Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 717 NHTSA owner-reported complaints for the 2018 Ford Explorer. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 717 · page 1 of 29
The transmission is actively slipping and dropping out of gear while driving causing unexpected loss of acceleration on public roads. This represents an extreme road safety hazard. The manufacture was notified but refused to offer assistance or grace coverage immediately following a Premium CARE factory contract expiration.
On March 25, 2026, an authorized Ford dealership in Florida performed a safety recall involving the rear suspension toe links. The recall addressed a condition that Ford states can result in loss of steering control and increased crash risk. After the recall was completed, I drove approximately 1,200 miles home believing the safety defect had been corrected. After returning home, I began experiencing rear-end instability. The vehicle would sway when driving over even small bumps. I took the vehicle to another authorized Ford dealership, which confirmed the original recall repair had not been performed correctly. The dealership found problems with the rear suspension and alignment that required extensive corrective repairs, including replacement of rear suspension components and correction of the rear suspension alignment. Both rear tires had also developed severe, uneven wear and were determined to be unsafe, requiring replacement despite being only about two months old. No warning lights or messages appeared before or during this condition. I was unaware that the recall repair had been performed incorrectly and unknowingly drove approximately 1,200 miles with a compromised rear suspension after being told the safety recall had been completed. I am submitting this complaint because an improperly performed safety recall repair may have exposed me, my passenger, and others to the same safety risk the recall was intended to prevent.
The contact owns a 2018 Ford Explorer. The contact received notifications of NHTSA Campaign Numbers: 24V031000 (Structure) and 26V448000 (Structure); however, the parts to do the recall repairs were not yet available. The contact stated that while driving at an undisclosed speed, one of the windshield exterior A-Pillar trims detached and struck the windshield. The vehicle was taken to the dealer, where the remaining A-Pillar trim was removed. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The manufacturer was made aware of the failure. The failure mileage was approximately 18,600.
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted and stated that parts would be over a year to for the availability. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
July 12, 2026 I returned home and parked about 10 ft from my garage. I put my car in park, turned off the motor, and went to get out, when my husband started yelling at me that the car was moving. I pumped the brake, and heard a clicking sound. The car wouldn't stop, it ran into my house. Cracking my left headlight and denting my bumper. The car was in park, and I was unable to move the steering wheel. I had no control of the car. Thank goodness no one was standing in front of me. If it had happened just a short time before when I was at a splash pad full of children, it could have killed people. I contacted Ford Motor Company on Monday and the Customer Service representative did not offer any comfort, but simply stated that "she spoke for Ford Motor Co., and there was no financial compensation programs at this time." I never asked for money. I just want to know if my car is going to act possessed again, if there is a recall, if Ford would stand by their product (my 3-4th Ford car). She was rude, and not helpful at all. I took it to my dealership, and they said that they ran multiple tests on it, and it showed nothing. However, when my husband took it into the shop, he ran the black box, 2 days before and after, and it showed several erratic messages. None of which were mentioned today, when they announced that my car was available for pick up. Mind you, my headlight is cracked and bumper is dented. It looks like there might be a similar recall: NHTSA campaign number: 23V675. Ford’s own number for this recall is 23S55 - I don't know what to do about this. The dealership seemed interested in getting to the bottom of it, but may be dropping the ball. Is it possible that this recall would be on my car?? Please advise. I wanted Ford to take care of it, however it looks like I will need to file a report with my insurance company. I would say that there was a problem with the parking system, the brake system?
The contact owns a 2018 Ford Explorer. The contact stated that the driver's side front seat belt failed to click securely into the buckle. The seat belt warning light was illuminated. The contact stated that the failure was associated with NHTSA Campaign Number: 25V093000 (Seat Belts); however, the VIN was not included. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 97,000.
