Owner-reported complaints naming the fuel system system, filed with NHTSA
Data refreshed
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks. Every record below is an owner-reported complaint about the 2007 Ford F-350 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 8 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
Engine is the 2.7 Ecoboost and is becoming louder and louder with many ticks and sounds whether you are driving or idling the vehicle at a stop light. Every morning the engine ticks and revs very high and emits huge billowing white smoke from the exhaust whether it’s warm or cold outside. Believe the engine is needing to be replaced in the upcoming recall from ford for the exact engine.
Diesel Fuel leaking into the coolant
SINCE I BOUGHT THIS 2007 FORD F 350 I'VE HAD NOTHING BUT PROBLEMS FUEL PUMP INJECTORS EGR COOLER FUEL FILTERS BRAKES THE TRUCK HAS BEEN IN TH E SHOP THREE TIMES SINCE I'VE HAD IT NOW I'M PRAYING DONT ANYTHING ELSE GO WRONG WHAT A WASTE.;
TL* THE CONTACT OWNS A 2007 FORD F-350 TDI. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE INJECTION PRESSURE REGULATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 86,000.
TL* THE CONTACT OWNS A 2007 FORD F-350. THE CONTACT STATED WHILE THE VEHICLE WAS BEING SERVICED, THE TECHNICIAN STATED THE LINING OF THE FUEL TANK WAS COVERED WITH RUST WAS DELAMINATED. THE TECHNICIAN DIAGNOSED THAT A NEW FUEL SYSTEM AND THE FUEL FILTERS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 84,200 AND THE CURRENT MILEAGE WAS 85,300. UPDATED 04/30/13*LJ
TL*THE CONTACT OWNS A 2007 FORD F350 DUMP TRUCK DIESEL. THE CONTACT STATED THAT THE LINING OF THE FUEL TANK WAS COVERED WITH RUST AND DE-LAMINATED. THERE WERE ALSO PIECES OF RUST IN THE BOTTOM OF THE FUEL TANK. THE VEHICLE WAS TAKEN TO THE DEALER WHO DRAINED THE WATER SEPARATOR AND INSTALLED TWO FUEL FILTERS. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST SINCE THERE WERE NO RECALLS OR RELATED WARRANTIES. THE FORD MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE FAILURE MILEAGE WAS 25,430. UPDATED 05/05/11*LJ
THE 2007 FORD F350 HAS BEEN IN THE SHOP NUMEROUS TIMES FOR REPAIRS ON THE HIGH PRESSURE FUEL SYSTEM. IT IS IN FOR REPAIRS TODAY FOR THE 5TH TIME IN AS MANY MONTHS. *TR
THE TRUCK STARTS RUNNING ROUGH, HAS A LACK OF POWER AND BLOWS BLACK SMOKE. IN THE LAST YEAR, IT HAS OCCURRED ON APPROXIMATELY A MONTHLY BASIS. IN THE LAST 7 MONTHS, THE SAME DEALERSHIP HAS REPLACED 12 FUEL INJECTORS, 1 EGR COOLER, 2 EGR VALVES AND 1 FUEL PUMP. THE DEALERSHIP IS NOW TELLING US THAT A CYLINDER, VALVE AND PISTON HAVE FAILED AND THE TRUCK WHICH IS NOW OUT OF WARRANTY NEEDS A NEW ENGINE AT THE COST OF $12,748.27. THE TRUCK HAS BEEN AT THE SAME DEALERSHIP ALMOST EVERY MONTH THIS YEAR INCLUDING TWICE IN APRIL AND NOW TWICE IN OCTOBER SINCE MARCH 29, 2008 FOR THE SAME COMPLAINT AND THEY EXPECT US TO PAY FOR THE ENGINE. *TR
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .