2006 Ford F-350 Sd Suspension Problems

MY 2016 F350 SUPER DUTY 4WD DISESAL HAS A DEATH WOBBLE WITH ONLY 46,OOO MILES. THE DEALERSHIP AT SEMINOLE FORD, SEMINOLE OKLAHOMA 405-382-2222 TOLD ME I WOULD HAVE TO PAY 1200 TO FIX THIS. I WAS DRIVING 70MPH ON THE HIGHWAY YESTERDAY AND MY VEHICLE WENT OUT OF CONTROL ALMOST CAUSING ME TO WRECK. I IMMEDIATELY SCHEDULED AN APPOINTMENT WITH THE DEALERSHIP. I WILL FORWARD THE BILL WHEN I RECEIVE IT. THIS IS A SAFETY HAZARD AND A FACTORY DEFECT THAT I SHOULD NOT BE RESPONSIBLE FOR, I HAD THE VEHICLE AT THE DEALERSHIP ONE MONTH AGO AND HAD TO PAY FOR A NEW DEF HEATER AT THE TUNE ALMOST $1,000. AT THAT TIME THEY DID THEIR MULTI-POINT INSPECTION WHICH SHOWS THAT THE PARTS THAT FAILED WERE ALL FINE. PLEASE HELP ME AS FORD IS TRYING TO SCREW ME OVER ON A 70K TRUCK WITH MINIMAL MILES. THIS SHOULD BE A RECALL ISSUE THAT FORD SHOULD PAY FOR NOT THE CONSUMER.

NHTSA ID

11387670

Incident

Jan 11, 2021

Mileage

46,000 mi

DEATH SHIMMY. STEERING WHEEL SHAKES VIOLENTLY WHEN A BUMP OR DISCONTINUITY IN THE ROAD IS ENCOUNTERED. YOU CANNOT HOLD THE STEERING WHEEL DURING THIS EVENT. CURE IS TO REDUCE VEHICLE SPEED BELOW 15 MPH. THIS IS HAZARDOUS IF TRAVELING AT HIGH SPEED OR PULLING A TRAILER. AS YOU CANNOT HOLD THE WHEEL DURING THIS EVENT, THE VEHICLE WILL CHANGE LANES AND PRESENTS A FATAL HAZARD AS YOU ATTEMPT TO REDUCE SPEED FROM 65 MPH TO BELOW 15 MPH WITHOUT STEERING CONTROL. FORD ACKNOWLEDGES THE PROBLEM IN LETTER 09L02 SENT IN 2009 AND AGAIN IN 2015. THEIR SOLUTION TO PROPERLY INFLATE THE TIRES IS FALSE AS TIRE PRESSURE HAS NO EFFECT ON OCCURANCE OR SEVERITY. I HAVE REPLACED THE TIRES AND RUN UP THE PRESSURE IN 5 LB INCREMENTS FROM 55 TO 80 PSI. NO EFFECT IN THE FREQUENCY OR SEVERITY OF THE VIBRATION. ## VIN PASSED ## FORD F350 SUPER DUTY 2006 ##

NHTSA ID

10820036

Incident

Jan 1, 2015

Mileage

139,000 mi

I WAS IN OAKLAND CALIFORNIA I880 NORTH NUMBER FOUR LANE PULLING MY CAR TRAILER WITH A LOAD WHEN THE "DEATH WOBBLE" OCCURRED, BEFORE I COULD GRAB THE TRAILER BRAKES TO SLOW THE VEHICLE, THE RIG STARTED A WHIP AND THE TRAILER STRUCK THE "K" RAIL. I SLOWED TO ABOUT 10MPH BEFORE THE SHIMMY STOPPED. THE FENDER ON THE RIGHT SIDE OF THE TRAILER WAS DESTROYED AND BLEW BOTH TIRES ON THE TANDEM AXLE TRAILER. LUCKILY NO ONE ELSE WAS INVOLVED AND NO ONE WAS HURT. THIS TRUCK NOW IS ON IT'S THIRD SET OF THE FACTORY B.F. GOODRICH RUGGED TRAIL T/A RADIALS ON THE FRONT. I HAVE HAD THIS VEHICLE ALIGNED WITH EACH TIRE CHANGE AND HAVE EXPERIMENTED WITH TIRE PRESSURES, IT DOES NOT MATTER, AFTER ABOUT TEN THOUSAND MILES ON A SET OF TIRES IT SHIMMIES AGAIN. I HAVE RESORTED TO THE SAFETY AND RELIABILITY OF MY 30 YEAR OLD CHEVY HALF TON AND OVERLOADING IT BY UP TO 50% OUT OF FEAR FOR THIS TRUCK. BECAUSE OF SHEAR NUMBERS INVOLVED, NOTHING WILL EVER BE DONE BY THE NHTSA ABOUT THIS VEHICLE TYPE'S DEFECTS. *TR

