RoadVitals

1994 Ford F-350 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Newest Aug 1, 2006
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
4 investigations on file

Recall campaigns

7 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

06V286000

VEHICLE SPEED CONTROL

Aug 1, 2006
1,200,000 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
The risk: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
The remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
FORD MOTOR COMPANYManufacturer number 05S28View on NHTSA.gov
06E049000

EXTERIOR LIGHTING

May 24, 2006
27,176 units potentially affected
The defect: CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
The risk: WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
The remedy: CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
CK MOTORSPORT, INC.View on NHTSA.gov
01X001000

TIRES:TREAD/BELT

May 22, 2001
13,000,000 units potentially affected
The defect: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
The risk: SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
The remedy: THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
FORD MOTOR COMPANYManufacturer number 01B77View on NHTSA.gov
96V064000

SEATS

Apr 16, 1996
31,000 units potentially affected
The defect: THE WIRE HARNESS FOR THE POWER LUMBAR FEATURE ON THE SEAT IS UNDERNEATH THE FRONT SEAT CUSHION SUPPORT WIRES. THE SUPPORT WIRES ON THE DRIVER SEAT CAN CONTACT AND DAMAGE THE INSULATION HARNESS RESULTING IN A HIGH RESISTANCE ELECTRICAL SHORT THROUGH THE SUPPORT WIRES.
The risk: CONSEQUENCE OF DEFECT: OVER HEATING OF THE SUPPORT WIRES COULD RESULT, AND MELTING, SMOKE, OR POSSIBLE IGNTION OF THE SURROUNDING MATERIALS COULD OCCUR.
The remedy: DEALERS WILL INSPECT THE SEATS ON THE AFFECTED VEHICLES. IF NO DAMAGE IS FOUND, THE DRIVER SEAT WIRE HARNESS WILL BE COVERED WITH A PROTECTIVE CONVOLUTE TUBING, WRAPPED WITH ELECTRICAL TAPE AND THE HARNESS WILL BE REROUTED. IF DAMAGE IS FOUND, THE WIRE HARNESS WILL BE REPLACED.
FORD MOTOR COMPANYView on NHTSA.gov
94V169001

PARKING BRAKE:CONVENTIONAL

Sep 7, 1994
835,791 units potentially affected
The defect: THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
The risk: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
The remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
FORD MOTOR COMPANYView on NHTSA.gov
94V101000

ELECTRICAL SYSTEM:IGNITION:MODULE

May 25, 1994
900 units potentially affected
The defect: IN A HEAVILY LOADED VEHICLE, WHILE IN THE CRUISE CONTROL MODE, THE THROTTLE MAY NOT REDUCE IMMEDIATELY WHEN THE LOAD ON THE ENGINE IS DECREASED (SUCH AS WHEN THE VEHICLE CRESTS A HILL.) THIS CAN RESULT IN INCREASED VEHICLE SPEED WITHOUT PRIOR WARNING.
The risk: THIS CAN RESULT IN LOSS OF SPEED CONTROL OF THE VEHICLE, AND A POSSIBLE ACCIDENT.
The remedy: DEALERS WILL REPLACE THE ELECTRONIC ENGINE CONTROL MODULE.
FORD MOTOR COMPANYView on NHTSA.gov
94V018000

STRUCTURE:BODY:BUMPERS

Jan 2, 1994
370,000 units potentially affected
The defect: THE U-CLIP STYLE NUTS THAT RETAIN THE FRONT BUMPERS TO THE FRONT BUMPER INNER ARMS CAN FRACTURE.
The risk: IF ONE OF THE U-CLIP NUTS FRACTURES, THE BUMPER WILL LOOSEN AND RATTLE CAUSING FRACTURE OF THE REMAINING U-CLIP NUTS, RESULTING IN SEPARATION OF THE BUMPER FROM THE VEHICLE. IF THE BUMPER WERE TO DETACH FROM THE VEHICLE WHILE IT IS BEING DRIVEN, A VEHICLE COLLISION COULD RESULT.
The remedy: INSPECTION AND REPLACEMENT OF THE FOUR U-CLIP NUTS AND THE ASSOCIATED BOLTS.
FORD MOTOR COMPANYView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA05005ClosedEngineering Analysis

