Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 107 NHTSA owner-reported complaints for the 1991 Ford F-250. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 107 · page 1 of 5
FUEL LEAKED FROM HEATER WIRE IN FUEL FILTER. THE FUEL FOLLOWED THE WIRE UP THE COPPER CORE UNTIL IT REACHED A CRACK IN THE INSULATION ANY TIME THERE WAS FUEL PRESSURE, IE ENGINE RUNNING OR EVEN WITH BOOST PUMP PRESSURE WITH ENGINE OFF.
TL* THE CONTACT OWNS A 1991 FORD F-250. AFTER THE VEHICLE WAS PARKED, THE CONTACT NOTICED A STRONG FUEL ODOR FROM THE SIDE OF THE VEHICLE. THE CONTACT NOTICED FUEL POURING OUT OF THE OPENING OF THE TANK THAT SPILLED ONTO THE STREET AND UNDERNEATH ANOTHER VEHICLE. THE DEALER STATED THAT THE FUEL CHECK VALVE IN THE PUMP UNIT WAS DAMAGED, WHICH CAUSED THE FUEL TO TRAVEL FROM ONE TANK TO THE OTHER AND OVERFLOW. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 137,000.
TL* THE CONTACT OWNS A 1991 FORD F-250. AFTER REFUELING THE VEHICLE, FUEL STARTED LEAKING FROM THE FUEL TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 01I008000 (FUEL SYSTEM, GASOLINE) BUT THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 161,000. ..UPDATED 05/20/15 *BF THE CONSUMER HAS EXPERIENCED THE FUEL SWITCH OVER ISSUE AND WOULD LIKE TO BE ADDED TO THE RECALL. UPDATED 7/6/2015 *JS
I HAD JUST BEEN JUMPED BY AAA BECAUSE MY TRUCK WASN'T STARTING; THE AAA AGENT ALSO CLEANED THE BATTERY TERMINALS. I INTENDED TO HAVE IT TOWED TO THE FORD DEALER BECAUSE I DIDN'T THINK IT WOULD START. SINCE THE AAA AGENT WAS ABLE TO GET TO START, I DECIDED TO STILL TAKE IT TO THE DEALER TO FIND OUT WHY THE BATTERY WAS DEAD (GIVEN THEY HAD THE CAR FOR A MONTH AND HAD PUT IN A NEW BATTERY AND STARTER, AMONG OTHER REPAIRS). DRIVING THE 7 MILES TO THE DEALERSHIP THE CAR SEEMED TO BE ACCELERATING ON ITS OWN, THE ENTIRE WAY, I ONLY STEPPED ON THE GAS ONCE; IT WAS GOING 35 MILES/HOUR BY ITSELF (PER THE SPEEDOMETER). I DIDN'T KNOW WHY THIS WAS HAPPENING AND WHEN I TRIED TO SLOW DOWN USING THE BRAKES, THE TRUCK WAS VERY DIFFICULT TO STOP, SUCH THAT I NEARLY REAR-ENDED MULTIPLE CARS. IT WAS ALL I COULD DO TO PUSH THE BRAKE DOWN AND TWICE HUGE AMOUNTS OF SMOKE CAME FROM UNDER THE VEHICLE (PROBABLY THE BRAKES WERE NOW OVERHEATING?). WHEN I WAS 500 FEET FROM THE DEALERSHIP I TOOK A QUICK LEFT TURN AND HONESTLY COULD NOT STOP THE TRUCK, I THREW IT INTO PARK AND SHUT IT OFF JUST IN TIME TO MISS PLOWING INTO PARKED VEHICLES. SMOKE BILLOWED OUT FROM BELOW THE HOOD. I HAVE NEVER BEEN SO FRIGHTENED IN MY LIFE-I WAS SURE I WAS EITHER GOING TO SMASH INTO SOMEONE SINCE I COULDN'T STOP OR THE TRUCK WAS GOING TO IMPLODE IN FIRE, OR SOMETHING AND I WOULD BE DEAD. I WAS NOT ABLE TO SUCCESSFULLY STOP IT USING THE BRAKES. THE PARKING BRAKE WAS ALSO NOT WORKING (WHICH IS ALSO WHY I WAS RETURNING IT TO THE DEALER). WHEN I ASKED THE SERVICE PERSON AT THE FORD DEALERSHIP IF HE'D SEEN A STUCK THROTTLE LIKE THIS BEFORE, HE SAID, "YES, SOMETIMES WHEN VEHICLES SIT FOR A WHILE". THIS IS A SATURDAY, SO THEY ARE GOING TO EVALUATE THE PROBLEM ON MONDAY. THE SERVICE REP ALSO SAID SOMETIMES CLEANING THE TERMINALS MIGHT CONTRIBUTE TO EXTRA CONDUCTION, WHICH MIGHT HAVE CAUSED THE ACCELERATION ISSUE. *TR
