2007 Ford F-350

THIS INVESTIGATION WAS OPENED BASED ON 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL OSCILLATIONS AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN SURFACE.ODI WAS CONCERNED ABOUT THESE COMPLAINTS BECAUSE MANY OF THEM ALLEGED LOSS OF CONTROL AND THE LOSS OF CONTROL OCCURREDAT SPEEDS ABOVE 50 MILES PER HOUR.AT THE TIME THESE COMPLAINTS WERE RECEIVED, ODI WAS ALSO AWARE OF THE TSB 07-10-10 AND EARLY WARNING FIELD REPORTS THAT DISCUSSED THE SHIMMY CONDITION ON THE SUBJECT VEHICLES.SINCE OPENING THIS INVESTIGATION, ODI HAS CONFIRMED, BASED ON CONSUMER COMPLAINTS, WARRANTY DATA, TESTING CONDUCTED BY VRTC, AND ODI INSPECTION OF COMPLAINT VEHICLES, THAT THE OWNERS OF THE SUBJECT VEHICLES ARE EXPERIENCING SHIMMY EVENTS ON THEIR VEHICLES.HOWEVER, ODI HAS ALSO CONFIRMED THAT OWNERS TYPICALLY DO NOT MAINTAIN THEIR TIRES AT THE PRESSURES RECOMMENDED BY FORD ON THE TIRE LABEL.FURTHER, ODI HAS FOUND THAT IN ORDER FOR SHIMMY TO OCCUR, TIRE PRESSURES MUST BE SUBSTANTIALLY BELOW (AT LEAST 20%) THOSE SPECIFIED ON THE VEHICLE TIRE LABEL.ODI CONSIDERS THESE UNSAFE TIRE CONDITIONS TO BE THE RESULT OF ONE OF THREE TYPICAL SITUATIONS.THE TIRES ARE BEING IMPROPERLY MAINTAINED, THE OWNERS ARE INTENTIONALLY SETTING THE TIRE PRESSURES LOW TO ENHANCE RIDE QUALITY, OR AFTERMARKET TIRES (NOT DESIGNED FOR USE ON THE VEHICLE) ARE INSTALLED TO CHANGE THE APPEARANCE OR FUNCTION OF THE VEHICLE.THE SUBJECT VEHICLES ARE INTENDED AND DESIGNED TO BE USED AS HEAVY DUTY VEHICLES AND AS SUCH REQUIRE THAT THE TIRES BE CAPABLE OF HANDLING THE LOADS FOR WHICH THE VEHICLE IS DESIGNED AND MARKETED.IN ORDER FOR THE TIRES TO BE CAPABLE OF HANDLING THESE LOADS, THE PROPER TIRE PRESSURE MUST BE MAINTAINED.IN LIGHT OF THE INFORMATION GATHERED IN THIS INVESTIGATION AND FORD'S AGREEMENT TO NOTIFY SUBJECT VEHICLE OWNERS (NOW AND EVERY TWO YEARS UNTIL THE VEHICLES REACH TEN YEARS FROM THEIR PRODUCTION DATE) ABOUT THE IMPORTANCE OF MAINTAINING PROPER TIRE PRESSURES ON THEIR VEHICLES, FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.

ODI HAS RECEIVED 78 CONSUMER COMPLAINTS OF SEVERE SUSPENSION AND STEERING WHEEL SHIMMY AND OSCILLATIONS COMMENCING AFTER THE SUBJECT VEHICLES TRAVELED OVER AN UNEVEN ROAD SURFACE. THE MAJORITY OF THESE INCIDENTS OCCURRED AT SPEEDS OF 50 MPH OR GREATER.THIRTEEN OF THE COMPLAINTS RECEIVED BY ODI ALLEGE LOSS OF STEERING CONTROL AND THAT THE VEHICLE CHANGED DRIVING LANES UNCONTROLLABLY.FOUR OF THE COMPLAINTS RECEIVED BY ODI ALLEGE THAT THE VEHICLE LEFT THE ROAD SURFACE AS A RESULT OF THE VIOLENT SUSPENSION AND STEERING WHEEL OSCILLATIONS.IN ONE CASE THE CONSUMER ALLEGES THAT AFTER THE VEHICLE LEFT THE ROAD SURFACE, IT CRASHED INTO A WOODED AREA.ADDITIONALFACTORS CONTRIBUTING TO THE OPENING OF THIS EA WERE EARLY WARNING FIELD REPORTS,SUBMITTED BY FORD, DESCRIBING SUSPENSION SHIMMY / OSCILLATIONSAND A FORD TSB (07-10-10) DESCRIBING THE SUSPENSION SHIMMY ISSUE AND HOW TO REPAIR THE PROBLEM.FORD HAS DESCRIBED SHIMMY AS SELF-EXCITED OSCILLATION OF THE STEERING WHEELS WITH ACCOMPANYING WHEEL TRAMP.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA) TO DETERMINE IF THE SHIMMY CONDITION THAT OCCURS ON THE SUBJECT VEHICLES CREATES A CONDITION WHERE THE VEHICLE BECOMES DIFFICULT TO CONTROL OR STARTLES THE DRIVER, THUS PRESENTING A SAFETY RISK.

GT Radial Adventuro AT3, 275/70R-18 Load Range E The tire exploded at 65mph while pulling a trailer. I still have what is left of it. The debris flying off the vehicle into traffic and the need to pull completely off the road. The sharp reduction of speed in traffic on a 4 lane divided highway. The tire has not been inspected by any official or company. I had purchased hazard insurance from Walmart when I bought the tires. They refused to honor the coverage due to the tire having no tread. The 2nd tire, purchased at the same time, was on the drivers side, but they refused to consider the tread remaining on that tire as an example of the blowouts previous tread. I have an active TPMS (tire pressure monitoring system) on the truck and no alarms went off prior to the explosion. It did alarm after the explosion. It is also mounted, where I as the driver, can monitor it. The blowout severely damaged my truck. My insurance indicates they will cover the cost of repairs after my deductible, but not replacement of the tires. My 2 million miles operating my own semi causes me to believe the tire was manufactured in a defective manner. I have never seen, or recall a non-retread tire shedding ALL of it's tread. Recaps generally will. I have contacted Walmart Corporate and Giti Tire. Neither has responded. Lucky only my truck was damaged and the highway scattered with debris for other travelers to encounter!

NHTSA ID

11678553

Incident

Jul 25, 2025

Engine is the 2.7 Ecoboost and is becoming louder and louder with many ticks and sounds whether you are driving or idling the vehicle at a stop light. Every morning the engine ticks and revs very high and emits huge billowing white smoke from the exhaust whether it’s warm or cold outside. Believe the engine is needing to be replaced in the upcoming recall from ford for the exact engine.

NHTSA ID

11612469

Incident

Sep 4, 2024

Diesel Fuel leaking into the coolant

NHTSA ID

11523994

Incident

May 5, 2023

Ford death wobble. Truck shakes violent and almost loses control driving at 60 miles per hour.

NHTSA ID

11473720

Incident

Jul 13, 2022

This truck has the problem known as the “death wobble.” I bought the vehicle from Johnson City Ford in Johnson City Tennessee after they said they had inspected it and everything was fine on the truck. It was used so I bought the extended warranty. The truck started shaking so violently I couldn’t drive it. I took it back to this Ford place. They replaced the universal joint under my warranty. I left didn’t get it home and it started again shaking. I took it back to them and they confirmed the death wobble and said there were no recalls and they want 3600 dollars to fix the problem. I called Ford corporate and they said there were no recalls or programs to help with this problem.

NHTSA ID

11467253

Incident

Dec 1, 2020

The contact owns a 2007 Ford F-350 equipped with Nitto tires, Tire Line: Dura Grappler, Tire Size: 275/65/18, DOT number: EAW2215. The contact stated that while driving the vehicle there was an abnormal sound coming from the rear of the vehicle. Upon inspection it was discovered that the driver’s side rear tire had experienced tread separation. The cause of the failure was not determined. The local dealer was notified of the failure and informed the contact that the tires were not included in NHTSA campaign number: 14T014000 (Tires) due to the manufacturing date of the tire. The contact indicated that the tire had experienced the same failure listed in the recall. The manufacture was not yet notified. The failure mileage was 30,000. Consumer stated thread separation happened with the second tire 2 weeks later. Manufacture was notified and all 4 tires have now been replaced prematurely.

NHTSA ID

11426850

Incident

Jul 21, 2021

Mileage

30,000 mi

SINCE I BOUGHT THIS 2007 FORD F 350 I'VE HAD NOTHING BUT PROBLEMS FUEL PUMP INJECTORS EGR COOLER FUEL FILTERS BRAKES THE TRUCK HAS BEEN IN TH E SHOP THREE TIMES SINCE I'VE HAD IT NOW I'M PRAYING DONT ANYTHING ELSE GO WRONG WHAT A WASTE.;

NHTSA ID

11365421

Incident

Oct 15, 2020

Mileage

55 mi

VEHICLE STARTED RUNNING VERY ROUGH WHEN GOING DOWN THE ROAD, AND HARD TO START. FOUND THE FICM WIRING HARNESS SMOKING AND CHAFED THROUGH WHERE IT HAD RUBBED ON ENGINE.

NHTSA ID

11143726

Incident

Oct 9, 2018

Mileage

130,000 mi

In monitoring our technical service inquiries and technical service bulletins from Ford, there is the potential for moderate to severe steering wheel oscillation (wobble) to occur. After extensive testing and outside feedback, the following details have been established to correct or prevent steering wheel oscillation occurrences in lifted 05-16 Ford Super Duty 4wd pickups.

FORD: IF THERE IS AN INTERMITTENT LACK OF POWER, SURGE, OR HESITATION WHILE DRIVING THE BRAKES WILL OVERRIDE ACCELERATION. *RM

FORD TRUCK: SOME TRUCKS EQUIPPED WITH A 6.0L DIESEL ENGINE MAY EXHIBIT A HARD START/LONG CRANK OR NO START CONDITION DUE TO LOW INJECTION CONTROL PRESSURE (ICP). *PE

SLOW FUEL FILL--MIL ON WITH DTC P0191. *NJ

WATER IN THE FUEL TANK BEHIND REAR AXLE - 6.0L, 6.4L AND 7.3L DIESEL ENGINE. *KB UPDATED 2/29/08. *NJ

CUSTOMER SATISFACTION PROGRAM. VEHICLES EQUIPPED WITH FIXED PEDALS ACCELERATOR PEDAL INSPECTION. EFFECTIVE UNTIL JUNE 30, 2007. *KB THIS PROGRAM IS BEING EXTENDED UNTIL JUNE 30, 2008. UPDATED ON 09/25/07. *NJ