ENGINE COMPARTMENT FIRES

Opened Mar 22, 2005
Closed Aug 2, 2006

EA05-005 IS CLOSED WITH FORD?S ACTIONS IN RECALLS 05V-017, 05V-388, AND 06V-286, RECALLING APPROXIMATELY 6.7 MILLION VEHICLES EQUIPPED WITH TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCHES (SCDS).THE BRAKE SYSTEMS IN THESE RECALLED VEHICLES GENERATE A VACUUM THAT CAN POTENTIALLY CAUSE THE SCDS TO FAIL AND, IN CERTAIN SWITCH INSTALLATION ORIENTATIONS, CATCH FIRE.FORD IS ALSO INCLUDING THE ENTIRE POPULATION OF 1998 EXPLORERS.FORD HAS INFORMED ODI THAT TESTING TO DETERMINE THE CAUSE OF FAILURES IN THE 1998 EXPLORERS WILL CONTINUE AFTER THIS INVESTIGATION IS CLOSED.ODI BELIEVES THAT THE VEHICLES EXHIBITING THE FACTORS CAUSING SCDS FAILURE DESCRIBED IN THIS REPORT CORRELATE WELL WITH THE OBSERVED FAILURE RATES ON THESE VEHICLES BY MODEL AND MODEL YEAR.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST IN THE NON-RECALLED VEHICLES MANUFACTURED WITH SCDS THAT ARE NOT INCLUDED IN FORD?S RECALLS.ODI WILL CONTINUE TO MONITOR THE NON-RECALLED POPULATION FOR INCIDENCE OF ENGINE COMPARTMENT FIRES.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED CLOSING REPORT FOR DETAILS.

ELECTRICAL SYSTEMLed to recall 05V388000
EA95012ClosedEngineering Analysis

FAILURE OF SERPENTINE BELT

Opened Mar 31, 1995
Closed May 28, 1996

AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.

POWER TRAINLed to recall 96I003001
PE94087ClosedPreliminary Evaluation

TRNS OIL COOLER LINE FAILS

Opened Nov 18, 1994
Closed Mar 31, 1995

FORD HAS ACKNOWLEDGED A SERIOUS PROBLEM WITH THE ACCESSORY DRIVE BELT SYSTEM (SERPENTINE BELT) IN THE SUBJECT VEHICLES.SEVERAL SERVICE BULLETINS HAVE BEEN ISSUED TO ADDRESS CONCERNS RELATED TO BELT TRACKING OR WEAR.FORD MAINTAINS THAT THE SUBJECT CONDITION DOES NOT PRESENT AN UNREASONABLE RISK TO HIGHWAY SAFETY, ARGUING THAT THE LOW INCIDENCE OF FAILURES ALLEGING SAFETY CONSEQUENCES (I.E., FIRES, FLUID LEAKS, AND/OR ACCIDENTS) IS STRONG EVIDENCE IN SUPPORT OF THIS CLAIM.FORD HAS INDICATED RECEIPT OF 4,445 FIELD REPORTS AND 46891 WARRANTY CLAIMS CONCERNING THE SUBJECT CONDITION. FORD MAINTAINS THAT THE LOW NUMBER OF REPORTED HOSE RUPTURES AND/OR FIRES, RELATIVE TO TOTAL BELT FAILURES, SHOWS THAT THE PROBLEM IS A DURABILITY CONCERN THAT PRESENTS VERY LITTLE RISK TO MOTOR VEHICLE SAFETY.FORD INTENDS TO ADDRESS THE PROBLEMIN A SERVICE BULLETIN SCHEDULED FOR PUBLICATION THE WEEK OF MARCH 13, 1995.ODI HAS RECEIVED SEVERAL CLAIMS ALLEGING THAT INCIDENTS OF BELT FAILURE ARE CAUSING COLLATERAL DAMAGE TO ADJACENT FLUID SYSTEMS (E.G., POWER STEERING HOSE, COOLANT HOSE, AND AUTOMATIC TRANSMISSION OIL COOLER HOSE).RELEASE OF THESE FLUIDS WITHIN THE ENGINE COMPARTMENT MAY RESULT IN A VEHICLE FIRE, IF EXPOSED TO A SUFFICIENTLY HOT SURFACE AREA.THE AUTOIGNITION TEMPERATURE FOR TRANSMISSION OIL MAY BE AS LOW AS 300 C (570 F), WHILE POWER STEERING FLUID AND ENGINE COOLANT ARE GENERALLY HARDER TO IGNITE (CLOSER TO 500 DEGREE C (900 DEGREEF)).DAMAGE TO BATTERY CABLE INSULATION HAS ALSO BEEN ALLEGED AS A CONSEQUENCE OF SERPENTINE BELT FAILURE.ODI HAS RECEIVED FOUR REPORTS ALLEGING FAILURE OF ADJACENT FLUID SYSTEM HOSES FROM CONTACT WITH A BROKEN SERPENTINE BELT.ONE REPORT INVOLVED AN ECONOLINE RV CUTAWAY CHASSIS WITH A 7.3L V-8 NAVISTAR ENGINE, USED IN THE TRANSPORT OF DISABLED CHILDREN.AN ENGINE COMPARTMENT FIRE DESTROYED THE VEHICLE IN NOVEMBER 1994.THE FIRE IS ALLEGED TO HAVE BEEN CAUSED WHEN THE SERPENTINE BELT BROKE AT HIGHWAY SPEED AND RUPTURED A TRANSMISSION COLLER LINE. THE REPORT ALLEGES FINDING BELT FRAGMENTS AND TRACES OF TRANSMISSION FLUID UP THE ROAD FROM THE FIRE SCENE, NEAR WHERE THE DRIVER HAD HEARD A POP JUST PRIOR TO THE FIRE.THE DRIVER REPORTEDLY SUSTAINED MINOR BURN INJURIES WHILE EVACUATING PASSENGERS.OWNER REPORTS ALSO ALLEGE SOME LOSS OF VEHICLE CONTROL OCCURS WITH THE BELT FAILURES, DUE TO THE LOSS OF POWER ASSIST CAPABILITY TO THE BRAKING AND STEERING SYSTEMS.THE SERPENTINE BELT DRIVES THE POWER STEERING PUMP AND THE VACUUM PUMP FOR THE BRAKE BOOSTER IN THE SUBJECT VEHICLES.AS STATED IN FORD BULLETIN 93-23-27: SOME DIESEL POWERED VEHICLES ARE EXPERIENCING DRIVE BELT TRACKING CONCERNS.THIS IS CAUSED BY FRONT END ACCESSORY DRIVE (FEAD) MISALIGNMENT, WHICH MAY RESULT IN THE BELT COMING OFF THE ACCESSORY DRIVE PULLEYS.IF THIS OCCURS, SEVERAL WARNING LIGHTS WILL ILLUMINATE AND THE VEHICLE WILL LOSE ALTERNATOR AND A/C FUNCTION AND WATER PUMP CIRCULATION.IN ADDITION, STEERING EFFORTS WILL INCREASE AND, AFTER ONE OR A FEW BRAKE APPLICATIONS, BRAKE EFFORTS WIL PROGRESSIVELY INCREASE. THERE ARE THREE ODI COMPLAINTS AND FIVE FORD COMPLAINTS, NOT INCLUDED IN THE FAILURE REPORT SUMMARY OF THIS RESUME, ALLEGING THAT THE REDUCTIONIN VEHICLE CONTROL ASSOCIATED WITH ACESSORY DRIVE BELT FAILURE RESULTED IN AN ACCIDENT.THIS INVESTIGATION IS BEING UPGRADED TO FURTHER ANALYZE THE POTENTIAL SAFETY CONSEQUENCES OF SERPENTINE BELT FAILURE IN THE SUBJECT VEHICLES.

POWER TRAIN
PE94004ClosedPreliminary Evaluation

HYDRAULIC BRAKE LINE CRACKS/LEAKS

Opened Jan 25, 1994
Closed Apr 29, 1994

There is no summary currently available

SERVICE BRAKES, HYDRAULIC

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .