2005 Ford F-250 Electrical Problems

Odometer Fraud. The contact owns a 2005 Ford F-250. The contact purchased the vehicle from a private seller on social media. The contact stated that the sellers advertisement indicated the odometer mileage was 96,000. The contact later purchased a new vehicle and decided to sell the existing vehicle. The existing vehicle was posted on social media for sale. A potential buyer noticed the vehicle and obtained a Carfax report. The potential buyer then sent a copy of the Carfax report to the contact. The Carfax report indicated that the odometer was reported at 303,000 in 2023. The contact then contacted the seller and informed the seller of the discrepancy. The contact was informed that the odometer had been swapped prior to the sale. The contact stated that seller then deleted the advertisement from social media and rejected all further communications with the contact.

NHTSA ID

11692282

Incident

Jan 29, 2025

Mileage

303,000 mi

Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because I'm having this issue

NHTSA ID

11653078

Incident

Mar 25, 2025

Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road

NHTSA ID

11606568

Incident

Aug 3, 2024

The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly

NHTSA ID

11582251

Incident

Apr 10, 2024

The contact owns a 2005 Ford F-250. The contact stated while driving at various speeds, the vehicle loss motive power. The vehicle was later restarted and the vehicle operated as designed. The vehicle was taken to the local dealer who replaced the fuel injection control module however, the failure recurred. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA campaign number 05V270000 (Electrical System). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 36,000.

NHTSA ID

11418273

Incident

May 1, 2005

Mileage

36,000 mi

WHEN DRIVING, THE TRUCK WILL DIE. SOMETIMES TRUCK CAN BE RESTARTED OTHER TIMES HAD TO HAVE IT TOLLED. WE HAVE REPLACED FUEL PRESSURE REGULATOR, REGULATOR, START SWITCH R&R INSTRUMENT CLUSTER, ALTERNATOR, BATTERIES AND THE PROBLEM STILL EXIST. HAVE TAKEN IT TO A FORD DEALER AND THEY CAN NOT FIND THE PROBLEM. THEY SAY IT IS NOT COVERED ON RECALL 05V270000

NHTSA ID

11396937

Incident

Nov 26, 2019

Mileage

95,000 mi

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. ADDITIONALLY, THE VEHICLE STALLED WITHOUT ANY WARNING INDICATORS ILLUMINATING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY, ALTERNATOR, AND FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 162,000.

NHTSA ID

11097019

Incident

May 11, 2018

Mileage

162,000 mi

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO OPERATE AND STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE AND INJECTION CONTROL PRESSURE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V27000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100. UPDATED 06/21/16*LJ

NHTSA ID

10853867

Incident

Apr 3, 2016

Mileage

100,100 mi

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

NHTSA ID

10788546

Incident

Oct 21, 2015

Mileage

113,000 mi

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ICP PRESSURE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

NHTSA ID

10671023

Incident

Nov 7, 2014

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT UPON START-UP. THE FAILURE WAS RECURRING. THE STARTER WOULD TURN OVER BUT THE ENGINE WOULD NOT ENGAGE. THE BATTERY WAS REPLACED TWICE BUT TO NO AVAIL. ADDITIONALLY, BLACK SMOKE WAS EMITTING FROM THE VEHICLE AND THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109000.

NHTSA ID

10583335

Incident

Mar 24, 2014

Mileage

109,000 mi

2005 FORD F-250. CONSUMER STATES ENGINE FAILURE *TGW THE CONSUMER STATED THE ENGINE FAILURE NEARLY CAUSED AN ACCIDENT, WHEN IT SHUT DOWN ON A MAJOR HIGHWAY. SUBSEQUENTLY, THE CONSUMER ALSO EXPERIENCED A FAILURE WITH THE FUEL INJECTION CONTROL MODULE. AFTER HAVING THE FUEL INJECTION CONTROL MODULE REPLACED, THE CHECK ENGINE LIGHT ILLUMINATED AFTER LEAVING THE DEALERSHIP. THE CHECK ENGINE LIGHT ILLUMINATED DUE TO A FAILED EGR VALVE. THE CONSUMER WAS ALSO INFORMED THE ALTERNATOR WAS SPIKING, AND NEEDED TO BE REPLACED AS WELL AS THE EGR COOLER AND HEAD GASKETS. *JB

NHTSA ID

10340024

Incident

Jun 23, 2010

Mileage

60,770 mi

MY 2005 FORD F-250 SUPERDUTY 6.0L DIESEL, FIRST INCIDENT WAS MAY OF 2007, AT 16,000 MILES MY TURBO CHARGER WENT BAD WHEN I WAS TRAILERING MY HORSES IN VERMONT, FORCED TO STOP AT UNKNOWN DEALERSHIP WHO "CLEANED" SOMETHING SO I WOULD MAKE IT BACK TO MY HOME. AGAIN ON THE DRIVE HOME I LOST THE TURBO. IT HAD TO BE REPLACED AT THE DEALERSHIP, COLUMBIA FORD, CT THE NEXT DAY. I WAS TOLD I HAD TO DRIVE MY TRUCK HARD AND EVERYDAY IN ORDER TO PREVENT THE PROBLEM FROM OCCURRING AGAIN. IN MARCH 2010 BROUGHT MY TRUCK TO MONACO FORD, THE MOTOR HAD TO BE REMOVED DUE TO "ALL OF THE GASKETS AND SEALS IN THE MOTOR LEAKING, AS WELL AS THE TURBO CHARGER BEING BAD AGAIN. THIS OCCURRED AT 24,500 MILES. THE SIDE WALLS OF MY TIRES ARE PEELING, THE RUNNING BOARD ON THE DRIVERS SIDE IS FALLING OFF, AND THE BODY SIDE MOLDING IS COMING OFF AND NOW AT 26,000 MILES THE AIR POSITION SELECTOR FOR THE CLIMATE CONTROL SYSTEM IS NOT WORKING. IF I PUT IT IN A POSITION FOR VENTING OR FOR FRONT AND FLOOR I JUST BLOWS THROUGH THE DEFROST VENTS. OBVIOUSLY THE WARRANTY HAS PASSED WITH THE EXCEPTION OF THE MOTOR AND I HAVE 26,500 MILES ON THIS TRUCK. *TR

NHTSA ID

10339426

Incident

May 5, 2007

Mileage

16,000 mi