NHTSA ID

10558662

Incident

Aug 20, 2012

Mileage

50,440 mi

FRONT END OF TRUCK WOBBLES-SHAKES OUT OF CONTROL WHEN GOING OVER EXPLANATION JOINT ON OVERPASS. DOES NOT STOP WOBBLE UNTIL VEHICLE IS SLOWED DOWN TO ABOUT 30MPH. FEAR OF GETTING REAR-ENDED. *TR

NHTSA ID

10558052

Incident

Jan 11, 2008

Mileage

16,000 mi

WAS TRAVELING ON THE HIGHWAY AT A RATE OF SPEED OF 55MPH ON A 2006 F350 SUPER DUTY 4X4 WHEN I WENT OVER AN UNEVEN SURFACE ON THE HIGHWAY WHICH CAUSED THE FRONT END TO SHAKE VIOLENTLY ALMOST CAUSING ME TO HIT A VEHICLE ON MY RIGHT HAND SIDE. THOUGH I HAD EXPERIENCED A FLAT BUT EVERYTHING LOOKED FINE. CANNOT DRIVE THIS VEHICLE IN THIS CONDITION. TIRE PRESSURE ON ALL WHEELS IS FINE. *TR

NHTSA ID

10507287

Incident

Apr 4, 2013

Mileage

85,034 mi

I OWN A 2006 FORD F-350 KING RANCH CREW CAB FOUR WHEEL DRIVE TRUCK. I AM THE ORIGINAL OWNER. A FEW TIMES THROUGH OUT THE YEARS THERE HAD BEEN A SHAKE AFTER HITTING A BUMP IN THE ROAD AT 60MPH+. WE RECEIVED A LETTER NOTING A POTENTIAL PROBLEM. WE BROUGHT THE TRUCK TO THE DEALER AND THEY REPLACED BRAKES AND 2 TIRES (OTHER 2 HAD BEEN REPLACED PREVIOUSLY) AND WHEN WE DROVE IT HOME IT STARTED "THE DEATH WOBBLE" (AS THE DEALER CALLS IT-AND AS I SEE MANY OTHERS ON THE INTERNET). THE TRUCK STARTED EXPERIENCING VIOLENT FRONT-END SHAKING. DURING AN EPISODE OF LEFT-TO-RIGHT SHAKING, THE TRUCK IS VERY DIFFICULT TO CONTROL. WITH MY HAND PLACED ON THE 12:00 POSITION ON THE STEERING WHEEL, THE SHAKING VIOLENTLY TURNS THE STEERING WHEEL TO WHERE MY HAND IS GOING BACK AND FORTH BETWEEN 10:00 AND 2:00. SLOWING DOWN TO 30MPH HAS STOPPED EACH OF THE THREE EPISODES. THIS TRUCK HAS DEALER INSTALLED TIRES AND DOES NOT HAVE A LIFT KIT ON IT. AIR PRESSURE IN THE TIRES EQUAL MANUFACTURERS RECOMMENDATION. THEY ACTED AS IF THIS IS AN UNCOMMON PROBLEM AT FIRST, AND SAID THEY HAVE NEVER HEARD OF A LETTER THAT WENT OUT. THEN THE NEXT VISIT THEY SAY SO COMMONLY, THAT IT IS THE DEATH WOBBLE AND WILL COST $1500. IT APPEARS THAT FORD MOTOR COMPANY HAS BLAMED TIRE PRESSURE, GIANT AFTERMARKET TIRES, AND LIFT KITS FOR THIS PROBLEM. MY TRUCK HAS NONE OF THESE POSSIBLE CAUSES. *TR

