2008 Ford Explorer Problems

Report #1 - My grandma brought this 08' Explorer back in 2014, and after she passed, my mom drove it for the next 2 years. It started having general maintenance issues, then the cats were stolen, but then, one night my mother was coming home from a relative's house, when she was trying to keep up with the flow of traffic on [XXX] , and she noticed that the vehicle was not accelerating at all and the vehicle stalled out. She had it towed home and it sat on the streetside for some time. After digging through the internet, I figured that Ford designed the throttle-body wiring to settle next to the cooling hoses, and after time, the wires rot from the hot temperatures of the hoses and crack/snap causing the vehicle to either stall, or possibly have unintended acceleration. Ford never recalled this issue! Also, it had a massive coolant leak, from which was believed to be the cheap plastic T-Stat housings that Ford never recalled, and to top it all off: the right rear turn-indicator failed from the faulty wiring harnesses... As a result, we ended up having it scrapped/junked. It was sad to see her go, but obviously Ford doesn't care about their customers safety and will find any loophole to avoid recalling a vehicle... Ford needs to get their stuff together or they need to be shut down!... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

AN ORANGE WRENCH LIGHT COMES ON ON MY DASHBOARD AND I CAN'T PICK UP SPEED. I'VE HAD IT LOOKED AT A FEW TIMES AND NO ONE CAN FIGURE OUT THE PROBLEM. THERE'S BEEN MANY PEOPLE ON YOUTUBE COMPLAINING OF THE SAMETHING. THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED IMMEDIATELY, LUCKILY THE INTERSTATE WASN'T BUSY WHEN MY TRUCK LOST ITS ABILITY TO ACCELERATE. I COULD'VE CAUSE A CAR PILE UP AND THERE COULD'VE BEEN MANY LIVES LOST

The contact owns a 2008 Ford Explorer. The contact stated that while attempting to park the vehicle, the gear shifter was shifted into park, and the vehicle rolled backwards about an inch. No warning lights were illuminated. The contact stated that the parking brake was enabled to stop the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed with possible transmission failure. The vehicle was not repaired. The contact referenced an unknown recall; however, the VIN was not associated with a recall related to the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.

AN ORANGE WRENCH LIGHT COMES ON ON MY DASHBOARD AND I CAN'T PICK UP SPEED. I'VE HAD IT LOOKED AT A FEW TIMES AND NO ONE CAN FIGURE OUT THE PROBLEM. THERE'S BEEN MANY PEOPLE ON YOUTUBE COMPLAINING OF THE SAMETHING. THIS IS VERY DANGEROUS AND SHOULD BE INVESTIGATED IMMEDIATELY, LUCKILY THE INTERSTATE WASN'T BUSY WHEN MY TRUCK LOST ITS ABILITY TO ACCELERATE. I COULD'VE CAUSE A CAR PILE UP AND THERE COULD'VE BEEN MANY LIVES LOST

TRANSMISSION FAILURE, FRONT DRIVER SEAT WILL NOT ADJUST BEFORE GOING OUT WOULD MOVE ON ITS OWN AND CAUSE INTERIOR LIGHTS TO COME ON. PREVIOUS OWNER TOOK VEHICLE IN AFTER PURCHASE FOR HARD SHIFTING OF TRANSMISSION AND NO REPAIRS WERE DONE. TRANSMISSION PROBLEM WAS NOT DISCLOSED TO ME AT TIME OF PURCHASE.

WHILE DRIVING THE VEHICLE, THE IGNITION SWITCH WILL ACTIVATE THE MEMORY SEAT FUNCTION CAUSING INTERIOR LIGHTS TO ACTIVATE AND THE DRIVER SEAT TO MOVE BACKWARD LEAVING THE DRIVER UNABLE TO REACH PEDALS OR STEERING WHEEL WHILE VEHICLE IS IN MOTION. OCCURS ON BOTH CITY STREETS AND HIGHWAYS. UNSEEN CAUSE TRIGGERS THE EVENT.

Stalling in mid traffic. I was told it is poor quality of timing components. The vehicle has less than 200,000 miles and has had routine maintenance as it was a police investigation car

I got the car from my landlord, my husband never checked the oil or fluids even though I was on him, it died 2 months after we got it, the guy said before we purchased it that it still was under warranty for transmission, so when it died I thought ok it's covered, so the landlord said it was the motor it seized he said had no coolant and was 2qts of oil over I said well he never added anything & I said it never overheated, he said I don't know how it was done but it will cost $3800 to fix, so I was hoping that there might be a recall that can fix this or also he puts new rear in the car a week after I got it, does any of this sound like it is his side that is reliable to fix it?

