2008 Ford F-150 Problems

See attached document for complaint.

My 5.4 v8 triton motor timing came phasers are bad the truck runs fine when cold when it gets warmer up it rattles and shakes and stalls air bag light stays on I had to pull the fuse bc it beeps and warning light so it's not active

The truck has a body frame that was cracked in several spots and welded back together in more then 5 different spots and the welding job is very poor. The truck has a power steering line leak, cvs axle leaks and a exhaust manifold leak. The dealership fixed upper ball joints when we agreed on lower and upper in the front. They added a exhaust but did not do the job correctly with completing the job and the welding of it. Ive made a complaint with the loan company and i as well have talked to the owner of the dealership and he fights that none of those things are wrong with the truck and im lying but i have had a inspection done on the truck. When i got the truck i looked it over and so did my brother i pointed the issues of what needed fixed that i could see and that was not done. I then started having issues with the truck and took it to a mechaninc and had an inspection done

CAM PHASERS WENT OUT TWICE BEFORE 150K. STEERING SHAFT AND STEERING FLUID LINES RUST OUT AROUND 150K.

The truck has a body frame that was cracked in several spots and welded back together in more then 5 different spots and the welding job is very poor. The truck has a power steering line leak, cvs axle leaks and a exhaust manifold leak. The dealership fixed upper ball joints when we agreed on lower and upper in the front. They added a exhaust but did not do the job correctly with completing the job and the welding of it. Ive made a complaint with the loan company and i as well have talked to the owner of the dealership and he fights that none of those things are wrong with the truck and im lying but i have had a inspection done on the truck. When i got the truck i looked it over and so did my brother i pointed the issues of what needed fixed that i could see and that was not done. I then started having issues with the truck and took it to a mechaninc and had an inspection done

HAD CRUISE CONTROL SET WHILE DRIVING ALONG FREEWAY. NEEDED TO SLOW DOWN AND TAPPED BRAKE TO RELEASE CRUISE CONTROL. NOTHING HAPPENED. PRESSED BRAKE AGAIN TO SLOW DOWN AND ENGINE POWER INCREASED TO COINCIDE WITH CRUISE CONTROL SETTING. MANUALLY SHUT OFF CRUISE CONTROL AND IT DISABLED. CRUISE CONTROL CURRENTLY WILL NOT SHUT OFF BY UTILIZING BRAKE SYSTEM.

The contact owns a 2008 Ford F-150. The contact stated that after turning off the vehicle, the contact attempted to restart the vehicle and became aware that the gear shifter was not in park(P). The contact inspected the gear shift lever, and the gear shifter was in the park(P); however, the contact was unable to move the gear shift lever. The contact depressed the brake pedal, moved the gear shift lever, and was able to restart the vehicle. A mobile mechanic arrived at the residence and replaced the shifter cable, and the vehicle was repaired. The contact stated that on a separate occasion, while arriving at her sister's residence, the failure reoccurred. The shift indicator displayed that the vehicle was not in park(P). However, the gear shifter lever was in park(P). A neighbor stopped by and assisted the contact by going underneath the vehicle and manually shifting the gear. The vehicle was restarted and driven to the residence. The failure had progressively worsened, and the vehicle was no longer driven. The vehicle was parked at the residence. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 135,000.

Vehicle will not go into reverse. After research and reviews of this transmission in this year model, the reverse band is a known issue by Ford. Even the transmissions installed for replacement have bad reverse bands. There was a service advisory put out by ford but the advisory is no longer available. The reverse band is weak and the incorrect part was installed from factory.

My emergency brake doesn't work and light is on,and air bags did not deploy when I was hit from behind.

When stepping on brake peddle gos so far Dow foot hits accelerator pedal causing the truck to lunge forward as if accelerator stuck. Nearly caused accident, dealer said there was no fix to raise the brake pedal.

I experienced a loss in power while driving and not driving, as well as locking my keys in the vehicle once It would not unlock. The gear shifting knob stopped due to what seemed like resistance an the damaged caused by sales man to the top plunger cap just after i paid. Recently the battery and the alternator are not working and when power is ran through the vehicle, an obvious sound of a live cable buzzing in the rear cab exterior light and seemed to be spliced in a n unsafe way.

Vehicle caught on fire from the engine compartment while driving. Total loss, Fire Department responded to the scene. Two persons on board of the vehicle had to escape the fire, pulled over and jumped out.

