2006 Ford F-150 Visibility Problems

Around the 1st of February 2026 the weather had turned cold around 6 degrees Fahrenheit and I had just had my vehicle inspected in January so I know everything was fine then. My wife and I had driven to her office about 2 miles from our home and I of course had the heat on and defrost on. We went into the office to clean because that a weekly job for us usually under an hour. When we came out my windshield was cracked on the passenger side starting at the bottom going straight up about 8” long. The weather stayed cold and a few days later it cracked more and then more and then more. It’s moving over towards the drivers side horizontally about eye level. There is no rock strike where the crack started, it seems to me that when heat was applied to the windshield something expanded or contracted or flexed while we were inside the office because it was cracked when we came out to leave. I haven’t taken it to a Ford dealership to have it looked at or filed an insurance claim. It’s been about two months now I need to get it fixed before the whole windshield collapses into my lap. I realize the safety issue with a cracked windshield and it could cause me and others on the road to get hurt. I’ve only driven it to doctors appointments and to pick up medication at the store a mile away. I’ve never had a vehicle that has had the windshield crack due to clod weather when it was heated up and then cooled back down. Either the glass was manufactured incorrectly or it was installed incorrectly or the framing expanded or contracted causing it to bind the glass. If you could please look into this for me it would be greatly appreciated.

NHTSA ID

11727945

Incident

Feb 1, 2026

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER WINDOWS WERE LEAKING DURING INCLEMENT WEATHER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

NHTSA ID

10811724

Incident

Dec 22, 2015

Mileage

110,000 mi

THE DRIVER'S SIDE WINDOW REGULATOR ON MY 2006 FORD F150 HAS BROKEN THREE TIMES, I WAS ABLE TO GET TWO REPLACED UNDER WARRANTY, BUT THE THIRD TIME HAPPENED THIS LAST MONTH, I AM REPLACING IT TODAY. I BELIEVE FROM MY EXPERIENCE, AND FROM THOUSANDS OF FORUM ENTRIES CITING THE SAME THING, THAT FORD SHOULD RECALL THIS PART. THIS PART IS GOING TO COST ME APPROXIMATELY $400.00 TO REPAIR. *TR

NHTSA ID

10490934

Incident

May 1, 2010

Mileage

60,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-150 SUPER CREW CAB. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW REGULATOR FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 108,000.

NHTSA ID

10490310

Incident

Dec 24, 2012

Mileage

108,000 mi

THE PASSENGER IN MY VEHICLE TRIED ROLLING UP THE WINDOW WHILE AT A STOPLIGHT AND IT WOULD NOT GO UP. THE WINDOW SWITCH WILL WORK TO ROLL THE WINDOW DOWN BUT NOT TO ROLL IT UP. AFTER APPROXIMATELY 11 MONTHS THE DRIVERS SIDE WINDOW IS DOING THE SAME THING, WILL GO DOWN BUT NOT UP. WITH THE WINDOW STUCK IN THE DOWN POSITION, MY VEHICLE IS NOW EXPOSED TO THE ELEMENTS, RAIN PARTICULARLY, AND I FEAR THE WATER FROM THE RAIN IS GOING TO AFFECT THE REST OF MY DOOR SWITCHES, AND POSSIBLY RUIN THE LEATHER SEATS AND THE POWER FUNCTIONS FOR MY SEATS AS WELL. IT IS A DISTRACTION AND A HAZARD TO HAVE TO DRIVE WITH THE WINDOW DOWN CONSTANTLY. *TR

NHTSA ID

10460377

Incident

Jul 4, 2011

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT ALL FOUR WINDOW REGULATORS FAILED AND AS A RESULT, SHE WAS UNABLE TO OPEN OR CLOSE THE WINDOW. AFTER SEVERAL ATTEMPTS, THE WINDOW WOULD OPEN HOWEVER, IT WOULD FAIL TO CLOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE ALL FOUR WINDOW SWITCHES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 57,900 AND THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