NHTSA ID

10498268

Incident

Jan 16, 2013

Mileage

145,000 mi

I WAS TRAVELING NORTH ON I59 THROUGH MERIDIAN MISSISSIPPI AT APPROXIMATELY 8:00 PM YESTERDAY ON 06/22/2012. I CAME ACROSS AN OVERPASS AT ABOUT 70 MPH WHEN THE ROUGH SURFACE OF THE BRIDGE CAUSED THE TRUCK TO SHAKE VERY VIOLENTLY IN THE FRONT END. I IMMEDIATELY TRIED TO CONTROL/CORRECT IT BY HOLDING THE STEERING WHEEL FIRMLY AND BRAKING. IT STARTED TO SUBSIDE AND THEN STARTED AGAIN. I HELD THE STEERING WHEEL STRAIGHT AND FIRM, AND BRAKED HARDER UNTIL THE SHAKING STOPPED. I HAD SLOWED TO APPROXIMATELY 40 TO 50 MPH BEFORE IT HAD STOPPED. THIS ALL TOOK PLACE IN MATTER OF SECONDS. THOUGH FRUSTRATED BECAUSE I HAD JUST PURCHASED THE TRUCK EARLIER ON THIS DAY, I FEEL FORTUNATE THAT IT HAPPENED WITH LITTLE TRAFFIC. I HAD RECENTLY CROSSED OVER LAKE PONTCHARTRAIN BRIDGE IN LOUISIANA JUST HOURS EARLIER. *TT

NHTSA ID

10462846

Incident

Jun 22, 2012

Mileage

165,700 mi

THE INITIAL OCCURRENCE IN DECEMBER 2011 WAS A STEERING STICK IN THE DIRECTION OF THE TURN AND REQUIRED FORCE TO TURN OPPOSITE THE DIRECTION OF THE TURN. THE PROBLEM CEASED AND DID NOT REOCCUR UNTIL MID-MAY OF 2012. THE PROBLEM MANIFESTED ITSELF AS A SEVERE OSCILLATION OF THE VEHICLE STEERING ACCOMPANIED BY DIRECTIONAL STICKING AND "INDEXING" IN THE STEERING. THE FIRST ATTEMPT AT REPAIR WAS TO FLUSH THE POWER STEERING SYSTEM. THIS ACTUALLY RESULTED IN A WORSE OSCILLATION. THE PROBLEM WAS STILL INTERMITTENT BUT OCCURRING MORE FREQUENTLY. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM AND I ASKED FOR THE STEERING GEAR TO BE REPLACED. THIS DID NOT SOLVE THE PROBLEM. THE NEXT STEP WAS TO REPLACE THE STEERING DAMPER. THIS ALSO DID NOT RESULT IN ELIMINATION OF THE PROBLEM. DURING THE DAMPER REPLACEMENT IT WAS NOTED THAT THERE EXISTED A VERY SMALL AMOUNT OF PLAY IN THE DRAGLING BALL JOINT. WHILE NOT PARTICULAR OUT OF THE ACCEPTABLE RANGE WE AGREED TO REPLACE THE DRAG LINK. THE DRAG LINK HAS BEEN REPLACED AND THE VEHICLE CONTINUES TO DEMONSTRATE A "WALKING" MOTION REQUIRING THE OPERATOR TO ACTIVELY STEER THE VEHICLE TO REMAIN IN A LANE. IN ADDITION, THE VEHICLE WILL DEMONSTRATE RELATIVELY GOOD STABILITY IN A SWEEPING TURN UNTIL THE WHEEL IS DISPLACED BEYOND ROUGHLY 5 DEGREES AT WHICH POINT THE STEERING DISPLAYS AN ACTIVE PULL IN THE DIRECTION OF THE TURN. THE VEHICLE IS BEING RETURNED TO THE DEALER FOR CONTINUED EVALUATION. THE FORD TECHNICIANS HAVE EXAMINED AND PASSED THE POWER STEERING PUMP, THE HYDROSLAVE SYSTEM, FRONT TIRES, FRONT TIRE PRESSURE, FRONT BALL JOINTS AS WELL AS THE FRONT AXLE U-JOINTS. AT THIS POINT, THEY HAVE NO FURTHER SUGGESTIONS AS TO THE CAUSE OF THE PROBLEM. *TR

NHTSA ID

10460501

Incident

Dec 1, 2011

Mileage

100,000 mi

THE VEHICHE WHEN TRAVELING AT HIGHWAY SPEEDS IN EXCESS OF 55 MPH WHEN HITTING A BUMP BEGINS TO SHAKE WHICH GROWS TO A VOILENT SHAKING. IN ORDER TO STOP THIS SHAKING THE VEHICLE MUST BE SLOWED UNDER 25 MPH. THIS HAS HAPPENED ON NUMEROUS OCCASIONS BETWEEN THE DATE ABOVE AND TODAY. REPEATED SERVICE VISITS TO A LOCAL FORD DEALERSHIP SERVICE CENTER HAVE BEEN UNABLE TO CORRECT THE PROBLEM. *TT