My 5.4 v8 triton motor timing came phasers are bad the truck runs fine when cold when it gets warmer up it rattles and shakes and stalls air bag light stays on I had to pull the fuse bc it beeps and warning light so it's not active

My emergency brake doesn't work and light is on,and air bags did not deploy when I was hit from behind.

PLASTIC TIMING GUIDES ARE RIPPED FROM MOUNTING LOCATION BY TIMING CHAINS AND DROP INTO THE OIL SYSTEM, USUALLY CAUSING LOSS OF OIL PRESSURE, CONTAMINATED OIL, TRASH-FILLED MOTOR, AND ACCELERATED WEAR OF THE TIMING CHAINS, RESULTING IN ENGINE DAMAGE. USUALLY THE GUIDES BREAK OFF AT OR BEFORE 100,000 MILES AND THE CHAINS NEED REPLACING BETWEEN 120,000 AND 200,000 MILES, DEPENDING ON HOW THE TRUCK IS DRIVEN. METAL REPLACEMENT GUIDES ARE AVAILABLE AT MOST SHOPS AND ONLINE PARTS STORES.PRICES RANGE BETWEEN $10 AND $40. OCCURS IN 4.6L AND 5.4L V8 ENGINES.

TL* THE CONTACT OWNS A 2008 FORD F-150. WHILE THE CONTACT WAS STOPPED AT A TRAFFIC LIGHT, HE SMELLED EXHAUST FUMES INSIDE THE CABIN OF THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO CAUSEWAY FORD LINCOLN (LOCATED AT 375 NJ-72, STAFFORD TOWNSHIP, NJ 08050, (609) 597-8083), WHERE IT WAS DIAGNOSED THAT BOTH EXHAUST MANIFOLDS, GASKET, AND HARDWARE BOLTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 70,000. *CW CONSUMER STATED HE HAS SOLD THE VEHICLE.*JB

The truck has a body frame that was cracked in several spots and welded back together in more then 5 different spots and the welding job is very poor. The truck has a power steering line leak, cvs axle leaks and a exhaust manifold leak. The dealership fixed upper ball joints when we agreed on lower and upper in the front. They added a exhaust but did not do the job correctly with completing the job and the welding of it. Ive made a complaint with the loan company and i as well have talked to the owner of the dealership and he fights that none of those things are wrong with the truck and im lying but i have had a inspection done on the truck. When i got the truck i looked it over and so did my brother i pointed the issues of what needed fixed that i could see and that was not done. I then started having issues with the truck and took it to a mechaninc and had an inspection done

Door fails to close and latch shut. Several other recalls on this issue but my vin was not included. I am currently not able to drive the car with out the door falling open Related recalls provided to me by Ford 17s33 19n06 18n03

The mirrors are not convex, the do not meet safety standards for viewable angles. Impossible to use to back up.

The defroster does not blow. There is an issue with the actuator and although the air can be heard blowing, the air is restricted at the firewall. Per the dealership, it is a known issue. I can't drive my truck in winter because it won't defrost. I live in Fargo, ND.

Walmart Auto Center installed the incorrect tire size 255/70R17 on my factory setup with factory wheels. Westlake SU318 All Season 255/70R17 112T SUV/crossover tires were installed in place of the correct size 245/70R17 tires. Walmart is refusing to fix my truck and I had the brake lines blow out 3 weeks after installing the tires. I am a current threat to the public and myself driving with these incorrect tires. Walmart will not replace the tires. Walmart is attempting to coverup this by not providing the information to carfax. I have submitted a carfax update case#XXX. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT THE SPARE WHEEL WAS RUSTED AND TRANSMISSION FLUID WAS LEAKING. IN ADDITION, THE TIRE PRESSURE INDICATOR WAS ILLUMINATED. THE CONTACT CALLED CHAPMAN FORD (1485 MANHEIM PIKE FRNT, LANCASTER, PA 17601) WHERE A SERVICE APPOINTMENT WAS SCHEDULED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 79,542. *TT *JS

