2010 Ford F-450 Sd Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2010 Ford F-450 Sd, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine250.0%
- Fuel system125.0%
- Tires & wheels125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
2010 FORD F-450. CONSUMER WRITES IN REGARDS TO DIESEL FUEL GETTING INTO OIL DUE TO OPEN INJECTORS. *TGW THE CONSUMER ALSO STATED ENGINE LIGHT ILLUMINATED AND THE EXHAUST WAS EMITTING SMOKE.
2010 FORD F-350 6.4 DIESEL GOES INTO "CLEANING EXHAUST FILTER" MODE AND ENGINE BEGINS SKIPPING AT HIGHWAYS SPEEDS. WHEN AT A STOPLIGHT/SIGN, IT WILL ALMOST SHUT DOWN. WHEN ACCELERATE FROM LIGHT/SIGN, GREY/BLUE SMOKE STREAMS FROM VEHICLE. DEALER STATES THEY HAVE NOT HAD ANY REPORTED PROBLEMS AND CAN NOT IDENTIFY ANY ISSUES BECAUSE THEY CAN NOT RE-CREATE THE REPORTED PROBLEM. VEHICLE NOW HAS 14000 MILES. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2010 FORD F-450. CONSUMER WRITES IN REGARDS TO DIESEL FUEL GETTING INTO OIL DUE TO OPEN INJECTORS. *TGW THE CONSUMER ALSO STATED ENGINE LIGHT ILLUMINATED AND THE EXHAUST WAS EMITTING SMOKE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
LT275/70R18 E While driving west on I10 near Thermal California, the rear driver side tire lost 100% of its thread at a 65 MPH speed. When the thread separated from the tire it damaged fender area of the truck extensively and caused a violent throw and shake of the rear of the truck. The interesting fact is that even after losing 100% of the thread he tire steel belts exposed the tire stayed inflated at 80PSI. This fact is know because I was actively monitoring TPMS tire pressure while safely pulling over. The tries were inspected and pressure levels were checked prior taking off for the trip to Thermal CA to pick up the family 5th wheel camper. These tires supposed to have a thread life of 60,000 miles, mine had reached 32000 miles. At this point there is a huge concern and low confidence in Goodyear brand tire and this may happen to the other tires on my truck and may happen under the load of the 35 foot family RV. No one was injured, and no one reproduced this problem and the manufacturer hasn't yet inspected the tire. As it was stated there was zero warning from TPMs system prior to the failure.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .