JUNE 2018.

NHTSA ID

11118597

Incident

Aug 5, 2018

Mileage

203,011 mi

I'VE HAVE MY VEHICLE FOR 10 YEARS. PAID THE DEALERSHIP $450 TO HAVE A WARRANTY FOR THE POWER TRAIN AND WHEN I WENT TO THE DEALERSHIP FOR THEM TO FIX IT THEY WOULDN'T. I FIND OUT THAT MY MAJOR ISSUES ARE THE MECHANICAL DIFFERENTIAL. STILL HAVING THE THIS ISSUE TO THIS DAY AND CAN NEVER HAVE MY TRANSMISSION CLEANED OR FLUSHED BECAUSE OF THAT. ALSO, MY FUEL SYSTEM GETS CLOGGED A LOT AND GAS MILEAGE IS HORRIBLE. ALSO, MY ANTIFREEZE LEAKS AFTER I PAID MONEY TO HAVE THE CRACKED SEAL FIXED. THIS IS JUST SCRATCHING THE SURFACE. I HAVE MANY THINGS WRONG WITH MY VEHICLE I FEEL SHOULD BE COVERED BY THE MANUFACTURER BUT I WOULD LIKE TO KNOW WHAT DEFECTS ARE OUT THERE FOR MY VEHICLE. *JS

NHTSA ID

10690744

Incident

Feb 25, 2015

FUEL SPILL BECAUSE DEFECTIVE FILLING HOSE. *TR

NHTSA ID

10664054

Incident

Dec 13, 2014

Mileage

65,000 mi

EXACT DATES ARE VARIOUS , VEHICLE HAS 39000 MILES ON IT PRESENTLY , HAVE MULTIPLE VEHICLES , DRIVE OVER THE ROAD TRUCK DRIVER ... CHANGED BRAKES AND ROTORS TWICE , EMERGENCY BRAKE NOT WORKING , HAD FIXED , HAD TO HAVE EKG REPLACED AND SOME EXHAUST SENSOR , TIRES WORE OUT AT 29000 , EXHAUST SYSTEM REPLACED , BOTH BALL JOINTS REPLACED , PINION GEAR GASKET LEAKING FROM REAR END , BOTH CV JOINTS LEAKING , APPEARS RIGHT CV JOINT NEEDS REPLACING , GETS 14 MPG ( 4.0 LITER ) PAINT PEELING FROM ROOF FOR QUITE AWHILE NOW , RUSTING AROUND FUEL TANK DOOR , AS ALL ARE ...... VEHICLE HAS BEEN A NIGHTMARE , GETTING RID OF THIS AT 39000 MILES , FORD HAS A BETTER IDEA , BUY ANOTHER ONE ! *TR

NHTSA ID

10627965

Incident

Jul 18, 2007

Mileage

17,000 mi

ON APRIL 6TH OF THIS YEAR I PURCHASED A 2004 FORD EXPLORER. THE NEXT DAY I TOOK THE CAR FOR CITY INSPECTION...IT PASSED. THE VERY NEXT DAY (SUNDAY) THE CHECK ENGINE LIGHT CAME ON. THE ABS LIGHT WOULD ALSO ILLUMINATE. I TOOK THE CAR TO AUTOZONE TO HAVE IT DIAGNOSED (EGR VALVE). ONLY THE CHECK ENGINE LIGHT COULD BE DIAGNOSED BECAUSE THE ABS LIGHT CAME ON AT RANDOM WHILE I WAS DRIVING. THE CAR WAS STILL UNDER THE 1000 MILE WARRANTY SO THE EGR VALVE WAS REPLACED AND A SPEED SENSOR BELIEVED TO BE THE PROBLEM WITH THE ABS LIGHT. I PURCHASED AN INDEPENDENT EXTENDED WARRANTY SO I WOULD BE COVERED FOR ANY SURPRISE EXPENSES. I HAD MY CHANCE TO USE IT IN JUST A FEW MONTHS LATER WHEN THE CAR RAN HOT. THE REPAIR WAS NOT COVERED. THIS HAPPENED IN JULY, JUST A FEW MONTHS AFTER BUYING THE CAR. EARLIER THIS MONTH (NOVEMBER 2012) THE SERVICE ENGINE LIGHT CAME ON AGAIN BUT IT DIDN'T STAY ON SO I COULDN'T GET IT DIAGNOSED. NO NEED TO HAVE IT DIAGNOSED BECAUSE THE BATTERY LIGHT CAME ON TOO. I TOOK IT TO AUTOZONE ONCE AGAIN AND THE BATTERY TESTED BAD. IT WOULDN'T START AT THE STORE. I BOUGHT THE BATTERY, IT WAS INSTALLED AND CHECKED AGAIN. THE ALTERNATOR SHOWED IT WASN'T CHARGING. I HAD TO HAVE THE ALTERNATOR REPLACED. WITH THE COLD WEATHER, I DISCOVERED THE DEFROST VENTS DON'T WORK. AIR ONLY BLOWS FROM FRONT VENTS. ON THE MORNING OF NOVEMBER 19TH, I WAS TAKING MY SON TO SCHOOL AND THE OVERDRIVE LIGHT STARTED FLASHING. IT HAPPENED AGAIN WHILE ON MY WAY HOME FROM WORK ON NOVEMBER 21ST. SO NOW I SUPPOSE I HAVE TRANSMISSION PROBLEMS. FORD NEEDS TO ANSWER FOR THEIR HORRIBLE ENGINEERING. *TR

NHTSA ID

10485460

Incident

Apr 6, 2012

Mileage

114,000 mi

FILLED UP THE TANK AND IT REGISTERED NO FUEL, BAD FUEL SENSOR. *TR

NHTSA ID

10473089

Incident

Aug 30, 2012

Mileage

43,800 mi

1-"MILES TO E" HAVE ALWAYS REGISTERED AS DASHES AFTER A FILL UP SINCE 2004. DEALER SAYS NOTHING IS WRONG AND TO ADD GAS ADDITIVE (WHICH DOESN'T WORK) OR I CAN HAVE IT FIXED AT MY EXPENSE. DEALER HAS BEEN SOLD AND NEW DEALER NOW HAS "NO RECORD" OF MY PREVIOUS COMPLAINTS-- WHENEVER I HAD THE CAR IN FOR SERVICE I ASKED THEM TO CHECK IT. I SEE PLENTY OF OTHER COMPLAINTS FOR THIS SAME PROBLEM BUT FORD REFUSES TO FIX THIS AS WELL. 2-BACK HATCH BELOW WINDOW HAS CRACKED RECENTLY. HUSBAND HAD SAME VEHICLE DIFFERENT YEAR AND HIS CRACKED AS WELL. DEALER ACKNOWLEDGES MANY VEHICLES WITH SAME PROBLEM BUT SAYS THERE IS NO RECALL AND FORD WILL NOT FIX IT. I SEE THERE IS NOW A CLASS ACTION SUIT FOR THIS DEFECT. JUST WANTED TO GO "ON RECORD" AS ANOTHER UNHAPPY FORD OWNER (OF OVER 40 YRS).

NHTSA ID

10406670

Incident

May 13, 2011

Mileage

65,000 mi

THE FUEL GAUGE SHOWS A FALSE FULL AND THE TANK DOES NOT FILL ALL THE WAY. THE FUEL GAUGE SHOWS A FALSE EMPTY SHOWING YOU HAVE A HALF A TANK WHEN YOU MAY ACTUALLY HAVE 3 GALLONS. RUNNING OUT OF FUEL ON THE HIGHWAY IS NOT SAFE. THE GAS STATIONS PUMP SHUTS OFF AUTOMATICALLY GIVING YOU THE IMPRESSION THAT THE TANK IS FULL AND IS CONFIRMED FULL BY AN INACCURATE GAS GAUGE WHICH SHOWS FULL. SO YOU MIGHT HAVE 18 GALLONS IN A TANK THAT SHOULD HAVE 22.5 GALLONS AND THE GAUGE SHOWS A HALF TANK WHEN YOU HAVE 3-4 GALLONS. *TR

NHTSA ID

10384483

Incident

Aug 15, 2008

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIAN REPLACED THE FUEL PUMP, THROTTLE BODY AND SEVERAL UNKNOWN SENSORS IN THE VEHICLE. THE FAILURE RECURRED AND THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN ADVISED THAT THEY WOULD PERFORM EXTENSIVE DIAGNOSTIC TESTING ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WOULD OCCUR INTERMITTENTLY IN COLD TEMPERATURES LESS THAN TWENTY DEGREES. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