"TAKATA RECALL" I WAS TAKING MY GRANDCHILDREN HOME ON A DIRT ROAD AND HIT A DEER WHICH SPUN ME AROUND AND SMASHED INTO A BIG TREE HEAD ON.THE CRASH WAS SO HARD THAT THE FRONT BUMPER WAS CRUSHED AGAINST THE MOTOR BLOCK,DECLARED TOTALLED FROM MY INSURANCE COMPANY.MYSELF,I HAD A WHIPLASH,MY GREAT NIECE (PASSENGER) BROKE HER WRIST,MY GRANDSON HAS LEG PROBLEMS AND MY GRANDDAUGHTER HIT HER HEAD REAL HARD!MR. (XXXXX) THE OWNER WAS DRIVING!!!!!!! PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

2008 FORD F 150. CONSUMER WRITES IN REGARDS TO NON OPERATIONAL MIDDLE PASSENGER SEATBELT. CONSUMER IS ALSO SEEKING A REFUND FOR VEHICLE. *LD THE CONSUMER STATED THE DEALER KNOWINGLY SOLD THE VEHICLE WITH DEFECTIVE SEAT BELTS. *JS

TOOK VEHICLE IN FOR ENGINE REPAIR. TECHNICIAN DISCOVERED BOTH FRONT COIL SPRINGS BROKEN. ALMOST NEW TIRES WORN BALD ON THE INNER EDGE. ONLINE RESEARCH INDICATES THIS HAS BEEN A MAJOR COMMON PROBLEM ON THE 04-08 F-150, WITH NO RELIEF FROM FORD.

LEFT FRONT COIL SPRING BROKEN . FOUND BROKEN DURING ALIGNMENT INSPECTION FEBRUARY 12,2019 . ODOMETER 73750 .

STOP AT GAS STATION AND TURNED TRUCK OFF AND ENTERED STORE. RETURNED TO TRUCK AND CRANKED. PUT IN DRIVE DROVE AROUND STATION TO ENTRANCE OF MAIN HIGHWAY. ABOUT 20 YARDS TO STOP SIGN TO HIGHWAY I WAS GOING ABOUT 5 MPH AND I LIFTED RIGHT FOOT OFF OF GAS PEDAL TO APPLY BRAKE. THE TRUCK SLOWLY STARTED TO SPEED UP. I APPLIED THE BRAKE WITH ONE FOOT AND THE TRUCK STARTED TO APPLY MORE GAS UNTIL I HAD BOTH FEET ON THE BRAKE AND PUSHING AS HARD AS POSSIBLE AND IT WAS PUSHING ME TOWARD THE HIGHWAY IN FRONT OF A ONCOMING CAR. THE BACK TIRES STARTED TO SPIN. I PUT THE TRUCK IN NEUTRAL THE ENGINE REVVED TO AROUND 6-1/2 RPM BEFORE I COULD TURN THE SWITCH OFF. I SIT THERE FOR ABOUT 30 SECONDS WITH ENGINE OFF THEN RESTARTED THE TRUCK AND IT WAS OK.. I HAVE AN APPOINTMENT ON 7/18/2011 WITH A FORD DEALERSHIP TO HAVE THE TRUCK LOOKED AT. I HAVE LOOKED OVER YOUR WEB SITE AND THERE HAS BEEN MANY OTHER F 150 TRUCKS WITH THE SAME PROBLEM IT SEEMS AS MINE. I THINK YOU NEED TO THINK ABOUT TALKING TO FORD MOTOR COMPANY ABOUT A POSSIBLE RECALL. I HAVE A 17 YEAR OLD DAUGHTER THAT SOMETIMES DRIVES MY TRUCK AND THAT WAS THE FIRST THING THAT I THOUGHT OF. WHAT IF SHE HAD BEEN DRIVING WHEN THIS HAPPENED, WOULD SHE HAVE REACTED AS FAST AS I DID BEFORE BEING PUSHED OUT IN FRONT OF THE ONCOMING CAR.. JUST SOMETHING TO THINK ABOUT.. *KB

