1995 Ford F-350 Problems

THERE WAS A VIBRATION WHEN CONSUMER APPLIED BRAKES AT ANY SPEED. CONSUMER HAD BRAKES INSPECTED AND DISCOVERED THAT FRONT BRAKE ROTORS ON BOTH SIDES OF VEHICLE HAD CRACKED WHICH CAUSED VIBRATION. DEALERSHIP WAS UNWILLING TO ASSIST THE CONSUMER. *AK CONSUMER IS CONCERNED THAT THIS COULD CAUSE THE WHEELS TO LOCK UP. *JB

THE POPPING OUT OF THE O-RING OF THE HOSE CONNECTION TO THE HYDRAULIC UNIT CAUSED BRAKE AND POWER STEERING FAILURE, THIS HAS HAPPENED ON 2 OCCASIONS. NLM

TL* THE CONTACT OWNS A 1995 FORD F-350. THE CONTACT STATED THAT THE ENGINE CAUGHT FIRE WITHOUT WARNING WHILE PARKED IN A DRIVEWAY. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND STATED THAT AN INSPECTION REPORT WOULD BE PROVIDED. THE VEHICLE WAS NOT INSPECTED BY A DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

MY 1995 F350 7.3 POWER STROKE WILL WITHOUT WARNING STALL. THIS HAS HAPPENED WHILE IDLING OR DRIVING. ENGINE CAN BE RESTARTED AS THOUGH NOTHING HAD HAPPENED, IT MAY DO IT AGAIN IN 1 MILE OR 10 MILES. THERE IS NO HISTORY OF OVERHEATING OR ANY RELATED ISSUES THAT MAY CAUSE THIS PROBLEM. AS OF TODAY WE ARE NOT DRIVING THE VEHICLE AS SEEMS TOO DANGEROUS TO DRIVE. IS THIS RELATED AT ALL TO THE CAM SENSOR UNIT OR SOMETHING ELSE IN THE ENGINE? *TR

TL*THE CONTACT OWNS A 1995 FORD F350. THE VEHICLE HAS UNIROYAL LAREDO LTL, SIZE LT235/85R16 TIRES. WHILE DRIVING AT AN UNKNOWN SPEED, THE FRONT DRIVER SIDE TIRE TREAD SEPARATED AND CAUSED THE VEHICLE TO VEER OFF THE ROAD, DOWN AN EMBANKMENT, AND INTO SOME TREES. THE VEHICLE CRASHED AND FLIPPED OVER ON THE DRIVER SIDE. THERE WERE TWO OCCUPANTS IN THE VEHICLE. THE CONTACT'S WIFE WAS SEATED IN THE PASSENGER SEAT AND WAS FATALLY INJURED. THE CONTACT RECEIVED MINOR INJURIES. A POLICE REPORT WAS FILED. AN INVESTIGATOR PROVIDED THE COMPLAINT INFORMATION ON THE CONTACT'S BEHALF. THE PURCHASE DATE AND DEALER INFORMATION WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 124,055.

WHILE DRIVING ABOUT 60 MPH ON THE HIGHWAY, THE DRIVER HEARD A LOUD BANG COMING FROM THE DRIVER'S SIDE TIRE AND DISCOVERED THE TREAD SEPARATED FROM THE TIRE, THE CONSUMER LOST CONTROL OF VEHICLE, CAUSING A COLLISION WITH A CONCRETE BARRIER. THERE WERE NO FATALITIES. FIRESTONE, STEELTEX AT, P265/75R16. *AK *JB *NLM

WHILE DRIVING AND WITH NO WARNING CONSUMER TRIED TO PUT VEHICLE IN REVERSE AND THE VEHICLE WOULD NOT ACCELERATE EVEN WHEN FOOT WAS ON THE ACCELERATOR PEDAL. THE VEHICLES CLUTCH PACK AND TRANSMISSION BURNED OUT. THE VEHICLE IS ON IT'S THIRD TRANSMISSION. THE CONSUMER FEELS THE MANUFACTURER SHOULD PROVIDE SOME FINANCIAL ASSISTANCE. *AK *TS *NLM

FIRE

TL* THE CONTACT OWNS A 1995 FORD F-350. WHILE TRAVELING 30 MPH, THE CONTACT NOTICED A SCRAPING SOUND COMING FROM THE REAR OF THE VEHICLE. AFTER EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE FUEL TANK WAS FRACTURED FROM THE SUPPORT STRAPS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT MILEAGE WAS 250,000 AND THE FAILURE MILEAGE WAS 245,000.

