1993 Ford F-350 Problems

HAD BOTH OF MY STEER TIRES BLOW OUT GOING DOWN THE HIGH WAY RIGHT SIDE I HAD A TRAILER ON AND THE OTHER I HAD JUST GOT ON TO THE INTERSTATE. PUT A HOLE IN MY FLOOR ON DRIVERSIDE AND BROKE THE BRAKE LINE ON THE DRIVERSIDE AS WELL. PASSENGER SIDE JUST LET LOOSE WITH NO WARNING. I STILL HAVE ALL FOUR TIRES AND THE TREAD. THESE WERE 235/85R16

TL*THE CONTACT OWNS A 1993 FORD F350. THE CONTACT STATED THAT THE PARKING BRAKE SYSTEM WAS INEFFECTIVE. THE PARKING BRAKE DOES NOT HOLD THE VEHICLE AND CAUSES IT TO ROLL FREELY. HE TOOK THE VEHICLE TO THE DEALER ON TWO OCCASIONS AND THEY REPLACED THE BRAKE CABLES TWICE AT THE COST OF $300 EACH. WHEN THE FAILURE RESURFACED, THE CONTACT CALLED THE MANUFACTURER IN REFERENCE TO NHTSA CAMPAIGN ID NUMBER 94V169001 (PARKING BRAKE:CONVENTIONAL) AND WAS INFORMED THAT HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS. THE FAILURE MILEAGE WAS 45,000 AND CURRENT MILEAGE WAS 202,000.

WHILE DRIVING THE SERPENTINE BELT SNAPPED OFF. THIS CAUSED THE VEHICLE TO LOSE POWER AND EXTENDED STOPPING DISTANCE. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE PROBLEM. THE CAUSE WAS NOT DETERMINED. PLEASE PROVIDE MORE INFORMATION. *NM

EXHAUST FUMES WERE LEAKING INTO THE CAB OF THE VEHICLE. CONSUMER CONTACTED THE DEALER, WHO DIDN'T THINK THAT THIS PROBLEM WAS IMPORTANT, AND WILL NOT SERVICE VEHICLE IN A TIMELY MANOR. ALSO, CONSUMER ASKED FOR MANUFACTURER'S TELEPHONE NUMBER, BUT THE DEALER REFUSED TO COOPERATE. *AK

MY FORD F350 CREWCAB CAUGHT ON FIRE FOR NO APPARENT REASON. I AM JUST NOW FINDING OUT THAT THERE IS A RECALL ON MY VEHICLE BECAUSE OF SPONTANEOUS FIRES ON MY YEAR AND MODEL. I SPENT ALMOST $3000.00 ON REPAIRS AND HAVE BEEN HAVING ONGOING PROBLEMS WITH THE ENGINE QUITTING WHILE DRIVING. I WOULD LIKE TO KNOW IF THERE IS ANY REMEDY THAT I CAN OBTAIN FROM FORD. I HAVE NOT BEEN ABLE TO USE THIS TRUCK FOR OVER 2 YEARS BECAUSE OF THE ENGINE QUITTING AND THEN A NO START SITUATION. VEHICLE WILL START AFTER IT COOLS DOWN BUT WILL STOP WITHIN A HALF HOUR.THIS IS FRUSTRATING BECAUSE THIS IS MY ONLY VEHICLE AND I HAVE LOST USE OF THE TRUCK AND HAD TO STOP WORKING BECAUSE I AM A CONSTRUCTION CONTRACTOR AND NEEDED IT TO WORK. I HAVE HAD THE TRUCK TO THE DEALER NUMEROUS TIMES. AFTER RESEARCHING PROBLEMS ONLINE I HAD ONLY FOUND OUT THEN ABOUT POSSIBLE UNDERHOOD FIRES ON MY VEHICLE. I ALSO FOUND OUT ABOUT OTHER TSB AND RECALL INFORMATION OF WHICH I HAD NOT BEEN NOTIFIED. *TR

1993 FORD F-350 WITH A 5.8 ENGINE, I RECEIVED THIS INFO. FROM ALLDATA. I READ ON FORD'S WEB SITE THAT A SAFETY RECALL GENERALLY NEVER EXPIRES... RECALL #'S 00S57 FUEL PRESSURE REGULATOR REPLACEMENT, # 00V424000 FUEL PRESSURE REGULATOR MALFUNCTION, # 01L008000 FUEL PUMP CHECK VALVE DEFECT., ALL THREE OF THESE HAVE THE SAME SYMPTOMS, CAUSES FUEL FROM THE REAR TANK TO TRANSFER TO THE FRONT TANK AND CAUSE FUEL TO RUN OUT OF THE FUEL FILLER NECK OF THE FRONT TANK AND DOWN THE SIDE OF THE TRUCK ONTO THE GROUND. I HAVE OWNED THE TRUCK FOR 6 YEARS AND HAVE NEVER RECEIVED ANY TYPE OF NOTICE FOR THIS, ONE NOTICE STATES THAT VEHICLE OWNERS WOULD BE NOTIFIED STARTING MAY 2001, FORD SENT ME AN EMAIL TODAY STATING THAT THEY WOULD NOT REPAIR THIS, I EVEN SENT THEM THE RECALL #'S, I HOPE THAT YOU CAN OFFER ME SOME HELP ON THIS, AS I REALLY DO NOT WANT MY TRUCK TO CATCH FIRE WITH OR WITHOUT MY FAMILY IN IT. THANK YOU *TR UPDATED 03/06/09. *JB

CLUTCH SLAVE CYLINDER TOO CLOSE TO EXHAUST AND OVER HEATS O-RING CAUSING LOSS OF BRAKE FLUID AND LOSS OF CLUTCH. LESS THAN 50,000 MILES ON TRUCK AND IS USED FOR TOWING 5TH WHEEL RV SOME TIMES IN MOUNTAINS IT HAS WENT OUT TWO TIMES NOW ONCE ABOUT TWO YEARS AGO AND JUST TODAY, 08/17/2005. HEAT INSULATOR WAS IN PLACE BOTH TIMES. *JB

THE CLUTCH GOT STUCK IN DRIVE. CONSUMER HAD TO APPLY THE BRAKES IN ORDER TO STOP THE VEHICLE. CONSUMER WAS NOT ABLE TO REMOVE THE GEAR, AND THE VEHICLE IS IN THE SHOP FOR T REPAIRS. *AK

TL* THE CONTACT OWNS A 1993 FORD F-350 EQUIPPED WITH BCT HI-RUN TIRES, SIZE L235/85R16 (NA). WHILE DRIVING APPROXIMATELY 65 MPH, THE FRONT DRIVER SIDE TIRE BLEW OUT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TIRE TREADS WERE SEPARATING FROM THE TIRES AND THE TIRES NEEDED TO BE REPLACED. WHILE AT THE INDEPENDENT MECHANIC, THE OTHER THREE TIRES BLEW OUT. THE TIRES WERE NOT REPAIRED. THE TIRES WERE NOT ORIGINAL EQUIPMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 190,000 AND THE TIRE FAILURE MILEAGE WAS 4,000. THE VIN AND DOT NUMBER WERE NOT PROVIDED.

DT*: THE CONTACT STATED WHILE DRIVING 60 MPH ON THE INTERSTATE IN NORMAL ROAD CONDITIONS, THE LEFT INNER DUALLY TIRE TREAD SEPARATED WITHOUT WARNING. THE CONTACT MANAGED TO PULL OVER WITHOUT INCIDENT. UPON INITIAL INSPECTION, THE CARCASS OF THE TIRE REMAINED INFLATED, YET THE TREAD WAS COMPLETELY SEPARATED. THERE WAS DAMAGE TO THE FUEL LINES FROM THE INITIAL TIRE TREAD SEPARATION. THERE WERE NO OBVIOUS ROAD HAZARD OR DEBRIS. THE MANUFACTURER WAS NOT ALERTED. THE TIRE WAS A BRIDGESTONE LT 215/85/R16, LOAD RANGE E. UPDATED 03/30/07. *JB

WHILE DRIVING AT APPROXIMATELY 10 MPH FORD, F350, SUPERDUTY TRUCK SUDDENLY VEERED OFF OF THE ROAD TO RIGHT AND HIT A TELEPHONE POLE, CAUSING $6,000.00 DAMAGE TO VEHICLE. DEALER EXAMINED VEHICL, AND DETERMINED THAT LOWER STEERING SHAFT BROKE, CAUSING LOSS OF CONTROL. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK

STEERING GEAR BOX CAUSED RIVITS ON CROSS MEMBER OF FRAME TO STRETCH, ALSO CAUSING A SNAPPING NOISE IN FRONT END, ON CLOSER INSPECTION IT WAS FOUND THAT CROSS MEMBER OF FRAME AT STEERING BOX WAS LOOSE, FORD WOULD NOT SHARE IN REPAIR COST DUE TO VEHICLE BEING OUT OF WARRANTY. *SLC

WHILE STOPPED AT RAILROAD CROSSING, DRIVER NOTED SMOKE COMING FROM THE INSTRUMENT PANE. AS SHE GUIDED CHILDREN OUT OF VEHICLE HOT PLASTIC AND FIRE DROPPED ONTO HER FEET.

CONSUMER STATES THAT THE IGNITION SWITCH HAS BEEN REPLACED FOUR TIMES IN TWO MONTHS. *AK

HAD BOTH OF MY STEER TIRES BLOW OUT GOING DOWN THE HIGH WAY RIGHT SIDE I HAD A TRAILER ON AND THE OTHER I HAD JUST GOT ON TO THE INTERSTATE. PUT A HOLE IN MY FLOOR ON DRIVERSIDE AND BROKE THE BRAKE LINE ON THE DRIVERSIDE AS WELL. PASSENGER SIDE JUST LET LOOSE WITH NO WARNING. I STILL HAVE ALL FOUR TIRES AND THE TREAD. THESE WERE 235/85R16

STEERING GEAR BOX CAUSED RIVITS ON CROSS MEMBER OF FRAME TO STRETCH, ALSO CAUSING A SNAPPING NOISE IN FRONT END, ON CLOSER INSPECTION IT WAS FOUND THAT CROSS MEMBER OF FRAME AT STEERING BOX WAS LOOSE, FORD WOULD NOT SHARE IN REPAIR COST DUE TO VEHICLE BEING OUT OF WARRANTY. *SLC

REAR SEAT BELTS FAILED TO FUNCTION ON RESTRAINT. *AK

PLASTIC ASSEMBLY CAUSES THE BELT TO WEAR. RESULTING IN A LOSS OF POWER. TT

THE DRIVESHAFT CAME OFF DUE THE DEFECTIVE WELDS AND BOLTS WHICH MAY CAUSE A LOSS OF VEHICLE CONTROL.*AK WHILE AFTER 2 HRS DRIVE THE POWER STEERING FLUID HAD LEAKED OUT,ALSO DIESEL FUEL WAS LEAKING. *ET

ACCESSORY DRIVELINE HAS BROKEN NINE TIMES. TT

WE OWN A 1993 FORD F350. IT WAS PARKED IN FRONT OF OUR HOUSE ATTACHED GARAGE. IT WAS NOT RUNNING. MY HUSBAND WENT OUTSIDE AND WALKED BETWEEN THE TRUCK AND GARAGE. HE SMELLED SMOKE, LOOKED TOWARD THE PICKUP AND SAW SMOKE COMING OUT FROM UNDER THE HOOD. HE QUICKLY RAISED THE HOOD AND PUT THE FIRE OUT. OUR CRUISE CONTROL HAD NOT BEEN WORKING FOR SOME TIME. MY HUSBAND PURCHASED THE SWITCH FROM CANTON MOTORS AND REPLACED IT. THE CRUISE CONTROL WORKED AGAIN, FOR AWHILE. IT HAS NOT CAUGHT ON FIRE AGAIN, YET BUT I'M AFRAID WE HAVE ANOTHER DEFECTIVE SWITCH. FORD HAS A RECALL ON 1993 PICKUPS NOW FOR THAT PROBLEM BUT WHEN I CHECKED OUR VIN, IT STATES THERE IS NO RECALL ON IT. I BELIEVE THAT FORD SHOULD REIMBURSE US FOR THE SWITCH WE PURCHASED AND REPLACE IT. THE FIRST SWITCH IS POSSIBLY AVAILABLE. THE CURRENT ONE IS STILL ON THE PICKUP. I TALKED TO FORD CUSTOMER SERVICE TO RESOLVE THIS PROBLEM BUT NO HELP WAS OFFERED AND THE LADY WAS RATHER RUDE. I DO NOT REMEMBER THE DATE OF THE FIRE. THE CRUISE CONTROL DOES NOT WORK NOW. *TR

WHILE VEHICLE WAS PARKED A FIRE STARTED UNDER THE HOOD. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

HAD BOTH OF MY STEER TIRES BLOW OUT GOING DOWN THE HIGH WAY RIGHT SIDE I HAD A TRAILER ON AND THE OTHER I HAD JUST GOT ON TO THE INTERSTATE. PUT A HOLE IN MY FLOOR ON DRIVERSIDE AND BROKE THE BRAKE LINE ON THE DRIVERSIDE AS WELL. PASSENGER SIDE JUST LET LOOSE WITH NO WARNING. I STILL HAVE ALL FOUR TIRES AND THE TREAD. THESE WERE 235/85R16