NHTSA ID

10378626

Incident

Feb 15, 2007

Mileage

45,000 mi

WERE A FAMILY A FORD EXPLORER MY FAMILY HAS 4 OF THEM RANGING FROM THE YEARS 1996,99,2002,2004 AND EVERYONE OF THESE VEHICLES HAVE SERIOUS ISSUES. RANGING FROM ROTTING SUSPENSION PARTS,TO WHEEL BEARING ISSUES ON NEWER MODELS,ROTTING FUEL AND BRAKE LINES,THIS IS SUPPOSED TO BE AN AMERICAN MADE COMPANY THAT IS JEOPARDIZING THE LIVES OF AMERICAN AND CHILDREN WITH TOTAL DISREGARD OF HUMAN LIFE,BUT I BET YOU THE OWNERS OF FORD DON'T HAVE THESE ISSUES THEY PROBABLY DRIVES FOREIGN HAHA BUT SERIOUSLY SOMEONE WILL GET HURT BY THIS AND IT COSTING THOUSANDS OF DOLLARS OUT OF POCKET TO FIX AN ONGOING PROBLEM WITH THESE TRUCKS PLEASE DO A RECALL ITS SO UNFAIR AT THIS POINT. *TR

NHTSA ID

10365355

Incident

Nov 11, 2010

Mileage

93,000 mi

2004 FORD EXPLORE DIES ON THE ROAD WHILE DRIVING. GOING 70 MPH DOWN THE INTERSTATE AND THE VEHICLE DIED LUCKILY I WAS DRIVING ON THE SIDE LANE AND GOT OFF TO THE SHOULDER SO WE WEREN'T STUCK IN THE MIDDLE OF INTERSTATE TRAFFIC. CALLED A TOW TRUCK AND HAD THE VEHICLE DIAGNOSED AT AN AUTO REPAIR SHOP. FUEL PUMP HAD TO BE REPLACED. THE AUTO SHOP REPLACED THE PUMP. *TR

NHTSA ID

10348467

Incident

Aug 7, 2010

Mileage

85,555 mi

MY 2004 FORD EXPLORER HAS BEEN KILLING WHEN COMING TO A STOP, SLOWING DOWN AND WHEN I AM DRIVING AT SPEEDS UP TO 40MPH. MY POWER STEERING THEN GOES. THERE ARE NO WARNINGS WHEN THIS IS GOING TO HAPPEN. IT IS OCCURRING DAILY AND I THEN HAVE TO PUT THE TRUCK IN PARK, REMOVE THE KEY AND THEN RESTART. WHEN I DO THAT, IT RUNS LIKE IT NEVER HAPPENED. NO CHECK ENGINE LIGHT ECT... I HAVE BEEN CALLING THE DEALERSHIP ABOUT THIS FROM DAY ONE. AT FIRST I WAS TOLD THAT IF IT DOES NOT FAIL WHEN I BRING IT IN IT WILL BE HARD TO SAY WHAT IT IS. THEN I CALLED BACK BECAUSE IT WAS HAPPENING MORE FREQUENTLY. I BROUGHT MY TRUCK IN THURS. THE DEALERSHIP HAD IT ALL DAY AND SAID IT WAS READY TO GO. I DROVE 1/2 MILE DOWN THE ROAD AND THE TRUCK KILLED. I IMMEDIATELY CALLED THEM BACK TO LET THEM KNOW. I WILL BE BRINGING IT BACK NEXT WEEK. I AM VERY WORRIED ABOUT THIS FAILURE AND I FEEL THAT THIS IS DEFINITELY A DEFECT IN THE FORD. *TR

NHTSA ID

10282994

Incident

Aug 13, 2009

Mileage

72,000 mi

2004 FORD EXPLORER XLS, 41,000 MILES ON MULTIPLE OCCASIONS MY CAR HAS SHUT OFF, LOOSING POWER FOR THE BRAKES AND STEERING. IT USUALLY HAPPENS WHEN DECELERATING AT A STOPLIGHT, OR EVEN DECELERATING OFF THE HIGHWAY ONTO AN EXIT RAMP. IT HAS OCCURRED AT LEAST FOUR OF FIVE TIMES AND I'VE BEEN VERY LUCKY EACH TIME TO BE ABLE TO PULL OVER, PUT MY CAR IN NEUTRAL, AND RESTART IT. THE CAR HAS NO TROUBLE STARTING BACK UP. I'VE RESEARCHED ON THE INTERNET ABOUT THIS PROBLEM AND HAVE FOUND THAT MY EXPERIENCE IS NOT UNIQUE. THIS IS A VERY DANGEROUS SITUATION AND THE 2004 FORD EXPLORER CAN BE VERY UNSAFE IF THERE IS SOME SORT OF FAILURE. PLEASE HELP ME. *TR

