Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Engine reportsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
8
Latest Aug 13, 2025
Share of all reportsThis category as a share of every owner report on file for this model year. One report can name more than one component, so the categories overlap.
4%
of 199 total
Crash or fire reportedReports in this category whose submitter recorded that a crash or a fire occurred. The reporter's own answer on the NHTSA form, not a verified finding.
2
Injuries or deaths reportedTotals the submitters entered on their own reports in this category. Not verified by NHTSA and not a casualty statistic.
2
What this page shows
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 2018 Ford F-350 Sd submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Owner reports naming engine
Shown in the owner’s own words, exactly as filed
Engine
Filed Aug 13, 2025
The contact owns a 2018 Ford F-350. The contact stated while driving 55 MPH and hauling a boat, the vehicle made abnormal banging sounds and stalled. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle was restarted but was undrivable. The vehicle was towed to a dealer, but the diesel mechanic was unavailable to service the vehicle. The vehicle was then towed to a certified mechanic and was diagnosed with a blown engine. The contact was informed that the engine needed to be replaced. The vehicle was being repaired. The contact stated that the failure had occurred in Vancouver Island, Canada, where the vehicle remained for the repair. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 72,000.
NHTSA ID
11680411
Incident
Aug 1, 2025
Mileage
72,000 mi
ElectricalEnginePowertrain (other)
Filed Jul 14, 2025
Truck went into limp mode wile driving on highway had to have trailer towed 980 miles egr cooler rubbing on wire harness on firewall staffing wires ro short out fuel injection this is a manufacturer defect.why would egr cooler and electrical wire harness be placed so close is a big safety and fire hazard ....cost of repairs at ford dealer in Columbia Tennessee $800 for repairs
NHTSA ID
11673394
Incident
Jun 21, 2025
EnginePowertrain (other)
Filed Mar 5, 2025
The contact owns a 2018 Ford F-350. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shifted hard into gear, and the vehicle was shaking erratically. Additionally, the engine overheated. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was unknown.
NHTSA ID
11646440
Incident
Feb 5, 2025
ElectricalEngineFuel system
Filed Feb 15, 2025
Fire reported2 injuries reported
Unknown component that failed. Suspicion, the fuel system located at the back of the fire wall on drivers side. The fire started in that location and was extremely hot and fast moving. The truck was fully engulfed within 1.5 minutes then burnt the attached 5th wheel trailer and contents. It was a total loss of 3 vehicles 2018 Ford F350, 2021 Dutchman Voltage 5th wheel trailer, and a 2013 Polaris RZR side by side UTV. All was reduced to rubble within 15 Min. Our safety and lives were at risk, we had 30-45 seconds from smelling and seeing smoke to flames. We were traveling on Interstate 15 at highway speeds and had to stop as safe as possible on the shoulder of the road. The vehicle has not been inspected as far as I know, the frame is all what is left. There were no warning lights and all gauges read normal,
NHTSA ID
11642894
Incident
Feb 12, 2025
Engine
Filed Apr 26, 2024
The contact owns a 2018 Ford F-350. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed that it was due for a software update and the code was reset. The vehicle was repaired but the check engine warning light illuminated on the way back to the residence. The vehicle was taken back to the same local dealer where it was diagnosed that the exhaust system and catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 42,600.
NHTSA ID
11585486
Incident
Apr 16, 2024
Mileage
42,600 mi
Engine
Filed Dec 1, 2023
The contact owns a 2018 Ford F-350 SD. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact diagnosed the vehicle and retrieved DTC Code: P24AF (Particulate Matter Sensor Circuit Range/Performance has been detected). The contact stated that the vehicle had previously received a recall repair regarding an ECM software upgrade related to DTC Code: P24AF. The contact stated he contacted the dealer and informed the dealer of the failure and the diagnostic code. The dealer advised the contact that the repair would not be covered under warranty. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 27,000.
NHTSA ID
11557906
Incident
Nov 28, 2023
Mileage
27,000 mi
EngineFuel system
Filed Nov 16, 2023
This issue is connected with the 6.7L diesel engine. When sitting and idling it starts to idle really fast and the exhaust has an odor and strong fumes. It did not use to do this. I took to my Ford dealership and they say it's normal and there is nothing wrong. I have talked with other people that own the Ford diesel and they have experienced the same issue and been told the same thing by their dealership. No warnings or anything come up when the vehicle does this. If you enter the vehicle and touch the brake or accelerator it will then idle back down.
NHTSA ID
11555552
Incident
Oct 19, 2022
Engine
Filed Dec 7, 2021
Fire reported
Engine caught fire. Vehicle is waiting to be inspected to determine what caused the fire.
NHTSA ID
11442955
Incident
Nov 3, 2021
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Other components reported on this vehicle
Categories with enough reports to have a page of their own