2000 Ford F-350 Sd Owner Complaints

MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

NHTSA ID

10924549

Incident

Oct 14, 2016

Mileage

107,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT LOCATED UNDER THE FUEL FILTER, THE O-RING AND THE DRAIN LINE FAILED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRAIN LINE AND INDICATED THAT THERE WAS TOO MUCH PRESSURE FLOWING INTO THE FUEL FILTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/10/16*LJ UPDATED 11/3/2017*JS

NHTSA ID

10851896

Incident

Nov 10, 2015

Mileage

102,000 mi

FORD F-350. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE INFLATION PRESSURE PROBLEMS. *SMD THE CONSUMER STATED THE TIRE WAS INFLATED TO 55 PSI TO SOFTEN THE RIDE. LATER, WHILE HAULING TRACTOR THE TREAD ON ONE OF THE TIRES PEELED OFF. THE CONSUMER PUT THE SPARE ON THE TRUCK. THE CONSUMER WAS ADVISED TO RUN THE TIRES AT THE MAXIMUM INFLATION PRESSURE FOR THE BEST WEAR, MAXIMUM LOAD CAPACITY, BEST MILEAGE AND LONGEST LIFE. EACH OF THE TIRES EVENTUALLY FAILED ONE AT A TIME. WHEN THE CONSUMER PURCHASED NEW TIRES, THEY WERE INFLATED 60 PSI FOR THE FRONT AND 50 PSI FOR THE REAR, INSTEAD OF 80 PSI. EVERYTHING WAS FINE FOR A WHILE, UNTIL THE CONSUMER STARTED TO EXPERIENCE ROUGH RIDING AND NOISY TIRES AS A RESULT OF IMPROPER INFLATION. THE RETAILER STATED THE INFLATED THE TIRES ACCORDING TO WHAT WAS PRINTED ON THE DOOR STICKER. THE UNDER INFLATION CAUSED EXCESSIVE SIDEWALL FLEX, REDUCED MILEAGE, SHORTENED LIFE AND SEVERAL TIRE FAILURES. *JB *CN

NHTSA ID

10806829

Incident

Oct 1, 2015

AS WE WERE RETURNING HOME FROM A ROAD TRIP, WE HEARD A SCREECHING NOISE COMING FROM THE LEFT WHEEL WELL AREA WHEN WE MADE WIDE SWEEPING TURNS AND HIGHWAY CURVES. WE PULLED OVER AND, UPON INSPECTION, SAW OUR ORIGINAL ALLOY WHEEL ON OUR TRUCK WAS CRACKED. ONE OF THE WHEELS WAS DANGEROUSLY CLOSE TO COMING OFF THE HUB. PHOTOS DOCUMENT HOW SEVERE THE CRACKING OF THE WHEELS WAS - THREE OF FOUR WHEELS WERE FOUND TO HAVE CRACKS AND CHUCKS OF METAL MISSING,COMPROMISING THE INTEGRITY OF THE WHEELS AND THE SAFETY OF OUR VEHICLE. WE HAD TO PURCHASE NEW WHEELS AT A COST OF ALMOST $1,300.

NHTSA ID

10761675

Incident

Feb 12, 2015

Mileage

156,300 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE STALLED ALTHOUGH THE FUEL LEVEL WAS AT CAPACITY. THE CONTACT TOOK HIS VEHICLE TO AN INDEPENDENT MECHANIC AND THE DEALER WHO BOTH STATED THAT HAVING LESS THEN 5% BIO DIESEL WOULD CAUSE THE FAILURE TO OCCUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE CURRENT MILEAGE WAS 200,000.

NHTSA ID

10598654

Incident

Jun 16, 2011

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE WIRES THAT WERE CONNECTED TO THE MASTER CYLINDER AND ONTO THE ELECTRICAL CONNECTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 160,000.

NHTSA ID

10555724

Incident

Jun 4, 2013

Mileage

160,000 mi

DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

NHTSA ID

10522341

Incident

Jun 27, 2013

Mileage

247,560 mi

I WAS TRAVELING DOWN THE HIGHWAY AT 60 MILES PER HOUR WHEN I HEARD A LARGE BANG. I STOPPED AND DIDN'T SEE ANYTHING UNTIL I STOPPED FOR GAS. GAS WAS LEAKING OUT THE FILL HOSE AND I LOOKED UNDER THE TRUCK AND THE GAS TANK STRAP HAD BROKE AND THE TANK WAS VERILY HANGING ON. I PURCHASED TWO STRAPS TO HOLD THE TANK IN PLACE UNTIL I COULD GET TO A FORD DEALERSHIP. THIS IS THE SAME PROBLEM THAT FORD RECALLED THE 150 AND 250 MODELS FOR. LUCKILY FOR ME THE TANK DID NOT RUPTURE AND CATCH FIRE. THE 350 NEEDS TO BE RECALLED TO FIX THIS PROBLEM BEFORE SOMEONE IS KILLED. *TR