NHTSA ID

10426963

Incident

Apr 1, 2011

Mileage

53,000 mi

BOTH DRIVER AND PASSENGER SIDE REVIEW MIRRORS ARE NOT STATIONARY. THEY ARE LOOSE AND PIVOT WHEN CLOSING A DOOR. DRIVER'S SIDE ALSO VIBRATES WHILE DRIVING MAKING IT DIFFICULT TO SEE OUT OF. THIS HAS BEEN REPORTED TO FORD DEALERSHIP WHERE THEY STATED "IT IS JUST A POOR DESIGN WITH A 'BREAK-AWAY FEATURE' THAT APPEARS TO HAVE BEEN 'OVERWORN' BY PREVIOUS OWNER, POSSIBLY DUE TO USE OF THINNER GASKETS IN MIRROR ASSEMBLY". WHEN ASKED ABOUT LONGEVITY AND ANTICIPATED LIFESPAN OF MIRRORS PRIOR TO FAILURE DUE TO WEAR, THEY STATED IT WAS NOT A WEAR-PART, HOWEVER, THEY ALSO DENIED IT BEING DEFECTIVE AND QUOTED ME $1200 FOR PARTS AND LABOR TO REPLACE. WARRANTY WOULD NOT COVER SINCE THE DEFECT WAS MECHANICAL AND NOT ELECTRICAL. THE DEALERSHIP ALSO STATED THE MIRRORS THAT WOULD BE INSTALLED WOULD BE EXACTLY THE SAME AND THERE WAS NO GUARANTEE THIS WOULD NOT HAPPEN AGAIN. I WAS UNABLE TO GET A CORRECTIVE ACTION OR REASONING WHY MY PARTICULAR MIRRORS ARE NOT SATISFACTORY, BUT I HAVE HEARD THIS IS NOT A NEW PROBLEM FOR THIS VEHICLE. LOOKING AT BOTH OF MY MIRRORS, IT IS OBVIOUS THEY SHOULD HAVE SOME SORT OF LOCKING MECHANISM (SNAP-IN-PLACE DESIGN) LIKE MOST VEHICLES. THERE HAS NOT BEEN ANY ACCIDENT INVOLVED WITH THIS SAFETY ISSUE. THIS IS TO DOCUMENT A KNOWN PROBLEM FOR AWARENESS PURPOSES AND TO POTENTIALLY RECEIVE A CORRECTIVE ACTION FOR MY FAULTY MIRRORS. THIS ISSUE HAS BEEN ON-GOING, AND AN ARBITRARY INCIDENT DATE HAS BEEN ASSIGNED. *TR

NHTSA ID

10324971

Incident

Mar 31, 2010

Mileage

55,000 mi

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). POWER WINDOWS FOR THE F-150 NOT WORKING PROPERLY. I HAVE MANY FRIENDS WHO OWN THIS TYPE OF TRUCK AND THEY ARE COMPLAINING OF THE SAME THING. AND THE AVERAGE FIX IT PRICE IS $500. [XXX] *TR

NHTSA ID

10315821

Incident

Mar 2, 2010

Mileage

55,000 mi

WINDOW FELL DOWN WHILE DRIVING ON THE FREEWAY. LOUD NOISE AS WINDOW FELL INSIDE THE DOOR I ALMOST CRASHED. VERY CLOSE CALL. I HAVE TALKED TO MANY OWNERS OF THIS SAME MODEL , DIFFERENT YEARS, ALL REPORT THE SAME PROBLEM. *TR