WHEN DRIVING IN THE RAIN, IF I GO THROUGH A PUDDLE ON THE PASSENGER SIDE OF THE CAR, THE POWER STEERING FAILS FOR VARYING AMOUNTS OF TIME. IT HAS HAPPENED MORE THAN ONCE, THROUGH THE LIFE OF THE CAR. I ONLY JUST FOUND OUT I COULD MAKE A COMPLAINT.

STIFFNESS IN STEERING WHEN YOU TURN THE WHEEL . NO SOUNDS COMING FROM POWER STEERING/BELT OR ANYTHING FOR THAT MATTER .. JUST WHEN YOU SLOW TO TURN IT'S STIFF

INTERIOR DOME LIGHTS TURN ON WHILE DRIVING. THIS HAS HAPPENED INTERMITTENTLY FOR ABOUT A YEAR AND HAS HAPPENED AT VARIOUS SPEEDS AND EVEN WHEN THE VEHICLE IS NOT MOVING. THIS IS A SAFETY ISSUE WHEN IT HAPPENS WHILE DRIVING AT NIGHT AS IT MAKES IT MUCH HARDER TO VIEW THE ROAD AND EXTERNAL SURROUNDINGS.

THE AIR BAG INDICATOR LIGHT IS ON AND STAYS ON. I TOOK IT TO MY FORD DEALER AND THEY ARE SAYING I NEED A NEW MODULE IN ORDER FOR MY AIRBAG TO DEPLOY PROPERLY. AFTER RESEARCHING ON LINE, I SEE HUNDREDS OF SIMILAR COMPLAINTS WITH NO RESULTS. I AM CONCERNED THAT THIS IS AN ONGOING PROBLEM THAT FORD IS TURNING A BLIND EYE TO. THIS IS A SAFETY CONCERN THAT SHOULD BE ADDRESSED AND SOON. THERE ARE COMPLAINTS ON MODELS FROM 1999-2014, AND THE BOTTOM LINE IS THAT CUSTOMERS ARE HAVING REPAIRS MADE THAT ARE NOT FIXING THE PROBLEM. I WENT TO THE OFFICIAL FORD SITE TO REVIEW THIS INFORMATION AND HAVE BEEN SHOCKED THAT THIS ISSUE CONTINUES TO REAR ITS UGLY HEAD. *TR

The stickers are not on properly. My childs safety wasnt put at risk. I asked a CPST to help with a fit and intall check and we noticed the defected stickers.

TRANSMISSION ON MY FORD EXPLORER V8 4.6 LIMITED NOT CHANGING INTO LAST GEAR. WHEN COMING TO A COMPLETE STOP TRANSMISSION JERKS SLIGHTLY. AT 61000 MILES NOW ..... I DIDN'T EXPECT TRANSMISSION PROBLEMS. FRONT WHEEL BEARINGS ARE HUMMING..... I HAD THIS WHEEL BEARING PROBLEM BEFORE ON MY OTHER 2008 FORD EXPLORER XLT 6 CYLINDER 4.0

Report #1 - My grandma brought this 08' Explorer back in 2014, and after she passed, my mom drove it for the next 2 years. It started having general maintenance issues, then the cats were stolen, but then, one night my mother was coming home from a relative's house, when she was trying to keep up with the flow of traffic on [XXX] , and she noticed that the vehicle was not accelerating at all and the vehicle stalled out. She had it towed home and it sat on the streetside for some time. After digging through the internet, I figured that Ford designed the throttle-body wiring to settle next to the cooling hoses, and after time, the wires rot from the hot temperatures of the hoses and crack/snap causing the vehicle to either stall, or possibly have unintended acceleration. Ford never recalled this issue! Also, it had a massive coolant leak, from which was believed to be the cheap plastic T-Stat housings that Ford never recalled, and to top it all off: the right rear turn-indicator failed from the faulty wiring harnesses... As a result, we ended up having it scrapped/junked. It was sad to see her go, but obviously Ford doesn't care about their customers safety and will find any loophole to avoid recalling a vehicle... Ford needs to get their stuff together or they need to be shut down!... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The wiring harness going into the back of what I believe is the throttle position sensor has a 180° turn in the wiring in a very short distance. There are four wires involved in that portion of the wiring harness. The wiring is also next to the hot, cooling system hoses coming out of the firewall. These factors caused the wiring to crack prematurely creating surges in the idle and the vehicle speed to be uncontrollable due to shorts/arcing in the electrical wiring. An extremely dangerous situation. My daughter ran into a bullard because she started the vehicle, put it in drive, and it took off on her. Vehicle would drive at 20 to 25 miles per hour on its own without stepping on the gas pedal. After two or three attempts, I was able to satisfactorily fix the wiring. Please note that the attached pictures do not show the original condition of the wiring. I attempted to use liquid electrical tape on one of my first attempts but that soon cracked as well. You will see that in one of the photos. I may have original pictures of the electrical wiring on my desktop computer and will gladly submit those at a later time if I can find them. This failure in the wiring should be easy to identify in any 2008 Ford Explorer.

TIRE SENSOR WAS ON AND TRANSMISSOIN IS LEAKING

WHEN THE ABS SENSORS IN THE FRONT HUB ASSEMBLIES FAIL, THE TRACTION CONTROL SYSTEM GOES INTO A SPORADIC LIMP MODE THAT CUTS POWER TO THE WHEELS CAUSING A TEMPORARY LOSS OF CONTROL LEAVING THE VEHICLE POWERLESS IN ON COMING TRAFFIC. THIS EVENT USUALLY OCCURS WHEN TURNING ON TO A ROAD WAY, BRAKING WHILE TURNING, OR ACCELERATING ON THE EXPRESSWAY. *TR

TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE DRIVING ON THE HIGHWAY, THE WINDSHIELD BLEW OUT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE WINDSHIELD WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000.

DRIVER & PASSENGER MIRROR LIDS ON SUN VISORS HAVE BROKEN APART. IT IS CLEAR THAT THE PLASTIC USED WAS OF INFERIOR QUALITY. LIDS BREAK OFF, MIRROR LIGHT STAYS ON AND: 1) RUNS BATTERY DOWN OR 2) POTENTIALLY CAUSES FIRE DUE TO OVERHEATING OF MATERIALS. *TR

THE DRIVER'S SAFETY DEVICE (SEAT BELT) DOES NOT WORK PROPERLY. IT IS SOMETIMES DIFFICULT TO CLICK/LOCK IT IN PLACE, EVEN WITH FORCEFUL PRESSURE. IN ADDITION, THE SEAT BELT WILL COME UNLOCKED. THIS CAN HAPPEN WHILE DRIVING OR NOT IN MOTION. ALL INDICATIONS ARE THAT THE SEAT BELT IS LOCKED IN PLACE (NO DASH LIGHTS INDICATING IT IS NOT) BUT THEN IT WILL AUTOMATICALLY COME OUT OF THE LOCKED POSITION. WHAT GOOD IS A SEAT BELT IF IT DOESN'T WORK? THIS HAS HAPPENED TO MY HUSBAND AND ME.

THE DRIVER SAFETY SEAT BELT DOES NOT EASILY LOCK IN PLACE EVEN WITH A HARD PUSH AND COMES OUT OF THE RETAINER UNDER PRESSURE ON THE BELT - ONLY REPEATED HARD PUSHES UNTIL A CLICK SOUNDS IS EFFECTIVE! THE LOCKING MECHANISM APPEARS TO BE LOCKED WHEN IN FACT IT IS NOT. THE DRIVER IN A FATALITY WOULD BE ACCUSED OF NOT FASTENING HIS SEAT BELT WHEN HE THOUGHT IT WAS LOCKED IN PLACE. THE WARNING LIGHT ON THE DASH INDICATING THE SEAT BELT IS NOT FASTENED DOES NOT COME ON WHEN THE LOCKING MECHANISM IS NOT LOCKED IN PLACE MAKING THE DRIVER THINK THAT THE BELT IS SECURE WHEN IT IS NOT.