NHTSA ID

10459147

Incident

Aug 8, 2008

Mileage

30,000 mi

CPSC#I1190270A. 2006 FORD F350. CONSUMER STATED THE STEERING WHEEL BEGAN TO OSCILLATE BACK AND FORTH VIOLENTLY WHEN HE HIT A SMALL BUMP IN THE ROAD. I WAS UNABLE TO CONTROL THE STEERING WHEEL UNTIL MY SPEED WAS REDUCED TO BELOW 40 MPH. I LEARNED THIS PROBLEM IS VERY COMMONLY REFERRED TO AS THE "DEATH WOBBLE" AND THE FIX IS $ 875. *LN THE CONSUMER VEERED OFF THE PAVEMENT AND WENT DOWN A GRASSY EMBANKMENT. *JB

NHTSA ID

10427395

Incident

Sep 11, 2011

THIS HAS HAPPENED SEVERAL TIMES WHEN THE TRUCK IS TRAVELING ALONG A ROAD OR HIGHWAY. YOUR DRIVE TURNS INTO A DEATH WOBBLE. THE TRUCK IS UNCONTROLLABLE AND JUMPS LANES AND IS ALL OVER THE ROAD. THIS IS A DANGER THAT HAS BEEN PRESENTED TO FORD BY MANY AND IT IS JUST BEING IGNORED. THIS IS A TRUE DANGER AND MAY NOT ONLY KILL THE DRIVER AND PASSENGERS BUT ANYONE DRIVING DOWN THE ROAD. IT'S ALL OVER THE INTERNET AND HAPPENING ALL OVER THE COUNTRY. THIS IS BEING SWEPT UNDER THE CARPET, JUST AS THE PINTO WAS, WITH MANY DEATHS. YOU AS THE SAFETY BOARD NEED TO STEP UP AND DO SOMETHING SO CONSUMERS CAN DRIVE THE VEHICLES THAT THEY HAVE PURCHASED, FOR MANY OVER $55,000. *TR

NHTSA ID

10419336

Incident

Jul 17, 2011

Mileage

25,000 mi

2006 FORD F350 SD 4X4 FRONT END ALIGNED LESS THAN 1 MONTH PRIOR WITH ALL TIRE PRESSURE CHECKED AND CORRECTED. DRIVING IN DRY CONDITIONS APPROACHING AN OVERPASS ON A CURVE, FRONT OF OVERPASS BRIDGE SURFACE IS BUMPY AND ROUGH, SPEED 45-50 MPH. HIT ROUGH SURFACE AND FRONT END STARTED TO SHAKE UNCONTROLLABLY!!!! HAD TO HIT BRAKES AND SWEAR TO SHOULDER TO KEEP FROM GOING OFF OVERPASS! *LN

NHTSA ID

10378327

Incident

Jan 23, 2011

Mileage

82,356 mi

TL* THE CONTACT OWNS A 2006 FORD F-350 SUPER DUTY. THE CONTACT WAS DRIVING APPROXIMATELY 60 MPH OVER A ROAD BUMP WHEN THE CONTACT LOST ALL STEERING CONTROL. HE HAD TO DECREASE THE VEHICLES' SPEED TO 30 MPH TO REGAIN STEERING CONTROL. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE STEERING BUSHING, SHOCKS, LOWER CONTROL, AND IDLER ARMS WERE REPLACED. THE FAILURE RECURRED WITHIN THREE WEEKS OF THE REPAIRS. THE CONTACT LOCATED AN INVESTIGATION (NHTSA ITEM NUMBER: PE07057- SUSPENSION:FRONT) WHICH DESCRIBED FAILURE AND INQUIRED WITH THE DEALER. THE DEALER SET THE TIRE PRESSURE TO THE CORRECT MANUFACTURER'S SPECIFICATIONS TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 86,800 AND THE CURRENT MILEAGE WAS 86,444.

NHTSA ID

10363770

Incident

Aug 15, 2010

Mileage

86,800 mi

I HAVE A 2006 FORD F350 4 WHEEL DRIVE SINGLE WHEEL LONG BED KING RANCH. I WILL BE DRIVING DOWN THE ROAD OR INTERSTATE ANYWHERE BETWEEN 30 AND 80 MILES AN HOUR, AND IF YOU HIT THE SMALLEST IMPERFECTIONS IN THE ROAD THE TRUCK WILL START SHAKING VIOLENTLY, UNCONTROLLABLE, THE STEERING WHEEL MOVES ABOUT 14 INCHES SIDE TO SIDE SO FAST AND HARD, THAT IT TAKES ILL I'VE GOT TO HOLD ON TO THE WHEEL. YOU CAN HEAR THE TIRES CHIRP SIDE TO SIDE ON THE PAVEMENT IT WOBBLES SO SEVERELY. I'VE REPLACED THE STEERING DAMPENER, THE POWER STEERING PUMP, HAD IT ALIGNED 4 TIMES, BRAND NEW TIRES, I HAVE ADJUSTED THE CASTOR ACCORDINGLY TO FORDS TSB FORUM, HAD MY ROTORS TURNED, AND WHEELS AND TIRES BALANCED SO MANY TIMES. ITS SO BAD, IT SHAKES THE STUFF IN THE BED OF MY TRUCK ONTO THE HIGHWAY. MY TRUCK ONLY HAS 92,000 MILES ON IT. IM AFRAID TO DRIVE IT. ALL I KNOW IS THAT I DIDN'T PAY 64,000 DOLLARS FOR A TRUCK THAT I CANT DRIVE. I WILL SPEND THE MONEY TO FIX IT, BUT FORD SAYS ITS A NORMAL CONDITION. *TR

NHTSA ID

10362727

Incident

Oct 22, 2010

Mileage

92,000 mi

TL*THE CONTACT OWNS A 2006 FORD F-350 SUPERDUTY. WHILE DRIVING OVER A BUMP OR POTHOLE, THE FRONT END WOULD SHIMMY. THE CONTACT CALLED THE DEALER WHO STATED THAT THE FRONT END DAMPENER NEEDED TO BE REPLACED. THE CONTACT REPAIRED THE PROBLEM HIMSELF. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

NHTSA ID

10359557

Incident

Sep 15, 2007

Mileage

90,000 mi

WHILE DRIVING ALONG THE HWY AT APPROX 65MPH I RAN ACROSS A PATCH OF UNEVEN ROAD AT WHICH CAUSED MY 2006 F350 4X4 STEERING TO SHAKE VIOLENTLY I HAD TO CAREFULLY PULL OVER TO THE SHOULDER WHICH WAS NO SMALL TASK AS THERE WAS A LOT OF TRAFFIC THE SHAKING WOULD NOT STOP UNTIL I WAS ALMOST STOPPED THIS HAPPENED 4 TIMES ON DIFFERENT ROADS . THE VEHICLE IS STOCK NOT LIFTED AND HAS OEM TIRES. I AM TRYING TO FIND A FIX BUT I AM FINDING OUT THIS IS A COMMON PROBLEM FOR FORD AND THEY ARE UNWILLING TO HELP FIX. *TR

NHTSA ID

10293635

Incident

Nov 24, 2009

Mileage

109,000 mi

VEHICLE CONTROL COMPROMISED WHEN INCURRING SHARP CHANGES IN ROAD SURFACE (POTHOLES, EXPANSION JOINTS, ETC). *TR

NHTSA ID

10292033

Incident

Nov 10, 2009

Mileage

41,000 mi

EXCESSIVE FRONT END SHIMMY ON OCCASION WITH MY FORD F350 4X4. I HAVE RECEIVED A LETTER FROM FORD DISCUSSING THIS ISSUE. THE FIRST TIME THE PROBLEM OCCURRED, MY TIRE PRESSURE WAS LOW AND SUBSEQUENTLY MAINTAINING PROPER TIRE PRESSURE SEEMED TO PREVENT THE PROBLEM FOR A WHILE. HOWEVER, RECENTLY I HIT SOME BUMPS WHILE TRAVELING ON THE HIGHWAY AT A SPEED OF APPROXIMATELY 65 MPH AND THE FRONT END BEGAN TO SHIMMY VERY VIOLENTLY. I KNEW TO HIT THE BRAKES TO REGAIN CONTROL OF THE STEERING, BUT I HAD TO STAY ON MY BRAKES UNTIL I SLOWED TO APPROXIMATELY 40 MPH BEFORE I COULD REGAIN CONTROL OF THE STEERING WHEEL. I CALLED A LOCAL FORD SERVICE CENTER, BUT THEY SAID THEY WOULD "ONLY BE GUESSING" AT THE PROPER WAY TO FIX THE PROBLEM. I THEN CALLED FORD CUSTOMER SERVICE TO DISCUSS THE ISSUE, AS I AM NERVOUS ABOUT RIDING ON THE HIGHWAY WITH THE VEHICLE. THEY SUGGESTED THAT I CALL SEVERAL SERVICE CENTERS UNTIL I FIND ONE THAT HAS EXPERIENCE WITH TRYING TO FIX THIS PARTICULAR PROBLEM. I HAVE DONE THAT AND I HAVE FOUND THAT NONE OF THE LOCAL DEALERS KNOW HOW TO CORRECT THE PROBLEM. THIS SHIMMY PROBLEM IS OCCURRING MORE AND MORE OFTEN AND I AM CONVINCED THAT IT WILL EVENTUALLY RESULT IN AN ACCIDENT ON THE HIGHWAY. *TR

NHTSA ID

10288585

Incident

Oct 13, 2009

Mileage

62,000 mi

I OWN A 2006 FORD F-350 4X4 SHORT BED CREW CAB PICKUP TRUCK. I AM THE ORIGINAL OWNER AND NO MODIFICATIONS HAVE EVER BEEN MADE. I HAVE KEPT THE VEHICLE IN GOOD MECHANICAL SHAPE, KEPT THE TIRES INFLATED TO RECOMMENDED LEVELS, AND KEPT THE TIRES BALANCED AND ROTATED. THE VEHICLE HAS ALWAYS EXPERIENCED A SEVERE STEERING OSCILLATION WHENEVER THE VEHICLE IS TRAVELING OVER 50 MPH AND HITS A SMALL BUMP ON THE HIGHWAY. THE OSCILLATION IS MOST SEVERE IF THE BUMP IS HIT WHILE IN A LEFT TURN. WHEN THIS OCCURS, I BREAK UNTIL SPEED IS REDUCED TO ABOUT 30 MPH TO 40 MPH AND THE OSCILLATION STOPS. WHEN THIS OSCILLATION OCCURS, THE VEHICLE HAS LIMITED STEERING CONTROL. IT GENERALLY TRAVELS IN A STRAIGHT DIRECTION BUT DOES NOT RESPOND WELL TO STEERING WHEEL INPUT UNTIL THE OSCILLATION IS DAMPENED. THE VEHICLE IS DIFFICULT AND IN SOME CASES IMPOSSIBLE TO CONTROL. THIS OSCILLATION HAS OCCURRED NUMEROUS TIMES. IN THE CASE TODAY, THIS OSCILLATION WAS SO SEVERE THAT IT HAS CAUSED THE VEHICLE TO SWERVE INTO THE OPPOSING TRAFFIC LANE. I NEARLY HAD A HEAD ON COLLISION, THE OPPOSING VEHICLE MOVED OVER TO THE SHOULDER TO ALLOW ME TO PASS. THESE OSCILLATIONS HAVE OCCURRED WITH BOTH THE ORIGINAL CONTINENTAL LT275/70R18 TIRES AND ALSO THE REPLACEMENT MICHELIN LT275/70R18 TIRES. TIRES PRESSURES HAVE BEEN MAINTAINED AT 65 PSI FRONT AND 75 PSI REAR AS RECOMMENDED BY THE OWNER'S MANUAL. *TR

NHTSA ID

10281763

Incident

Aug 25, 2009

Mileage

67,039 mi

2006 FORD F-350 SD 2WD HAS A VIOLENT FRONT END SHIMMY THAT HAS BEEN CAUSED BY THE SMALLEST IMPERFECTION IN THE HIGHWAY. AT SPEEDS OF 50MPH+ THE SHAKING IS SO INTENSE THAT IT CAUSES SWERVING AND YOU MUST COME TO A NEAR COMPLETE STOP BEFORE THE SHAKING WILL CEASE. SINCE IT HAPPENS ON THE FREEWAY, WE HAVE NEARLY BEEN REAR ENDED AND HAVE SWERVED INTO OTHER LANES. THIS IS A SAFETY CONCERN FOR ALL PASSENGERS IN THE VEHICLE. IT CAN OCCUR ONCE EVERY OTHER DAY OR FOUR TIMES IN 20MILES. *TR

NHTSA ID

10280408

Incident

Aug 13, 2009

Mileage

65,000 mi

2006 FORD F-350 SUPER DUTY DUAL AXLE. VEHICLE SUFFERS SEVERE, VIOLENT, AND UNCONTROLLABLE SHIMMY / VIBRATIONS WHEN CROSSING UNEVEN PAVEMENT. MOST NOTABLY WHEN DOING SO WHILE IN A LEFT ANGLED TURN. MUST APPLY IMMEDIATE HEAVY BREAKING TO BELOW 20 MPH TO GET THE UNCONTROLLABLE VIBRATION TO STOP. HAVE NEARLY BEEN REAR-ENDED ON NUMEROUS OCCASIONS DUE TO THIS ISSUE. TIRES ARE PROPERLY INFLATED AND VEHICLE SUSPENSION IS COMPLETELY FACTORY STOCK. THIS IS A VERY DANGEROUS SITUATION AND HAS BEEN OCCURRING SINCE PURCHASE NEARLY TWO YEARS AGO. *TR

NHTSA ID

10279629

Incident

Aug 6, 2009

Mileage

26,000 mi

TL*THE CONTACT OWNS A 2006 FORD F-350 SD. WHILE DRIVING APPROXIMATELY 65 MPH, THE STEERING VIBRATED AND WOBBLED EXCESSIVELY. IN ADDITION, THE FRONT END OF THE VEHICLE BEGAN TO SHIMMY. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. IMMEDIATELY, THE DRIVER PULLED THE VEHICLE OVER. SHE DROVE TO AN AUTHORIZED DEALER, BUT THEY COULD NOT DUPLICATE THE FAILURES. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER AND AN INDEPENDENT MECHANIC ON SEPARATE OCCASIONS FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. CURRENTLY, THE AUTHORIZED DEALER IS REPLACING THE STEERING STABILIZER SHOCK AND DRAG LINK. THE VIN WAS UNABLE TO BE ENTERED INTO THE SYSTEM. THE FAILURE MILEAGE WAS 65,000 AND CURRENT MILEAGE WAS 87,000.

NHTSA ID

10276278

Incident

Sep 15, 2008

Mileage

65,000 mi

I OWN AN 06' FORD F350 SD. I FIRST NOTICED AN EXTREME TIRE SHIMMY/BOUNCE AT AROUND 15,000 MI, WHEN A POT HOLE, BRIDGE EXPANSION OR ROUGH ROAD IS ENCOUNTERED. THE TRUCK NOW HAS 105,000 MI. AND THE PROBLEM HAS BECOME SOME EXTREME THAT I BELIEVE IT IS TOO DANGEROUS TO DRIVE UNTIL THE PROBLEM IS REMEDIED. THE BOUNCING IS SO EXTREME THAT CONTROL OF THE TRUCK IS NEARLY LOST. FORD HAS SENT ME A LETTER CLAIMING IMPROPER TIRE PRESSURE IS THE PROBLEM, I HAVE ADJUSTED BUT TO NO HELP. THE TRUCK SHIMMYS/ SHAKES UNCONTROLLABLY, AT EVERY BUMP ENCOUNTERED. THIS IS AN EXTREMELY DANGEROUS SITUATION WHICH IS WIDE SPREAD AMONG SD OWNERS ACCORDING TO POSTINGS ON THE WEB. PLEASE HELP! *TR

NHTSA ID

10274553

Incident

Jun 11, 2009

Mileage

15,301 mi

I HAVE A 2006 FORD F350 CREWCAB SUPERDUTY THAT HAS A SHIMMY / VIBRATION IN CAB OF TRUCK WHICH HAPPENS WHEN I HIT A DIP OR BUMP AND IF I SLOW DOWN SOMETIMES IT GOES AWAY QUICKLY WHEN I SLOW DOWN AND SOMETIMES I HAVE SLOW DOWN BELOW 30MPH. HOW SAFE IS THAT ON AN INTERSTATE? I DID RECEIVE A LETTER FROM FORD SAYING THIS COMMON BUT I DISAGREE BECAUSE THIS IS MY THIRD SUPERDUTY AND THE LAST TWO I DID NOT EXPERIENCE THIS PROBLEM BUT THEY HAD DIESEL ENGINES THIS IS GAS. MY DEALERSHIP TOLD FORD CUSTOMER REP THAT I NEED A ROAD WORTHY TEST OR THE DRIVE SHAFT IS OUT OF BALANCE SO THEY ARE GUESSING TOO. THE DEALERSHIP DID NOT EVEN KNOW ABOUT THIS LETTER THAT FORD SENT TO SUPERDUTY OWNERS. FORD REP STATED THERE IS NO RECALL ON THIS VEHICLE. THE SERVICE MANAGER AT THE LOCAL DEALERSHIP BELIEVES THE PROBLEM IS BECAUSE A GAS ENGINE IS TOO LIGHT AND THE SUPERDUTYS WERE MADE FOR DIESEL ENGINES. I HAVE NO IDEA HOW TRUE THIS IS BUT MY FIRST TWO SUPERDUTY TRUCKS I HAD WERE DIESEL AND I DID NOT EXPERIENCE THIS. I HAVE DRAFTED UP A LETTER TO SEND TO NYS ATTORNEY GENERAL AND TO FORD BUT I AM NOT VERY CONFIDENT ABOUT THE END RESULTS. MY WARRANTY HAS RUN OUT AND NOW IT IS ON MY NICKEL. I EVEN PUT NEW E RATED TIRES ON THE TRUCK IN DECEMBER AND HAS BEEN AT THE DEALERSHIP TWICE WHICH THEY SAID THE TIRES WERE OUT OF BALANCE AND NEEDED TO BE ROTATED. I HAVE LESS THAN 3,000 MILES ON THESE TIRES SO THAT DID NOT MAKE ANY SENSE. AS OF THIS DATE THE TIRES HAVE BEEN BALANCED A TOTAL OF THREE TIMES WHICH ABSOLUTELY NO SENSE EITHER. I AM GOING TO GET A SECOND OPINION FROM MY MECHANIC THAT I HAVE BEEN USING FOR OVER 20 YEARS WHICH IS NOT A FORD DEALERSHIP TO SEE IF THE PROBLEM CAN BE RESOLVED SINCE I AM NOT GETTING MUCH HELP FROM FORD OR THE DEALERSHIP. THIS SHIMMY / VIBRATION DOES GET ME NERVOUS AT TIMES AND DO NOT FEEL I AM VERY SAFE IN KEEPING THIS BIG PICKUP UNDER CONTROL AND I DO NOT EXCEED THE SPEED LIMIT MORE THAN 5 MPH. I HAVE BEEN A FORD PERSON FOR OVER THIRTY YEARS AND NOW I MAY HAVE TO CHANGE. *TR

NHTSA ID

10269838

Incident

Jan 11, 2009

Mileage

31,000 mi

I AM DISAPPOINTED IN THE FINDINGS ON THE F-350 SUPERDUTY FRONT SUSPENSION SHIMMY AS IT IS CALLED. I HAVE A 06 F-350 SD WITH ONLY 54,000 MILES ON IT. THE FRONT END HAS BEEN COMPLETELY REPLACED TWICE AND NEEDS IT AGAIN BUT FORD WILL NOT WARRANTY IT BECAUSE OF THE FACTORY WARRANTY EXPIRING. THIS SEVERE SHIMMY IS REAL AND TO ALLOW A FINDING THAT STATES THE TIRE PRESSURE IS TO BLAME IS COMPLETELY FALSE AND SO STUNNING. DOES THE ODI REALLY EXPECT THE VEHICLE OWNERS TO BUY THIS. LOOKS LIKE FORD HAD ITS HAND IN THIS ONE AGAIN. I WANT MY TRUCK FIXED AND I WILL NOT PAY FOR IT. FORD KNOWS THIS PROBLEM EXIST BUT IS NOT LARGE ENOUGH YET TO RECALL. WILL SOMEONE DIE FIRST? MY TRUCK IS THAT SEVERE IT WILL LEAVE THE ROAD IF YOUR NOT EXPECTING IT. THE TIRE PRESSURE IS CORRECT AND NO SUSPENSION MODIFICATIONS. I HAVE HAD THIS FRONT END COMPLETELY REBUILT TWICE EVERY YEAR SO FAR SINCE PURCHASE AND AS OF MARCH OF THIS YEAR IT NEEDS IT AGAIN. THEY WANTED TO CHARGE ME $1400.00 TO FIX IT EVEN THOUGH IT HAS REALLY NEVER BEEN FIXED FROM THE INITIAL REPAIR. PLEASE COME TAKE A RIDE AND CHECK MY TIRE PRESSURE YOU WILL BE COMPLETELY SCARED BEFORE WE ARE DONE. *TR

NHTSA ID

10267644

Incident

Feb 17, 2007

Mileage

18,000 mi