This vehicle was inspected by a certified Ford dealership (Premier Ford, Service Advisor: Harry). Ford Motor Company’s Consumer Affairs Department subsequently reviewed the case under Complaint ID: XXX. In their official written response, Ford explicitly admitted the root cause, stating: "the vehicle experienced a failure to the harness for the alternator which melted due to heat from the exhaust." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Dealership is not honoring active recalls due to body damage causing car to be deemed total loss by dealership and is in process of being rebuilt
The windshield wiper motor failed, causing the windshield wipers to stop operating properly. At the same time, the windshield washer system is unable to spray washer fluid onto the windshield. This significantly reduces visibility during rain and when the windshield becomes dirty, creating a safety hazard. No warning lights were displayed
While driving at highway speed on a 2-lane highway with three children under the age of [XXX] in the vehicle, my 2018 Ford Explorer experienced sudden complete engine failure with no prior warning. No warning lights, no temperature gauge change, no unusual sounds. The vehicle went from operating normally to catastrophic failure instantaneously, forcing me to sharply cross active traffic to exit the roadway. The vehicle came to rest near a train track. The root cause was internal water pump failure. Ford's design places the water pump inside the engine, causing coolant to leak internally with no external indicators and no dashboard warning until catastrophic damage has already occurred. Ford did not install a coolant level sensor in the reservoir, and the only coolant warning available is an overheating alert, which never triggered. I had taken every reasonable precaution. Two thousand miles prior, an oil change showed no coolant contamination. One week prior, I physically checked the coolant level and it was within safe range. Ford's design gave me zero opportunity to detect or prevent this failure. This is a known recurring issue. Over 86 engine complaints have been filed with NHTSA for this model year alone and Ford has been aware of this defect since at least 2007. Despite class action litigation in both Canada and the United States, Ford has not issued a U.S. recall. Repair costs exceed $9,000. I am requesting NHTSA open a formal investigation and compel Ford to issue a U.S. recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Explorer. The contact stated that while driving at approximately 30 MPH, the check engine warning light illuminated. The vehicle was driven to the residence and then to an independent mechanic shop, where a full diagnostic inspection was not performed; however, the mechanic suspected that coolant bubbled internally and the contact was informed that the head gasket might need to be replaced. The mechanic was unable to disassemble the engine for further inspection. The vehicle was then taken to a dealer, who diagnosed that the water pump needed to be replaced, and the vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 112,000.
The contact owns a 2018 Ford Explorer. The contact had received notification of NHTSA Campaign Number: 26V101000 (Suspension), and the recall repair was completed. The contact stated that immediately after the recall repair, while driving on several occasions at various speeds, the rear end of the vehicle fishtailed, and the contact lost control of the vehicle. The vehicle was taken to the same dealer on several occasions; however, the failure could not be duplicated. The contact was advised that the tires needed to be replaced. The contact purchased and replaced the tires and had a four-wheel alignment performed, but the failure persisted, although not as severe. While the vehicle was parked, the contact became aware that the tread on the rear tires was extremely worn. The manufacturer was notified of the failure. The failure mileage was approximately 118,000.
The contact owns a 2018 Ford Explorer. The contact received notification of NTHSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the dealer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.
While driving out of a turn or curve, the steering does not return to center. Which may cause veering into other lanes or off the road.
Less that 100k miles and my transmission already needs replaced. Last year my engine was sputtering making my car jerk while driving went to shop they did a total transmission fluid changed but said my transmission is likely going bad it helped mostly and I had high hopes the problem was solved it was not fast forward to now my transmission went then caused the torque converter to go my car was shaking so bad while stopped and in drive in order to go i had to put my foot all the way to the floor and quickly move to the break sometimes my car would fly other times it would take so long to go that people would try to fly around me then my car would shoot forward and id have to slam on breaks and the rpm gage was all over the place while maintaining the same speed. My car should not need a new transmission at under 84000 miles. This was so dangerous. When I did a search so many reddit posts about 2018 explorers torque converters and Transmissions going bad. I'm livid. I don't have 8k to replace the transmission in a vehicle i still owe 10k on
Vehicle: 2018 Ford Explorer Mileage at Failure: 62,212 miles On [XXX] while driving my 2018 Ford Explorer, the wrench warning light suddenly illuminated on the dashboard. At the same time, the vehicle experienced a significant loss of power and became extremely sluggish in acceleration. When I pressed the accelerator pedal, the vehicle failed to respond normally and did not accelerate as expected. This condition created a serious safety hazard because the vehicle could not maintain or increase speed when needed in traffic. Had this occurred while entering a highway, crossing an intersection, or attempting to avoid another vehicle, it could have resulted in a crash. The vehicle has been inspected by McCarthy Ford. The dealership diagnosed transmission-related problems and provided a repair estimate of $6,384.94. Ford Motor Company previously issued Customer Satisfaction Programs 20B27 and 20N07 for certain Ford Explorer vehicles equipped with the 6F35 transmission. Ford's own documentation acknowledges that transmission torque converter overheating may result in low performance, lack of acceleration during launch, sluggish vehicle operation, vibration, shuddering, and related transmission concerns. These symptoms are consistent with the condition experienced in my vehicle. I reported the issue to Ford Motor Company and sent a certified letter to CEO James D. Farley, Jr. requesting assistance and a policy adjustment due to the known transmission and torque converter concerns. To date, I have not received a satisfactory response. I am submitting this complaint because the sudden loss of acceleration and reduced vehicle power created a significant safety risk while operating the vehicle on public roadways. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while driving 65 MPH, the front Driver-side A-pillar trim detached and struck a nearby vehicle. The contact pulled over to check on the vehicle that was struck by the front driver’s side A-pillar trim and retrieved the trim piece. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 45,000.
My vehicles transmission has been replaced 2 times already (3 years apart)- now it is overheating. Absolutely no warning lights have came on at any time in regards to any of my situations - My vehicle is available for inspection at any time. When the transmission went in my vehicle, I was traveling on an interstate with my child. The dealer has confirmed replaced the transmission as it was still under the 5 year warranty - my vehicle is set to go back into the shop today to be inspected as to why it is overheating.
The airbag light shown in the attached photo came on at an unknown period of time. We did not know when this came on that it was not a normal light. This is a safety issue as there are many causes for this light to come on, and with this light being on the airbag may not deploy properly or at all during a collision. We did take the vehicle to the Ford dealership for warranty work and they did not say anything about the light on the dash. Which adds to the reason why we did not know that the light meant there was a problem. There are other airbag lights that come on in the sinners console for the passenger side airbags that are orange as well.
Attempted to make an appointment on XXX with [XXX], 2121 W Bell Rd, Phoenix, AZ 85023 phone 602-375-7400 to have the two open safety recalls completed( 26V101 & 24v031). Could not make a service appointment because the service writer said that parts were not available and had no idea of when they would be available to fix the safety recalls. Service writer indicated they COULD NOT notify me when parts were available. I was to continuously call them for follow up as to when the car could be fixed. I continue to use the vehicle in spite of the safety defects as I can not afford another transportation method. Please help me get my Explorer fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The driver side Keyless door entry pillar has come off on the highway and hit something. The keyless door entry panel came off in 2023 and Koons Ford of Annapolis charged me $ 523.00 to fix the panel. The panel has a small clip and double stick tape. Sorry, double stick tape is not going to hold up to weather variations throughout the year, wind speed and age. Terrible and dangerous design. You gave 2017 a Recall 25S53 for ford but NOT 2018
The horn on my vehicle activates (blows) when I turn the steering wheel to certain positions. I believe this to be a road hazard. Especially since I had to remove the horn relay to prevent the horn from blowing in traffic until I can get it repaired. Several other Ford vehicles have been recalled for this exact problem. Just to diagnose this problem at the Ford dealer is $170.00. Help!
The exterior A-pillar applique trim piece began detaching from the vehicle while driving. The part became loose and was hanging from the vehicle whilst in motion, at which point I safely pulled over and removed it to prevent it becoming a road hazard. The trim is now fully detached and available for inspection upon request. Upon checking Ford's official recall portal, the recall is confirmed as incomplete against this vehicle with the status "remedy not yet available." Ford's own recall notice stated parts were anticipated in the latter half of 2024 — it is now June 2026 and parts remain unavailable, representing an 18-month overrun on Ford's own published commitment. No warning was given prior to the trim becoming loose. No crash, fire or injury occurred. I am requesting this be logged as an active safety incident rather than a routine pending recall, and that NHTSA apply pressure on Ford to prioritize parts availability for owners whose trim has already physically detached while driving.
The transmission completely failed without any warning lights or any other audible or visible signs of failure. This left my stranded on the side of the road. The local dealership has told me that I do have to replace the transmission. I have since called Ford Manufacturing's customer service department who told me there are no programs available to help assist with the cost of the transmission repair. There were no lamps, messages, sounds, smells, or visual cues.
Total engine failure in the Ford Explorer XLT 2.3L ecoboost.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .