2018 Ford Explorer Interior & seats Problems

The contact owns a 2018 Ford Explorer. The contact stated that due to sunlight exposure, the outer layer of the dashboard peeled off and continued to expand near the location of the air bags. The contact was concerned that the defect might cause an air bag deployment malfunction in the event of a crash. The vehicle was taken to the local dealer, and the contact was informed that the entire dashboard needed to be replaced. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 45,000.

NHTSA ID

11696552

Incident

Oct 30, 2023

Mileage

45,000 mi

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, the A-pillar trims on the front passenger’s side and the front driver's side became loosened. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that on a separate occasion, while driving at 70 MPH, the hood unexpectedly opened. The contact stated that the hood was slightly ajar. The message "Hood Ajar" was displayed. The contact pulled over to the shoulder of the roadway and pushed the hood down. The contact continued driving. Most recently, while driving 70 MPH, the failure reoccurred with the message "Hood Ajar" displayed. The contact pulled over to the side of the shoulder and pushed down and closed the hood. The vehicle was not diagnosed or repaired after the most recent failure. The manufacturer was not made aware of the failure. The failure mileage was unknown.

NHTSA ID

11682266

Incident

May 21, 2025

The contact owns a 2018 Ford Explorer. The contact stated that the tailgate had failed to open. The vehicle was taken to a local dealer, where it was diagnosed that the tailgate latch had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

NHTSA ID

11674260

Incident

May 29, 2025

Mileage

70,000 mi

Driver's side heated seat coil burnt out. Many complaints about this.

NHTSA ID

11630360

Incident

Dec 12, 2024

Air bag style seat belt has broken twice and won’t allow seat belt to latch after it breaks. Broke while seat belt was in use and driving down the highway. When replacing the buckle I found that the frame piece on the seat was broke and moved when trying to tighten the buckle. The buckle has been unavailable online through multiple vendors and finally found one in stock.

NHTSA ID

11585972

Incident

Mar 16, 2024

The contact owns a 2018 Ford Explorer. The contact stated that the leather on the dashboard was peeling, and the contact was concerned that the passenger's side air bag might deploy. The vehicle was taken to the dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,000.

NHTSA ID

11524364

Incident

Jan 19, 2020

Mileage

15,000 mi

The contact’s wife owns a 2018 Ford Explorer. The contact stated that the dashboard had started to peel. The contact also noticed that bubbles had started to form on the passenger’s side dashboard to the driver’s side dashboard above the air bag housing. The contact also stated that he noticed that the leather had started to peel. No warning light was illuminated. The contact stated that he was concerned that the failure could cause the air bag to deploy erroneously. The vehicle was taken to the dealer where it was diagnosed that the dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was advised to call the NHTSA Hotline. The failure mileage approximately 50,000.

NHTSA ID

11518931

Incident

Jan 25, 2023

Mileage

50,000 mi

REACHING UNDER DRIVER SEAT AND CONTACTED SEAT FRAME SHARP AND CUT FINGER.

NHTSA ID

11299566

Incident

Jan 15, 2020

Mileage

10,000 mi

VEHICLE WAS STRUCK FROM BEHIND BY A PICK-UP TRUCK DRIVING AT A HIGH RATE OF SPEED. UPON IMPACT MY VEHICLE'S FRONT SEATS COLLAPSED INTO THE BACK SEATS CAUSING THE SEAT BELTS TO BE INEFFECTIVE. AS A RESULT THE PASSENGER IN MY VEHICLE SUSTAINED BACK AND NECK INJURIES. MY VEHICLE WAS STATIONARY AS THE TRAFFIC WAS AT A STANDSTILL. THE VEHICLE THAT STRUCK MY VEHICLE WAS TRAVELING AT ABOUT 70 MILES PER HOUR.

NHTSA ID

11278137

Incident

Aug 16, 2019

Mileage

28,000 mi

WHILE TRAVELING THROUGH BALTIMORE FOR APPROXIMATELY 45 MINUTES DURING THE CHRISTMAS HOLIDAY. I WAS SITTING IN THE BACK SEAT OF MY FRIENDS 2018 FORD EXPLORER SPORT. I HAD THE HEATED SEAT SET TO 2. I HAD FALLEN ASLEEP DURING THE TRIP. WHEN I WOKE UP I HAD A SEVERE DISCOMFORT. UPON ARRIVING AT OUR DESTINATION MY FRIEND LOOKED TO SEE WHY I WAS IN SUCH PAIN. ON MY LEFT BUTTOCK WAS A LARGE BURN. I HAVE ENCLOSED A PICTURE OF THE BURN I RECEIVED. THE BURN HAS BLISTERED AND IS NOW AN OPEN WOUND. THIS OCCURRED ON CHRISTMAS EVE. I HAVE BEEN TREATING THE AREA WITH BURN OINTMENT.