NHTSA ID

10266188

Incident

Apr 20, 2009

Mileage

40,000 mi

GAS TANK HAS A LEAK AND I CAN SMELL FUMES. *TR

NHTSA ID

10259932

Incident

Feb 25, 2009

2004 FORD EXPLORER LIMITED WITH FAULTY GAS GAUGE. CAR SAID 70 MILES TO EMPTY YET MY WIFE AND TWO KIDS (AGES 3&5) RAN OUT OF GAS ON THE HIGHWAY. THEY HAD TO HIKE 1 MILE DOWN THE EXPRESSWAY TO GET ASSISTANCE. THIS IS OBVIOUSLY A SERIOUS SAFETY CONCERN. THE ONLY THING WORSE THAN NO GAS GAUGE IS ONE THAT DOES NOT READ ACCURATELY. THANKFULLY THEY EVENTUALLY ARRIVED HOME SAFELY WITH THE ASSISTANCE OF STRANGERS. *TR

NHTSA ID

10229270

Incident

Jun 17, 2007

Mileage

42,000 mi

THIS IS A ON GOING PROBLEM, OUR FORD EXPLORER HAS TROUBLE WITH THE LINKAGE TO THE CARBURETOR, THE FIRST TIME WE HAD PROBLEM WITH THE EXPLORER WAS OCT OF 04. BICKFORD FORD IN SNOHOMISH WA. TRIED TO REPAIR IT. THEN THERE WAS TWO TIMES BICKFORD TRIED TO FIX IT, THE LAST TIME WE TALKED TO BICKFORD THEY SAID THAT THEY DID NOT KNOW HOW TO FIX THE PROBLEM AND THAT FORD MOTOR CO. DID NOT KNOW HOW TO FIX IT EITHER. WE ALSO TUCK IT TO ANOTHER AUTO REPAIR SHOP AND THEY SAID THAT THEY COULD NOT FIX IT EITHER. WE HAVE NO CHOSE BUT TO CONTINUE TO DRIVE IT , BUT WE ARE ALSO AFRAID IT COULD CAUSE A BAD ACCIDENT. THE PROBLEM IS , WHEN YOU ARE STOPPED OR JUST STARTING OUT AND GIVE GAS IT DOSE NOT START TO GO SO YOU GIVE IT A LITTLE BIT MORE GAS AND THEN IT WILL JUMP FORWARD OR BACKWARD( IF YOU ARE BACKING UP) TO APPOINT THAT IT WILL SOME TIMES SQUEAL THE TIRES. IT ALL SO STALLS WHEN YOU SLOW DOWN TO TURN A CORNER. THAT IS ALSO DANGEROUS IN HEAVY TRAFFIC. AFTER FOUR ATTEMPTS TO REPAIR IT IS STILL DOING THE SAME THING. *TR

NHTSA ID

10227677

Incident

Oct 26, 2004

Mileage

11,658 mi

MY GAS GAUGE ON MY 2004 FORD EXPLORER HAS FAILED ME MANY TIMES. I TOOK IT TO MY DEALERSHIP & THEY TOLD ME TO ADD SOME FUEL ADDITIVE TO MY GAS TANK & THIS WOULD CURE THE PROBLEM. WELL IT HAS NOT & MY WARRANTY IS OUT!!! I'M VERY CONCERNED FOR MY WIFE'S SAFETY IF SHE RUNS OUT OF GAS, SO WE HAVE TO KEEP A WRITTEN LOG AS TO THE MILEAGE BEFORE FILL-UP'S. I'M TOLD THE SENSOR IS BAD & WOULD COST CLOSE TO $1,000.00 TO REPAIR. I HAVE COMPLAINED TO FORD & THEY REFUSE TO REPAIR SINCE THE WARRANTY IS OUT. I HAVE ALSO COMPLAINED TO FORD ABOUT A BACK HATCH PANEL THAT HAS CRACKED FOR NO APPARENT REASON DIRECTLY UNDER THE EXTERIOR FORD EMBLEM & THEY WILL NOT REPAIR THIS SINCE IT IS OUT OF WARRANTY. THESE ARE BOTH FOR SURE MANUFACTURER DEFECTS, THAT FORD SHOULD BE MADE TO REPAIR AT THEIR COST. *TR