I WAS TRAVELING LESS THAN 10 MPH WHILE DRIVING IN THE PARKING DECK AT WORK WHEN MY 2008 F150 FORD TRUCK SUDDENLY ACCELERATED !! I PUT MY FOOT ON THE BRAKES AND THE TRUCK WOULD NOT STOP!! JUST AS I WAS IN THE PROCESS OF PUTTING THE TRUCK OUT OF GEAR - IT RAN INTO THE VEHICLE IN FRONT OF ME. LUCKILY IT DID NOT DAMAGE THE OTHER VEHICLE ( WHICH WAS A BIG SUV ) BUT IT DID $2,000.00 WORTH OF DAMAGE TO MY TRUCK!! I TOOK THE TRUCK INTO THE FORD DEALERSHIP FOR DIAGNOSIS AND REPAIR. THEY SAID THEY COULD NOT GET IT TO DUPLICATE THE PROBLEM. I CONTACTED FORD'S COMPLAINT AND CUSTOMER SERVICE DEPARTMENTS.THEY DENIED MY REQUEST FOR ASSISTANCE IN THIS MATTER AS THEY CLAIM THEIR ANALYSIS DOES NOT INDICATE ANY EVIDENCE OF A MANUFACTURING OR DESIGN DEFECT. I WENT TO THE FORD DEALERSHIP WHERE I PURCHASED MY TRUCK TO TRY TO TRADE IN MY TRUCK FOR ANOTHER VEHICLE. DESPITE THE FACT THAT I HAVE BOUGHT 7 FORD TRUCKS IN THE PAST - 6 OF THEM AT THIS PARTICULAR DEALERSHIP , THEY WERE NOT WILLING TO WORK WITH ME ON A DEAL FOR TRADING IN MY TRUCK. THEY TOLD ME THAT I HAD GOTTEN 47,000 MILES OUT OF MY TRUCK BEFORE THIS PROBLEM OCCURRED , AND THAT I COULD PROBABLY GET ANOTHER 47,000 MILES OUT OF IT BEFORE IT DOES IT AGAIN!!! THEN 28 DAYS AFTER THE FIRST OCCURRENCE - MY TRUCK DID IT AGAIN!!!! THIS TIME I WAS IN TRAFFIC IN THE PROCESS OF STOPPING MY TRUCK FOR A TRAFFIC LIGHT. I HAD JUST TAKEN MY FOOT OFF OF THE BRAKES ( MY FOOT WAS STILL RESTING ON TOP OF THE BRAKES ) AND I WAS COASTING TO A STOP. SUDDENLY THE TRUCK JUST SPEEDED UP OUT OF CONTROL !!! I APPLIED THE BRAKES , AND AGAIN THE TRUCK WOULD NOT STOP!!!! I QUICKLY THREW THE GEAR IN NEUTRAL AND TURNED OFF THE KEY. AS SOON AS I DID THIS, THE BRAKES SKIDDED ON AND MY TRUCK JUST BARELY STOPPED BEFORE HITTING THE CAR IN FRONT OF ME!! I AM IN CONSTANT FEAR OF THIS OCCURRING AGAIN!!! BOTH TIMES I HAVE BEEN DRIVING AT A VERY SLOW SPEED ( LESS THAN 10 MPH ) BUT WHAT IF IT HAPPENS WHEN I'M ON THE FREEWAY TRAVELING AT HIGH SPEEDS. THIS IS LIFE THREATENING. *TR

LOW TIRE PRESSURE WARNING LIGHT CAME ON EVEN AFTER GETTING AIR AT DISCOUNT TIRES. WHILE DRIVING ON HIGHWAY HAD A BLOWOUT. ONLY SIDE WALL CAME APART. FIRESTONE DESTINATION LE3 265/60R18 110T M+S

TL* THE CONTACT OWNS A 2008 FORD F-150 EQUIPPED WITH CAPITOL PRECISION TRAC II TIRES, SIZE: 255/70R16. WHILE DRIVING AT ANY SPEED, THE VEHICLE PULLED TO THE LEFT. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE RUBBER SEPARATED FROM THE INNER CORE OF THE TIRES. THE DEALER STATED THAT THERE WAS A RECALL, BUT IT EXPIRED. THE CONTACT STATED THAT THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS 8,000 AND THE VEHICLE FAILURE MILEAGE WAS 62,000.

THE INCIDENT TOOK PLACE ON AN EXIT ON INTERSTATE (I-610 LOOP SOUTH IN HOUSTON). MY SON CAME TO A STOP WHEN CAR IN FRONT STOPPED ABRUPTLY. THIS IS WHEN MY SON WAS REAR ENDED BY 2016 F-250 THAT WAS TOWING HORSE TRAILER. THIS PUSHED MY SON'S TRUCK INTO THE CAR IN FRONT. IMPACT COMPLETELY BUCKLED MY SON'S TRUCK BED AND DAMAGED THE FRONT AND THE INSIDE CABIN. BOTH THE FRONT SEATS BROKE (BACK RECLINING PORTION SNAPPED BACKWARD) PLUS NEITHER AIRBAGS INFLATED FROM THE IMPACT. SO MY QUESTION IS WHY WOULD THE FRONT SEATS SNAP BACKWARDS (IS IT DESIGN FLAW?) AND WHY DIDN'T THE AIRBAGS INFLATE FROM THE IMPACT TO THE CAR IN FRONT? FROM THE DAMAGE TO ALL THE VEHICLES INVOLVED YOU CAN SEE THAT IT WAS A VERY HARD IMPACT.

TL* THE CONTACT OWNS A 2008 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO ENTER THE VEHICLE, THE CONTACT HELD THE DOOR HANDLE TO STEP UP INTO THE VEHICLE HOWEVER, THE DOOR HANDLE DETACHED. THE CONTACT FELL AND HIT HIS HEAD ON THE DOOR AND THEN FELL ONTO THE NEIGHBORING VEHICLE. MEDICAL ATTENTION WAS NOT SOUGHT HOWEVER, THE CONTACT SUFFERED FROM HEADACHES. THE CONTACT CONTACTED RICHMOND FORD WEST (10751 W BROAD ST, GLEN ALLEN, VA 23060; (804) 273-9700) AND WAS INFORMED THAT THE HANDLE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 176,000.

I experienced a loss in power while driving and not driving, as well as locking my keys in the vehicle once It would not unlock. The gear shifting knob stopped due to what seemed like resistance an the damaged caused by sales man to the top plunger cap just after i paid. Recently the battery and the alternator are not working and when power is ran through the vehicle, an obvious sound of a live cable buzzing in the rear cab exterior light and seemed to be spliced in a n unsafe way.

THE INSTRUMENT CLUSTER ON MINE IS STARTING TO FAIL, THE GAUGES AREN'T ALWAYS ACCURATE, THE BRAKE LIGHT STAYS ON MOST OF THE TIME EVEN THOUGH THERE IS NO PROBLEM IN THE BRAKE SYSTEM THE PARKING BRAKE SENSOR IS GOOD ALREADY CHECKED IT, AND THE FLUID LEVEL IS FULL AND THE SENSOR IN THE MASTER CYLINDER IS GOOD. DUE TO THE CLUSTER MALFUNCTION ESPECIALLY AT NIGHT THE INTERIOR LIGHT WILL COME ON AND STAY ON WHILE DRIVING LEADING TO A GLARE ON THE WINDSHIELD AND SIDE WINDOWS WITCH MAKES SEEING WHERE YOUR GOING VERY DIFFICULT, AND ABOVE THE CLUSTER ON THE DASHBOARD IT BEGINS TO GET HOT WHILE DRIVING SEEMS TO BE A SAFETY ISSUE. WHILE THE TRUCK IS PARKED THE INTERIOR LIGHT WILL COME ON FOR NO REASON. I CHECKED THE SWITCH ITS NOT THAT AND FROM WHAT IVE GATHERED ITS THE INSTRUMENT CLUSTER AND THE CONNECTION ON IT, THE CLUSTERS SEEM TO BE A WEAK SPOT ON THESE TRUCKS IVE SEEN MULTIPLE TRUCKS WITH THIS PROBLEM

ANY SETTING ABOVE 60 DEGREES ON THE AIR CONDITIONER BLOWS HOT AIR NO MATTER WHAT THE TEMPERATURE IS OUTSIDE, OR WHETHER YOU ARE SET ON RECIRCULATING, ETC. *TR

WE BOUGHT THIS TRUCK BRAND NEW IN FEBRUARY 2008 AND THE AIR CONDITIONER DOES NOT BLOW COLD AT IDLE. IT WILL BLOW APPROXIMATELY 70 DEGREES OUT OF THE VENTS ON A 90 DEGREE DAY. I HAVE TAKEN IT TO 2 DIFFERENT DEALERS AND BOTH CHECKED AND TEST DROVE THE TRUCK, ONLY TO ADVISE "THERE IS NOTHING WRONG WITH IT" IT IS BLOWING COLD ENOUGH ACCORDING TO THEM ON MAX A/C GOING DOWN THE HIGHWAY, SO THEIR SUGGESTION WAS TO NOT CHANGE IT FROM MAX A/C. *TR