1995 FORD 1 TON GAS TANK DROPPED OUT BECAUSE OF RUSTY STRAPS LEAKED GAS, NO FIRE BUT AN EXPENSIVE CLEANUP, EPA CLEANUP, FIRE DEPT RESPONSE AND TOWING. *TR

ON FEBRUARY 18, 2014, AT APPROXIMATELY 10 AM, I WAS MOVING OUR 1995 FORD F-350 TO PARK IT AT A FRIENDS HOUSE, THE TRUCK STARTED LOSING POWER, I SMELLED AN ELECTRICAL SMELL & SMOKE STARTED COMING FROM THE DASHBOARD, I JUMPED OUT OF THE TRUCK & OPENED THE HOOD & THE ENGINE COMPARTMENT WAS IN FLAMES, I IMMEDIATELY DIALED 911 & CONNECTED TO OUR LOCAL FIRE DEPARTMENT, THEY ARRIVED WITHIN MINUTES BUT THE FRONT HALF OF THE TRUCK WAS TOTALLY DESTROYED, I WAS NOT AWARE OF THE RECALL ON THESE TRUCKS UNTIL A MECHANIC FRIEND HEARD ABOUT MY TRUCK CATCHING FIRE & TOLD ME ABOUT THE PROBLEM WITH THEM. *TR

VEHICLE CAUGHT ON FIRE WHILE PARKED; LOCAL FIRE DEPARTMENT ARRIVED TO EXTINGUISH THE FIRE. THE CAUSE OF THE FIRE WAS DETERMINED TO BE AN ELECTRICAL SOURCE. THE PART OF THE ELECTRICAL SOURCE IS AVAILABLE FOR ANALYSIS. DEALER AND THE MANUFACTURER WERE NOT NOTIFIED AT THIS TIME.*AK

THIS IS REGARDING INABILITY OF AN AUTHORIZED FORD DEALER (GENTRY FORD - BAKER CITY, OREGON) TO INSPECT AND DETECT A BALL JOINT PROBLEM WHICH WOULD BE EASILY DETECTABLE IN MOST VEHICLES. MY CONCERN IS THAT IMPENDING BALL JOINT FAILURE FOR THIS PARTICULAR YEAR/MODEL MAY BE UNDETECTABLE IN SOME INSTANCES EVEN WHEN THE VEHICLE HAS BEEN THOROUGHLY INSPECTED BY AN AUTHORIZED FORD DEALER SUCH AS GENTRY FORD. PRIOR TO PURCHASE OF THIS VEHICLE, I TEST DROVE IT. DURING THE SHORT TEST DRIVE I HAD NOT NOTICED ANY SYMPTOMS OF LOOSE BALL JOINTS ALTHOUGH I DID NOTICE SOME WANDERING ON THE FREEWAY BUT ATTRIBUTED IT TO LOCAL ROAD CONDITIONS. WHILE DRIVING HOME ON THE FREEWAY I NOTICED THE WANDERING STEERING WAS PRESENT BUT ATTRIBUTED IT TO VARYING ROAD CONDITIONS. HALFWAY HOME, SOME SHARP TURNS AT SLOW SPEEDS CAUSED BINDING DURING THE TURN. FINALLY, AFTER ARRIVING HOME AND MAKING A 90 DEGREE TURN UPHILL INTO MY DRIVEWAY (1-2 MPH) I REALLY NOTICED THE SEVERITY OF THE BALL JOINT CONDITION. NOT SURE WHAT WAS HAPPENING I TOOK THE TRUCK TO A DIFFERENT LOCAL FORD DEALER WITH A REQUEST TO INSPECT THE FRONT SUSPENSION FOR ANY ADVERSE CONDITIONS. THEIR REPORT REVEALED THAT THE RIGHT FRONT BALL JOINTS WERE LOOSE AND THEIR VEHICLE INSPECTION REPORT REFLECTED THAT THE SUSPENSION WAS UNSAFE AND NEEDED IMMEDIATE ATTENTION (RED). THE GENTRY FORD SERVICE DEPARTMENT, WAS APPARENTLY UNABLE TO DETECT ANY PROBLEM(S) WITH THE FRONT SUSPENSION ACCORDING TO THE VEHICLE SAFETY INSPECTION REPORT DONE ON THE TRUCK 4 DAYS PRIOR TO PURCHASE AND HAD CHECKED THE SUSPENSION BLOCK AS (GREEN) INCORRECTLY SHOWING IT WAS SAFE. MY MAIN CONCERN IS THAT NOT ALL FORD DEALERS MAY BE ABLE TO DETECT AN UNSAFE BALL JOINT CONDITION WHICH MAY REQUIRE A TSB TO INSURE DETECTION OF UNSAFE BALL JOINT CONDITIONS DURING NORMAL SAFETY INSPECTIONS.

FRONT AIR SPRING HOUSING BUSTED, RESUTLING IN VEHICLE STALLING AND OTHER MALFUNCATIONS. CONSUMER HAS CONTACTED THE DEALER, DEALER HAS REPLACED PARTS. PROBLEM STILL OCCURS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

WHILE STEPPING INTO VEHICLE REAR BUMPER IT CAVED IN, CAUSING CONSUMER'S FOOT TO GET STUCK, THE CONSUMER THEN FELL AND HIT THE CONCRETE WHIL HIS FOOT WAS STILL LODGED IN THE BUMPER, AS A RESULT THE CONSUMER SUSTAINED A LEFT HEEL FRACTURE IN TWO PLACES, A TWISTED BACK, NECK AND A HIP INJURY. DEALER NOTIFIED. *NLM

MY TRUCK FRACTURED THE FRAME ON BOTH MAIN RAILS RIGHT BEHIND THE CAB AT THE FRONT OF THE CARGO BOX. THE FRACTURES RUN FULL HEIGHT OF BOTH BEAMS AND THE ONLY REMAINING ATTACHMENT WHEN I FOUND THE PROBLEM WAS THE VERY BOTTOM LIP OF THE C-SHAPE CHANNEL. WHEN I WOULD ACCELERATE THE TRUCK IT BENT UP IN THE MIDDLE OF THE FRAME - RIGHT OVER THE FRONT GAS TANK. AT THE TIME THE TRUCK WAS CARRYING A 9 1/2 FT. TRUCK CAMPER WITH A LIT AND OPERATING PROPANE REFRIGERATOR. IF THE FRAM HAD SEPERATRED WHILE DRIVING AN EXPLOSION WOULD HAVE MOST LIKELY FOLLOWED. PLEASE ALSO NOTE THAT ALLSTATE HAS HAD CLAIMS ON 3 OF THESE IN THE RECENT PAST IN THE ANCHORAGE, AK CLAIM OFFICE ALONE. PLEASE INVESTIGATE.

WHILE TRAVELING STEERING WHEEL WANDERS LEFT TO RIGHT AND THERE IS A LOT OF PLAY INSIDE OF VEHICLE. DEALERSHIP IS AWARE OF PROBLEM. *AK

WHILE DRIVING IN NEW MEXICO IN SEPTEMBER 2001 I EXPERIENCED A SUDDEN LOSS OF POWER STEERING. CONTINUING FOR APPROXIMATELY AN ADDITIONAL 1/2 MILE I PULLED OVER AND CHECKED THE POWER STEERING AREA. THE HIGH PRESSURE HOSE END CONNECTED TO THE POWERSTEERING PUMP HAD SEPARATED FROM THE FITTING IN THE PUMP. UPON FURTHER INSPECTION I FOUND THAT THE END THAT SEPARATED USED AN INTERNAL SNAP RING ALLOWING THE METAL LINE TO SEPARATE FROM THE PUMP. THE OTHER END OF THE LINE WAS A STANDARD HIGH PRESSURE HYDRAULIC FLARE FITTING COMMON TO BRAKE LINES AND OBVIOUSLY FAR SUPERIOR IN DESIGN TO THE FAILED END. THERE IS A SEGMENT OF HIGH PRESSURE OF HIGH PRESSURE HOSE SO THE REASON FOR THIS INFERIOR TYPE OF CONNECTOR IS UNCLEAR AND UNSATISFACTORY. CONTACTING FORD PROVIDED NO SATISFACTION AND NO ANSWERS. FOUR FORD DEALERS HAVE BEEN CONTACTED AND ALL ARE FAMILIAR WITH THE PROBLEM. CONTACTED FORD DIRECT AND THEY SAID CONTACT THE DEALER. I HAVE THE FAILED HOSE AND A SOLUTION - PLEASE CONTACT ME. I PLAN TO CHANGE THIS REGARDLESS OF ANY OUTSIDE ASSISTANCE OR COOPERATION. THE LOCAL TV STATION ALREADY DID A PIECE ON THIS EVENT LAST WEEK AND I'M GETTING THUMBS UP FOR PURSUING THIS. LET'S GET SOMETHING DONE. THIS IS TOTALLY UNSAFE AND THERE IS AN OBVIOUS AND INEXPENSIVE CURE.*AK

ON FEBRUARY 18, 2014, AT APPROXIMATELY 10 AM, I WAS MOVING OUR 1995 FORD F-350 TO PARK IT AT A FRIENDS HOUSE, THE TRUCK STARTED LOSING POWER, I SMELLED AN ELECTRICAL SMELL & SMOKE STARTED COMING FROM THE DASHBOARD, I JUMPED OUT OF THE TRUCK & OPENED THE HOOD & THE ENGINE COMPARTMENT WAS IN FLAMES, I IMMEDIATELY DIALED 911 & CONNECTED TO OUR LOCAL FIRE DEPARTMENT, THEY ARRIVED WITHIN MINUTES BUT THE FRONT HALF OF THE TRUCK WAS TOTALLY DESTROYED, I WAS NOT AWARE OF THE RECALL ON THESE TRUCKS UNTIL A MECHANIC FRIEND HEARD ABOUT MY TRUCK CATCHING FIRE & TOLD ME ABOUT THE PROBLEM WITH THEM. *TR

TL*THE CONTACT OWNS A 1995 FORD F350. THE VEHICLE CAUGHT FIRE APPROXIMATELY ONE HOUR AFTER IT WAS PARKED ON THE SIDE OF THE ROAD. THE FLAMES WERE COMING FROM THE HOOD OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND A REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THERE WAS NO PROPERTY DAMAGE. THE VEHICLE WAS NOT INSURED FOR FULL COVERAGE. RECENTLY, THE CONTACT RECEIVED A RECALL NOTICE AND HE STRONGLY BELIEVES THAT THE FIRE WAS RELATED TO THE RECALL. THE CURRENT AND FAILURE MILEAGES WERE 100,000. UPDATED 09/13/08. *LJ

THE UNDERCARRIAGE SPARE TIRE CARRIER FELL OFF WHILE THE CONSUMER WAS DRIVING, THE CONSUMER HEARD A LOUD NOISE BUT DIDN'T REALIZE WHAT HAD HAPPENED UNTIL PULLING IN THE DRIVEWAY, IT HIT THE FUEL TANK, AND LUCKILY DID NOT PUNCTURE IT. *SLC

WHEN THE CAR HITS A BUMP, THE FRONT WHEELS START TO SHAKE UNTIL THE CAR SLOWS DOWN . *AK

THE TEMPERED GLASS IN THE WINDSHIELD AND ALL DOOR GLASS HAS BECOME DISTORTED WITH RIDGES AND IS CAUSING POOR VISIBILITY. NLM

INSTRUMENT PANEL LOOSE DUE TO BROKEN MOUNTING STUDS.

DRIVER'S SIDE REAR DOOR JAMS,PULLING BUCKLING APART AT SEAM.

INSTRUMENT PANEL LOOSE DUE TO BROKEN MOUNTING STUDS.

CONTINUOUS REPAIRS AND FAILURES ON THE ANTI LOCK BRAKE SYSTEM, FAILURES CAUSE VIBRATION AND LOCK UP.

INSTRUMENT PANEL LOOSE DUE TO BROKEN MOUNTING STUDS.

CAN NOT WEAR THE SEAT BELT SHOULDER BELT COMES OVER CONSUMER FACE. TT

INSTRUMENT PANEL LOOSE DUE TO BROKEN MOUNTING STUDS.