NHTSA ID

10521716

Incident

Apr 19, 2013

Mileage

175,000 mi

THIS ISSUE WAS ON A 2000 FORD F350 RESCUE TRUCK ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO GARAGE IN KING NC AND $900.00 LATER AFTER NEW FUEL TANK FUEL FILTER AND FUEL PUMP TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

NHTSA ID

10520505

Incident

Jan 14, 2013

Mileage

86,000 mi

THIS ISSUE WAS ON A 2000 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO TABS GARAGE IN KING NC AND $1700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 3 INJECTORS DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

NHTSA ID

10520498

Incident

Jun 8, 2013

Mileage

160,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH AND MAKING A RIGHT HAND TURN, HE LOST CONTROL OF THE VEHICLE CAUSING HIM TO CRASH INTO SOMEONE'S MAILBOX. THE CONTACT STATED THAT THE POWER STEERING BECAME EXTREMELY LOOSE AND THE BRAKES ALSO FAILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS LATER TOWED HOME. THE TOW TRUCK DRIVER INFORMED THE CONTACT THAT THE POWER STEERING HOSE LOOKS AS IF IT FRACTURED, WHICH MAY HAVE POSSIBLY CAUSED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 253,000.

NHTSA ID

10482170

Incident

Oct 24, 2012

Mileage

253,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT ATTEMPTED TO OPEN THE REAR DRIVER AND PASSENGER SIDE DOORS BUT NOTICED THAT THE TOP DOOR LATCH WOULD NOT RELEASE. THE BOTTOM LATCH RELEASED WITHOUT FAILURE. THE CONTACT WAS UNABLE TO OPEN THE REAR DOORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THAT THE DOOR ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

NHTSA ID

10462300

Incident

Apr 15, 2012

Mileage

237,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT THE FRONT PASSENGER WHEEL WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 224,430 AND THE CURRENT MILEAGE 224,455.

NHTSA ID

10462041

Incident

Jun 17, 2012

Mileage

224,430 mi

THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

NHTSA ID

10447480

Incident

Feb 10, 2012

Mileage

156,972 mi

2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

NHTSA ID

10430199

Incident

Oct 14, 2011

TL* THE CONTACT OWNS A 2000 FORD F-350 DIESEL. THE CONTACT NOTICED THERE WAS A EXCESSIVE RUST ON THE FRAME AND THE EXTERIOR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO ADVISED HIM THAT HE NEEDED A FRAME, TRUCK BED, ETC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 118,000. UPDATED 12/05/11

NHTSA ID

10430184

Incident

Sep 15, 2011

Mileage

118,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT HEARD A NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT STOPPED THE VEHICLE TO INSPECT THE NOISE AND NOTICED THAT THE FRONT FUEL TANK STRAP WAS CORRODED AND FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING) THAT AND CONTACTED THE MANUFACTURER BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000. UPDATED 11/03/11*LJ UPDATED 12/02/11

NHTSA ID

10428904

Incident

Oct 2, 2011

Mileage

145,000 mi

TL* THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. THE CONTACT STATED THAT THE CLUTCH ARM BROKE WHILE THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH. THE VEHICLE WAS REPAIRED BY THE CONTACT. THE MANUFACTURER AND DEALER WERE CONTACTED TO REPORT THE FAILURE. THE FAILURE MILEAGE WAS 151,000 AND THE CURRENT MILEAGE WAS 154,000. UPDATED 08/31/11*LJ UPDATED 2/9/12 *CN

NHTSA ID

10403830

Incident

Apr 12, 2011

Mileage

151,000 mi

2000 FORD F350 CREW CAB 4X4 BRAKE LINE WAS CORRODED FROM DIFFERENT METALS USED. HAD HOLE IN LINE AND BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HAVE NO BRAKES. EXTREMELY DANGEROUS!!! *TR

NHTSA ID

10403672

Incident

May 27, 2011

Mileage

174,000 mi

FUEL TANK STRAP HAS BROKEN AGAIN.2ND TIME FOR THE REAR STRAP,FRONT REPLACED 1 TIME. ALSO REPLACED GAS TANK IN 2006 DUE TO LEAK FROM RUSTING AT SEAM,TANK IS STARTING TO LEAK AGAIN. TANK DROPPED TO THE STREET WHEN STRAP GAVE WAY LAST TIME,LUCKILY I WAS GOING SLOW ON A SIDE STREET. SPEAKING WITH OTHER OWNERS OF THESE TRUCKS,F-350 SUPERDUTY 2000 CAB AND CHASSIS MOST ARE HAVING OR HAVE HAD THE SAME ISSUES I AM HAVING. *TR