THE VEHICLE IS A 1990 AND THE SITE DOES NOT PROVIDE A SPACE CHOICE FOR THE 1990, ONLY '91 AND UP. THE TRUCK HAS THE EXACT SAME PROBLEM AS THE OTHER MANY FORD TRUCKS. WHILE IDLING, OR UNDERWAY, THE VEHICLE SPEWS GASOLINE FROM THE FRONT TANK, OUT ONTO THE ROAD, OR ANY DRIVEWAY, IF IDLING. IT'S CLEAR THAT ONCE YOU FILL THE REAR TANK AND THEN TRAVEL, THE FUEL, WHICH SHOULD RETURN TO THE REAR TANK IN A CYCLE, DOES NOT. IT SIMPLY RETURNS TO THE FRONT TANK, UNTIL IT FILLS THE FRONT TANK AND FLOODS OUT. THE PUMP IN THE REAR TANK APPEARS TO JUST CONTINUE TO RUN, FOR EXAMPLE,,,, YOU HAVE A FULL REAR TANK. YOU HAVE HALF A TANK OF FUEL IN THE FRONT TANK. YOU DRIVE. THE REAR TANK PUMP, PUMPS ALL OF THE FULL REAR TANK INTO THE FRONT TANK. SO, HALF A TANK OF GAS FLOWS OUT OF THE FRONT TANK, ONTO THE GROUND. OBVIOUSLY, THE CYCLE, WHERE THE FUEL SHOULD GO FROM REAR, TO ENGINE AND BACK, ISN'T HAPPENING. INSTEAD, THE FUEL ROLLS BY THE ENGINE AND RETURNS TO A FULL FRONT TANK, RATHER THAN THE REAR TANK, SO, ONTO THE GROUND GOES THE FUEL. ON AN OLDER RECALL REPORT, THE REPAIR IS DESCRIBED, WHERE THE 'JUMPER' MUST BE REPLACED, DESPITE THE FACT THERE'S NO SUCH THING, THERE'S A FUEL PUMP AND PROBABLY SOME SORT OF 'BI-VALVE' THAT SOMEONE'S POOR ENGINEERING FAILED ON THE WHOLE, AT THE TIME OF DESIGN. I THINK I'LL JUST PULL INTO THE LOCAL FORD LOT AND IDLE OUT A FEW GALLONS NOW AND THEN. BUT SINCE THE 90 ISN'T ON THE RECALL, DESPITE THE OBVIOUS EXACT PROBLEM AS THE 91'S AND UP, THERE'S NO USE. IT WOULD SEEM COMMON SENSE, THAT DEALERS COULD SIMPLY BE NOTIFIED THAT THE 1990 F 250'S ARE DOING THE EXACT THING AS MANY OTHER MAKES AND THE LEAST THE DEALER COULD DO, IS BE A LITTLE MORE SPECIFIC ABOUT THE REPAIR. BUT NOT IF THEIR CORPORATE ENGINEERS AND REPAIR CENTERS KEEP THE MECHANICAL INFORMATION SECRET, OR WRITTEN IN SOME MANUFACTURER 'CODE LANGUAGE'. *TR
TL* THE CONTACT OWNS A 1991 FORD F250. THE CONTACT STATED THAT GASOLINE FUEL WAS LEAKING FROM THE VEHICLE AND ONTO THE DRIVEWAY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL AND PROVIDED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 102,311 AND THE CURRENT MILEAGE WAS 102,622. ..UPDATED 09/07/12 *BF UPDATED 09/17/2012 *JS
TL* THE CONTACT OWNS A 1991 FORD F-250. THE CONTACT STATED THAT AFTER REFUELING THE VEHICLE, GASOLINE WOULD OVERFLOW FROM THE REAR FUEL TANK INTO THE FRONT FUEL TANK, CAUSING SPILLAGE. THE CONTACT BELIEVED THAT THE FUEL PUMP WAS DEFECTIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 93V125000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK ASSEMBLY). THE DEALER ADVISED THAT THE ENTIRE FUEL TANK WOULD NEED REPLACING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 150,000.
TL*THE CONTACT OWNS A 1991 FORD F250. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, HE NOTICED GASOLINE SPILLING OUT OF THE TANK. PRIOR TO THE SPILL, HE SMELLED A GASOLINE ODOR FOR ABOUT 6 MONTHS. THE VEHICLE WAS INSPECTED BY PEPBOYS WHO INFORMED THE CONTACT THAT THE FUEL TANK SELECTOR NEEDED TO BE REPLACED. THE VIN WAS UNKNOWN. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 38,525.
TL*THE CONTACT OWNS A 1991 FORD F-250. THE CONTACT STATED THAT WHEN HE FILLED THE FRONT TANK, THE FUEL WOULD BE SHIFTED TO THE REAR TANK. THE FAILURE OCCURRED EVERYTIME HE FUELED THE VEHICLE. THE CONTACT STATED THAT BECAUSE OF THE FAILURE, A PRESSURE WAS CREATED WITHIN THE TWO TANKS. THE VEHICLE. THE CONTACT CALLED THE DEALERSHIP AND REFERENCED RECALL 93V125000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY) AND WAS TOLD THAT THERE WERE NO ACTIVE RECALLS ON HIS VEHICLE. THE CONTACT CALLED THE MANUFACTURER WHO VERIFIED THAT THERE WERE NO ACTIVE RECALLS FOR THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 250,000. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.
DISCOVERER A/T TIRES SIZE LT265/75R16 CATASTROPHICALLY FAILED WHILE DRIVING AT HIGHWAY SPEED. TREAD COMPLETELY PEELED OFF. HAD ONLY BEEN DRIVING FOR 30 MINUTES AND OUTSIDE TEMPERATURE WAS 70 DEGREES F. TIRES HAD ABOUT 23,000 MILES ON THEM. 1-2 YEARS PREVIOUSLY, THE SAME TYPE TIRE ON OPPOSITE WHEEL DEVELOPED A BULGE IN THE SIDEWALL AND HAD TO BE REPLACED. *TR
I HAD 2 FAILURES WITH THE FIRST ABOUT 9/21/07 AND THE SECOND 10/6/07. THE VEHICLE IS A 1991 F250 HD AND IS OCCASIONALLY USED TO HAUL A SLIDE-IN CAMPER. ON BOTH OCCASIONS I HAD THE CAMPER ON THE TRUCK, LOADING THE TRUCK TO NEAR THE RATED CAPACITY OF THE TIRES BUT NOT OVER TO MY KNOWLEDGE. IN BOTH INSTANCES THE TIRE PRESSURE WAS CHECKED BEFORE LEAVING THE HOUSE, WERE WE TRAVELING A MODERATE SPEED, ABOUT 55 MPH, AND IT WAS COOL. IN BOTH CASES I NOTICED A VIBRATION BUT BEFORE I COULD EFFECT A SUBSTANTIAL RESPONSE THE TIRE EXPLODED. THE TRUCK REMAINED IN CONTROL BUT THERE WAS SUBSTANTIAL DAMAGE TO THE TRUCK. THE TIRES WERE ON THE REAR SO THERE WAS DAMAGE TO BOTH SIDES. THE FIRST TIME I HAD THE TIRE REPLACED BY THE DEALER AND HE GAVE ME OVER A 50% CREDIT, REFLECTING THE AMOUNT OF TREAD LEFT ON THE TIRE. THE SECOND TIME I HAD THE TIRE REPLACED WITH A DIFFERENT BRAND AND KEPT THE OLD TIRE FOR INSPECTION. *TR
DAD: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 93V125000 CONCERNING THE FUEL SYSTEM: TANK ASSEMBLY. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT II IS NOT INCLUDED IN THE RECALL DUE TO VIN. THE CONTACT REPAIRED THE VEHICLE AT HIS OWN EXPENSE. *AK THE DEALER CHARGED THE CONSUMER 500.00 TO REPLACE THE FUEL PUMP WHICH WAS DIFFERENT FROM THE RECALL. UPDATED 01/11/06. *JB
THERE WAS AN ACRID ODOR IN THE CABIN ON SEVERAL OCCASIONS. THE RADIO LIGHT BEGAN FUNCTIONING INTERMITTENTLY. THE DASH LIGHTS FAILED TO WORK TWICE. THE HEAD LIGHTS FAILED TO WORK TWICE, ON SEPARATE OCCASIONS FROM THE DASH LIGHTS. I WENT TO REPLACE THE HEADLAMP SWITCH, AND FOUND THE CONNECTOR CHARRED AND MELTED, AND THE B2 TERMINAL ON THE SWITCH WAS LOOSE AND DISCOLORED. THE SWITCH WAS CHARRED AROUND THE B2 TERMINAL.. I AM GOING TO REPLACE THE CONNECTOR ALSO. *JB
AFTER FUELING THE VEHICLE, CONSUMER NOTICED GAS BEING PUMPED OUT OF THE FRONT FILL POINT LIKE A FIRE HOSE. *PH THIS WAS THE THIRD FAILURE WITH THE CROSSOVER. CONSUMER THEN LEARNED THAT THIS FAILURE WASN'T GOING TO BE COVERED UNDER THE EXTENDED WARRANTY LIKE THE FIRST TWO. *PH
THE GASOLINE WAS NOT TRANSFERRING BETWEEN THE FUEL TANKS, CAUSING VEHICLE TO STALL DUE TO LOW GASOLINE. THE DEALER REPLACED THE FUEL TANK SENDER AND THE FUEL PUMP. *AK THERE WERE FOUR ATTEMPTS TO REMEDY THE TRANSFERRING OF FUEL FROM THE REAR TANK TO THE FRONT TANK THROUGHOUT THE FILLER CAP AND CAUSED LEAKAGE. THE CONSUMER REQUESTED THAT FORD COVER THE CHARGES. *SC *JB
WHEN THE FRONT TANK WAS EMPTY AND THE CONSUMER SWITCHED TO THE REAR FULL TANK, SOMEHOW THE GAS FROM THE REAR TANK PUMPED BACK INTO THE FRONT TANK WHICH RESULTED IN THE REAR TANK BEING EMPTY. *NLM *CB *NLM
FRONT SEATBELT WILL NOT EXTEND TO GIVE ROOM FOR CONSUMER TO PUT IT ON, CAUSING CONSUMER NOT TO HAVE A SEATBELT ON WHILE DRIVING. CAUSE UNKNOWN. DEALER NOTIFIED.*AK
WHILE DRIVING, VEHICLE WILL SHUT OFF.*AK *YH
BRAKES FAIL SOMETIMES. I NEED HELP. I JUST FOUND OUT ABOUT THIS RECALL OF 03/11/92TO LATE FOR THIS RECALL ?. NHTSA CAMPAIGN 92VO26000 .*AK
VEHICLE WAS EXAMINED BY THE DEALERSHIP FOR RECALL CAMPAIGN 01I008000 CONCERNING FUEL CROSSOVER. AFTER REPAIR WORK WAS PERFORMED, PROBLEM BECAME WORSE THAN IT HAD BEEN BEFORE DEALER MADE ADJUSTMENTS TO VEHICLE. POWER FAILURE OCCURS, THE MOTOR SHUTS DOWN AS IF IDLING. *JG *AK
HEADLIGHT SWITCH IS FAULTY CAUSING THE LIGHTS TO FAIL WHILE DRIVING. NLM
RECALL 96 V 071 00/ELECTRICAL SYSTEM IGNITION: VEHICLE EXPERIENCING PROBLEM WITH IGNITION SWITCH FAILING TO OPERATE/ WILL NOT TURN ON. HAD TO DISCONNECT SWITCH AND HOT WIRE TO GET VEHICLE TO START. MANUFACTURER NOTIFIED, AND INFORMED CONSUMER THAT THEY COULD NOT LOCATE VIN SYSTEM. ASKING NHTSA TO HELP IN THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS PROBLEM. *AK
TREAD STARTED COMING OFF TIRE. REMOVED BEFORE BLOWOUT. LOCAL DEALER CONTACTED BUT "NO RECALL PROGRAM ON THAT SIZE". SEEMS TO BE SAME PROBLEM AS WITH 235/75/R15'S. *AK (TIRESIZE: 235/85/R16)( DOT NUMBER: TIRE SIZE: 235/85/R16 )
CONSUMER WAS TRAVELING 58-59MPH AND PASSENGER'S REAR TIRE TREAD SEPARATED. ONLY WARNING WAS THAT VEHICLE SWAYED FORM SIDE TO SIDE. TREAD WAS HITTING REAR OF WHEEL WELL AND RUNNING WELL. VEHICLE HAD OVER $2407.00 WORTH OF DAMAGE. TIRE SIZE P265/75R16, APRROXIMATELY 3500, AFTERMARKET TIRES.*AK *JB
CONSUMER WENT TO START VEHICLE , SMOKE STARTED TO COME OUT OF ENGINE COMPARTMENT , FILLED TRUCK WITH BAD BURNING SMELL, SHUT OFF ENGINE AND NOTICED INSULATION HAS COMPLETELY MELTED ,WIRES OFF ENGINE,A MAJOR CONNECTOR WAS ALSO BURNED, BUT NO FUSES WERE BLOWN. CONSUMER HAS ALREADY FILED COMPLAINT EVOQ#861040 BUT SAME DEFECT RECOOCURRED. SERVICE MANAGER AT DEALER CLAIMED DEFECT WAS NOT UNUSUAL AND WAS AWARE OF DEFECT.*AK THE CONSUMER BELIEVES THE PROBLEM WA NOT ELECTRICAL. *YH
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .