2022 Ford F-150 Hybrid Problems

Driving along I-15 in vegas. Ambient temp was 112 degrees F. Engine stopped, check engine light came on and a 'stop safely' indicator appeared. Had to have the truck towed from the interstate to a Ford dealership.

I am reporting a safety-related transmission problem I experienced with my 2022 Ford F-150 equipped with the 10R80 automatic transmission. While driving normally, the transmission FAILS TO ENGAGE AT SLOW SPEEDS, THROTTLE WILL NOT RESPOND FOR UP TO 8 SECONDS This creates a potentially dangerous situation because the truck did not respond as expected when I needed predictable acceleration or propulsion. I believe this incident may be related to the known 10R80 CDF clutch-cylinder/sleeve problem. Ford technical information identifies axial movement of the CDF sleeve that can cause hydraulic-circuit leaks and harsh or delayed engagement and shifting. This condition can result in slipping, RPM flares, delayed engagement, unexpected gear changes, harsh downshifts, lurching, or loss of propulsion. This is a safety concern, not merely a transmission quality or reliability issue. Unexpected loss of propulsion or unpredictable shifting while merging, accelerating into traffic, crossing an intersection, turning, or traveling at highway speed can create a collision hazard. Because I personally experienced this unexpected transmission event, I request that NHTSA investigate the 10R80 CDF clutch-cylinder/sleeve condition in Ford F-150s. Please review Ford warranty claims, dealer repair records, transmission replacements, consumer complaints, and field-failure data to determine whether this is a safety defect requiring a recall. I believe owners should not have to wait for a potentially dangerous transmission failure before this known condition is addressed.

Driving along I-15 in vegas. Ambient temp was 112 degrees F. Engine stopped, check engine light came on and a 'stop safely' indicator appeared. Had to have the truck towed from the interstate to a Ford dealership.

Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.

Recall # 23V896 was sent to me on January 2024 and 14 months later still no parts available for the repair. Risk are the vehicle may roll in park and lose power while driving. I have already had one of the bolts break and it was replaced with a new defective bolt because replacements ( non - defective ) bolts were not yet available. Why is this taking over a year to resolve?

NHTSA states to file a complaint if there has been no remedy in reference to a safety recall in a timely manner. As of to date there is still an open recall on my truck and Ford has stated the recall is incomplete due to no remedy yet available. This recall has been in place since 12/22/23. My truck did have a broken hub bolt and I believe the dealership replaced the passenger rear axle hub. The dealership told me that this is only a temporary repair until Ford comes up with a remedy.

Highway Incident: While traveling at highway speeds, a sudden evasive braking maneuver caused the truck to drop power. Upon attempting to re-accelerate, the throttle pedal went to the floor with zero response, and the vehicle continued to decelerate on an active highway. Multiple trailing vehicles had to make emergency maneuvers to swerve around the decelerating truck to avoid a high-speed, rear-end collision. Subsequent Incidents: The vehicle repeatedly forces an uncommanded speed limit of 11 mph while attempting to accelerate from a complete stop or merge from stop signs. This severe lack of predictable acceleration creates an immediate risk of being T-boned or rear-ended by cross-traffic, making the vehicle entirely unsafe to operate in normal traffic conditions. An authorized Ford dealership has confirmed the underlying failure of the hybrid system. They kept the vehicle for approximately one month to replace the entire hybrid drive unit. Following that repair, the vehicle was returned to the dealer a second time, where technicians confirmed a software communication failure between the electric and gas systems, attempting to resolve it by flashing/reprogramming the ECU. The vehicle’s hybrid system and software have been extensively inspected and worked on by manufacturer-certified technicians at an authorized Ford dealership. It has not been inspected by police or insurance, as no physical collision has occurred yet. No warning lamps or messages.

Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.

Driving along I-15 in vegas. Ambient temp was 112 degrees F. Engine stopped, check engine light came on and a 'stop safely' indicator appeared. Had to have the truck towed from the interstate to a Ford dealership.

In the second year of ownership I noticed that occasionally I would get no throttle response from the gas pedal when trying to accelerate. After several occurrences I began to pay close attention as to when this was occurring. I found that this occurs mostly, not exclusively, when I am slowing the vehicle to a near stop, not a full stop and then accelerating to continue, like slowing to round a corner on a green light and getting into traffic. For example, I was exiting a Home Depot parking lot, the driveway exits to the roadway. As I approached the driveway to enter the roadway I slowed, preparing to stop. Seeing no traffic on the roadway I then pushed the accelerator to enter the roadway. The pedal was dead, I got absolutely no acceleration. I pushed the pedal down slowly, nothing. I pushed the pedal to the floor, nothing. The truck rolled out onto the road, I coasted to the side of the road. Had there been traffic I'd have been hit. This has happened 20 times in two years and 80K miles. The most recent event was this week with my wife present, very scary, dead pedal, not throttle response. If you research "Dead Pedal" on GOOGLE, you will get the following response: The "dead pedal" in the Ford F-150 PowerBoost—a dangerous lag or total loss of throttle response—is a widely reported issue, particularly when accelerating from low speeds, turning, or right after starting. [1, 2, 3] The cause can range from a software glitch to transmission issues or failing sensors. Ford said there was a TSB, however the work performed had no effect on the dead pedal on my truck. Invoice attached from March 2026, it just occurred again this week. I am going to trade the vehicle in but I doubt that Ford will disclose this flaw to the next buyer, it will be their's to discover, hopefully not by "accident". I am going to trade this vehicle in and I'm sure the new buyer will have no idea of this potentially deadly flaw.

My F150 will, on occasion, not accelerate when I am going slow and making a right turn. There are no fault lights, just the engine does nothing when I press the gas pedal. I coast to the intersection, apply the breaks, start the right turn, then press the accelerator to speed up. For about 6 seconds nothing happens (regardless of how hard I press the pedal), then the engine engages and the truck accelerates. I have mentioned this to my dealer several times, but they just keep explaining that they have not heard of the issue and they cannot replicate. I fear this may cause a serious accident if not resolved.

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure.

The contact owns a 2022 Ford F-150. The contact stated that the front driver’s side headlamp failed to illuminate as needed. The contact stated that the dealer had previously replaced the passenger’s side headlamp. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 40,000.

The vertical portion of the DRL stopped working. Looking online it looks like the LED bulb melts the light housing covering up the LED. I see many reports of this problem on forums and some have the vertical and horizontal strips do this so they lose DRL on that side of the truck.

Was stopped behind a car in line in the parking lot. The truck was in drive with the auto hold brake feature enabled. The auto hold disengaged and the car rolled forward rear ending the car in front of me. Collision alert didn't sound as expected. A similar recall came out August 6 for 2025 F150s.

When at a signal light with the brake pushed, we are experiencing an issue where the whole vehicle will unexpectedly lurch forward as if hit from behind after coming to a stop. This could possibly result in the truck hitting the vehicle in front of you if you are in tight traffic. Our local dealer inspected but could not find a solution.

The moonroof leaks causing water to spill into the cabin thru the headliner flowing onto the dash and coming into contact with electrical equipment dome lights infotainment system and could cause a potential issue with water and electrical system!!!

The contact owns a 2022 Ford F-150. The contact received notification of NHTSA Campaign Number: 25V315000 (Back Over Prevention); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that there was a chirping noise coming from underneath the chassis of the vehicle. The vehicle was taken to the dealer, who was unable to determine the cause of the failure. The vehicle was not repaired. The dealer confirmed that parts for the recall repair were not yet available. The manufacturer was made aware of the chirping issue and opened a case. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 6,795. VIN tool confirms parts not available.

The contact owns a 2022 Ford F-150. The contact stated while operating the vehicle, the air conditioner blower intermittently malfunctioned and would not blow air through the air vents. During the failure the front windshield could not be defogged or defrosted, creating a visibility hazard for the driver. The vehicle was taken to the local dealer on several occasions, but no failure was found. The vehicle was not repaired. The contact stated that a TSB was issued for the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 3,000.

Ford is non-responsive in fixing 3 recalls for my vehicle. I have been attempting to get a repair scheduled for over 6 months and keep getting told I will eventually get a call.

Injury caused when power tailgate failed to slowly lower upon release. Upon release, the tailgate fell open instead of slowly opening as normal (it is a power tailgate). The force of the falling tailgate twisted my wrist and the tailgate hit my arm as I was unprepared for the tailgate to fail and quickly fall. The tailgate operated normally immediately after this incident.

Rear passenger door latch failed and actually flew open in the middle of intersection while door was locked! Entered intersection from a full stop. Shut door repeatedly when we entered the truck. Seemed to have trouble shutting completely. Needed a couple tries get closed. Thankfully my kids had their seatbelts on! I have never heard of this kind of thing happening with today’s safety standards.

the blue cruise hands free driving feature does not work and has guided the vehicle off of the road. It also asks the driver to take the steering wheel, but will not register that has happened without a very hard pull on the wheel, which pulls the vehicle into other lanes of traffic. this is a very dangerous situation.

Brand New vehicle with 1000 miles on ODO, steering wheel almost completely locked up while driving and narrowly missed a head on collision. Dealership says steering gear assembly is faulty. Vehicle now inoperable and unsafe to drive

According to the dealer, Covert Ford in Austin, TX. A bolt on the rear axle holding the brakes to the rear axle is brittle and prone to failure. This bolt has sheared on my truck with just 10, 739.9 miles on it. The dealer says they cannot release the truck as the rear axle is damaged and the truck is un-driveable. The parts are not currently available to address the issue.

The truck was involved in a major crash, but none of the airs deployed. The accident took place on 1/29/2025. A shed not tied down blew off a trailer into my truck.