2006 Ford F-350 Sd Fuel system Problems

THERE IS A PROBLEM WITH THE INSTRUMENT CLUSTER AND THE PLUGS. THE DASH GOES DEAD, INTERIOR LIGHTS DONT WORK. POWER WINDOWS DONT WORK RADIO SHUTS OFF. VEHICLE RUNS IMPROPERLY. THE VEHICLE CAN BE SITTING OR MOVING. I HAVE DONE RESEARCH AND FOUND FORD TRUCKS FROM AS EARLY AS 2002-2008 HAVE THIS ISSUE. ITS UNSAFEAND A KNOW ISSUEWITH THESE YEAR FORD TRUCK F150-F450. A NEW DASH IS VERY EXPENSIVE AND USED ONES RUN THE RISK OF THE SAME ISSUE HAPPENING AGAIN. THE FIX IS SIMPLE, THE COST IS NOT. THERES VIDEOS ON YOU TUBE DOZENS OF FORUMS. EXCURSION EXPEDITIONS ARE ALSO HAVING THE SAME ISSUE. IM N THE MID WEST ITS COLD. I DROVE TO PICK UP A COIPLE ATVS AN HOUR NORTH. HALFWAY BACK ISSUES HAPPENED WHILE WINDOW WAS DOWN. DROVE HOME PREG FIANCE 5YR OLD IN THE BACK -3 OUTSIDE-15 WINDCHILL N WE'RE DRIVE 65MPH TO GET HOME. THAT WAS MISSERABLE.

NHTSA ID

11063262

Incident

Jan 2, 2017

Mileage

320,000 mi

THIS VEHICLES ISSUES BEGAN WITH THE GALVANIZING OF THE INTERIOR OF THE FUEL TANK FLAKING OFF AND GETTING INTO THE FUEL SYSTEM. IT IS A DIESEL. IT HAS BEEN TO THE SHOP TO HAVE THE FUEL TANK REPLACED, INJECTORS REPLACED, HIGH PRESSURE FUEL PUMP REPLACED TO NAME A FEW. ALL AFTER THE FUEL TANK PROBLEM. SINCE THEN THE VEHICLE HAS SHUT DOWN A NUMBER OF TIMES WHILE ON THE HIGHWAY. THIS IS EXTREMELY HAZARDOUS TO LOSE ALL POWER. FORTUNATELY OUR DRIVERS HAVE BEEN ABLE TO MANEUVER IT OFF THE HIGHWAY BEFORE CAUSING AN ACCIDENT. FORD HAS DENIED HAVING A PROBLEM WITH THEIR FUEL TANKS; HOWEVER, WHEN WE CHECKED AROUND WE FOUND IT TO BE QUITE COMMON. IN FACT WE HAD A DIFFICULT TIME SECURING A NEW TANK BECAUSE THERE WERE SO MANY REPLACEMENTS BEING DONE. I BELIEVE FORD SHOULD STEP FORWARD AND ADMIT THERE IS AN ISSUE AND DEAL WITH IT. WE DISCUSSED THIS WITH A ZONE MANAGER AND GOT NOWHERE.

