2000 Ford F-350 Sd Problems

THIS ISSUE WAS ON A 2000 FORD F350 RESCUE TRUCK ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO GARAGE IN KING NC AND $900.00 LATER AFTER NEW FUEL TANK FUEL FILTER AND FUEL PUMP TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

THIS ISSUE WAS ON A 2000 FORD F350 AMBULANCE ON ROUTE TO EMERGENCY CALL WHEN ENGINE SHUT DOWN AND LOST ALL POWER LIKE IT WAS OUT OF FUEL 7.3 LITER DIESEL AND TANK WAS FULL. HAD UNIT TOWED TO TABS GARAGE IN KING NC AND $1700.00 LATER AFTER NEW FUEL TANK FUEL PUMP 3 INJECTORS DUE TO LINER INSIDE OF TANK CAME OFF AND CLOGGED THE FUEL SYSTEM AND ENGINE FORD MOTOR COMPANY WAS NO HELP AND SAID SINCE THE VEHICLE WAS OUT OF WARRANTY THEY WOULD NOT DO ANYTHING TO RESOLVE THE COST ISSUES. *TR

FORD F-350. CONSUMER WRITES IN REGARDS TO VEHICLE TIRE INFLATION PRESSURE PROBLEMS. *SMD THE CONSUMER STATED THE TIRE WAS INFLATED TO 55 PSI TO SOFTEN THE RIDE. LATER, WHILE HAULING TRACTOR THE TREAD ON ONE OF THE TIRES PEELED OFF. THE CONSUMER PUT THE SPARE ON THE TRUCK. THE CONSUMER WAS ADVISED TO RUN THE TIRES AT THE MAXIMUM INFLATION PRESSURE FOR THE BEST WEAR, MAXIMUM LOAD CAPACITY, BEST MILEAGE AND LONGEST LIFE. EACH OF THE TIRES EVENTUALLY FAILED ONE AT A TIME. WHEN THE CONSUMER PURCHASED NEW TIRES, THEY WERE INFLATED 60 PSI FOR THE FRONT AND 50 PSI FOR THE REAR, INSTEAD OF 80 PSI. EVERYTHING WAS FINE FOR A WHILE, UNTIL THE CONSUMER STARTED TO EXPERIENCE ROUGH RIDING AND NOISY TIRES AS A RESULT OF IMPROPER INFLATION. THE RETAILER STATED THE INFLATED THE TIRES ACCORDING TO WHAT WAS PRINTED ON THE DOOR STICKER. THE UNDER INFLATION CAUSED EXCESSIVE SIDEWALL FLEX, REDUCED MILEAGE, SHORTENED LIFE AND SEVERAL TIRE FAILURES. *JB *CN

TL*THE CONTACT OWNS A 2000 FORD F350 SUPER DUTY. ON TWO SEPARATE OCCASIONS, WHILE DRIVING APPROXIMATELY 60 MPH, THE CABLE THAT HOLDS THE SPARE TIRE FAILED AND THE ENTIRE SPARE TIRE CABLE SUPPORT MOUNT HAD TO BE REPLACED. THE CURRENT MILEAGE WAS 700,095 AND FAILURE MILEAGE WAS 500,050.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20 MPH AND MAKING A RIGHT HAND TURN, HE LOST CONTROL OF THE VEHICLE CAUSING HIM TO CRASH INTO SOMEONE'S MAILBOX. THE CONTACT STATED THAT THE POWER STEERING BECAME EXTREMELY LOOSE AND THE BRAKES ALSO FAILED. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS LATER TOWED HOME. THE TOW TRUCK DRIVER INFORMED THE CONTACT THAT THE POWER STEERING HOSE LOOKS AS IF IT FRACTURED, WHICH MAY HAVE POSSIBLY CAUSED THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 253,000.

LOSS OF POWER STEERING AND POWER BRAKING MAKING DRIVING VERY DIFFICULT AND EXTREMELY DANGEROUS. *TR

2000 FORD F350 CREW CAB 4X4 BRAKE LINE WAS CORRODED FROM DIFFERENT METALS USED. HAD HOLE IN LINE AND BRAKE PEDAL WENT TO THE FLOOR CAUSING ME TO HAVE NO BRAKES. EXTREMELY DANGEROUS!!! *TR

BRAKE LINE FAILURE ON MAIN LINE FROM MASTER CYLINDER TO REAR AXLE. RELEASED FLUID ON GROUND AND IN AIR, BASICALLY NO BRAKES WHEN THIS HAPPENED' LINE WAS CORRODED RIGHT WHERE STAINLESS LINE CHANGES TO METAL SOME SORT OF DISSIMILAR METAL CORROSION GOING ON MANY CASES ON LINE ABOUT THESE TRUCKS AND BRAKE LINES.