THERE IS A SUSPECT DRIVING A SEA GREEN FORD EXPLORER IN BUXTON, NORTH CAROLINA FOR SEVERAL YEARS NOW WITHOUT A REGISTERED VEHICLE IDENTIFICATION NUMBER INSIDE THE DASHBOARDS OF HER VEHICLE AND THEREFORE IT IS OBVIOUSLY A THREAT TO OTHER VEHICLE ON THE HIGHWAY AND COULD INCUR LONG TIME DAMAGES TO ANOTHER VEHICLE OR PEDESTRIAN ON THE ROAD AT ANY GIVEN TIME PLUS THE SPACE WHERE IT IS SUPPOSED TO READ THE VIN IT IS PAINTED YELLOW AND READS IN BIG WHITE LETTERS AIR BAG.

THE AIR BAG INDICATOR LIGHT IS ON AND STAYS ON. I TOOK IT TO MY FORD DEALER AND THEY ARE SAYING I NEED A NEW MODULE IN ORDER FOR MY AIRBAG TO DEPLOY PROPERLY. AFTER RESEARCHING ON LINE, I SEE HUNDREDS OF SIMILAR COMPLAINTS WITH NO RESULTS. I AM CONCERNED THAT THIS IS AN ONGOING PROBLEM THAT FORD IS TURNING A BLIND EYE TO. THIS IS A SAFETY CONCERN THAT SHOULD BE ADDRESSED AND SOON. THERE ARE COMPLAINTS ON MODELS FROM 1999-2014, AND THE BOTTOM LINE IS THAT CUSTOMERS ARE HAVING REPAIRS MADE THAT ARE NOT FIXING THE PROBLEM. I WENT TO THE OFFICIAL FORD SITE TO REVIEW THIS INFORMATION AND HAVE BEEN SHOCKED THAT THIS ISSUE CONTINUES TO REAR ITS UGLY HEAD. *TR

TL* THE CONTACT OWNS A 2008 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 80 MPH, A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRONT WHEEL BEARING HUB ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED 30 MILES LATER. THE VEHICLE WAS REPAIRED A SECOND TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

BOTH FRONT WHEEL BEARINGS FAILED AND CAUSED DAMAGE TO FRONT AXLE THAT NEEDED TO BE REBUILT. *TR

AROUND 33K TRANSMISSION SHIFTED HARD...DEALERSHIP TIGHTENED THE BANDS AROUND 45K TRANSMISSION STILL SHIFTED HARD....DEALERSHIP REPROGRAMMED NOW AT 54K TRANSMISSION STILL SHIFTS HARD AND THE DEALERSHIP JUST REPLACED THE SOLENOID VALVE IN THE TRANSMISSION EVEN AFTER THE REPAIR WORK I AM STILL HAVING PROBLEMS. *TR

WE HAVE HAD TRANSMISSION PROBLEMS FROM THE START WITH THIS 2008 EXPLORER. WHEN SLOWING TO MAKE A TURN THE TRANSMISSION GETS HUNG BETWEEN GEARS, THEN THE ENGINE REVS UP, THEN THE TRANSMISSION WILL DROP INTO GEAR WITH NECK SNAPPING RESULT, LUNGING FORWARD QUICKLY. I'M AFRAID THAT THIS COULD CAUSE MY WIFE TO LOOSE CONTROL OF THE VEHICLE. ALSO THE LOCKING TORQUE CONVERTER DISENGAGES CONSTANTLY AT HIGHWAY SPEEDS, THEN RE-ENGAGES, THEN DISENGAGES. I WAS FINALLY ABLE TO GET A FORD ENGINEER NAMED DERRICK TO CHECK THE VEHICLE, BUT HE REFUSES TO ACKNOWLEDGE THE PROBLEM. ALL HE WANTS TO TALK ABOUT IS HOW SMOOTH THE VEHICLE RIDES ON THE HIGHWAY, JUST A LOT OF DOUBLE TALK TO DIVERT ATTENTION AWAY FROM THE PROBLEM. IT IS A CONSTANT PROBLEM, VERIFIED BY DAVID LAUGHLIN OF FORD MOTOR COMPANY, PAUL SANFORD OF COURTESY FORD, AND DAVE ADAMS OF COURTESY FORD. *TR

