2000 Ford F-350 Owner Complaints

On [XXX], I rented a Class C motorhome from Cruise America at their Duluth, Georgia branch (Reservation #[XXX]). When I picked up the vehicle, the Cruise America employee pointed to a handwritten note taped over the tire pressure warning light on the dashboard that said: “ignore tire sensor.” The note was already in place before I arrived, suggesting that other renters may have used the vehicle in that same unsafe condition. Three days later, while traveling northbound on [XXX] near Memphis, Tennessee, the RV suffered a sudden tire blowout at highway speed. We narrowly avoided a collision while maneuvering to the shoulder. Thankfully, no one was injured, but the incident was extremely dangerous and could easily have resulted in fatalities. Cruise America knowingly rented out a vehicle with an active tire pressure warning covered and concealed, depriving the driver of critical safety information. The company did not repair or document the issue, instead instructing renters to “ignore” the tire warning. This conduct may violate Federal Motor Vehicle Safety Standard No. 138 (49 C.F.R. § 571.138) and 49 U.S.C. § 30122, which prohibit making safety equipment inoperative or misleading drivers about safety system status. While TPMS sensors can fail naturally, covering the warning light constitutes deliberate concealment and undermines the system’s purpose. I am concerned that Cruise America may be circulating other rental vehicles in similar unsafe condition. Please investigate whether Cruise America, Inc. is in compliance with federal vehicle-safety laws governing TPMS functionality and rental-vehicle maintenance standards. Specifically, whether any branch locations are renting vehicles with disabled, covered, or ignored tire-pressure monitoring systems or other concealed safety warnings. Reported to Cruise America Customer Relations (Case #[XXX]). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11699088

Incident

Sep 18, 2025

The first and only notification received was the April 5, 2025 email. The 2000 F350 did experience issues of stalling on the road many times. After several thousand dollars of repairs, the camshaft position sensor was replaced by a commercial diesel mechanic. No warnings of any kind were displayed. The truck stalled on the freeway ramp and other streets. These issues occurred since 2000 when the truck was purchased. The lack of notification and choice of fix caused danger and a lot of repair costs. This is unacceptable.

NHTSA ID

11656953

Incident

Apr 5, 2025

On 7/2/24, I went to Robinson Brothers Ford in Baton Rouge, LA to address an unrepaired Recall item on a 1994 F350. The service advisor refused to perform the recall work. They stated that the vehicle was too old. This recall is concerning an issue with a switch that can leak break fluid and cause an engine fire.

NHTSA ID

11598243

Incident

Jul 2, 2024

I scan the truck misfire keep popping up I change four coil packs and all new sparkplugs and the same thing 4cyl misfire again and its paper sucking up thru tail pipe

NHTSA ID

11572050

Incident

Feb 12, 2024

I had purchesed a set of Dick Cepek Extreme Country LT315/75/R16. The tires have 9/32nd left with approximately 15,000 miles. While driving on the highway the sidewall of the tire peeled off in one strip causing the tire to no longer hold its shape and blow out. Had it been a steer tire the incident could have been much worse. Twenty minutes prior to the failure all tires were inspected and confirmed to be inflated to the proper psi and without damage.

NHTSA ID

11545335

Incident

Aug 13, 2023

The contact owns a 2000 Ford F-350 equipped with Guangzhou 9007 bulbs. The contact stated that upon installing the bulbs, he noticed that the low-beam and the high-beam bulbs provided similar illumination. The contact then received an email from Amazon notifying him of NHTSA Campaign Number: 21E004000 (Exterior Lighting). The contact was instructed to fill out a form on the manufacturer's website to receive replacement bulbs; however, the contact had yet to receive the replacement bulbs. The contact also made multiple attempts to reach the manufacturer by phone, but all the attempts were unsuccessful. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The bulbs were not replaced. The failure mileage was approximately 140,000. The VIN was not available.