NHTSA ID

10293921

Incident

Nov 28, 2009

Mileage

30,800 mi

DRIVERS WINDOW CONTROL. *TR

NHTSA ID

10288730

Incident

Jun 7, 2007

Mileage

42,000 mi

FAILURE OF THE DRIVERS SIDE POWER WINDOW SWITCH. OVER A MATTER OF MONTHS, THE OPERATION OF THE SWITCH DETERIORATED. INITIALLY, WHEN THE DRIVERS DOOR WINDOW SWITCH WAS PRESSED TO CLOSE, THE WINDOW WOULD HESITATE. THIS HESITATION BECAME WORSE UNTIL THE WINDOW WOULD NOT CLOSE WITHOUT REPEATED ATTEMPTS TO CLOSE THE WINDOW. AT TIMES, THE WINDOW HAD TO REMAIN OPEN OVERNIGHT AND AT SOME POINT IN TIME, THE CLOSE BUTTON WOULD WORK AGAIN. THERE WAS NO CLEAR INDICATOR TO A CONDITION THAT WOULD INITIATE THIS PROBLEM, NOR WAS THERE ANY PROCEDURE TO RETURN THE SWITCH TO OPERATION (ASIDE FROM REPEATED ATTEMPTS TO CLOSE THE WINDOW. THE MATTER WAS BROUGHT TOP THE ATTENTION OF FORD DURING THE FULL WARRANTY PERIOD AND THE DRIVERS DOOR WINDOW SWITCH ASSEMBLY REPLACED. THIS REPAIR APPEARS TO HAVE RESOLVED THE PROBLEM (IT HAS NOT OCCURRED SINCE). THIS INCIDENT IS BEING REPORTED AFTER LEARNING OF NUMEROUS OTHERS WHO HAVE EXPERIENCED THIS FAILURE. THESE CONVERSATIONS WERE WITH OTHERS OF F-150 AND OTHER FORD VEHICLES OF THE 2005-2006 ERA. A HIGH PERCENTAGE HAVE EXPERIENCED THIS PROBLEM. IF THE FAILURE OCCURRED UNDER THE 3YR/36,000 MILE WARRANTY, SWITCHES WERE NORMALLY REPLACED WITH NO COST TO THE VEHICLE OWNER. HOWEVER, M LARGE PORTION OF PEOPLE HAVE EXPERIENCED THIS CONDITION SHORTLY BEYOND THE WARRANTY PERIOD AND HAVE HAD TO LIVE WITH THE DEFECTIVE SWITCH OR PAY FOR REPLACEMENT. THE LARGE NUMBER OF PEOPLE WHO HAVE EXPERIENCED THIS FAILURE IS INDICATIVE OF A DEFECT IN THE SWITCH ASSEMBLY. *TR

NHTSA ID

10285181

Incident

Aug 10, 2009

Mileage

32,000 mi

1. MY TRUCK WAS SITTING IN THE DRIVEWAY NOT BEING DRIVEN OR ANYTHING AND THE RIGHT REAR PASSENGER WINDOW FELL INTO THE DOOR. 2. IF THE WEATHER HAD NOT BEEN SO NICE MY TRUCK WOULD BE FULL OF WATER OR SNOW. 3. I PURCHASED THE EXTENDED WARRANTY SO IT IS GETTING REPLACED, BUT I HAVE READ ABOUT THIS FAILURE AND AM PLANNING ON OWNING THIS TRUCK FOR LONG AFTER THE WARRANTY IS OVER WITH. IT SOUNDS LIKE EVEN IF THE PART IS FIXED THAT IT WILL FAIL AGAIN AND WILL CONTINUE TO FAIL UNTIL THE PART IS REPLACED WITH A STRONGER MORE SUITABLE PART THAT WILL STAND UP TO THE FORCES INVOLVED FOR THE LIFE OF THE VEHICLE INSTEAD OF JUST ABOUT 40K MILES AND UNTIL IT IS OUT OF WARRANTY. THIS PART IS CLOSE TO 400 BUCKS INSTALLED AND THE TRUCK HAS 4 WINDOWS. THAT IS A POTENTIAL OF 1600 BUCKS EVERY 40K MILES. I WOULD APPRECIATE A RECALL OR A SERVICE BULLETIN TO MAKE SURE THAT ALL OF US F150 OWNERS ARE PROTECTED AGAINST ALL THIS EXCESS COST. *TR

NHTSA ID

10247720

Incident

Nov 4, 2008

Mileage

40,000 mi

DRIVERS SIDE WINDOW WILL NOT GO UP ABOUT 75% OF THE TIME. I TOOK THE TRUCK TO A FORD DEALER TO BE CHECKED AND THEY SAID THE ELECTRICAL BOX IN THE DOOR NEEDED TO BE REPLACED AND IT WAS NOT UNDER WARRANTY. WHEN THE GENTLEMAN WENT TO CHECK THE PRICE FOR THE PART HE SAID HE COULD NOT ORDER IT BECAUSE THEY WERE OUT OF STOCK DUE TO THE HIGH DEMAND FOR THE PART. HE ALSO STATED THAT SINCE THE PART WAS UNAVAILABLE IT LEAD HIM TO BELIEVE THERE IS A BIG PROBLEM WITH WINDOWS RIGHT NOW. PERSONALLY, I KNOW THERE IS A PROBLEM BECAUSE I KNOW THREE OTHER PEOPLE WHO OWN FORDS AND THEY HAVE PROBLEMS TOO. MY MOTHER-IN-LAW HAS A FORD EXPLORER WHICH HAD THE SAME PROBLEM TWO YEARS AGO, THANKFULLY SHE WAS ABLE TO GET IT FIXED THROUGH A RECALL. WE FEEL THAT A VEHICLE THAT IS TWO YEARS OLD SHOULD NOT BE HAVING SUCH A PROBLEM. PLEASE INVESTIGATE THE PROBLEM FOR ALL FORD VEHICLES, NOT JUST THE F150, AND YOU WILL SEE A HUGE PROBLEM. WE FEEL IT IS TIME FOR A RECALL. *TR

NHTSA ID

10240212

Incident

Jan 15, 2008

Mileage

35,000 mi

TL*THE CONTACT OWNS A 2006 FORD F150 EXTENDED CAB. WHILE THE VEHICLE WAS PARKED, A STRESS CRACK DEVELOPED IN THE DRIVER'S SIDE WINDOW. THE DEALER STATED THAT NOTHING COULD BE DONE. THERE WAS NO CRACK ON THE INSIDE OR OUTSIDE TO INDICATE THAT SOMETHING HAPPENED TO THE WINDOW. THE CONTACT HAS PICTURES AVAILABLE. THE FAILURE MILEAGE WAS 40,000. UPDATED 09/10/08 *BF UPDATED 09/19/08. *JB

NHTSA ID

10233739

Incident

Jun 23, 2008

Mileage

40,000 mi

DRIVER''S SIDE EXTERIOR MIRROR VIBRATES WHEN GOING DOWN THE ROAD. THIS DISTRACTS THE DRIVER''S VISION AND COULD CAUSE AN ACCIDENT. IT GIVES YOU THE FALSE IMPRESSION THAT THERE IS A VEHICLE MOVING INTO YOUR BLIND SPOT. THIS HAS BEEN REPORTED TO THE DEALER THREE TIMES AND HAS NOT BEEN CORRECTED TO DATE.

NHTSA ID

10191622

Incident

Apr 10, 2007

Mileage

8,000 mi

MY 2006 FORD F-150 SUPER CAB PICKUP, 2X4, V-8 ENGINE, HAS A MAJOR PROBLEM WITH THE OUTSIDE MIRRORS FALLING TOWARDS THE GROUND CAUSING ME NOT TO BE ABLE TO PICK UP MOVING TRAFFIC WHILE DRIVING DOWN THE HIGHWAY...I HAVE TAKEN THE TRUCK TO THREE DIFFERENT FORD DEALERSHIPS AND THEY REFUSE TO GIVE ME A TRADE-IN ON A TRUCK WITH POWER MIRRORS...I HAVE HAD (3) NEW SETS OF MIRRORS INSTALLED ON THIS TRUCK ALREADY SINCE I PURCHASED THE TRUCK IN JANUARY 2006....I HAVE HAD A RESTRICTION PUT ON MY DRIVERS LICENSE STATING THAT I MUST HAVE A RIGHT HAND MIRROR ON ALL VEHICLES I DRIVE DUE TO HAVING AMBLYOPIA IN MY RIGHT EYE....CAN'T SEE ANYTHING WHEN MY MIRRORS POINT DOWN TOWARDS THE GROUND...SHOULDN'T' HAVE TO TAKE A BEATING ON THE TRADE-IN SINCE I BOUGHT THE TRUCK IN GOOD FAITH BELIEVING THAT FORD WOULD STAND BEHIND ITS WARRANTY...THEY ARE NOT REIMBURSING ME FOR THE TIME OR GAS TO TAKE THE TRUCK IN FOR REPAIRS AND I BELIEVE THREE SETS OF MIRRORS ARE ENOUGH....I WANT THIS TO BE DOCUMENTED IN CASE THAT I HAVE A MINOR OR MAJOR ACCIDENT THAT IS INVOLVING A LIFE BECAUSE I COULDN'T SEE OUT OF MY MIRROR WHILE CHANGING A LANE..... *NM