NHTSA ID

10762617

Incident

Mar 2, 2015

Mileage

30,100 mi

PURCHASED THIS VEHICLE LESS THAN A YEAR AGO AND WAS ORIGINALLY VERY PLEASED. SUDDENLY WE ARE NOW EXPERIENCING THE DEATH WOBBLE AS OTHER HAVE DESCRIBED. THE VIOLENT SHAKING OF THE FRONT END. THIS USUALLY OCCURS WHEN YOU ARE APPROACHING THE SPEED OF 60MPH. WE DO NOT HAVE TO HIT A BUMP FOR IT TO HAPPEN. THE OTHER COMPLAINT, IS THAT WE BOUGHT THIS TRUCK WITH VERY LOW MILEAGE FOR THE YEAR, RAN GREAT, LOOKED GREAT, VERY PLEASED UNTIL THIS LAST MONTH WHEN THE CHECK ENGINE LIGHT CAME ON AND IT SEEMS TO SPUTTER. PUT SOME HIGH QUALITY FUEL INJECTOR CLEANER IN THE TRUCK, THINKING IT MAY BE A INJECTOR STICKING. NOPE, DIDN'T FIX THE PROBLEM. LIGHT NEVER WENT OFF. TOOK IT TO A DEALERSHIP, THEY TESTED IT AND CAME BACK WITH YOUR FUEL TANK IS DETERIORATING PUTTING LITTLE METAL SHARDS IN YOUR ENGINE. YOU ARE LOOKING AT A POTENTIAL FULL ENGINE REBUILD COSTING A MINIMUM OF $6000. THIS IS UNACCEPTABLE FOR ANY VEHICLE MANUFACTURER TO NOT RECALL A VEHICLE THAT HAS A SERIOUS KNOWN PROBLEM. WE ARE STUCK WITH THIS TRUCK THAT IS NOT WORTH THE [XXX] PAPER THE TITLE IS WRITTEN ON. IT IS TIRING OF READING ALL THESE SIMILAR COMPLAINTS AND NO ONE IS DEFENDING THE CONSUMERS. AT WHAT POINT, DOES THE MANUFACTURER NEED TO BE HELD RESPONSIBLE TO OWN UP TO THE FAULTY EQUIPMENT AND FIX THE PROBLEMS? WHEN MY CHILD IS KILLED BECAUSE OF THE INABILITY TO CONTROL THE VEHICLE DUE TO THE STEERING PROBLEMS IN THE FRONT END OR THAT IT STOPS RUNNING IN THE MIDDLE OF THE HIGHWAY OR DOWNTOWN TRAFFIC BECAUSE THE FUEL TANK DETERIORATED FOR NO REASON AND DESTROYED THE ENGINE. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10703474

Incident

Apr 3, 2015

Mileage

75,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE DECELERATED AND FAILED TO RESPOND WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN SOME INSTANCES, THE VEHICLE STALLED AND THE POWER STEERING AND BRAKES MALFUNCTIONED. THE DEALER STATED THAT THE FUEL INJECTORS WERE FAULTY. THE FUEL INJECTORS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 102,000.

NHTSA ID

10610472

Incident

Dec 2, 2013

Mileage

102,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. THE CONTACT WAS TRAVELING 55 MPH WHEN THE VEHICLE DECELERATED INDEPENDENTLY, DESPITE THE ACCELERATOR PEDAL BEING DEPRESSED. THE VEHICLE WAS TOWED TO THE DEALER WHO CONFIRMED THAT THE FUEL TANK, FUEL PUMP AND FUEL INJECTOR UNIT NEEDED REPLACING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 23,000. ..UPDATED 11/14/12 *BF UPDATED 11/15/2012 *JS

NHTSA ID

10478200

Incident

Sep 28, 2012

Mileage

23,000 mi

WAS DRIVING ON A HEAVY TRAFFIC HIGHWAY, IN THE MIDDLE LANE, AND TRUCK JUST QUIT RUNNING. THIS IS UNJUSTIFIABLE!! OVER $5000.00 IN REPAIRS TO GET TO GET THIS TRUCK TO RUN! WHY HASN'T FORD ISSUED A RECALL ON THIS NOTORIOUS PROBLEM ON THESE DIESEL ENGINES?! I WILL CONTINUE TO PURSUE A CLASS ACT LAWSUIT OVER THIS, I DO BELIEVE THERE ARE ENOUGH FORD OWNERS VERY UNHAPPY REGARDING THESE CONTINUING ISSUES.

