2016 Ford F-450 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Ford F-450, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes125.0%
- Engine125.0%
- Powertrain (other)125.0%
- Suspension125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
On several occasions, a vehicle cut off our truck so driver had to slam on brakes. Brakes locked up and would not release and truck would not move. Driver had to turn off the truck, set and release the parking brake before they would release and allow him to move the truck. Put truck in brake shop (SW Brake and Alignment) and they replaced brakes lines, master cylinder, hydraboost and sensor and the problem is still not fixed and the shop mechanics are still able to reproduce this locking up and not releasing issue after having our truck for more than a month. They are putting our old parts back on and releasing the truck back to us because they cannot figure out how to fix this issue. This is a safety issue for driver and others on the roadway if truck is stuck and not able to be moved out of the roadway to safety while the truck is immobile.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2016 Ford F-450. The contact stated that while driving at an undisclosed speed, the vehicle experienced a loss of automotive power. An unknown engine-related message was displayed on the instrument panel. The vehicle was towed to a local dealer where it was diagnosed and determined that there were metal shavings inside the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 66,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WHILE DRIVING ON 3 OCCASIONS AT VARIOUS SPEEDS THE TRANSMISSION SHIFTED ON ITS OWN UNEXPECTEDLY TO FIRST GEAR CAUSING LOSS OF CONTROL DUE TO THE REAR WHEELS LOCKING UP. ON TWO OF THE OCCASIONS IT DISABLED THE VEHICLE AND REQUIRED REPAIRS. THE VEHICLE IS IN THE SHOP NOW GOING ON 3 MONTHS. *DT WHEN WE HEARD ABOUT HIM THE RECALL OF 1.5 MILLION TRUCKS WE FELT LIKE WE HAD A SOLUTION BUT FORD STATES THAT MY TRUCK IS NOT AFFECTED. MY COMPLAINT IN 06/2017 IS AN EXACT DESCRIPTION OF THE RECALL. I BELIEVE MY TRUCK IS AFFECTED. I HAVE NEARLY BEEN IN THREE ACCIDENTS STARTING WHILE THE VEHICLE WAS IN WARRANTY. I FEEL THE RECALL WILL ULTIMATELY AFFECT MORE VEHICLES....*BF.. *TR *DT*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
THE AIR SPRING BLOWED
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .