2015 Ford F-350 Sd Powertrain (other) Problems

Put it into drive and it went in reverse at least twice now (I'm assuming that's the transmission control modular...?) Luckily we didn't hit anyone and it's happened at home or a drive thru....no...not yet....it says our truck isn't part of the recall the year had (had no idea there even was a recall for it until it had the issue, and trying to figure it out and someone told us about it the same day the issue occured).....there were no other indicators of prior issues or warnings to it happening....

NHTSA ID

11625679

Incident

Nov 15, 2024

P20BA - DEF Reductant Heater Code for a defective DEF reductant heater on a 2015 F-350 6.7L diesel with 57,500 miles NOT covered under dealer emissions warranty.

NHTSA ID

11441227

Incident

Nov 21, 2021

TURBOCHARGER INTERCOOLER HOSE BLEW OF WHILE DRIVING CAUSING A LOUD EXPLOSIVE NOISE AND LOST OF COMPRESSION ALMOST CAUSING A CRASH. I WAS ON A MULTI-LANE HIGHWAY AND IT CREATED A SAFETY HAZARD

NHTSA ID

11415952

Incident

Apr 5, 2021

Mileage

128,000 mi

VEHICLE WAS ATTEMPTING TO CLEAN THE EXHAUST FILTER WITH THE DEF SYSTEM. CHECK ENGINE LIGHT CAME ON. VEHICLE BEGAN SLOWING DOWN. SCANNER REVEALED CODE P20BA-00, REDUCTANT HEATER "A" CONTROL CIRCUIT PERFORMANCE, AND P0884 TCM POWER SIGNAL INTERMITTENT. VEHICLE WAS BEING DRIVEN AT HIGHWAY SPEED. FORD DEALER CONTACTED REGARDING REPAIRS. ADVISED WAS NOT UNDER WARRANTY FOR EMISSIONS CONTROL. COST PROHIBITIVE TO REPAIR.

NHTSA ID

11366998

Incident

Oct 26, 2020

Mileage

51,408 mi

TL* THE CONTACT OWNS A 2015 FORD F-350. THE CONTACT STATED WHILE DRIVING 30 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT STATED THAT THE VEHICLE STARTED TO DECELERATE. THE CONTACT STATED THAT SEVERAL UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TOWED TO SAWGRASS FORD (14501 W SUNRISE BLVD, SUNRISE, FL 33323), TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 79,000.

NHTSA ID

11320321

Incident

Apr 1, 2020

Mileage

79,000 mi

ON MY 2115 FORD F 350 POWERSTROKE DIESEL THE CHECK ENGINE LIGHT CAME ON AND IT DE RATED THE POWER. I READ THE CEL CODE AND ITS PB20A WHICH IS A REDACTANT HEATER PERFORMANCE FAILURE. THIS PROBLEM IS COVERED UNDER WARRANTY FOR ALL MODELS 2011-14, F250-F 550 AND 2015 F450, F550 ONLY. FORD ISN'T COVERING THE F250 OF F350 IN THE 2015 YEARS. MY TRUCK MEETS THE DATE AND MANUFACTURING PLANT CRITERIA AND IT IS NO DRIVABLE BECAUSE OF THIS EMISSIONS CONTROL PART FAILURE. THE REDACDANT HEATER KEEPS THE DIESEL EXHAUST FLUID FROM FREEZING AND RENDERS THE VEHICLE UN DRIVABLE WHEN IT FALIS.

NHTSA ID

11265376

Incident

Sep 28, 2019

Mileage

97,000 mi

TL* THE CONTACT OWNS A 2015 FORD F-350 SUPERDUTY. WHILE DRIVING VARIOUS HIGH SPEEDS, THE FRONT END OF THE VEHICLE SHOOK UNCONTROLLABLY WITHOUT WARNING. THE CONTACT SLOWED THE VEHICLE DOWN UNTIL THE SHAKING CEASED AND RESUMED NORMAL OPERATION. THE CONTACT DROVE TO LARRY H. MILLER FORD LINCOLN DRAPER (11442 LONE PEAK PKWY, DRAPER, UT 84020, 801-590-0561) WHERE A FEW UNKNOWN PARTS WERE REPLACED; HOWEVER, THE FAILURE PERSISTED. SINCE THE INITIAL REPAIR, THE CONTACT HAD TAKEN THE VEHICLE TO SEVERAL INDEPENDENT MECHANICS AND WAS REPAIRED, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000.

NHTSA ID

11252438

Incident

Nov 1, 2018

Mileage

85,000 mi

DIESEL EXHAUST FLUID REDUCTANT HEATER FAULT, CHECK ENGINE LIGHT HAS ILLUMINATED AND IS NOT COVERED UNDER PREVIOUS RECALLS. RECURRING PROBLEM FOR FORD SUPER DUTY THAT NEEDS TO BE EXTENDED FOR THIS MODEL AS IT IS THE SAME PROBLEM THAT PREVIOUS ATTENTION WAS GIVEN TO. IT IS A EMISSIONS PROBLEM THAT FAILS ON THESE TRUCKS.

NHTSA ID

11187014

Incident

Mar 7, 2019

Mileage

55,250 mi

TL* THE CONTACT OWNS A 2015 FORD F-350. WHILE DRIVING 55 MPH AND MAKING A LEFT TURN, THE VEHICLE SHOOK AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT DIAGNOSED THE VEHICLE AND STATED THAT IT NEEDED A REDUCTANT HEATER CONTROL. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE DID NOT MEET THE CRITERIA FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.

NHTSA ID

11151599

Incident

Nov 13, 2018

Mileage

56,000 mi

THE CAR COULDN'T DRIVE ON HIGHWAY, SMOKE AND HUGE TRANSMISSION FLUID LEAKAGE, TOWED TO THE NEAREST FORD DEALER DEALER NOTE "INSPECTED AND FOUND BROKEN TRANS COOLER LINE CAUSING CONCERN, REPLACED TRANS COOLER LINES, CLEANED OFF, TOPPED OFF FLUID AND ROAD TESTED, OK" FORD F-350 2015, ODOMETER 4065 MILES

NHTSA ID

11143810

Incident

Oct 10, 2018

Mileage

4,065 mi

WHILE DRIVING ON THE HIGHWAY THE INSTRUMENT WARNING CLUSTER BEGINS TO ALERT OF ENGINE TEMP, LOW OIL PRESSURE, TRACTION CONTROL THE AIR CONDITION SYSTEM FAILS SO THE VEHICLE IS DRIVEN TO THE SIDE OF THE ROAD AND RESTARTED. THE RESTART CAN OCCUR IMMEDIATELY ON OCCASION BUT TYPICALLY WILL TAKE AT LEAST 30 MINUTES SOMETIMES SEVERAL HOURS. THE ISSUE IS REOCCURRING AND PLACED IN FORD SHOPS TO HAVE IT RETURNED WITH NO TROUBLE FOUND OR COULD NOT REPLICATE ISSUE.

NHTSA ID

11114911

Incident

Jul 4, 2018

Mileage

33,890 mi

AFTER PLACING THE VEHICLE IN PARK I LEFT TO GO INTO A BUILDING. ON MY RETURN THE VEHICLE WAS GONE AND WAS FOUND DOWN THE BLOCK AND WAS INVOLVED IN AN ACCIDENT. IT APPARENTLY DROVE OFF ON IT'S OWN. VIDEO OF THE ACCIDENT CONFIRMED THAT NO ONE WAS DRIVING. AS THE DRIVER, I DID PUT THE VEHICLE IN PARK AND COULD NOT FIGURE OUT WHAT HAPPENED. THE PARKING BREAK WAS NOT APPLIED. THE ONLY CONCLUSION WAS THAT SOME HOW THE VEHICLE SLIPPED INTO GEAR.

NHTSA ID

10969972

Incident

Nov 29, 2016

AT 40 TO 50 MPH THE TRUCK CAN EXPERIENCE LOSS OF POWER AND SEVERE "SHUDDERING" WE HAVE 2 2015'S THAT WE PURCHASED LAST SEPTEMBER AND BOTH ARE EXPERIENCE THE SAME ISSUE IT'S VERY SPORADIC SEEMS TO HAPPEN A FEW TIMES A WEEK. I'M CONCERNED FOR THE SAFETY OF MY COMPANY AS WE CAN BE PULLING TRAILERS AND CAN NOT HAVE THIS TYPE OF BEHAVIOR WHEN ON BUSY ROADS. FORD KNOWS THERE IS AN ISSUE AS STATED IN TSB 16-0041, BUT THEY WILL NOT ATTEMPT TO CORRECT IT UNLESS THEIR TECHS SEE IT HAPPEN..I HAVE ALREADY HAD IT INTO THE SHOP AND THEY COULDN'T SEE THE PROBLEM. IF YOU LOOK ON THE INTERNET IT APPEARS TO BE A PROBLEM ON QUITE A FEW 2015'S..HERE IS ONE FORUM OF MANY HTTP://WWW.FORD-TRUCKS.COM/FORUMS/1381159-FORD-RELEASES-TSB-15-0088-FOR-2015-ACTIVE-REGENERATION-JACKHAMMER-VALVES-ISSUE-33.HTML

NHTSA ID

10907541

Incident

Jul 25, 2016

Mileage

7,000 mi

I HAVE A F350 2015 VEHICLE, HAVING AN ENGINE KNOCK NOISE AND HESITATION PROBLEMS RIGHT AFTER THE ENGINE KNOCKS. I HAVE EXPERIENCED THESE CONCERNS FIVE TIMES. THE DEALERSHIP IS SAYING IS A CHARACTERISTIC OF THE VEHICLE DUE TO CALIFORNIA REGULATIONS. THERE IS A TSB TO THE CONCERN THAT I AM HAVING, BUT I DON'T THINK MY VEHICLE SHOULD HAVE THE HEADS REBUILT SINCE I JUST PURCHASED IT BACK IN DEC 2015. WHAT IS THE STATE DOING TO HAVE THIS CONCERN RESOLVE? I BROUGHT IT IN TWO DAYS AGO TO THE DEALERSHIP AND SINCE AFTER THE 4TH TIME OF THE ENGINE KNOCKED THE CHECK ENGINE LIGHT CAME ON THEY ENDED UP REPLACING A SENSOR. I PICKED UP THE VEHICLE FROM THE DEALERSHIP YESTERDAY AND ON MY WAY HOME, THE ENGINE KNOCKS TO HAPPEN AGAIN. I AM WAITING ON FMC TO CALL ME AND TELL ME WHAT THEY ARE GOING TO DO NOW. THE VEHICLE HAS TWO OTHER PROBLEMS A WINDSHIELD NOISE AT 60 TO 70 MILES PER HOUR ON WINDY DAYS. THEY RESEALED THE WINDSHIELD THE PROBLEM EXISTS. THEY ARE TELLING ME, THAT UNLESS THEY DUPLICATE THE ISSUE, THEY CAN'T DO ANYTHING. I SHOWED THEM A VIDEO THAT I RECORDED DURING THE CONCERN HAPPENING, BUT THEY ARE IGNORING IT. I SHOWED THEM A VIDEO THAT SOMEONE ELSE POSTED ON YOU TUBE SAME CONCERN. HOWEVER, SINCE THEY CANNOT DUPLICATE THEY CANNOT DO ANYTHING THAT IS THEIR ANSWER. I ALSO HAVE A PROBLEM OF THE TRANSMISSION, HARSH SHIFT AS SLOW SPEEDS SAME THING CAN'T DUPLICATE IS WHAT THE WORK ORDER FROM THE DEALERSHIP STATES. WHAT CAN I DO TO HAVE THIS VEHICLE LOOKED AT FOR THE CONCERNS I AM HAVING? IT HAS BEEN IN THE DEALERSHIP FOUR TIMES SINCE I BOUGHT IT.

NHTSA ID

10860805

Incident

Mar 13, 2016

Mileage

8,000 mi

DURING REGENERATION OF THE DIESEL PARTICULATE FILTER THE TRUCK LOSES POWER AND OPERATES ROUGHLY. THIS LAST OCCURRED AS I WAS MERGING INTO TRAFFIC ON THE HIGHWAY DURING SLICK ROAD CONDITIONS. THIS COULD HAVE VERY EASILY RESULTED IN LOSS OF TRACTION AND/OR COLLISION AS I WAS UNABLE TO ACCELERATE TO SPEED.

NHTSA ID

10819844

Incident

Dec 24, 2015

Mileage

5,100 mi

EPISODES OF VIOLENT SHAKING AND POOR ENGINE PERFORMANCE DURING REGENARATION. THIS HAS BEEN A ON GOING ISSUE. FORD CLAIMS IT IS CAUSE BY THE COMPUTER AND A REPROGRAM WILL BE OUT IN MARCH 2016. I FEEL THE TRUCK IS UNSAFE TO DRIVE SPECIALLY ON ICY ROADS.

NHTSA ID

10807235

Incident

Jul 1, 2015

Mileage

4,500 mi