NHTSA ID

11439021

Incident

Nov 18, 2019

Mileage

140,000 mi

The death wobble. Hitting a bump - no matter the size and without warning - may cause your entire vehicle to wobble/shake uncontrollably and loose ability to steer. You’re only recourse is to let off of the accelerator and TRY to hold the truck in the lane and pray you don’t have to brake or make a turn. It has happened multiple times but the worse was while traveling I-10 in San Antonio, Texas while pulling a horse and trailer.

NHTSA ID

11438157

Incident

Oct 3, 2021

The fuel tank sender on this vehicle is defective. Every single person I know, including over 100 people in a small facebook Ford group have broken fuel tank senders. Ford never recalled it and sell a new one for $600.

NHTSA ID

11434544

Incident

Sep 27, 2021

WHILE DRIVING ON THE N.Y THRUWAY. MY MICHELIN MLX TIRES TREAD SEPARATED FOR THE TIRE CAUSING A BLOW OUT AND TEARING OFF THE REAR PASSENGER DUALLY FENDER OF MY F350 . PIECES OF THE FEND AND TIRE FLEW ALL OVER THE N.Y THRUWAY

NHTSA ID

11365086

Incident

Aug 31, 2020

Mileage

70,000 mi

STOPPED AND PUT IN PARK,SLIPPED OUT OF PARK AND ROLLED. HAS HAPPENED 3 TIMES. *TR

NHTSA ID

11325360

Incident

May 20, 2020

Mileage

211,641 mi

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT WHILE INSPECTING THE FRONT WHEELS ON THE VEHICLE, THE CONTACT BECAME AWARE OF A FRACTURE ON ONE OF THE WHEELS. THE CONTACT STATED THAT THE FRACTURE WAS LOCATED ON THE INNER LIP OF THE WHEEL. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. VARSITY FORD (3480 JACKSON AVE ANN ARBOR MI) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 171,700.

NHTSA ID

11321990

Incident

Apr 1, 2020

Mileage

171,700 mi

THERE IS A SERIOUS ISSUE WITH THE STEERING THAT MY MECHANIC SAYS IS CALLED THE DEATH WOBBLE'. I WAS DRIVING DOWN THE ROAD AND THE STEERING BEGAN TO WOBBLE UNCONTROLLABLY. MY FRONT TIRES ARE NEW, STEERING COMPONENT ALL TIGHT AND INFLATION IS ACCURATE. I PULLED TO THE AIDE OF THE ROAD AND ALMOST CRASHED. THE 'WOBBLE' OCCURS SPORADICALLY AND IS NOT PREDICABLE. IT HAS OCCURRED 6-7 TIMES IN THE TWO YEARS I HAVE OWNED THE TRUCK. I AM EXTREMELY CONCERED AS IT IS MY ONLY TRANSPORTATION. MY MECHANIC IS SAYING IT IS A MANUFACTURER DEFECT AND FORD NEEDS TO ADDRESS.

NHTSA ID

11309470

Incident

Feb 12, 2020

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH FIRESTONE TIRES, TIRE LINE: TRANS FORCE AT, TIRE SIZE: LT 265/75R16, AND DOT NUMBER: 8XW8TR7. THE CONTACT STATED THAT WHILE THE VEHICLE WAS BEENING SERVICE FOR AN OIL CHANGE, THE TECHNICIAN NOTICED THE TREAD WAS SEPARATED FROM THE REAR DRIVER SIDE TIRE. THE TIRE WAS NOT REPLACED AND WAS NOT TAKEN TO A DEALER. THE CONTACT CALLED FIRESTONE COMPLETE AUTO CARE, (1439 S WASHINGTON ST, GRAND FORKS, ND 58201, (701) 203-558) AND WAS INFORMED THAT THERE WAS NO WARRANTY ON THE TIRES. THE CONTACT STATED THAT THERE WAS A DEFECT IN THE TIRE THAT COULD LEAD TO A BLOWOUT. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE OF THE VEHICLE WAS 271,374 AND TIRE WAS 42,200.