NHTSA ID

10399900

Incident

Apr 18, 2011

Mileage

120,000 mi

2000 FORD F-350. CONSUMER WRITES IN REGARDS TO FACTORY RECALL, CAM SENSOR/CAM PARTS AND REPLACEMENT *TGW THE CONSUMER STATED WITHIN DAYS OF PURCHASING THE VEHICLE, IT WAS INOPERABLE AS A RESULT DIRECTLY RELATING TO AND STEMMING FROM A SPECIFIC RECALL REGARDING THE CAMSHAFT. FORD SENT THE CONSUMER A RECALL LETTER TWO YEARS LATER. THE CONSUMER ALSO STATED THE VEHICLE HAD AN ELECTRICAL AND FUEL PROBLEM. *JB

NHTSA ID

10383812

Incident

Sep 15, 2008

TL*THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. WHILE CLEANING THE VEHICLE, THE CONTACT NOTICED THAT THE WHEEL HAD CRACKED THROUGH ONE OF THE SPOKES AND IF HE WERE TO LOSE CONTROL OF THE VEHICLE ON THE HIGHWAY, IT WOULD CAUSE A CRASH. THE DEALER WAS NOTIFIED WHO REFERRED HIM TO THE MANUFACTURER. THE MANUFACTURER TOOK A COMPLAINT. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 220,000 AND THE FAILURE MILEAGE WAS 190,000. UPDATED 12/30/11 *CN

NHTSA ID

10379735

Incident

Sep 16, 2008

Mileage

190,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE CAM SHAFT SENSOR WAS REPLACED IN AUGUST 2009 UNDER RECALL CAMPAIGN NUMBER 07V553000, WHICH WAS FOR ENGINE AND ENGINE COOLING. THE CAM SHAFT SENSOR THAT WAS REPLACED IN AUGUST OF 2009 WAS NOT REPLACED BECAUSE IT FAILED; IT WAS REPLACED BECAUSE THE DEALER STATED THAT THE CONTACT HAD TO GET THE NEW CAM SHAFT SENSOR. THE CONTACT HAD THE ORIGINAL CAM SHAFT SENSOR REPLACED SEPTEMBER 2005 AND WAS NOT HAVING ANY PROBLEMS. THE NEW CAM SHAFT SENSOR HAS FAILED IN JUST OVER A YEAR AND LESS THAN 4000 MILES. THE MANUFACTURER STATED THAT THE CAM SHAFT HAS A 12 MONTH 12000 MILE WARRANTY.THE FAILURE MILEAGE WAS 184329 AND THE CURRENT MILEAGE WAS 188600.

NHTSA ID

10357027

Incident

Sep 17, 2010

Mileage

184,329 mi

I HAVE A F-350 CREW CAB SUPERDUTY 2000, ON APRIL 13, 2010 MY TRUCK CUT OFF WITH ME IN THE MIDDLE OF THE ROAD IN WILMINGTON NC, AFTER GETTING THE TRUCK TOW IN TO THE GARAGE, I FOUND THAT THE CONNECT WIRE THAT HOOK UP TO THE HEADS FOR THE GLOW PLUGS IN THE HEAD WAS BARE WIRES THERE FROM THE PLASTIC. I AM WORRY IS THIS THE REASON IT CUT OFF ON ME IN THE MIDDLE OF THE ROAD, CAUSE THEY WAS TOUCHING ONE ANOTHER AND CAUSE THE TRUCK TO STOP RUNNING & WOULD NOT CRANK BACK UP. THE TUBO TUBE RUN WAS BESIDE THIS WIRING THAT HAVE ABOUT 5 OR SIX WIRE COMING OUT OF THE CONNECTION. *TR

NHTSA ID

10326721

Incident

Apr 13, 2010

Mileage

249,329 mi

ONE OF MY SPARK PLUGS SIMPLY BLEW OUT OF THE CYLINDER HEAD OF MY 2000 FORD F350. THESE WERE FACTORY PLUGS, SINCE MY TRUCK HAS LESS THAN 100,000 MILES. I SIMPLY STARTED MY TRUCK IN THE MORNING AND IT BLEW RIGHT AWAY. *TR

NHTSA ID

10324415

Incident

Apr 6, 2010

Mileage

92,000 mi