NHTSA ID

10174682

Incident

Nov 29, 2006

Mileage

3,550 mi

NEW 2006 FORD F150 EXTENDED CAB, LESS THAN 2500 MILES, DRIVING IN MODERATE TO HEAVY RAIN WHEN WINDSHIELD WIPERS COMPLETELY FAILED. FORTUNATELY THE DRIVER, MY SON, WAS ABLE TO IMMEDIATELY CROSS 3 LANES OF TRAFFIC AND PULL OFF THE ROAD WITHOUT ACCIDENT OR INJURY. THIS IS A SERIOUS DEFECT / FAILURE THAT COULD HAVE RESULTED IN SEVERE INJURY OR DEATH. WIPER MOTOR WAS REPLACED AT A FORD DEALERSHIP THE NEXT DAY.

NHTSA ID

10170851

Incident

Oct 12, 2006

Mileage

2,475 mi

DT*: THE CONTACT STATED THE SIDE VIEW MIRROR GLASS ON BOTH MIRRORS DID NOT STAY STATIONARY WHILE DRIVING OVER ROUGH ROADS AT ANY SPEED. THE MIRRORS POINTED DOWNWARDS, OBSCURING THE VIEW OF THE DRIVER. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THE MIRRORS WERE REPLACED. THE PROBLEMS PERSISTED, SO THE VEHICLE WAS TAKEN TO A SECOND SERVICE DEALER, WHO INFORMED THE CONTACT THAT A SECOND REPLACEMENT WOULD DO NO GOOD. THE MANUFACTURER WAS NOTIFIED. UPDATED 10/31/2006 - THE MANUFACTURER REFUSED ANY ASSISTANCE. *NM

NHTSA ID

10168825

Incident

Sep 14, 2006

Mileage

13,500 mi

THE TRUCK WAS DELIVERED ON 8/12 IN LATE EVENING WHEN IT WAS COOL, ON THE NEXT DAY IT WAS DISCOVERED THAT THE AIR CONDITIONING DID NOT COOL PROPERLY. IT SHOWED NO COLDER THAN 60 DEGREES ON MAX AIR IN THE LEFT MIDDLE VENT WITH ALL OTHERS CLOSED AND WITH 95 DEGREES OUTSIDE TEMPERATURE. WHEN RETURNED TO THE DEALER ON THE NEXT MORNING, THE SERVICE ORDER SHOWED "NO TROUBLE FOUND". THEY DO HOWEVER SHOW THAT REFRIGERANT(R134) WAS ADDED WHICH IS ODD AS THERE WAS NO TROUBLE FOUND. LATER IT WAS ADMITTED TO ME THAT THERE IS A PROBLEM WITH THE AIR CONDITIONING IN THESE TRUCKS, PARTICULARLY THE RECIRCULATION SWITCH ON THE AIR CONTROL PANEL IN THE TRUCK WHICH DOES NOT STAY ENGAGED. IT SEEMS THAT YOU MUST RE ENGAGE THE SWITCH EACH TIME THE TRUCK IS STARTED ALTHOUGH THIS DOES NOT ALWAYS WORK. THIS IS DANGEROUS IF YOU ARE UNFAMILIAR WITH THE TRUCK, AS OUTSIDE AIR IS BEING BROUGHT IN AT ALL TIMES THUS KEEPING THE DEFROST FROM WORKING PROPERLY AS WELL. FOUL AIR OR ROAD FUMES COMING INTO THE TRUCK TO AN UN SUSPECTING DRIVER. I WAS TOLD THAT FORD IS AWARE THAT IT IS A PROBLEM, BUT HAS TO THIS DATE OFFERED NO SOLUTION. I BELIEVE BASED ON THE RESPONSE FROM FORD, THAT THIS HAS BEEN A PROBLEM THEY ARE AWARE OF ON 2006 TRUCKS AND THE PUBLIC IS UN AWARE. *NM

NHTSA ID

10168732

Incident

Aug 13, 2006

Mileage

517 mi