2018 Ford Explorer Driver assistance Problems

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the A-pillar trim was beginning to detach from the windshield, allowing outside air to enter the vehicle. While in reverse, the back over prevention camera displayed a distorted image, or a solid blue screen without an image. The failure occurred several times while shifting into reverse. The dealer was contacted and confirmed that the part was not available yet available for the recall. The VIN was not under recall for the back-over prevention camera. The manufacturer was not made aware of the failure. The failure mileage was 78,896.

NHTSA ID

11722988

Incident

Jan 19, 2025

Mileage

78,896 mi

- I have experienced a sudden loss of engine power and speed on 5 occasions. Very scary and dangerous to completely lose power on the highway with cars behind you. Had to pull off onto the shoulder(s) in dangerous conditions, with two young kids in the backseat. Hazards, turn off the car, restart the car, etc. - When the power loss happens, the vehicle's dashboard lights turn on, including the engine and wrench icons along with the words "See Manual." - Based on my research, I believe it may be due to a defective throttle body and/or software, related to the "terrain management system." - Problem was not reproduced or confirmed by a dealer or independent service center - No inspections by the manufacturer, police, insurance representatives or others - No warning message is provided prior to the failure, which is another issue

NHTSA ID

11706887

Incident

Dec 21, 2025

The reverse camera does not work, when the car is in reverse.there is no visual on the monitor, which makes it unsafe when the car is in reverse, took the car to the dealer, was told that this car is not in recall

NHTSA ID

11705561

Incident

Mar 6, 2025

My rear view camera goes to a dark blue or gray s screen with the words “check surroundings for safety” & “Camera is unavailable” and it does not work. This is the same recall issue that is on 1,900+ plus vehicles from a recall. I have called and filled a complain with Ford and have visited 3 dealers in our area and that is what they tell me. I have photos and I need this repair done ASAP because I travel with an [XXX] I’ve called Ford four different times since July and I keep getting the run around and visit different t dealers that tell me that it is the same problem as the recall but the explorers are not yet part of the recall. I NEED YOUR HELP PLEASE THANK YOU [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11688234

Incident

May 28, 2025

My vehicle has defect in the electronic power brake assist system that lead to extended stopping distances and cause me to hit someone from behind.

NHTSA ID

11684671

Incident

Sep 13, 2024

The contact owns a 2018 Ford Explorer. The contact stated that while operating the vehicle, the display screen became inoperable. During the failure, the back over prevention camera was inoperable, and features including the engine temperature gauge was not available to the driver. The vehicle was taken to the local dealer who diagnosed that the D-Pin needed to be replaced. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 100,000.

NHTSA ID

11675025

Incident

Mar 21, 2025

Mileage

100,000 mi

On September 27th 2023 I brought my vehicle in because it was having shifting and vibration issues. To shop notice that the information I gave them was related to the transmission and with further review there was a recall on the transmission part of me coming into the shop. Which I wasn't aware of even when I brought my vehicle in months before that for recall maintenance. I had to pay for my transmission to be repaired we should have been done by Ford. The car was driving fine until early this year when it starts to do the vibration that was the issue previous when my transmission was going out. So I set up appointment at Ford dealership while I was in route to the dealership my car started to sputter and shake and fall out of gear. So I turned around tried to make it home in the car just stopped moving. I wasn't able to move forward or reverse there is no connection within the transmission for my car to move. I got my car towed to the dealership who diagnosed my car and my transmission and they stated that there was metal fragments found in the fluid level and I also said that the torque converter clutch performance never engage when it was testing it. I told him about my previous transmission issue with Ford and I also States them that four has have many federal recalls dealing with their transmissions in their vehicle.

NHTSA ID

11672297

Incident

Apr 7, 2025

The contact owns a 2018 Ford Explorer. The contact stated that occasionally while shifted into reverse(R), the rearview camera failed to properly display the image behind the vehicle. There was no warning light illuminated. Additionally, the contact stated that the failure had progressed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,265.

NHTSA ID

11671611

Incident

Jul 7, 2025

Mileage

100,265 mi

The contact owns a 2018 Ford Explorer. The contact stated while reversing, the back-over prevention camera system failed to function as intended. The contact stated the back-over prevention camera seized and displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with a failed back over prevention camera system. The contact was informed that the back over prevention camera system needed to be replaced. The vehicle was not repaired. In addition, the contact stated that the vehicle was taken to the dealer twice due to the persistent failure. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 200. The VIN was unavailable.

NHTSA ID

11667357

Incident

Jan 17, 2019

Mileage

200 mi

Radio and back up screen stop working 1 month after purchase.

NHTSA ID

11629482

Incident

Dec 20, 2023

Our radio and back up assistance screen just stop working

NHTSA ID

11606566

Incident

Nov 22, 2023

I own a 2018 Ford Explorer there has been an issue when it’s cold out the APIM is not responding and turning on the reverse camera when vehicle is put into reverse. When it is above 70 degrees Fahrenheit the APIM works intermittently. The problem with this is out of the blue when it decides to work at times it turns the radio on with volume at max level This has startled me not knowing it’s going to come on and it won’t let you turn the radio down or power it off. Ford says there is no recall on the issue.

NHTSA ID

11590792

Incident

May 24, 2024

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the cruise control failed to operate as needed. No warning lights were illuminated. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was unavailable. VIN tool confirms parts not available.

NHTSA ID

11586569

Incident

May 21, 2023

The contact owns a 2018 Ford Explorer. The contact stated that the rear backup camera would display a blue image on the infotainment screen. The dealer was notified of the failure and informed the contact that there were no recalls on the vehicle. The manufacturer was also notified of the failure and was given the same information as the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 42,000.