NHTSA ID

10477501

Incident

Aug 17, 2012

Mileage

61,547 mi

TL* THE CONTACT OWNS A 2006 FORD F-350 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT VARIOUS SPEEDS ON FIVE SEPARATE OCCASIONS. THE CONTACT ALSO STATED THAT THE FAILURE WAS DUE TO THE DELAMINATION OF THE FUEL TANK, WHICH CREATED A FLAKY SUBSTANCE WITHIN THE FUEL TANK. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS INFORMED THAT THE FUEL TANK WAS DELAMINATING. THE CONTACT REPLACED THE FUEL FILTER HIMSELF AFTER THE FIVE SEPARATE FAILURES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 9,000. UPDATED 02/15/12*LJ UPDATED 04/26/12

NHTSA ID

10445232

Incident

Jan 13, 2007

Mileage

9,000 mi

TL* THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING 30 MPH, THE VEHICLE BEGAN LOSING POWER. THE DEALER DIAGNOSED THAT THE INNER LINING OF THE FUEL TANK WAS RUSTED AND FOUR INJECTORS WERE DAMAGED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 56,000.

NHTSA ID

10428987

Incident

Oct 6, 2011

Mileage

56,000 mi

I HAVE A 6.0 MOTOR IN MY TRUCK. SINCE LAST OCT, 2010 I HAVE HAD THIS TRUCK IN SHOP MORE TIMES THEN WHAT IT IS WORTH. I HAVE HAD FIVE FUEL INJECTORS REPLACE, HEAD GASKETS, ONE HEAD, REAR END REPLACE AND NOW MY TURBO IS GOING OUT ON THIS MOTOR. I ALSO HAD THE TOW BOX REPLACE. THIS TRUCK HAS COST ME MORE THEN WHAT IT IS WORTH. I AM VERY UPSET WITH THIS KNOWING THAT FORD WAS A GOOD TRUCK MADE IN AMERICA., THE TOTAL COST FOR ALL MY PROBLEMS ENDED UP TO BE $18000.00 THIS IS NOT RIGHT>>>>>>>>>>>>>>>>THE TRUCK NOT WORTH THIS MY MILEAGE IS ONLY 184XXX AND HOURS ARE 4861.9 I FEEL LIKE I GOT SUCK IN A LEMON FROM THE FACTORY. NEVER RECEIVE ANY INFORMATION ON THIS TRUCK IF THEIR WERE PROBLEMS.. WHERE I LIVE THERE ARE ABOUT 200 OR MORE PEOPLE WITH THE SAME PROBLEMS. *TR

NHTSA ID

10428220

Incident

Oct 11, 2010

Mileage

64,000 mi

TL* THE CONTACT OWNS A 2006 FORD F350. THE CONTACT STATED THAT THE VEHICLE SUDDENLY LOST POWER AND WOULD NOT ACCELERATE OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE FUEL TANK LINER, CAUSING THE FILTER AND FUEL LINES TO BECOME CLOGGED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 38,000.

NHTSA ID

10408608

Incident

Jun 17, 2011

Mileage

38,000 mi

THE CONTACT OWNS A 2006 FORD F-350 DIESEL. THE VEHICLE AT IDLE OR DRIVING DOWN THE ROAD WILL WITHOUT NOTICE BEGIN TO BUCK, AND SUDDENLY INCREASE RPM'S AND ACCELERATE,OR WILL STALL. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REPLACED THE ERG VALVE. THAT CORRECTED IT FOR ABOUT 30 DAYS AND THEN IT STARTED IT AGAIN. I TOOK IT BACK AND THEY TOLD ME I WOULD HAVE TO REPLACE THE MANIFOLD NEXT, BECAUSE THE CARBON THAT HAD BUILT UP IN THE MANIFOLD. AFTER A LENGTHY DISCUSSION THEY ADMITTED THAT THIS IS A SERIOUS PROBLEM WITH THIS ENGINE. THE FORD ENGINEERS TOLD THEM THAT THIS ENGINE WAS DESIGNED BY INTERNATIONAL FOR THE EUROPEAN MARKET AND THEIR DIESEL FUEL IS MORE REFINED THAN OURS, STATING THAT IS WHAT IS CAUSING THE PROBLEM. FORD REFUSES TO STAND BEHIND THE PROBLEM. JUST LOOK AT THE INTERNET ABOUT THE 6.0 DIESEL ENGINE AND THERE IS PAGE AFTER PAGE STATING THE SAME PROBLEMS. AT THIS POINT I HAVE NOT CORRECTED THE PROBLEM, I AM STILL TRYING TO DECIDE HOW I SHALL PROCEED. THE VEHICLE HAS 96,000 MILES. I HAVE ONLY USED EXXON OR SHELL FUEL. *TR