NHTSA ID

10226585

Incident

Dec 10, 2007

Mileage

58,000 mi

I HAVE A 2004 FORD EXPLORER WITH 57,000 THAT STARTED STALLING WHILE DRIVING ABOUT 3 MONTH AGO. IT SHUTS OFF LIKE SOMEONE TURNED THE KEY. THE OCCURRENCE IS VERY RANDOM AND THERE IS NEVER ANYTHING COMMON BETWEEN OCCURRENCES EXCEPT IT TYPICALLY HAPPENS WHEN I AM BRAKING. IT'S AS IF IT'S RUNNING OUT OF GAS. IT TOOK ABOUT 10 MINUTES EACH TIME BEFORE IT WOULD RESTART. ALL 4 TIMES, EVEN THOUGH IT DIED LIKE THE KEY WAS TURNED OFF, IT ACTED LIKE IT WAS OUT OF GAS WHEN I WAS TRYING TO RESTART IT AND THEN ALL OF THE SUDDEN IT WOULD START LIKE NORMAL. SINCE THEN THE FOLLOWING HAS BEEN DONE: FUEL FILTER REPLACED, MAF SENSOR CLEANED AND THE IAC VALVE INSPECTED. THE SERVICE SHOP WHERE IT IS TAKEN SAYS THERE IS NEVER AN ERROR CODE IN THE SYSTEM WHEN I BRING IT IN. THE VEHICLE IS CURRENTLY UNSAFE TO DRIVE WITH THIS CONDITION. *TR

NHTSA ID

10220397

Incident

Jan 8, 2008

Mileage

56,000 mi

2004 FORD EXPLORER LIMITED-OWNED SUV FOR 38K BEEN IN SHOP REPEATEDLY-FROM MINOR TO MAJOR THINGS. SUV IS A $ 34,000 TURD. CURRENTLY NEEDING TO GO BACK TO SHOP FOR MULTIPLE REPAIRS. THE DAY OUR WARRANTY EXPIRES CAR IS GONE. *TR

NHTSA ID

10208226

Incident

Jan 3, 2006

TL*THE CONTACT OWNS A 2004 FORD EXPLORER. AFTER FILLING THE VEHICLE WITH GAS AND DRIVING A FEW MILES, THE FUEL CAP PRESSURE LIGHT ILLUMINATES AND THE ENGINE SHUTS OFF. THE CONTACT HAS TO EXIT THE VEHICLE AND RETIGHTEN THE FILLER CAP, WHICH THEN ALLOWS THE ENGINE TO RESTART. THE FAILURE HAS OCCURRED TWICE WITHIN 3 OR 4 GAS TANK FILL-UPS AND USUALLY WHILE DRIVING 50 MPH. HE HAS NOT YET TAKEN THE VEHICLE TO THE DEALER. FAILURE MILEAGE WAS 29,000 AND CURRENT MILEAGE WAS 29,500. UPDATED 12/12/07 *BF

NHTSA ID

10206750

Incident

Sep 29, 2007

Mileage

29,000 mi

DT*: THE CONTACT STATED INTERMITTENTLY THE VEHICLE STALLS WHILE RELEASING THE ACCELERATOR PEDAL AT 20-4 0MPH. NO WARNING LIGHTS HAVE ILLUMINATED. AFTER STALLING THE VEHICLE WILL RESTART, SURGE AND STALL AGAIN. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP FOUR TIMES. THE LAST VISIT TO THE DEALERSHIP THE ELEMENT, FILTER, COMPLETE MODULE ENGINE, THE KEY WAS REPROGRAMMED AND THE COOL RETURN WAS REPLACED. THE NEXT TIME THE VEHICLE WAS DRIVEN AFTER THE REPAIRS WERE PERFORMED THE VEHICLE STALLED WHILE CROSSING A RAIL ROAD TRACK. THE VEHICLE HAS STALLED A TOTAL OF FIVE TIMES. IT WAS TOWED TO THE DEALERSHIP FOUR OF THE FIVE TIMES. THE MANUFACTURER HAS BEEN ALERTED. THE FUEL PUMP WAS REPLACED. UPDATED 05/02/06. *JB

NHTSA ID

10154783

Incident

Apr 6, 2006

Mileage

16,500 mi

5 MONTHS AFTER PURCHASING CAR NEW IN 8/04 IT WOULD NOT START(1/05) ;WAS ABLE TO RESET FUEL PUMP SHUT-OFF SWITCH AND START CAR. DEALER (MUZI FORD, NEEDHAM, MASS.)EXAMINED CAR AND FOUND NOTHING. IN 2/05 CAR WOULD NOT START,COULD NOT RESET FUEL PUMP SHUT OFF SWITCH; DEALER REPLACED IT. IN 4/05 SAME PROBLEM OCCURRED AND DEALER REPLACED SWITCH , STATING IT WAS 'BURNED OUT'.IN 2/06 IDENTICAL PROBLEM OCCURRED AND BOTH SWITCH AND COMPUTER WERE REPLACED BY DEALER. FUEL PUMP SHUT-OFF SWITCH HAS BEEN REPLACED THREE TIMES AT THIS POINT. THE CAR IS A 2004 FORD EXPLORER XLS.*JB

NHTSA ID

10149801

Incident

Feb 3, 2006

Mileage

37,050 mi