NHTSA ID

11578657

Incident

Mar 1, 2023

Mileage

42,000 mi

The contact owns a 2018 Ford Explorer. The contact stated that on several occasions while in reverse, the back-over prevention screen displayed a black screen preventing the image from being seen. The vehicle was taken to a dealer where it was diagnosed that the APIM needed to be replaced. The vehicle was not repaired. The contact stated that the manufacturer was notified of the failure. The failure mileage was approximately 90,000.

NHTSA ID

11548259

Incident

Mar 15, 2023

Mileage

90,000 mi

APIM Module is bad

NHTSA ID

11534078

Incident

Jul 24, 2023

Recently my screen has not been working in the car. When I took it to the car dealership they said it was the APIM and it is 1400. They said they have had to order about 35 of them in the past month with cars having the same issue. If this is the case then a recall should be considered due to the price that is associated with this part

NHTSA ID

11533981

Incident

Jun 19, 2023

Have had the vehicle for less than a year have had nothing but lil problems but recently have gotten a cranking noise, transmission / coolant leaking under the vehicle. Also have water leaking from the exhaust line when car is in park. Driving back from work early in the morning a sounded like a big pop not sure what it have may been took it to the mechanic ass well twice an got it diagnosed an they’re response was they couldn’t find the problem. The area I’ve seen an heard the clunking the most would be under the vehicle at the center by the catalyst converter. Transmission jerks as well I’ve had this vehicle for 8 months a don’t seem to be what a vehicle should be doing.

NHTSA ID

11529461

Incident

May 26, 2023

The Sync infotainment screen is inoperable and black. My backup camera is no longer operational. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 98,000.

NHTSA ID

11515668

Incident

Mar 22, 2023

I have had three incidents of total brake failure on this vehicle. First, about 3 months ago I could not stop while parking in my garage and hit a work bench. I chalked it up to just a weird low speed incident as the brakes worked fine the next time I drove it. Second, I was traveling on wet roads and 27 degree weather and could not stop for a yellow light. At the time I attributed it to an icey skid because, again, the brakes worked fine the next time I needed them. But in retrospect, I do not recall any feeling that the brakes were working. Lastly, today I rear ended a car in front of me when the brakes and the supposed forward collision system both failed dramatically. I was probably going 25 MPH coming to a red light and started to apply my brakes several hundred feet before the intersection. Nothing happened and I, panicked, began pumping the pedal relentlessly. Finally the dashboard crash warning light started flashing and still no drop in speed. I tried to get into low gear, but by that time it was too late and I crashed into a van in front of me. It totaled my car and pretty well wiped out the rear doors and windows of the van. Fortunately, no one was injured. I was not cited because an EMT nurse was in the lane beside me and witnessed my brake pumping, steering wheel grabbing actions and could tell what was going on. The police are going to investigate the brake problem as well as my insurance company, USAA. There have been no brake recalls issued for my vehicle and any other recalls are up to date. There are approximately 50000 miles on it and it has had meticulous care and regular maintenance and brake shoes are still listed as good condition on my last visit for an oil change.

NHTSA ID

11510604

Incident

Mar 7, 2023

The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the infotainment screen was inoperable. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.

NHTSA ID

11509819

Incident

Jun 1, 2021

Mileage

89,000 mi

I have a 2018 Ford Explorer. My SYNC 3 is showing a black screen due to a failed APIM. I do not have my rear camera, GPS, or hands-free capability which impedes driving safely. Ford has recalled multiple other years of my vehicle for this same reason, but not the 2018. Ford has also extended it's warranty up to 7 years/100,000 miles on some years of my vehicle, for the same reason, but not the 2018. I am reading that there are numerous other owners who a have the same problem with only an expensive resolution. The Ford dealer confirmed the need to replace the APIM today at a cost of $1,417. This is unacceptable due to the safety factor and that they know this is a problem in their vehicles. I reported it to Ford and their response was my warranty is expired and there is no recall, so I have to pay.

NHTSA ID

11507492

Incident

Jan 23, 2023

The contact owns a 2018 Ford Explorer. The contact stated the rearview camera screen was blue and inoperable. The contact stated the “Camera not Available” warning light was illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the rearview camera to be replaced. The vehicle was not repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 40,000.

NHTSA ID

11507352

Incident

Jan 27, 2023

Mileage

40,000 mi

I’ve recently heard from a-couple ford owners and ford technicians them selves that our vehicles come with faulty APIM modules and I just recently found out there was a recall on the 2017 model . I do not understand why there is not a recall on the 2018 model also as mine and several other peoples screen went completely black out of nowhere which is a part called the APIM module has failed which is a safety hazard that I cannot call 911 in an event or even use the back up camera for the safety of my vehicle . APIM modules are not cheap and they are not covered by a lot of warranty companies but it includes so many vital parts or pieces that’s supposed to be included . Please seek to look into this APIM module recall for 2018 models also as it’s been a headache for many people .

NHTSA ID

11505735

Incident

Jan 26, 2023

The contact owns a 2018 Ford Explorer. The contact stated that while reversing, the back-up camera image was distorted and unviewable. The vehicle had also experienced various electrical failures which included the headlights independently turning on while the vehicle was off. Additionally, while driving at undisclosed speeds, the message "Key Not Detected" was displayed. The vehicle also experienced the liftgate opening independently while driving. The contact also had difficulties starting the vehicle. The vehicle was taken to the local dealer who diagnosed that the rear camera wire connector had failed due to water damage. The connector was replaced but later the failure reoccurred. The manufacturer was notified of the failure. The failure mileage was 20,000.

NHTSA ID

11503932

Incident

Feb 16, 2022

Mileage

20,000 mi