NHTSA ID

10406018

Incident

Dec 2, 2010

Mileage

96,000 mi

2006 FORD F-350 SUPER DUTY DIESEL DUMP TRUCK. THIS TRUCK HAS BEEN TO CROWLEY FORD IN PLAINVILLE CT. OVER 50 TIMES , YES THAT'S RIGHT I SAID 50. THE TRUCK HAS BEEN TOWED IN NO LESS THAN 6 TIMES IN 4 YEARS. MANY TIMES LEAVING A CREW OF 5 STRANDED ON THE SIDE OF A HIGHWAY. FORD TECHNICIANS HAVE NOT BEEN ABLE TO DETERMINE WHAT IS WRONG WITH THE VEHICLE. TRUCK WILL SUDDENLY LOOSE POWER OR JUST SHUT OFF. FORD HAS DENIED THAT THERE IS ANYTHING WRONG WITH THIS PARTICULAR TRUCK AND MOTOR BUT THERE ARE MANY CONTRACTORS IN OUR AREA THAT ARE HAVING THE SAME PROBLEM. RECENTLY THE TRUCK SAT AT CROWLEY FORD FROM MARCH 1 THROUGH THE END OF MARCH, THEIR TECH'S NOR FORDS TECH'S COULD FIGURE OUT WHAT WAS WRONG WITH IT. THEY ARE STILL DENYING THAT THE GAS TANK DELAMINATION HAS ANY BEARING ON THE SITUATION. COMPLETELY DISGUSTED WITH FORD AND THEIR LACK OF ATTENTION. I ASSUME ITS GOING TO TAKE A FATALITY OR TWO BEFORE THE PRESS PICKS UP ON THIS STORY AND FINALLY HOLDS FORD ACCOUNTABLE. IN THE MEAN TIME SMALL CONTRACTORS AND TRUCK OWNERS ARE TAKING IT IN THE WALLET BECAUSE FORD WILL NOT ACKNOWLEDGE THIS PROBLEM. PLEASE HELP US OUT HERE!!! *TR

