2020 Ford F-250 Sd Owner Complaints

The contact owns a 2020 Ford F-250 SD. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, while driving 40 MPH approximately two months later, the vehicle was running rough and stalled. The check engine warning light was illuminated. The contact pulled over to the side of the road. The vehicle was towed to a dealer, where it was diagnosed with a high-pressure fuel pump failure, causing the fuel system to become contaminated. The dealer determined that the fuel system needed to be replaced. The dealer submitted a diagnostic report to the manufacturer. The contact notified the manufacturer of the failure, and a case was filed. The vehicle was not repaired and was pending the manufacturer's decision regarding the coverage of the repair. The failure mileage was approximately 103,000.

NHTSA ID

11756201

Incident

Jul 15, 2026

Mileage

103,000 mi

DEF heater failure will cause increased emissions. The warning light flashes. I have seen details where there are issues with the wiring harness for the DEF heater.

NHTSA ID

11753244

Incident

Jun 1, 2026

10r140 paired with 6.7 powerstroke in a 2020 f250 build date 11/19 at the Kentucky plant. My truck specs and build date and location is in the timeframe of the planetary gear recall, ford has also issued tsb’s about the cdf bushing that should have been a recall because it is a design flaw on every 2020-2022 model truck. It’s not fair that we should have to pay for a tsb bc we don’t have warranty left. My truck has 84,000 miles but is out of the 5 years warranty period. Symptoms I am having with my transmission are: Harsh engaging to drive and reverse Flair shifts bad sometimes almost like it goes into neutral between changing gears Has shifted from 4th to 1st instead of 4th to 5th or 6th, then it started shifting normal right after. Had my factory 3250rpm limiter not been moved to 4500rpm the truck would have locked the rear wheels up and possible caused driveline damage or other damaged. Also had a car been behind me when this happened I would have been in a wreck because it slammed to a low speed and the car would have rear ended me. Slips in 4th and 7th gear the most but sometimes in other gears Bumps when it shifts a lot of the gears Sometimes shudders and shakes and will almost make like a pop noise Will clunk on downshift from 5-3 Sometimes clunks when upshifting 3-5 I have had the truck looked at by an independent diesel mechanic I use and he said there is a problem somewhere in the transmission, it’s either planetary gear or cdf bushing has moved or the drum itself has cracked. The component itself has not been inspected because the only was to inspect this is to tear the transmission down. The pan has been dropped and had a lot of metal material on the magnet. No codes on the dash but my mechanic said I had dtcs stored for the transmission. I have created a case claim with Ford trying to see if they will extend the recall for the known issue but I have had zero luck with them. I have videos of the issues but can’t upload them on here.

NHTSA ID

11752304

Incident

Apr 3, 2026

The contact owns a 2020 Ford F-250. The contact received notification for NHTSA Campaign Number: 22V256000 (Power Train); however, the recall repair could not be completed. The vehicle was taken to a dealer where it was diagnosed that a thrust washer was missing from the output planetary assembly and had disintegrated, contaminating the transmission case, transfer case, torque converter, cooling lines, and radiator. The missing washer caused the planetary gear to shift and damage the transmission case. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was 80,256.

NHTSA ID

11749392

Incident

May 27, 2026

Mileage

80,256 mi

Left rear seat belt buckle or system failed causing a fault in the Airbag/Restraint system. The fault initially happened in June of 2025 with about 50k miles on the vehicle. I took it to a dealer who told me the buckle was not available and the whole system needed to be replaced for over $1500. Vehicle seldom has anyone in the back seat but that is where my children sit. Looking at posts on the internet, this seems to be a common enough problem that this should be taken care of under recall or customer service warranty.

NHTSA ID

11743890

Incident

Jun 15, 2025

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number 24V957000 (Fuel System, Diesel); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that the vehicle had become inoperable due to a transmission failure. The contact associated the transmission failure with the recall; however, the dealer advised that the transmission repair would be at the owner's expense. The approximate failure mileage was 60,000.

NHTSA ID

11743767

Incident

Jun 25, 2025

Mileage

60,000 mi

The contact owns a 2020 FORD F-250. The contact received notification of NHTSA Campaign Number: (25V626000 (STEERING) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA ID

11741499

Incident

Sep 23, 2025

The contact owns a 2020 Ford F-250. The contact stated that he received NHTSA Campaign Number: 24V957000 (Fuel System, Diesel). The local dealer was contact who confirmed there were metal shaving in the fuel injectors. The vehilce was not repaired. The manufacture was not contacted. The failure mileage was approximately 30,000.

NHTSA ID

11737777

Incident

May 14, 2026

Mileage

30,000 mi

Vehicle: 2020 Ford F‑250 Super Duty VIN: [XXX] Issue: Front / CHMSL camera intermittent or inoperative Ford CSP 20B39 applies CSP cannot be completed due to Gateway Module failure Ford has not responded despite multiple written requests I have personally sent emails to them on: Sent April 6 Sent April 9 Sent April 16 4/29 - Called and asked for coordination. Received no acknowledgment RE: Request for Coordination With Dealer to Complete Recall 20B39 [XXX] [XXX] > Thu, Apr 16, 11:59 AM (13 days ago) to crcfmc, [XXX] , [XXX] , [XXX] Dear Ford Customer Relationship Center, I'm writing to follow up again on my previous emails of April 6 and April 9 regarding my 2020 Ford F-250 Super Duty (VIN: [XXX] ). I have not received any response or confirmation of receipt. I want to correct my earlier characterization — after further research, I understand that 20B39 is a Customer Satisfaction Program, not a safety recall. That said, the core issue and my position remain the same, and I want to lay out where things stand clearly. The situation: - My vehicle is covered under CSP 20B39 (Front View and CHMSL Camera — PCB conductivity issue causing intermittent camera operation) - The program is in effect through November 30, 2030 or 150,000 miles, and the repair is to be performed at no charge to the vehicle owner - My servicing dealer, Santa Margarita Ford, attempted to complete the CSP work but could not because the vehicle's Gateway Module is not communicating properly - The dealer has advised that the Gateway Module must be replaced before the camera work under XXX can be completed My position: Ford issued CSP XXX and committed to completing this repair at no charge. If the Gateway Module must be functional in order for Ford's own program to be executed, then resolving the Gateway Module issue is Ford's prerequisite to meet — not an out-of-pocket cost to push to the customer. I'm not asking for anything beyond INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11734594

Incident

Mar 23, 2026

While driving at speeds above 30mph truck will have the death wobble. We will lose complete control in direction of steering. Have to try to stop and then turn the wheel right and left before the truck will regain normal travel. Is a huge safety issue and has almost caused us to wreck. Has happened multiple times and we have been unable to determine what has caused the issue. We have had the steering column recall fixed and have even changed the tie rod ends with no change.

NHTSA ID

11734145

Incident

Mar 1, 2026

Vehicle experienced loss of power while in travel down a mountain. After inspection by a mechanic, CP4 pump had a catastrophic failure sending metal shards throughout the fuel system. This was less than a month after Fords SAFETY RECALL 24S78 that failed to remedy the problem, but before recall Number26V158 was issued.

NHTSA ID

11728380

Incident

Mar 11, 2026

This vehicle was delivered yesterday to my son through Autonation Sanford [XXX] . The CARFAX report stated a pre delivery inspection was done prior. On the way home he experienced loud screeching from the front wheels. Turns out $1650 later he needed new brakes and rotors. That is negligence, and fraud, especially with a commercial vehicle intended on towing a fishing boat. This was underhanded and a disgusting pattern of behavior. In addition, the open fixable recall was NOT completed as we just found out from searching the VIN on your website. The managers name is [XXX] , I have reached out to him to rectify this situation, and no call back. Truly grotesque, taking advantage of a [XXX] kid. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11728224

Incident

Mar 30, 2026

Component: Air Conditioning / Heater Subject: Recurrent HVAC System Failure - Passenger-Side Temperature Control Malfunction I am reporting a recurring failutre of the vehicle's HVAC system affecting the passenger-side temperature control. Specifically the passenger-side air vents intermittently and repeatedly blowing hot air while the driver-side continue to operate normally with cooled air. This condition results in inconsistent cabin temperature control andrenders the air conditioning system ineffective for occupants on the passenger side. Timeline of Failures and Repairs: July 2023: Initial occurrence of passenger side hot air condition. Vehicle was taken to authorized Ford dealership (McRee Ford). Repairs were performed; however the specific root cause either identified or not permanently corrected as another recurrence happened August 2025: Took it back to McRee Ford due to an identical issue reoccurred where the passenger side was blowing hot air. They attempted to repair with the same technician and was again only a temporary resolution as the issue again occurred March 2026: Passenger side blowing hot air for the third time. Took it to a different authorized Ford dealership (Cook Ford) where again, it was identified as a blend door actuator issue. Safety Concern: While the issue may appear to be a comfort concern, it presents a potential safety risk in high temperature environments such as Texas. (Heat related stress or illness for passengers) Multiple authorized dealership seem to be unable to resolve the issue. Currently vehicle is with Cook Ford and was advised that additional funding would be needed for a permanent fix. I've already been financially burdened with taking the vehicle twice to McRee Ford and now a third time to Cook Ford for the same issue, and being told upfront that the failure may again happen. I request an investigation into this matter and HVAC issue. Thank you.

NHTSA ID

11727893

Incident

Mar 26, 2026

02/04/2026 69k miles. I brought my vehicle in because I got a check engine light on the dash and had loss of power. Was informed that my fuel pump had failed and sent metal shards through the whole fuel system. The damage was covered by the recall, which also included reprogramming of the tcm and pcm. Was then told that the reflash of those systems was a failure, and that the Ford Motor Company was working on a remedy. My dealership has since completed a full fuel system replacement, and there still isn't a fix for the programming issue. This is a revenue generating vehicle, and the only one, for my small business. I lost many clients due to inability to perform the work I was contracted to do. My dealership did offer me a loaner vehicle, but it's not one that can perform the work that my truck was able to do, and was told not to use the vehicle for any commercial work or towing, as thats not allowed. Ive reached out to customer relations to get updates, and have had no help from them, save for telling me they're working on it, and will hope to have a remedy soon.

NHTSA ID

11727660

Incident

Feb 3, 2026

I was driving the truck and suddenly smoke came out from behind the radio. I stopped and checked and saw that the truck was on fire. I immediately tried to turn it off with the few water bottles that I had with me. I had no luck and the entire truck burned up.

NHTSA ID

11727106

Incident

Mar 23, 2026

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 25V626000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were on backorder. The contact was advised not to drive the vehicle. The manufacturer was made aware of the issue and confirmed that parts were on backorder. The contact had not experienced a failure.

NHTSA ID

11723014

Incident

Sep 19, 2025

The contact owns a 2020 Ford F-250. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, while attempting to schedule an appointment, the contact was informed that the recall repair had been placed on hold. The contact stated that recently, while driving approximately 60 MPH, the vehicle started to lose motive power. The contact stated that the vehicle stalled and was towed to the same local dealer. There was no warning light illuminated. The vehicle was diagnosed, and it was determined that the high-pressure fuel pump had failed, and the pump and the diesel fuel system needed to be replaced. The contact was provided and estimate for the repair. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was informed of the failure. The failure mileage was approximately 164,000.

NHTSA ID

11722208

Incident

Feb 28, 2026

Mileage

164,000 mi

The contact owns a 2020 Ford F-250. The contact received notifications of NHTSA Campaign Numbers: 24V957000 (Fuel System, Diesel) and 25V686000 (Back Over Prevention); however, the parts to do the recall repairs were unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The contact stated that the check engine warning light was intermittently illuminated. The contact stated that while driving at various speeds, the vehicle unintendedly decelerated and lost power. The vehicle was coasted to the side of the road, turned off, restarted, and the vehicle regained power and drove as intended. The message "Power Reduced” was displayed. The failure occurred approximately every 5 miles driven. The vehicle was taken to the dealer and was diagnosed with low fuel pressure, and it was determined that the fuel pump had failed and needed to be replaced. The vehicle had not been repaired because parts were not available. The manufacturer was not made aware of the issue. The failure mileage was approximately 95,000.

NHTSA ID

11721446

Incident

Dec 20, 2024

Mileage

95,000 mi

Good Morning, Ms. Edds My name is [XXX] . I spoke to you a few years back in regards, to a vehicle I had. Well, today I am writing about another situation . I have a 2020 Ford F250 vin [XXX] . Since purchasing this vehicle, I have had recall after recall on it and getting nowhere with Ford Motor Company Customer Service Division. I have a local dealership that I have taken it to Spalding Ford who does not take the time to look at the vehicle when I tell them there is an issue and what it is doing all they do is make 1 excuse after another and then about a week or so goes by and I get a recall letter about the issue I just complained about. The last time it was at this dealership they cracked my windshield and said they get back with me about getting it fixed so far nothing and I have called a number of times and now being told they had no idea about it. It has been several months but guess that is going to have to fall on me because no one wants to take accountability of their own actions. I have 3 outstanding recalls in which I complained about before the recall came into effect. I contacted a dealership located in the next county over who willingly sent a tech to my house for a recall when the tech got here he was unable to fix the recall do to the Ford Motor Company Customer Service Division running errors in their system and was unable to do the update. I have also complained about having steering issues and was told no there is nothing wrong but then all of a sudden, I received a recall letter. I am an average John Doe trying to take care of my [XXX] grandson and my [XXX} husband this is supposed to be my dependable vehicle for us I cannot just go out and trade it in and lose all the money I have placed into it already I don't have the funds or means to do that. I called and talked with the recall department and the gentleman i spoke with was really concerned and tansfered me to someone who didnt want to fix it INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11720861

Incident

Feb 27, 2020

The fuel tank is leaking fuel from the top where hose connects, it is cracked where the hose barb is connected to the tank

NHTSA ID

11718728

Incident

Feb 12, 2026

I was driving down the FM 112 in Lexington TX. The rear glass exploded. The center glass was not damaged just the glass on both sides

NHTSA ID

11718023

Incident

Feb 14, 2026

My cp4 fuel pump failed on my 2020 ford f250 and died while towing my 7000lb trailer for my business and had to get towed to shop to find out the entire fuel system needs replaced and ford dealer has it and says because recall 24s78 for my vehicle is on pause that there is nothing they can do about it and I’m stuck without my truck which I need for my business and believe ford is responsible to replace the fuel system with no charge to me when the cp4 pump is such a common failure in my trucks!

NHTSA ID

11717342

Incident

Feb 4, 2026

NHTSA Complaint Text (Copy/Paste) Vehicle: 2020 Ford F-250 Super Duty 6.7L Power Stroke Recall: 24S78 – Powertrain Control Module (PCM) Software Update Complaint: Ford has issued Recall 24S78 for the high-pressure fuel pump defect on my 2020 F-250, but the company has not provided an actual remedy. The recall shows as open on my VIN, and Ford’s documentation says a PCM software update is the fix, but Ford released the software and then pulled it back within a week. My dealership confirmed Ford removed the remedy from their system, so they cannot perform the recall at all. This leaves my truck exposed to a known safety defect with no available repair. The high-pressure fuel pump failure this recall addresses can cause sudden loss of power, engine stall, or complete shutdown while driving. Until a working remedy is released, I’m driving a truck that Ford has admitted has a serious safety defect, but they have not provided any fix or timeline. I am requesting NHTSA investigate why the remedy was withdrawn, why no replacement remedy has been provided, and why Ford is leaving owners with a known safety risk for an extended period. This is an expensive vehicle, and the defect can cause catastrophic engine damage and create a hazardous situation on the road. Owners deserve an effective recall remedy that is actually available. Not exactly sure when the recall was first brought to light but I do know it has been months now.

NHTSA ID

11717279

Incident

Oct 1, 2025

The contact owns a 2020 Ford F-250. The contact stated that while driving at an undisclosed speed, the check engine and loss of power warning lights were illuminated. In addition, the vehicle sputtered. The vehicle was driven to the shoulder of the road. The vehicle was then towed to an independent mechanic, where it was diagnosed with fuel systems failure. The contact was informed that the fuel system needed to be replaced. In addition, the contact was informed that a complete fuel system and maintenance needed to be performed to fix the vehicle. The vehicle was repaired. The contact received notification of NHTSA Campaign Number: 24V957000 (Fuel System, Diesel); however, the part was not yet available. The dealer was made aware of the failure. The contact was informed that the recall was not associated with the VIN. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,050.

NHTSA ID

11717257

Incident

Jan 26, 2026

Mileage

120,050 mi

While driving cross country, my dash warning light came on and said " In 50 miles your vehicle will lose power and you won't be able to drive more than 5 mph. DEF problem". I spent $70,000 on this vehicle used with 50K miles on it. Recall from 2024, this is unacceptable. Now another recall for steering. The steering column disengagement. I am afraid to drive it. The dealer keeps telling me no fix yet. FORD has no email to complain. I am not sure what can be done. This is my first FORD, never again.

NHTSA ID

11716649

Incident

Oct 30, 2025