2008 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO HAVING PROBLEMS FILLING THE GAS TANK. *SMD THE CONSUMER STATED THE PUMP HOSE WOULD CLICK OFF AUTOMATICALLY, AS IF SIGNALING THE TANK WAS FULL, EVEN THOUGH THAT WAS NOT THE CASE. THE CONSUMER STATED IT TOOK APPROXIMATELY 20 MINUTES TO FILL THE TANK. THE CHECK ENGINE LIGHT ILLUMINATED SHORTLY AFTER, IT STARTED HAPPENING, BUT WENT OFF A SHORT WHILE LATER. A FLASHING RED LIGHT AND A WARNING TO SHUT DOWN THE ENGINE OCCURRED. AFTER SHUTTING DOWN THE ENGINE AND RESTARTING IT, THE PROBLEM SEEMED TO GO AWAY. THE RED LIGHT ISSUE OCCURRED TWICE. THE CONSUMER DISCOVERED FORD ISSUED A TSB SEVERAL YEARS AGO, OVER THE PROBLEM, AS IT APPARENTLY OCCURRED FREQUENTLY ENOUGH IN THE MARKET PLACE.

MY ENGINE LIGHT CAME ON AND I WAS UNABLE TO PUT GAS IN THE VEHICLE. I TOOK IT TO 3 LOCAL MECHANICS AND ALL 3 CONCURRED THAT DUE TO THE DESIGN OF THE GAS TANK VENT HOSE (WATER FROM THE ROAD) HAS ENDED UP IN THE GAS. THIS IN TURN CONTAMINATED THE GAS CANISTER AND GAS VENT VALVE. TO FIX THE PROBLEM THEY WILL BE REPLACING THE VENT HOSE, GAS VENT VALVE AND CANISTER. THIS IS INFORMATION WAS OBTAINED THROUGH RUNNING 3 DIFFERENT DIAGNOSTICS AND RECEIVING THE SERVICE BULLETIN (TSB 07-25-3). I CONTACTED FORD AND THEY STATED THERE IS A SERVICE BULLETIN ON THIS ISSUE BUT THEY WILL NOT HELP WITH THE REPAIRS SINCE MY WARRANTY IS OUT. THIS IS A KNOWN DEFECTIVE PART THAT THEY COULD HAVE REPLACED WHEN BEING NOTIFIED OF THE DEFECT AND IT WOULD HAVE PREVENTED THE WATER GETTING INTO THE VENT VALVE AND CANISTER CAUSING THIS EXPENSIVE REPAIR. I WILL BE GOING WITH THE CHEAPEST REPAIR WHICH IS $609.00 AND TO THE AVERAGE WORKING PERSON THIS IS A BIG EXPENSE FOR SOMETHING THAT COULD HAVE BEEN PREVENTED. I BELIEVE FORD SHOULD BE MADE TO REPAIR THIS ISSUE HAS BEEN REPORTED BY CONSUMERS AND THEIR POORLY DESIGNED PART CAUSED THE PROBLEM NOT THE CONSUMERS. THANK YOU FOR INVESTIGATING MY COMPLAINT. *TR

TL*THE CONTACT OWNS A 2008 FORD EXPLORER. THE CONTACT STATED THE ICE AND SNOW FREEZE THE DOORS AND FRAMES ON HIS VEHICLE AND HE CANNOT OPEN THEM. THE VEHICLE WAS TAKEN TO THE DEALER TWICE; HOWEVER, THEY STATED THAT THERE WAS NO FIX FOR THE PROBLEM. THERE WERE NO RELATED RECALLS OR WARRANTIES. THE FAILURE MILEAGE WAS 7,000 AND THE CURRENT MILEAGE WAS NOW 20,000. UPDATED 03/24/10 *BF UPDATED 07/27/10*JB

TL*THE CONTACT OWNS A 2008 FORD EXPLORER. THE VEHICLE HAS MICHELIN CROSS TERRAIN TIRES, SIZE P235/65/R18. THE CONTACT NOTICED THAT THE TIRE TRACTION WAS POOR WHEN DRIVING IN INCLEMENT WEATHER CONDITIONS. UPON FURTHER INSPECTION, SHE NOTICED THAT THE TREAD ON ALL FOUR TIRES FAILED. SHE TOOK THE TIRES TO SEVERAL DIFFERENT TIRE DEALERS AND THEY STATED THAT THE TIRES HAD ABNORMAL TREAD WEAR AND NEEDED TO BE REPLACED. THE TIRE MANUFACTURER ASSUMED PARTIAL RESPONSIBILITY FOR THE TIRES. THE CONTACT STILL HAS POSSESSION OF THE TIRES. THE FAILURE AND CURRENT MILEAGES WERE 11,300. THE CONSUMER HAS SINCED REPLACED THE TIRES. UPDATED 03/24/09.(JB