NHTSA ID

10402237

Incident

Mar 1, 2011

Mileage

10 mi

WE OWN A FORD F-350 DIESEL PICKUP. IT IS A 2006, PURCHASED NEW. IT HAS HAD REPEATED POWER FAILURE IN THE LAST TWO AND HALF YEARS, WITH OTHER SIMILAR PROBLEMS BEFORE THAT. MOST RECENTLY WE HAD IT TOWED TO OUR DEALERSHIP TO THE TUNE OF $2500.00 REPAIR FOR FUEL INJECTORS AND FUEL INJECTOR MODULES. THE PROBLEM, IS SAFETY FOR OUR LIVES AND POSSIBLY OTHERS IN OUR PATH. THE VEHICLE HAS RECURRING ENGINE FAILURE CAUSING IT TO DIE WHILE DRIVING. THIS HAS HAPPENED NOT ONLY AT A STOP LIGHT, BUT THROUGH INTERSECTIONS, AND ON STRAIGHT ROADS. WE MOST RECENTLY HAD IT DIE TWICE WHILE PULLING 2 HORSES IN A TRAILER. QUICKLY SHIFTING INTO NEUTRAL TO RESTART TO AVOID AN ACCIDENT. IT HAD TO BE TOWED TO OUR HOME JUST LAST THURSDAY APRIL 14TH DUE TO NOT RESTARTING. TODAY, APRIL 18TH, WE TOOK THIS TRUCK TO OUR LOCAL FORD DEALERSHIP AS WAS RECOMMENDED BY FORD MOTOR CO. APPARENTLY THERE IS AN ISSUE WITH THESE TRUCKS HAVING ENGINE/POWER FAILURE AND OTHER THINGS ASSOCIATED WITH THE INTERNATIONAL PARTS THAT WERE USED FOR THIS YEAR TRUCK. WE ARE RETIRED, TRYING TO RUN A BUSINESS WHICH DEPENDS ON THIS PICKUP. WE ARE FEARFUL OF THIS HAPPENING WHILE DRIVING ON A HIGHWAY, THROUGH AN INTERSECTIONS, OR COMING TO A STOP AND LOSING POSER. OUR LIVES ARE AT STACK AND THOSE AROUND US. OUR WARRANTY IS UP ON THE TRUCK. THE LAST TIME IS WAS JUST OUT OF WARRANTY ONE MONTH. NO ONE FROM FORD EVER MENTIONED RENEWING OUR WARRANTY AT ANY TIME EITHER. WE WOULD LIKE TO SEE THIS ADDRESSED AS THERE ARE THOUSANDS OUT THERE HAVING SIMILAR ISSUES. IT IS NOT JUST A "LEMON", IT IS AN ERROR MADE THAT SHOULD BE RECALLED. *TR

NHTSA ID

10396672

Incident

Apr 14, 2011

Mileage

92,482 mi

TL*THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING 50 MPH THE VEHICLE STALLED. AFTER THREE ATTEMPTS THE VEHICLE WOULD NOT START. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE DIESEL FUEL TANK WAS CONTAMINATED AND THE COATING INSIDE THE TANK CAME APART. THEY WILL NOT REPAIR THE FAILURE UNDER WARRANTY BECAUSE HE USED THE WRONG DIESEL FUEL. THE CONTACT WILL BE RESPONSIBLE FOR THE REPAIR COST OF $7,000. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 11,000.

NHTSA ID

10376475

Incident

Jan 12, 2011

Mileage

11,000 mi

ON 2006 FORD F350 VEHICLE WITH 6.0 DIESEL , THE EGR COOLERS HAVE DEFECT THAT CAUSE THEM TO LEAK. AFTER READING INTO THIS IT IS A COMMON ISSUE. I TOOK THE TRUCK TO FORD AND THEY STATED IT IS A VERY COMMON PROBLEM AND THAT I SHOULD LOOK INTO AN AFTERMARKET COOLER SINCE THE OEM UNIT FAILS QUITE OFTEN TO THE FREQUENCY OF 2 TO 3 WITHIN 100,000 MILES. THIS REPAIR IS APPROX. 1000 TO 2000 DEPENDING ON IF THE HEAD GASKETS HAVE BEEN SUBSEQUENTLY DAMAGED AS WELL. IN MY CASE I HAD TO REPLACE THE OIL COOLER ALONG WITH EGR COOLER AN EGR VALVE AND HEAD GASKET. MY TOTAL BILL WAS $2095.63 FORD STATED IT IS A VERY COMMON PROBLEM AND HAS TSB,S ON THIS BUT HAS NO PLANS FOR A VOLUNTARY RECALL. THEY DID STATE THAT THEY WILL ONLY COMPENSATE IF INSTRUCTED TO DUE TO A RECALL. THESE ISSUES IF RESEARCHED ONLINE ARE MORE COMMON THEN PEOPLE NEEDING ANY OTHER PARTS ON THIS VEHICLE. WHEN THESE COOLERS FAIL THE EGR GET WET AND DOES NOT FUNCTION. THIS CAN HAPPEN AT HIGHWAY SPEEDS WITH CAN MAKE YOU LOOSE POWER THUS LOOSING HYDROBOOST FOR BRAKING AND STEERING. *TR

NHTSA ID

10301990

Incident

Jan 10, 2010

Mileage

160,000 mi

ENGINE FILTERS GET CLOGGED UP AND CAUSE THE TRUCK TO RUN ERRATICALLY AND STALL, CAUSED FROM DEBRIS FROM A FAULTY FUEL TANK. *TR

NHTSA ID

10282524

Incident

Aug 31, 2009

Mileage

83,506 mi

FUEL TANK DELAMINATED CAUSING ENGINE STUTTER OR COMPLETE SHUT OFF. FUEL TANK REPLACED BY FORD UNDER WARRANTY. HAD VEHICLE IN FOR SERVICE/ REPAIR AND WAS TOLD THAT THERE WAS PROBLEMS WITH NEW TANK BUT THAT IT WAS NOT COVERED UNDER WARRANTY. *TR

NHTSA ID

10241368

Incident

Sep 8, 2008

Mileage

36,300 mi

2006 FORD F350 DIESEL: STARTS HARD, EVEN IN WARM WEATHER. ALMOST IMPOSSIBLE TO START DURING COLDER WEATHER. TRUCK SOMETIMES STALLS WHILE DRIVING - PROBLEM WITH FUEL INJECTION. *TR

NHTSA ID

10201978

Incident

Sep 3, 2007

2006 FORD F350 THE CONTACT CONTINUOUSLY EXPERIENCE SEVERE LOSS OF POWER. CONTACT HAS TWO EXACT VEHICLES. CONTACT HAS FILED A COMPLIANT ON FILE. *MC THE CONSUMER STATED THE MANUFACTURER REFUSED TO ACKNOWLEDGE THERE WAS A PROBLEM WITH THE INJECTORS AND FUEL PUMP. UPDATED 02/27/07. *JB

NHTSA ID

10184791

Incident

Jan 17, 2007

TL* - THE CONTACT HAS A 2006 FORD F-350 SUPER DUTY, THAT CONTINUOUSLY EXPERIENCES SEVERE LOSS OF POWER. WHILE DRIVING ON THE HIGHWAY, OR GOING UP A HILL THE VEHICLE STALLS WITHOUT ANY PRIOR WARNING. THE VEHICLE DOES NOT HAVE ENOUGH POWER TO PULL THE 5TH WHEEL. THE CONTACT HAS TAKEN THE VEHICLE TO THE DEALER AND THEY STATED THAT THE INJECTORS BROKE IN HALF, DUMPING RAW FUEL INTO THE HOT OIL OF THE MOTOR. THEY ALSO STATED THAT THERE ISN'T ANY KNOWN REPAIR FOR VEHICLE'S FAILURE. THE CONTACT CAN PROVIDE COPIES OF INVOICE REPAIR. *JB UPDATED 2/27/2007 - THE CONSUMER HAS TWO IDENTICAL VEHICLES AND BOTH FAILED IN THE SAME MANNER. *NM

NHTSA ID

10179019

Incident

Jan 17, 2007

Mileage

50,000 mi

CHECK ENGINE LIGHT ON SEVERAL TIMES AND UNABLE TO IDENTIFY PROBLEM. 10/10/06 EGR POSITION ERROR BUT STATED OKAY AT THIS TIME. SEVERE LOSS OF POWER FOUND 4 INJECTORS REPLACED 11/27/06. 12/08/06 CHECK ENGINE LIGHT ON WITH REPLACEMENT OF EGR VALVE 12/18/06. TURNS OVER WITHOUT START WITH PUFFS OF BLACK SMOKE. ENGINE GOT HOT. SMOKE SMELLED OF ANTIFREEZE AND LOST ALL POWER. REPLACED 4 INJECTORS, FUEL PUMP, FUEL LINE FITTING. 1/12/07 SEVERE LOSS OF POWER, TRUCK AT GARAGE. *JB

NHTSA ID

10178622

Incident

Jan 12, 2007

Mileage

58,221 mi