2013 Ford F-350

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.

Driving along at 70 mph and just crossed a bridge and met the asphalt when all of a sudden the steering wheel shook violently & almost caused a fatal accident. Tractor trailer & cars swung to avoid me. Went to pull out onto expressway & at 15 mph & the rumble strips along the right shoulder caused it to shake again tremendously. This vehicle has had at least 8 episodes with the death wobble.This vehicle was taken in to a Ford dealership on December 3, 2025 and was supposed to be fixed entirely. Someone is going to be killed until Ford realizes the problem.Please act on this issue. I have reported these incidents three-times to you folks with out hearing back.

NHTSA ID

11721290

Incident

Feb 24, 2026

Was driving at 55mph and suddenly truck went into a terrible death wobble & almost caused a serious crash. On 11/25/2025 I had taken it in to the ford dealership to correct this problem since it had happened four times in August & September of this year. Which also almost caused four serious accidents. The ford dealer replaced L & R dragline ends & adjuster sleeve.Replaced right outer tie rod end & replaced track bar ball joint. Performed 3D wheel alignment & road tested on highway..This is the second time I’m writing you to get this recalled.

NHTSA ID

11706276

Incident

Dec 19, 2025

STEERING BECAME ERRATIC & UNCONTROLABLE WHILE DRIVING AT 55MPH. STEERING WHEEL SHOOK . IT WAS A DEATH WOBBLE AND ALMOST CAUSED A SERIOUS ACCIDENT. THIS HAS HAPPENED FOUR TIMES IN THE LAST TWO MONTHS. THIS IS A 2013 FORD F-350 WITH 102,000 MILES. EACH TIME TRUCK HAD IT HAPPEN, IT WAS AFTER A EXPANSION JOINT IN ROAD WAS GONE OVER. TRUCK WAS TAKEN TO FORD DEALER & WE ARE WAITING FOR THEIR ASSEMENT OF THE PROBLEM.

NHTSA ID

11701500

Incident

Aug 3, 2025

The contact owns a 2013 Ford F-350. The contact stated that while reversing, the rearview camera was intermittently inoperable. The message "Camera Unavailable - See Dealer" was displayed. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 115,000.

NHTSA ID

11694994

Incident

Oct 19, 2025

Mileage

115,000 mi

My 2013 F-350 Super Duty 6.7 Diesel truck has a problem with the DEF system and power loss. I had a check engine light come on, and an AutoZone scan shows a P20BA Power Train System and a few other codes were noted (see attached documents). I took it to my selling dealer, and they confirmed the Reductant Heater needs to be replaced. I found out there is a recall for this defective part on just about every Ford F-Series 6.7 Diesel "except" my specific year and model. The recall on all of the other F-Series trucks have the same defective part as my truck has. Why is Ford getting away with this. If the part installed in my truck is the same defective part that is being replaced on all of the other trucks, why is my truck not included in the recall, it is the same defective part. It is costing me over $1,700.00 to replace a known to Ford and NTSB, a defective part. I would think Ford should be ordered to include my truck in the recall or replace at cost of parts only and not the full-blown excessive charge I am having to pay. PLEASE HELP

NHTSA ID

11682365

Incident

Aug 5, 2025

1. The tread seperated from the tire at 60mph on highway. small vibration prior to incident. 2. Extremely dangerous to all. Vehicle was towing loaded horse trailer, middle lane. 3. Tried to bring up to Michelin corporate with little help available. 4. I will be taking tire to vender/dealer for inspection. have photos available. 5. only warning was small vibration that became present at 50-60 mph and went away at lower speeds. Vehicle did not vibrate on prior day. thought is was out of balance wheel.

NHTSA ID

11650326

Incident

Mar 23, 2025

The contact owns a 2013 Ford F-350. The contact stated while driving 65-75 MPH over a bumpy road surface, the vehicle experienced a death wobble. The contact stated that the steering wheel and the front end of the vehicle were shuddering violently, nearly causing the contact to lose control of the vehicle. The contact stated that upon decelerating to 20 MPH, the vehicle failure ceased, and the contact pulled over to the side of the road temporarily. The contact resumed driving. The contact stated that the failure had been recurring while driving. The dealer was notified of the failure and advised the contact that the VIN was not included in a recall. The vehicle was not diagnosed or repaired. The contact related the failure to Ford Campaign Number: 20N04. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 125,000.

NHTSA ID

11645258

Incident

Feb 21, 2025

Mileage

125,000 mi

Several months ago I noticed a shrill whining noise coming from the engine compartment. Upon closer inspection, I observed raw emissions coming from the exhaust manifold. Upon research I noticed that this was a very common problem with the 6.7 diesel between 2011 and 2014 with Ford even putting out a service bulletin (SSM50330) and designing repair parts and new heads for their defective design of exhaust studs. The repair of this defective part is very costly and they expect the owners of the vehicles to bear the entire cost of this repair. This is not only a safety issue because of exhaust gases entering the cab of the vehicle, but is also an EPA issue because these gases are passing directly to the atmosphere without being treated or going through the catalytic converter!

NHTSA ID

11630962

Incident

Jan 20, 2024

Certain 2011-2022 Model Year Super Duty Vehicles Equipped with 6.7L Engine - Emission Control Information Label Update for Qualified Vehicles

Some 2012-2016 vehicles equipped with a touchscreen navigation system and the language set to Arabic may exhibit a blank screen. This may be the result of the ribbon cables not being fully seated inside the front display interface module (FDIM) or an improper software configuration of the FDIM.

Touchscreen navigation system - arabic language - blank screen

In monitoring our technical service inquiries and technical service bulletins from Ford, there is the potential for moderate to severe steering wheel oscillation (wobble) to occur. After extensive testing and outside feedback, the following details have been established to correct or prevent steering wheel oscillation occurrences in lifted 05-16 Ford Super Duty 4wd pickups.

FORD: 2011-2014 F-SUPER DUTY VEHICLES EQUIPPED WITH 6.7L DIESEL ENGINE MAY EXPERIENCE A RUNNING ROUGH OR MISFIRE DURING EXHAUST REGENERATION PROCESS *CN

FORD: ON SOME DIESEL TRUCKS, VARIOUS COMBINATION OF DIAGNOSTIC TROUBLE CODES (DTC) FOR LOOSE, MODIFIED, DAMAGED OR MISSING GROUND G400 WHICH WAS RELOCATED BY BODY BUILDERS OUTFITTERS ON VEHICLE MODIFICATION. MODEL 2011-16 F SUPER DUTY. *PE