THE SPARK PLUG LOCATED AT THE REAR OF THE RIGHT CYLINDER BANK OF A 6.8 LITER GASOLINE ENGINE WAS EJECTED. THE SPARK PLUGS IN THIS ENGINE HAVE NEVER BEEN CHANGED TO MY KNOWLEDGE SO THIS IS NOT A RESULT OF IMPROPER TORQUING PROCEDURES. THE ENGINE HAD BEEN OPERATING PROPERLY AND VERY SELDOM HAS GONE OVER 70 MPH. ACCELERATION AT THE TIME OF FAILURE WAS LIGHT AND THE VEHICLE WAS NOT TOWING. NO FIRE ENSUED ALTHOUGH THERE WAS A FAINT GASOLINE ODOR UNDER THE HOOD RIGHT AFTER I SHUT THE ENGINE DOWN. THE FAILURE WAS OBVIOUS BECAUSE THE SPARK PLUG AND ATTACHED COIL PACK WAS LYING ON TOP OF THE CYLINDER HEAD. THE FORD DEALER ACKNOWLEDGED THAT THIS HAS BEEN A PROBLEM IN THESE ENGINES. *TR

2000 FORD F-350. CONSUMER WRITES IN REGARDS TO FACTORY RECALL, CAM SENSOR/CAM PARTS AND REPLACEMENT *TGW THE CONSUMER STATED WITHIN DAYS OF PURCHASING THE VEHICLE, IT WAS INOPERABLE AS A RESULT DIRECTLY RELATING TO AND STEMMING FROM A SPECIFIC RECALL REGARDING THE CAMSHAFT. FORD SENT THE CONSUMER A RECALL LETTER TWO YEARS LATER. THE CONSUMER ALSO STATED THE VEHICLE HAD AN ELECTRICAL AND FUEL PROBLEM. *JB

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT LOCATED UNDER THE FUEL FILTER, THE O-RING AND THE DRAIN LINE FAILED ON MORE THAN ONE OCCASION. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN TWICE AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE DRAIN LINE AND INDICATED THAT THERE WAS TOO MUCH PRESSURE FLOWING INTO THE FUEL FILTER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000. UPDATED 05/10/16*LJ UPDATED 11/3/2017*JS

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE STALLED ALTHOUGH THE FUEL LEVEL WAS AT CAPACITY. THE CONTACT TOOK HIS VEHICLE TO AN INDEPENDENT MECHANIC AND THE DEALER WHO BOTH STATED THAT HAVING LESS THEN 5% BIO DIESEL WOULD CAUSE THE FAILURE TO OCCUR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 130,000. THE CURRENT MILEAGE WAS 200,000.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE WIRES THAT WERE CONNECTED TO THE MASTER CYLINDER AND ONTO THE ELECTRICAL CONNECTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) BUT WAS ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 160,000.

TL*THE CONTACT OWNS A 2000 FORD F350 SD. SHE STATED THAT SHE RECEIVED FORD RECALL NOTICE THE FIRST WEEK IN NOVEMBER OF 2009 AND THE DEALER WAS NOT ABLE TO GIVE HER AN APPOINTMENT UNTIL JANUARY 15 2010. THE DEALER ADVISED HER TO PARK THE VEHICLE OUTSIDE SINCE A FIRE COULD OCCUR. SHE STATED THAT THE REPAIR EXCEEDED A REASONABLE TIME. THE CURRENT MILEAGE WAS 160,000. UPDATED 02/1710 *BF UPDATED 02/19/10.*JB

AS WE WERE RETURNING HOME FROM A ROAD TRIP, WE HEARD A SCREECHING NOISE COMING FROM THE LEFT WHEEL WELL AREA WHEN WE MADE WIDE SWEEPING TURNS AND HIGHWAY CURVES. WE PULLED OVER AND, UPON INSPECTION, SAW OUR ORIGINAL ALLOY WHEEL ON OUR TRUCK WAS CRACKED. ONE OF THE WHEELS WAS DANGEROUSLY CLOSE TO COMING OFF THE HUB. PHOTOS DOCUMENT HOW SEVERE THE CRACKING OF THE WHEELS WAS - THREE OF FOUR WHEELS WERE FOUND TO HAVE CRACKS AND CHUCKS OF METAL MISSING,COMPROMISING THE INTEGRITY OF THE WHEELS AND THE SAFETY OF OUR VEHICLE. WE HAD TO PURCHASE NEW WHEELS AT A COST OF ALMOST $1,300.

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT STATED THAT THE FRONT PASSENGER WHEEL WAS CRACKED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 224,430 AND THE CURRENT MILEAGE 224,455.

2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

LEAF SPRINGS BROKE WHILE HAULING LOADS. PULLING A 16 FEET TRAILER WITH ONE SMALL MINI PONY SPRING BROKE, CAUSES SWAYING IN DECEMBER 2006. PULLING 28 FEET TRAILER ON INTERSTATE IN JANUARY 2006 HAD SAME THING HAPPEN. NOW THE 3RD EVENT USING 30 FEET HORSE TRAILER TAKING 6 HORSES TO FARRIER HAD SAME PROBLEM. COULD CAUSE SERIOUS ACCIDENT BY FORCING VEHICLE OFF ROAD WHILE TOWING.*AK

TL* THE CONTACT OWNS A 2000 FORD F-350 SD. THE CONTACT ATTEMPTED TO OPEN THE REAR DRIVER AND PASSENGER SIDE DOORS BUT NOTICED THAT THE TOP DOOR LATCH WOULD NOT RELEASE. THE BOTTOM LATCH RELEASED WITHOUT FAILURE. THE CONTACT WAS UNABLE TO OPEN THE REAR DOORS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTICS. THE TECHNICIAN ADVISED THAT THE DOOR ASSEMBLY WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 237,000.

2000 F350 RUST : 8 FT. BED, RAILS UNDER BED, CAB RUST, CROSS MEMBER UNDER BED FROM RIGHT FRAME TO LEFT FRAME, RUNNING BOARDS. REPLACED OIL PAN BECAUSE OF RUST YEARS EARLIER. *TR

MANUAL TRANSMISSION KEEPING HANGING UP AND IS HARD SHIFTING INTO GEARS

DRIVING DOWN THE ROAD THE OTHER DAY IN ARE 2000 F-350 7.3 DIESEL REG CAB CHASSIS TRUCK PULLING 25,000 LB GOOSENECK TRAILER WAS DIS ENGAGING THE CLUTCH WHEN THE CLUTCH ASSEMBLY BROKE THE BUSHINGS WENT OUT AND BROKE LEAVING THE CLUTCH USELESS DRIVING IN BUSY TRAFFIC CLUTCH STAYED STICKING CAUSED A FIRE UNDER VEHICLE. *TR

2000 FORD F 350. CLUTCH WILL NOT DISENGAGE DRIVELINE WHEN DEPRESSED. 2 ND FAILURE OF SUCH NATURE. VEHICLE WILL KEEP ROLLING IN CURRENT GEAR AND SPEED WHEN CLUTCH IS DISENGAGED. CAN DO NOTHING BUT STALL THE ENGINE BY HARD BRAKING OR TURNING OFF THE KEY BOTH CREATE OTHER DANGERS. FIRST FAILURE HAPPENED AT 38K MILES SECOND AT 52K. PAID FOR FIRST REPAIR OUT OF POCKET- SAID TO BE THE CLUTCH MASTER CYLINDER BOOT RIPPING WHILE UNDER PRESSURE. SEEKING FORD TO FIX THIS TIME. FORD DEALERSHIPS IN NORFOLK VA AND KNOXVILLE TN DENY THAT THIS IS A SAFETY ISSUE. I DO NOT UNDERSTAND THEIR LOGIC. *AK

CLUTCH RELEASE BEARING (THROW OUT BEARING) ACTUATOR ARM FAILURE RESULTING IN MOVEMENT OF VEHICLE WHILE CLUTCH PEDAL IS DEPRESSED THIS IS THE SECOND FAILURE OF THE SUBJECT PART IN THE LIFE OF THIS SERIAL NUMBER TRUCK. THE FIRST OCCURRED AT APX. 37,000 MILES; THE SECOND AT APX. 95,000 MILES. BOTH REPAIRS WERE COMPLETED USING OEM PARTS. I AM IN POSSESSION OF THE SECOND FAILED PART AND WILL MAKE IT AVAILABLE FOR INSPECTION UPON REQUEST. THIS FAILURE IS A MAJOR SAFETY ISSUE AS THE POWER TRAIN CAN NOT BE INTERRUPTED BY NORMAL MEANS. THAT IS, ONE NORMALLY DEPRESSES THE CLUTCH PEDAL TO INTERRUPT POWER TRANSMISSION AND APPLIES BRAKE ACTION TO STOP THE VEHICLE. WHEN THE SUBJECT ARM FAILS, ONE DEPRESSES THE CLUTCH PEDAL AND THE VEHICLE CONTINUES MOVEMENT, CAUSING AN INHERENT REACTION DELAY TO ASSES THE ABNORMALITY, SUBSEQUENTLY FOLLOWED BY APPLICATION OF BRAKE PRESSURE TO STOP THE VEHICLE, CAUSING A SIGNIFICANT BIND IN THE TRANSMISSION, RESULTING IN THE INABILITY TO MOVE THE TRANSMISSION SHIFTER OUT OF GEAR, THEN ONE MUST EITHER TURN OFF THE IGNITION OR APPLY BRAKE PRESSURE OF SUFFICIENT FORCE TO STALL THE ENGINE; ALL OF WHICH HAS CONSUMED AND EXCEEDED A REASONABLY PLANNED STOPPING DISTANCE. THE RESULTING DELAY MAY RESULT IN INJURY OR DEATH OF BY STANDERS, SHOULD THEY BE PINCHED BETWEEN THE FAILURE VEHICLE AND A STATIONARY OBJECT. THE OPERATING NATURE OF A TRUCK OF THIS DESIGN INCREASES THE RISK OF INJURY OR DEATH, FOLLOWING THE DESCRIBED FAILURE. THE MANUFACTURER MARKETS THIS TRUCK TO COMMERCIAL OPERATORS AND ONE WILL ROUTINELY FIND THE VEHICLE EMPLOYED ON WORK SITES AND SIMILARLY CONGESTED AREAS. THIS FAILURE LEAVES THE TRUSTING AND CAPABLE OPERATORS OF THIS VEHICLE AND UNSUSPECTING BY-STANDERS AT RISK OF INJURY OR DEATH; WHILE AT PLAY OR ON THE WORK PLACE.

DRIVERS SEAT BELT WOULD NOT LATCH CORRECTLY. *TR

I HAVE A 2000 FORD F350 PSD 4X4 THAT HAS BEEN HAVING MORE AND MORE PROBLEMS RECENTLY WITH THE DOOR AJAR FUNCTION. IN WARMER WEATHER ONE OR MORE OF THE DOOR CLOSED SWITCH SENSORS IS MALFUNCTIONING SHOW THE DOOR OPEN WHEN THEY ARE ALL CLOSED. I HAVE TRIED OPENING AND CLOSING ALL DOORS REPEATEDLY BUT NO IMPORVEMENT. LATELY IT HAS BEEN HAPPENING MORE AND WITH COOLER TEMPS AS WELL. I TALKED TO THE FORD DEALER HERE IN TOWN AND THEY SAID THEY HAD HEARD OF THIS AND TOLD ME TO TRY WD40 AS A FIX BY SPRAYING IT INTO THE DOOR CLOSER WHERE THE SWITCH IS BURIED. NO LUCK. THIS MAY NOT SOUND TO BAD OF A PROBLEM, HOWEVER THE RESULTS OF THE TRUCK THINKING THE DOOR IS OPEN IS NOT GOOD. IF THE TRUCK IS RUNNING, THE INTERIOR LIGHTS STAY ON UNTIL A SPEED OF 15MPH OR MORE IS HIT, THEREBY AUTO SHUTTING OFF THE INTERIOR LIGHTS. HOWEVER AS SPEED DECREASES AND GOES BELOW THE 15MPH THE LIGHTS TURN BACK ON. IT MAKES IT VERY DIFFICULT TO SEE AT NIGHT DRIVING FORWARD AND ALMOST IMPOSSIBLE TO BACK UP. THE OTHER CONCERN IS AFTER THE TRUCK IS SHUT OFF, THE INTERIOR LIGHTS STAY ON UNTIL THE SWITCH RELEASES OR A SELF TIMER SHUTS OFF THE LIGHTS. THIS HAS CAUSED A SLIGHT DRAIN IN BATTERY, MAKING IT SLIGHTLY DIFFICULT AT TIMES TO START A TRUCK WHICH NEEDS ALL THE JUICE IT CAN GET TO TURN OVER. I HAVE SEEN THIS DEFECT IN THE DOOR CLOSURE SWITCH HAPPEN IN AN OLD WORK TRUCK I USED TO DRIVE (99 FORD F150). I WOULD LIKE TO INSTALL A SECURITY DEVICE IN THE FUTURE, HOWEVER IF THE DOOR REMAIN AJAR, THIS COULD POSE TO BE A PROBLEM TO THE FUNCTIONALITY OF SUCH A DEVICE. ANY HELP WOULD BE APPRECIATED IN SEEING IF THIS IS A REGULAR PROBLEM OR A SAFETY CONCERN. THANKS, PAUL. *AK

RECALL ALREADY DONE ON OCTOBER 29, 2002 FOR WIPER MOTOR. ON NOVEMBER 12, 2004 I STARTED THE TRUCK UP AND A MINUTES LATER I LOOKED AND SAW SMOKE COMING FROM THE UNDERNEATH THE HOOD AND THE WIPERS RUNNING ALL BY THEMSELVES IN THE PARKED POSITION, THE WIPER MOTOR MALFUNCTIONED AGAIN. IT WAS TOWED TO THE DEALERSHIP AFTER CALLING THEM. TOTAL REPLACEMENT COVERAGE IS UNKNOWN AND DAMAGE IS UNKNOWN AT THIS TIME. *JB