NHTSA ID

11306253

Incident

Jan 30, 2020

Mileage

42,200 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH SIX BF GOODRICH COMMERCIAL T/A ALL SEASON TIRES, SIZE: LT235/85/R16 /LRE MPLUS (NA). AFTER APPROXIMATELY 150 MILES OF USE, A BUBBLE WAS PRESENT ON THE SIDEWALL OF THE OUTER REAR DRIVER'S SIDE TIRE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. AN UNKNOWN DEALER WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE TIRE FAILURE MILEAGE WAS 150. THE VIN AND VEHICLE FAILURE MILEAGE WERE UNKNOWN.

NHTSA ID

11287527

Incident

Dec 1, 2019

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT THE INDEPENDENT FACILITY AND THE SELLER OF THE VEHICLE MADE NO MENTION OF A FAILURE WITH THE FRONT BRAKES AND THE REAR BRAKES, WHICH WERE WARPED BEFORE THE VEHICLE WAS SOLD. IN ADDITION, THE ENGINE COOLING FAN HAD HOLES. THE VEHICLE WAS NOT INSPECTED NOR DIAGNOSED BY A DEALER. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE ENGINE COOLING FAN, AND FRONT AND REAR BRAKES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.

NHTSA ID

11098977

Incident

May 16, 2018

Mileage

148,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH BF GOODRICH ALL TERRAIN T/A TIRES, SIZE: LT285/75R16. WHILE DRIVING 70 MPH, THERE WAS A VIBRATION IN THE TIRES AND A LOUD NOISE WAS HEARD AS IF SOMETHING HIT THE VEHICLE. THE CONTACT STATED THAT THERE WAS ALSO A LOUD POPPING SOUND. THE CONTACT WAS ABLE TO EXIT THE FREEWAY AND, UPON EXITING, NOTICED THE TIRE TREAD ON THE ROADWAY ALONG WITH DAMAGE TO THE FRONT DRIVER SIDE FENDER AND RUNNING BOARD. THE CONTACT CALLED AAA TO CHANGE THE TIRE. THE VEHICLE WAS THEN DRIVEN TO AN INDEPENDENT TIRE SHOP. THE CAUSE OF THE FAILURE WAS NOT DETERMINED, BUT ALL FOUR TIRES WERE REPLACED. THE VEHICLE AND TIRES WERE NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED CASE NUMBER: 123-53467. THE VEHICLE FAILURE MILEAGE WAS 218,589 AND THE APPROXIMATE TIRE FAILURE MILEAGE WAS 213,000.

NHTSA ID

11031960

Incident

Sep 9, 2017

Mileage

218,589 mi

TL* THE CONTACT OWNS A 2000 FORD F-350 EQUIPPED WITH ALCOA WHEELS, 16X6K FRONT (NA). THE CONTACT STATED THAT THE FRONT PASSENGER SIDE WHEEL LOST AIR DUE TO A SPLITTING WHEEL. THE VEHICLE WAS TAKEN TO A LOCAL TIRE SHOP, BUT THEY WERE UNABLE TO REPAIR THE TIRE DUE TO THE RIM FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE CONTACT RESEARCHED ONLINE AND FOUND THAT THE ALCOA COMPANY VOLUNTARILY RECALLED THE WHEELS. THE VIN AND TIRE AND VEHICLE FAILURE MILEAGE WERE UNKNOWN.

NHTSA ID

11011773

Incident

Jul 6, 2017

MESA A/P2 TIRES, CRACKING AROUND BEAD WITH ONLY 3889 MILES ON SUPPOSEDLY NOT BIG O BRAND MESA NOT FOUND IN MENU

NHTSA ID

10865267

Incident

May 5, 2016

Mileage

233,544 mi

TL* THE CONTACT OWNS A 2000 FORD F-350. WHILE DRIVING 15 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN AND FAILURE MILEAGE WERE UNKNOWN. UPDATED 10/30/14*CN

NHTSA ID

10631982

Incident

Sep 1, 2013

TL* THE CONTACT OWNS A 2000 FORD F350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING ASSIST AND THE BRAKES FAILED WITHOUT WARNING. ON ANOTHER OCCASION, THE VEHICLE BECAME RESISTANT TO ACCELERATING ATTEMPTS AS THE CONTACT EXITED A DRIVEWAY AND THEN STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE MECHANIC STATED THAT THE INJECTORS WERE DEFECTIVE AND THE INJECTOR DEVICE MODULE (IDM) HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE AND CURRENT MILEAGE WAS 130,000. THE VIN WAS NOT PROVIDED.

NHTSA ID

10545312

Incident

Sep 24, 2013

Mileage

130,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, HE HEARD A POPPING NOISE COMING FROM THE FRONT END OF THE VEHICLE. AFTER INSPECTING THE VEHICLE, HE NOTICED THAT THE FRONT DRIVER'S AND PASSENGER'S SIDE ALLOY WHEELS WERE FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TR

NHTSA ID

10505945

Incident

Apr 8, 2013

Mileage

90,000 mi

MY 2000 F350 SD RIGHT REAR SINGLE WHEEL 4X4 ALUMINUM RIM CRACKED ON SEAM NOT AT BOLT HOLES CALLED FORD WAS TOLD THEY NEVER HEARD OF THIS PROBLEM THAT'S FUNNY CALLED JUNK YARD AND WAS TOLD THIS IS A COMMON PROBLEM I THINK FORD NEEDS TO RECALL THEM DUE TO COULD CASE DEATH IF DRIVING AT BREAKS APART TODAY I TOOK TIRE OFF RIM IT IS CRACKED WHOLE WAY THRU I STILL HAVE RIM TO SHOW OR SEND PICTURE THEY ARE FACTORY FORD RIMS. *TR

NHTSA ID

10472097

Incident

Aug 23, 2012

Mileage

200,000 mi

TL* THE CONTACT OWNS A SET OF YOKOHANA LT TIRES, SIZE: 265 75R 16 (N/A). THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE FRONT PASSENGER SIDE TIRE EXPLODED, CAUSING DAMAGE TO THE HOOD AND FENDER. SEVERAL WEEKS LATER THE REAR PASSENGER SIDE IRE EXPLODED, ALSO CAUSING EXTENSIVE DAMAGE TO THE REAR OF THE VEHICLE. THE TIRES WERE ONLY 3 MONTHS OLD WHEN THE FAILURE OCCURRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND STATED THAT THEY WOULD SEND SOMEONE TO FURTHER INVESTIGATE THE TIRES. THE VEIHCLE FAILURE MILEAGE WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 10,000.THE VIN WAS NOT AVAILABLE.

NHTSA ID

10471566

Incident

Apr 6, 2012

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THE HEADLIGHTS BECAME CLOUDY AND CAUSED THE LIGHTS TO APPEAR DIM. THE CONTACT WAS HAVING A HARD TIME DRIVING AT NIGHT. THE DEALER INSPECTED THE VEHICLE AND SUGGESTED THAT THE HEADLIGHT ASSEMBLY BE REPLACED. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 115,000. UPDATED 06/05/12 *BF

NHTSA ID

10455679

Incident

Apr 12, 2006

Mileage

65,000 mi

TL* THE CONTACT OWNS A 2000 FORD F-350. THE CONTACT STATED THAT HE ATTEMPTED TO ACCELERATE, BUT THE VEHICLE WOULD NOT RESPOND. THE VEHICLE HAD NOT BEEN DIAGNOSED BY THE DEALER AND NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 182,000.

NHTSA ID

10454744

Incident

Apr 10, 2012

Mileage

182,000 mi