NHTSA ID

11163734

Incident

Dec 24, 2018

I RECENTLY PURCHASED A 2018 FORD EXPLORER ON AUGUST 30 FROM HAMMONASSET FORD IN MADISON, CT. I PAID SEVERAL THOUSAND DOLLARS EXTRA FOR A SAFETY PACKAGE WHICH INCLUDES REAR SEAT BELT AIRBAGS. WE WERE DISAPPOINTED TO DISCOVER AN ISSUE IN THE SECOND ROW OF SEATS THAT HINDERS US FROM USING ONE OF THE SEATS BECAUSE OF THE AIRBAG CONFIGURATION. THE MIDDLE SEAT WHERE THERE ARE SEAT BELTS FOR THREE ONLY FITS TWO PEOPLE. THE DESIGN OF THE SEAT BELT LATCHES IS A FLAWED ONE. THE SEAT BELTS OVERLAP WHICH IS A SAFETY CONCERN NOT TO MENTION A HUMAN BODY CANNOT FIT IN THE SPACE THEY ALLOTTED. THIS CAR IS ADVERTISED FOR SEVEN PEOPLE BUT ONLY CAN SEAT SIX. I HAVE SEVEN PEOPLE IN MY FAMILY INCLUDING A BABY IN A CAR SEAT AND WE ALL CAN'T GO IN THE CAR TOGETHER AT THE SAME TIME BECAUSE OF IT. I REACHED OUT TO THE DEALERSHIP AS SOON AS WE GOT THE CAR HOME AND THEY TOLD ME TO GO TO FORD. THE PERSON I TALKLED TO TOLD ME NO NEED TO TALK TO THE OWNER OR BOTHER HER. THEY WOULD NOT HELP ME BECAUSE THEY SAID IT IS A DESIGN ISSUE NOT ANYTHING THEY CAN REPAIR. I REACHED OUT TO FORD WHO SAID THE SAME THING. I CONTINUED TO REACH OUT TO THE DEALERSHIP WHO HAD SERVICE REACH OUT TO FORD TO SEE IF THEY CAN CHANGE THE SEAT BELTS IN THE CAR BUT DUE TO SAFETY ISSUES THEY WERE TOLD THEY CANNOT AND AGAIN THEY SAID IT IS A DESIGN ISSUE NOT A MANUFACTURING ISSUE THEREFORE I SHOULD GO TO THE BBB.IN ADDITION TO HAMMONASSET FORD, I ALSO WENT TO HOFFMAN FORD IN EAST HARTFORD TO SHOW THE SALES MANAGER THE CAR. HE WAS SHOCKED ABOUT THE DESIGN OF THIS CAR. WE LOOKED AT THE SAME EXACT CAR WITHOUT THE SAFETY PACKAGE AND THE SEAT BELTS WERE NOT FLAWED. THE SALES MANAGER AT HOFFMAN FORD SAID HE CANT HELP ME BECAUSE I DIDN'T BUY THE CAR THERE BUT IF FORD REACHED OUT TO HIM HE COULD HELP. I CONTACTED THE BBB BUT THEY DECLINED MY APPLICATION DUE FOR THE SAME REASON SAYING IT IS NOT AN MANUFACTURING ISSUE.

NHTSA ID

11139860

Incident

Aug 30, 2018

Mileage

200 mi

ON 2, 2018 FORD EXPLORER BASIC MODEL VEHICLES, THE FRONT PASSENGER AIRBAG INDICATOR HAS COME ON AND THEN GONE OFF AND STAYED OFF WITH MY 14 YEAR OLD 118 LB, 5' 9" CHILD IN THE FRONT SEAT. FIRST INCIDENT: MARCH 23, 2018. IN THE FIRST VEHICLE THE JOURNEY WAS APPROXIMATELY 30 MINUTES ON A 4 LANE ROAD. NO TURNING OR BRAKING AFFECTED THE CONDITION. SECOND INCIDENT: APRIL 4, 2018. IN THE SECOND VEHICLE, VIN [XXX], ON A HOUR AND THIRTY MINUTE JOURNEY, ON I-75 BETWEEN NAPLES, FL AND FT. MYERS, FL, MY CHILD SAT IN THE FRONT PASSENGER SEAT AND THE AIRBAG INDICATOR SHOWED THE AIRBAG WAS "ON". ON THE RETURN RIDE, WITH SITTING IN THE SAME POSITION, THE AIRBAG INDICATOR SHOWED THE AIRBAG WAS "OFF". BOTH INCIDENTS OCCURRED WHILE STRAIGHT LINE DRIVING, NO BRAKING OR TURNING AFFECTED THE INCIDENT. WE BROUGHT BOTH VEHICLES BACK TO THE DEALERSHIP FROM WHICH WE LEASED THEM AND SHOWED THEM THE ACCOMPANYING PICTURE. THEY TOLD US THAT IT COULD BE THAT MY CHILD IS TOO LIGHT FOR THE SEAT SENSOR, BUT THEY WERE NOT POSITIVE. THE HEAD OF THE SERVICE DEPT AND HIS LEAD TECHNICIAN WITNESSED THE AIRBAG INDICATOR IN THE "OFF" POSITION WITH MY CHILD SITTING IN THE SEAT. THEY SAID THEY HAVE NEVER SEEN THIS BEFORE. THEY ADVISED THEY CONTACTED FORD WITH THE FIRST VEHICLE VIN AND WERE DOING THE SAME WITH THIS SECOND VEHICLE AS WELL. I FEEL THIS IS A SIGNIFICANT SAFETY ISSUE AS THERE IS NO CERTAINTY, SHOULD WE GET INTO A VEHICLE CRASH AND NEED THE FRONT PASSENGER AIRBAG TO DEPLOY, THAT THE AIRBAG WILL ACTUALLY DEPLOY GIVEN THE CIRCUMSTANCES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11083343

Incident

Apr 4, 2018

Mileage

1,200 mi